Академический Документы
Профессиональный Документы
Культура Документы
Make sure you have the holes for the motor mount stick offset
Important! use prop no larger than 8" Motor mount stick is laminated from ply mm1 the correct direction to give 2 degrees right thrust. Match over these
diameter. Prototype uses on the outsides, and balsa mm2 on the insides. drawings and mark parts for orientation.
cut down GWS 9x7. A larger "compress" the assembly slightly for a snug fit
prop will require lengthening in gearbox. Hinges from small
the landing gear. Important! There are no notches
Forward pieces of CA hinge
F2 MB1 Forward in formers F9A and F9B, the stringers 1 1/4 dihedral EACH tip.
material
Important! Notches in BC1, BC2, BC3, go on top of these. Top and bottom stringers
Battery hatch go all the way to the tail, each one a little
and BH3 face forward.
BH3 shorter than the last so that they follow the
contour of the rear of the fuselage.
BH4 BS1
BH1 BH2
and BH5
BS2
Round toothpicks BH3 BS3 BS3
Bottom nose
Sandwich carbon rod between two H1 BS2
BS1 BS1 stringer locations
H1
Important! score and break fuselage sides at H1
F2 location. Wick with thin CA after Assembly. CG Wing mounts with
small nylon screw 1/8 sq top center stringer
WF2
C1 glued to plastic cowl.
Make locating pins from Center top. stringer is TS1.
Laminate from two TS
round toothpicks and glue to C1 Others are TS2. 1/16 carbon rod
F3 Scrap 1/16 reinforcements F9A
WF1
Glue plastic spinner over GWS
Fuselage side F9B
rubber spinner.
MB2
Sandwich main gear Hitec HS-50 F8
between F5A, F5B, Make these crosspieces from 1/16 scrap
or similar.
MB1 and F5C. F7 to keep covering from bowing sides.
Lower spine
BC1 F6
GWS IPS DX-A F2
C1 F4
F1
MB2
BC1
T4 Fill trailing edge in this area with Ply discs glued to back
scrap balsa to reinforce for wing of wheelpant to keep it
mounting bolt from rotating.