Академический Документы
Профессиональный Документы
Культура Документы
Green Environment
Petrozone International
Environmental Division
PR OFI LE
SINOPEC etc. It was started with 4 employees and now more than 150
employees work with Petrozone. In addition, the Petrozone has
extended its wing to other areas and opened various divisions like
Industrial Division, Fire & Safety Division, Environmental Services
Division.
AIR QUALITY MONITORING EQUIPMENT
FENCELINE MONITORING
CEMS
PROCESS MONITORING
MARINE MONITORING
Total Petroleum Hydrocarbons – Crude oil found in Soils and Water Analyzer
Scrubber
Hydrolysis Unit
Data Acquisition and Validation
Export to Intranet/Internet
Scentinal is more than just a monitoring station, it can also act as an
intelligent process controller. Scentinal is equipped with up to three
optional programmable relays that can be used to activate alarms,
mitigation technology, and any other electrical device based on monitored
parameters. For example, the Scentinal can be used to measure emissions
from the exhaust of a bio-scrubber and bypass carbon polishing filter if
odour levels are below set limits, or activate misting stations if odour levels
at perimeter are exceeding 5 OU/m3.
Scentinal is easy to setup and use. Each Scentinal comes pre-loaded with a
SIM card so all you have to do is mount it to a wall or a pole and power the
unit up. Scentinal will detect its location using built-in GPS, and start
transmitting to the central server. All configuration and maintenance can
be done on the on-unit 7” touch screen monitor or remotely through the
SIMS software.
DR 1000 Flying Laboratory, Drone Environmental Monitoring
OS
The Scentroid DR1000 is a fully capable flying laboratory, used to sample and
analyze ambient air at heights of up to 150 meters above ground. Air quality CH4
mapping, model verification, analysis of potentially dangerous sites are all
made possible by this novel innovation.
H2S
The Scentroid DR1000 flying laboratory provides continuous monitoring of
multiple chemicals. While in flight, five built-in chemical sensors can provide CO
remote monitoring of chemicals selected at the time of ordering. Chemical CO2
monitoring can be provided for H2S, CH4, CO2, SO2, VOCs, and close to 30 other
selected chemicals. Sensor readings along with GPS position and altitude can
provide 3D mapping of ambient pollution and odour levels. This feature can SO2
also be used to guide the operator into a plume for bag sampling.
• Fugitive Emission
• Flare Emission
• Leak Detection
along oil pipe lines
• Landfill Methane
• Odour Emission
• And much more
ENVIRONMENT IMPACT ASSESSMENT REPORT
Corporate Office
Office No 304 & 305,
Kinan Al Sharq,
Khalid Ibn Walid Street,
Rakah Ash Shamaliyah,
Al Khobar, 34225,
Kingdom of Saudi Arabia.
Tel: +966-13-8587100
Fax: +966-13-8587100
Email: info@petrozoneintl.com
Web: www.petrozoneintl.com