Академический Документы
Профессиональный Документы
Культура Документы
Section A
HIGHNESS
Short Questions
Q6. In the heat treatment of gears, we say that internal diameter shrinks but overpin diameter increases.
Why?
Q7. Prior to nitriding why we temper the steel above nitriding temperature?
Q11. Ring gear is subjected to the gas nitriding, its hardness was found to be 700 VPN but there is change
in the dimension of dowel holes. Explain the reason behind this effect
Q19. What is the structure in the core of a induction hardened part. Compare it with the structure of core
in carburizing
Q24. If an alloy is formed by substitutional solid solution, Its diffusion is slow. Why?
ECD
Active nucleus
Isothermal Annealing
Inter-lamellar spacing
Co-operative growth
Lead Patenting
Retained austenite
Q27. There is alloy known as SAE 9310 in a annealed condition. Requirement of final properties are
ECD = 1.5 mm
Core Hardness = 35 HRC
Q28. Crown wheel fails after running hours of only 100. Even though it meet all the requirements of
ECD, surface hardeness. During the failure analysis, it was found 0.1 % Molybdenum was present?
Explain the reason for failure?
Section B
Q1. Prove that volume change is 4% while transformation from FCC to martensite by bain distortion
model?