Академический Документы
Профессиональный Документы
Культура Документы
This Specification covers the welding defects repair detected by the N.D.T applicable
procedures.
2. References
Repair shall be complied with the requirements of the following codes, standards and
Purchaser requirements.
3. Application
/conversion/tmp/scratch/386490764.doc Page 2 of 4
PT Gerbang Sarana Baja
Standard Procedure Responsible Procedure No. Revision
WELDING REPAIR Department WRP.002.GSB.J435. No.
PROCEDURE Engineering 03 0
3.3.1 All essential variables used in the welding repair shall be in accordance with the
applicable SMAW or GTAW welding procedure, latest approved edition.
3.3.2 Overlap or Excessive Convexity.
These defects shall be reduced by removal of excess weld metal by grinding.
Grinding
3.3.3 Excessive concavity of welds or craters, under cutting (0.8 mm over). These
defects shall be cleaned and deposited additional weld metal. Undercuts less
than 0.8 mm shall be cleaned by grinding.
Weld Grinding
PT or MT Weld
/conversion/tmp/scratch/386490764.doc Page 3 of 4
PT Gerbang Sarana Baja
Standard Procedure Responsible Procedure No. Revision
WELDING REPAIR Department WRP.002.GSB.J435. No.
PROCEDURE Engineering 03 0
4. Documentation
All welding repair shall be documented.
/conversion/tmp/scratch/386490764.doc Page 4 of 4