Академический Документы
Профессиональный Документы
Культура Документы
RVVPX310B1
6-port sector antenna, 2x 698–960 and 4x 1710–2690 MHz, 65° HPBW, 3x RET with
manual override. Internal Bias-Tee from Port 1 Band 1.
l Integrated Internal Remote Electrical Tilt (RET), with independent control of electrical tilt
with manual override on all arrays
l AISG 2.0 interfaces are via integrated internal smart bias tees on low band (694–960
MHz) RF Port 1 and a single pair of AISG 8-pin DIN input (male) and output (female)
connectors
OBSOLETE
This product was discontinued on: June 1, 2017
Replaced By
RVVPX310R-V 6-port sector antenna, 2x 698–960 and 4x 1710–2690 MHz, 65° HPBW, 3x RET with manual
override. Bands cascaded SRET.
Electrical Specifications
Frequency Band, MHz 698–790 790–890 890–960 1710–1920 1920–2170 2300–2690
Gain, dBi 15.8 16.1 16.1 17.2 17.4 18.4
Beamwidth, Horizontal,
68 67 63 63 62 61
degrees
Beamwidth, Vertical, degrees 9.9 8.9 7.9 8.3 7.4 5.9
Beam Tilt, degrees 0–10 0–10 0–10 0–10 0–10 0–10
USLS (First Lobe), dB 18 18 18 18 18 17
Front-to-Back Ratio at 180°, dB 30 28 28 33 36 34
CPR at Boresight, dB 16 15 14 23 22 17
CPR at Sector, dB 13 11 6 8 6 5
Isolation, dB 25 25 25 25 25 25
Isolation, Intersystem, dB 30 30 30 30 30 30
VSWR | Return Loss, dB 1.43 | 15.0 1.43 | 15.0 1.43 | 15.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
PIM, 3rd Order, 2 x 20 W, dBc -150 -150 -150 -150 -150 -150
Input Power per Port,
300 300 300 250 250 250
maximum, watts
Polarization ±45° ±45° ±45° ±45° ±45° ±45°
Impedance 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm
Gain by Beam Tilt, average, dBi 5 ° | 15.6 5 ° | 15.9 5 ° | 15.9 5 ° | 16.7 5 ° | 17.2 5 ° | 17.8
10 ° | 15.6 10 ° | 15.8 10 ° | 15.9 10 ° | 16.8 10 ° | 17.2 10 ° | 17.6
Beamwidth, Horizontal
±0.7 ±1.9 ±1.2 ±2 ±2.5 ±6
Tolerance, degrees
Beamwidth, Vertical Tolerance,
±0.7 ±0.5 ±0.2 ±0.5 ±0.6 ±0.6
degrees
©2018 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope.
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: September 19, page 1 of 3
2017 May 29, 2018
Product Specifications
RVVPX310B1
* CommScope® supports NGMN recommendations on Base Station Antenna Standards (BASTA). To learn more about the benefits of BASTA,
download the whitepaper Time to Raise the Bar on BSAs.
Array Layout
General Specifications
Operating Frequency Band 1710 – 2690 MHz | 698 – 960 MHz
Antenna Type Sector
Band Multiband
Performance Note Outdoor usage
Mechanical Specifications
RF Connector Quantity, total 6
RF Connector Quantity, low band 2
RF Connector Quantity, high band 4
RF Connector Interface 7-16 DIN Female
Grounding Type RF connector body grounded to reflector and mounting bracket
Radiator Material Brass | Low loss circuit board
Radome Material ASA, UV stabilized
Reflector Material Aluminum
RF Connector Location Bottom
©2018 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope.
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: September 19, page 2 of 3
2017 May 29, 2018
Product Specifications
RVVPX310B1
Dimensions
Length 2533.0 mm | 99.7 in
Width 353.0 mm | 13.9 in
Depth 209.0 mm | 8.2 in
Net Weight, without mounting kit 32.0 kg | 70.5 lb
Packed Dimensions
Length 2720.0 mm | 107.1 in
Width 436.0 mm | 17.2 in
Depth 320.0 mm | 12.6 in
Shipping Weight 54.0 kg | 119.0 lb
Regulatory Compliance/Certifications
Agency Classification
ISO 9001:2008 Designed, manufactured and/or distributed under this quality management system
Included Products
T-029-GL-E — Adjustable Tilt Pipe Mounting Kit for 2.0"-4.5" (50-115mm) OD round members for panel antennas. Includes
2 clamp sets.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
©2018 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope.
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: September 19, page 3 of 3
2017 May 29, 2018