Академический Документы
Профессиональный Документы
Культура Документы
NO YES
X, Y and Z are entry
points for pressure
accessories and/or PED does not apply PED does not apply
assemblies
Go to
X Y
Determine state of Determine state of Manufactured for The volume is more Assemblies referred to in Article 4
appropriate than the YES point
fluid contents fluid contents specific equipment X (2) shall be subjected to a global
nominal size DN? conformity assessment
GAS LIQUID GAS LIQUID YES NO NO procedure comprising:
Determine fluid group* Determine fluid group* Determine fluid group* Determine fluid group* Classified The nominal size DN is more Go to Assessment of each item of
in the same appropriate than the volume?
YES point pressure equipment making
Group 1 Group 2 Group 1 Group 2 Group 1 Group 2 Group 1 Group 2 Choose a Y
category up the assembly and referred
module from
as the NO to in Article 4 (1) which has not
Category IV
Table 1* Table 3* Table 4* Table 5* Table 6* Table 7* Table 8* Table 9* equipment it been previously subjected to a
Table 2*
protects conformity assessment procedure
The nominal size DN
and the volume are and to a separate CE marking;
Determine maximum allowable pressure in bar Determine maximum allowable pressure in bar equally appropriate the assessment procedure shall
and volume in litres and nominal size DN in mm be determined by the category of
each item of equipment;
Use the table to determine the appropriate conformity assessment category Compare the output category,
starting from X, with that
from Y, and take the highest Assessment of the integration
Choose a module from the category or a higher category
Z category of these two of the various components
of the assembly as referred to in
sections 2.3, 2.8 and 2.9 of
SEP Annex I, which shall be determined
CATEGORY II CATEGORY III CATEGORY IV Go to by the highest category applicable
point
+ + +
SOUND MODULE B MODULE B MODULE B to the equipment concerned other
ENGINEERING MODULE A2 MODULE D MODULE C2 MODULE D Z
PRACTICE (DESIGN TYPE) (PRODUCTION TYPE) (PRODUCTION TYPE) than that applicable to any safety
accessories;
CATEGORY I MODULE D1 MODULE B
(DESIGN TYPE) + MODULE F MODULE B
(PRODUCTION TYPE) + MODULE E MODULE B
(PRODUCTION TYPE) + MODULE F
* Conformity assessment tables. To determine which
applies to your asset, use the Lloyd’s Register PED Assessment of the protection of
MODULE A MODULE E1 MODULE H MODULE G MODULE H1 category selection mobile or desktop app, found at an assembly against exceeding
www.lr.org/ped. When reviewing the tables, please the permissible operating limits
note the exceptions.
as referred to in sections 2.10 and
3.2.3 of Annex I, shall be conducted
in the light of the highest category
applicable to the items of
PED modules: Notified Body involvement summarised equipment to be protected.
Manufacturers may select from a range of conformity assessment modules to show the Essential Safety Requirements are met, which include: KEY TERMS
• Manufacturer’s self-certification Please note: The following are summaries of the Notified Body’s CoC – Certificate of Conformity Go to
• Third-party type examination or design examination involvement and are not exhaustive. To determine which applies to DoC – Declaration of Conformity point
• Third-party inspection your asset, use the Lloyd’s Register PED category selection desktop ESRs – Essential Safety Requirements Z
• Quality management system certification tool or our mobile app. Visit www.lr.org/ped for more information. NoBo – Notified Body
To find out more about how Lloyd’s Register can help you, email inspection@lr.org
or visit www.lr.org
Lloyd’s Register assumes no responsibility and shall not be liable to any person for any loss, damage or expense
caused by reliance on the information or advice in this document or howsoever provided.
Lloyd’s Register, LR and any variants are trading names of Lloyd’s Register Group Limited, its subsidiaries and affiliates.
© Lloyd’s Register Group Limited 2018