Folding Instructions
Pteranodon
%
Goatfish
5
Chapter 5: Folding Instructions 6 +0066 aSPteranodon
1. Begin with a square, paper in hall 3. Bring all four corners
colored side up. Fold and ige to edge and together at the bottom,
tunvold along the diagonal unfold. Repeat the other forming. Preliminary
Fold.
Tum the paper over direction
Secrets
+ ee» Origami Deove?
4, Petal-fold the front and 5. Fold one flap 6, Fold theupper leftedge 7, Fold the top point down
back flaps to forma Bird down in front and down to the horizontal along a crease that passed
Base. one behind. crease andunfold. Repeat through the crease
with the upperrightedge. intersection along the
center
u
8.Foid up the ip of the 9. Untold.1o step 6 10. Open-sink the IL. Spread-sink the
comer along a crease point in and out on the tov0 fop near
aligned with the existing existing creases Repeat
horizontal crease.
v 0 4
12, Fold one long 13, Fold the boom left fap 14, Fold the flap up again so that the
flap up in fromt and ‘up to lie along the horizontal cerease hits the edge at the sme poimr,
‘one up behind. crease; crease lightly and but now the left edues are aligned.
unfold. Crease firmly and unfold.
ay)
Folding Instructions: Pteranodon «eeeees+64
15, Again, fold the flup up with 16. Crimp using the 17. Pull out the loose 18. The raw edges should be
the crease hitting the leftedge existing creases. paper completely on perfectly horizontal; if they
in the same place, but now the bboth the near and far aren’t, adjust the crimp and
right edges are aligned. Crease sides of the flap. flatien. ‘Then reverse-fold the
firmly and unfold. white flap to the left
19. Squash-fold the 20, Fold the comer 21, Fold a rabbit ear.
flap over to the right. ‘over to the left,
Tea
22, Bring one layer in 23, Fold one flap |. Repeat steps.
front, thus hiding the down, 13-22 on the right.
lip of the rabbit ear
Origami Design Secrets6604
25, Fold one layer to 26. Fold one flap 27. Open the right side 28, Close the model
the lef down. of the model, which back up.
causes the hidden ede
to squash downward.
W
29. Crimp the left 30, Reverse-fold the comer. 31, Mountain-fold
side upward Note that the mountain fold ‘an edge behind,
aligns with a valley erease Repeat behind.
on the layer beneath, Repeat
behind,
232, Fold the right ed 33, Narrow the flap by 3M. Carefully reverse-fold 35, Outside reverse
overand over, dividing forming a rabbit ear through the thick layers, fold the layers,
theangle in thirds. Repeat behind. The top edge of the reverse
Repeat hehind. fold hits 1
¢ marked spot
Folding Instructions: Pteranodon «>
>
>
36. Mountain-fold the
rear flap to the front
as far as possible
>
>
Y
40, Fold the wing tip
down, Repeat behind.
y
Y
~
44, Pull out some
loose paper from the
leading edge of the
wing. Repeat behind,
37. Fold the topedge
down,
41. Fold the wing tip
buck up so that the left
edge is aligned with
the layer beneati,
Repeat behind,
45. Tuck the small
corner under a raw
edge. Repeat behind.
» Origami Design Secrets
38, Bring the near
wing in front of the
head.
42, Unfold to step 40.
46, Shape the head
and legs.
at
39, Fold the wing
down and unfold
Repeat behind.
$
43. Crimp the wing
on the existing
creases. Repeat
behind
47. Finished Pterunodon.
Hold the neck and fe
and pull to make him fap
his wingsGoattish
1, Begin with a square, colored 2. Fold the paper in half from 3. Bring all four corners
sideup. Fold and unfold along the edge to edge and unfold. together at the bottom,
diagonals. Turn the paper over. Repeat the other direction. ning a Preliminary Fold
Folding Instructions: Goatfish ee eeepb}
ove
4. Petal-fold the front
and back flaps to form,
a Bird Base,
5. Hold one flap
down in front
and one behind,
6. Fold the upper left
eclye down to the
horizontal crease and
unfold. Repeat with
the upper right edge.
8, Pull out some
loose paper as far
28 possible
9. Squash-fold the eomner, 10, Pull out some loose
swinging the white flap paper on the right as in
over tothe lettalonga step 8
vertical valley fold
12, Mountain-fold the
edge underneath
13, Using the existing
creases, bring the two
bottom comers together
while buckling the
middle upward,
14. Reverse-fuld the
cealge inside.
Origami Design Secrets
v
7. Fold one flap up to
the right so that the
right edge is aligned
with the layer
underneath .
AL. Open cut
the flap and
fatten,
15, Repeat steps
7 4 behinw,97% 9
17. Open out the raw 18, Mowntain-fold the 19. Fold the flap in half,
edges and fold the flap comer underneath, forming a small reverse
down and to the right fold as you close it.
q q @
|
20, Reverse-fold the 21. Fold the wo points up 22. Fold and unfold 23. Reverse-fold the
commer. and out to the sides, one tothe split point. pairof pointsto the left,
the left, one to the right. so that the folded edge
Repeat behind. Jines up with the erease
you made in step 21
qtr 9
24. Crimp the bottom, 25, Fold and unfold, 26, Unlold to step 24. 27. Fold and unfold along
that its bottom edge is the right ae
28.Crimp the point 29, Pull out the loose ). Fold sind unfold 31, Outside reverse-
‘using the existing paper completely. fold the flap, then put it
creases, behind the left flap.
Folding Instructions: Goatfish «32, Crimp the left point upward; 33. Fold the flap up
note that the lower ereases are along the folded ed
perpendicular to the edge.
36. Reverse-fold four 37. Crimp the left flap upward on the
comness upward. existing creases; al the same time, push
down some paper from the underside of
the flap to the right of the crimp.
ty
39, Reverse-fold the corner
4»
42, Reverse-told two
‘comers to align with the
folded edges.
40. Unwrap a single layer.
43, Reverse-fold two
ccommers to align with the
folded edges.
124 Origami Design Secrets
34. Fold the flap back to
the left alonga crease
perpendicular to the edge.
35. Unfold to step 33,
38, Mountain-fold the
inside flap as far down as
possible.
u
A. Reverse-fold the comer.
44, Reverse-fold and squash the near
flap up and over to the left, forming
4 long gusset in the layer behind the
flap. Repeat behind,777
45. Reverse-fold one edge. 46, Squash-fold the 47. Turn the paper over.
Do not repeat behind, flap upward.
48. Tuck the ele 49, Turn the paper 50, Vold the thick SIL, Fold one flap down
into the pocket. back over. edge upward in front and behind
52, Fold and unfold, making a 53, Fold the top point down 54. Reverse-fold the edge, tucking
light pinch through the diagonal along a horizontal crease that the excess paper underneath using a
crease, runs through the pinch you just’ vertical mountain fold.
made.
“e,
55. Fold the flap up. 56, Unfold to step 53.
57. Refold, making the cre:
fon the front side match the
creases on the fur side
Folding Instructions: Goatfish «
BeoO
a
wry
58, Mountain-fold the edges 59, Mountain-iold one of the
inside in front and hehind two paired flaps inside.
60, Refold the crimp
you undid! in step 26.
PRP vem yoipe.
61, Outside reverse-fold 2, Pull out the comer
the right side. Repeat behind.
64, Crimp the corner and twist 65. Crimp the right
it upward to the lel, Repeat side underneath,
hehine,
67. Reverse-fold the middle 6% Mountin-old ts botom
point (of three) upward
« Origami Design Secrets
Crimp the point
dona Repeat bel
iw
66, Reverse-fold two inside
corners created by the crimp.
yap
69, Finished Goatfish,