Академический Документы
Профессиональный Документы
Культура Документы
Pantalla anterior
Bienvenido: r080fp2
Producto: WHEEL DOZER
Modelo: 834K WHEEL DOZER L4Y
Configuración: 834K Wheel Dozer L4Y00001-UP (MACHINE) POWERED BY
C18 Engine
Desarmado y Armado
836K Landfill Compactor, 834K Wheel Dozer and 988K Wheel Loader Power Train
Número de medio -KENR6490-06 Fecha de publicación -01/09/2015 Fecha de actualización -05/12/2017
i07203763
Removal Procedure
Table 1
Required Tools
Start By:
Ensure that the machine and tire and or wheel assembly are properly
supported at all times.
Improper procedures that are used to remove and install tires and or
wheel assemblies can result in personal injury or death.
Improper blocking of the rear axle housing can cause personal injury.
Place wood blocks between the rear axle housing and the rear main
frame to prevent oscillation of the rear axle housing.
Illustration 1 g00683293
2. Place suitable chocks in front of the front tires and behind the front tires, as shown.
Illustration 2 g00367854
3. Place suitable block (2) between axle housing (3) and rear main frame (1) on both sides of the
machine, as shown. This will prevent the rear axle housing from oscillating.
Illustration 3 g00683052
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.jsp&called… 2/3
3/7/2018 834K Wheel Dozer L4Y00001-UP (MACHINE) POWERED BY C18 Engine(M0087637 - 05) - Sistemas y componentes
Illustration 4 g00683053
4. Position Tooling (A) under the rear frame, as shown. Make sure that Tooling (A) is positioned under
the frame rails.
5. Use Tooling (A) to raise the rear of the machine until the tires are off the ground.
Illustration 5 g00367856
Note: Do not damage the valve stem when the tire and the rim are removed.
9. Use a suitable lifting device to remove tire (4) and the rim as a unit. The combined weight of the tire
and of the rim is approximately 1590 kg (3500 lb).
Installation Procedure
1. Install tire (4) and the rim in the reverse order of removal.
a. Tighten bolts (5) to a torque of 570 ± 80 N·m (420 ± 60 lb ft). Turn bolts (5) an additional 60° ±
5°.
Copyright 1993 - 2018 Caterpillar Inc. Tue Jul 03 2018 16:46:02 GMT-0500 (hora estándar de Perú)
Todos los derechos reservados.
r080fp2
Red privada para licenciados del SIS.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.jsp&called… 3/3