Академический Документы
Профессиональный Документы
Культура Документы
DSEGenset
ELECTRO-MAGNETIC COMPATIBILITY
The DSE710 is an Automatic Start The module can be controlled from TEMPERATURE
Control Module suitable for a wide a PC that is located up to a BS EN 60068-2-1
Ab/Ae Cold Test -30 oC
variety of single diesel or gas gen- maximum distance of 100 meters BS EN 60068-2-2
set applications. away. Bb/Be Dry Heat +70 oC
VIBRATION
Monitoring an advanced list of The DSE720 is an Automatic Mains BS EN 60068-2-6
engine parameters, the DSE710 Failure Control Module Ten sweeps in each of three
major axes
will automatically shut down the incorporating all the features of the 5 Hz to 8 Hz @ +/-7.5 mm,
engine, or indicate a warning, on DSE710 plus the ability to monitor 8 Hz to 500 Hz @ 2 gn
detection of a fault condition, the mains (utility) supply, HUMIDITY
indicating the fault on the module’s automatically controlling the BS EN 60068-2-30
front panel LCD display or LED. switch-over to generator when the Db Damp Heat Cyclic 20/55 oC
@ 95% RH 48 Hours
mains (utility) power fails. BS EN 60068-2-78
The module can be easly Cab Damp Heat Static 40 oC
@ 93% RH 48 Hours
configured using the DSE810
interface and PC. Front panel SHOCK
editing is also available. BS EN 60068-2-27
Three shocks in each of three major axes
15 gn in 11 mS
DEGREES OF PROTECTION
PROVIDED BY ENCLOSURES
BS EN 60529
IP65 - Front of module when installed into the
control panel with the supplied sealing gasket.
1 2 2 2
DSE710/20
7
OTHER
ISSUE 4
®
DSEGenset
DSE710/20 SPECIFICATION
DC SUPPLY
DSE720 OUTPUTS
AUXILIARY
Solid state
2.4 A DC at supply voltage
FUEL/START
Solid state
3.4 A DC at supply voltage
DSE710
GENERATOR C.T.
5 A secondary 0.5 VA
DIMENSIONS
OVERALL
209 mm x 146 mm x 30.3 mm
8.2” x 5.7” x 1.2”
PANEL CUT-OUT
182 mm x 137 mm
7.2” x 5.4”
RELATED MATERIALS
TITLE PART NO’S
DSE710 Installation Instructions 053-013
DSE720 Installation Instructions 053-005
DSE710 Operator Manual 057-066
DSE720 Operator Manual 057-001
DSE700 PC Software Manual 057-002
Deep Sea Electronics Plc maintains a policy of continuous development and reserves the right to change Registered in England & Wales No.01319649 055-035/08/10 (4)
the details shown on this data sheet without prior notice. The contents are intended for guidance only. VAT No.316923457