Академический Документы
Профессиональный Документы
Культура Документы
DHCP services
web server
ftpd
Question2
Refer to the exhibit. Which list refers only to end
devices?
A,D,E,F
A,H,B,C
D,E,F,G
Question3
Refer to the exhibit. A PC is connected to a network.
Which action will verify that the PC can communicate
with its default gateway?
Question4
During the encapsulation process, what identifiers
are added at the transport layer?
Question5
Refer to the exhibit. The tracert command is initiated
from PC1 to PC4. Which device will send a response
to the initial tracert packet from PC1?
Athens
Ankara
PC4
Paris
Question6
A network technician has made a UTP cable that is
terminated as T568A on one end and T568B on the
opposite end. What type of cable has been
constructed?
console
patch
Question7
Refer to the exhibit. Host A is configured with the correct IP address for the default
gateway of the router R1 FastEthernet0/1 interface. How will a packet that is sent from
host A to host B be handled by the devices on the network?
R1 will drop the packet because R1 does not have a specific route in its routing table to the 10.1.1.0/24 n
R1 will forward the packet to its default gateway, the next hop router R2. R2 will forward the packet to
connected network 10.1.1.0/24.
R1 will forward the packet to its default gateway, the next hop router R2. R2 will drop the packet becau
default route to network 10.1.1.0/24.
Question8
Refer to the exhibit. While configuring a network, a
technician wired each end of a Category 5e cable as
shown. Which two statements are true about this
setup? (Choose two.)
Chọn ít nhất một câu trả lời
The cable is terminated in a way that the transmit pin is wired to the receive pin.
Question9
Refer to the exhibit. Which layered network model is
shown in the diagram?
OSI
Cisco
TCP/IP
Question10
Refer to the exhibit. A host is connected to hub 1.
Which combination of IP address, subnet mask, and
default gateway can allow this host to function in the
network?
Question11
Refer to the exhibit. Host A is able to access resources on the local LAN but is unable to
access any resources on the Internet. What is the likely cause of this problem?
Chọn một phương án trả lời.
The host address is a network address.
Question12
Refer to the exhibit. A network technician is trying to determine the correct IP address
configuration for Host A. What is a valid configuration for Host A?
Question13
Refer to the exhibit. Assume all devices are using default configurations. How many
subnets are required to address the topology that is shown?
Question14
Which three IPv4 addresses represent subnet
broadcast addresses? (Choose three.)
Chọn ít nhất một câu trả lời
192.168.4.221 /27
192.168.4.63 /26
192.168.4.129 /26
192.168.4.95 /27
192.168.4.51 /27
192.168.4.191 /26
Question15
Which option shows how a router will route packets
to a remote network?
Chọn một phương án trả lời.
Question16
An organization has been assigned network ID
10.10.128.0 and subnet mask 255.255.224.0. Which
IP address range can be used for this organization?
Chọn một phương án trả lời.
10.10.128.0 to 10.10.192.255
10.10.128.0 to 10.10.160.255
10.10.128.0 to 10.10.0.159
10.10.128.0 to 10.10.159.255
10.10.128.0 to 10.10.159.0
Question17
Refer to the exhibit. All devices in the network use
default configurations. How many broadcast domains
are there in this topology?
11
9
3
Question18
When connectionless protocols are implemented at
the lower layers of the OSI model, what is usually
used to acknowledge that the data was received and
to request the retransmission of missing data?
Chọn một phương án trả lời.
Ethernet
a connectionless acknowledgement
UDP
IP
Question19
Refer to the exhibit. What three statements are true about the IP configuration that is
shown? (Choose three.)
Question20
Which two types of media can provide bandwidth up
to 1 Gb/s? (Choose two.)
Chọn ít nhất một câu trả lời
1000 BASE-TX
100 BASE-FX
10 BASE-T
100 BASE-T
1000 BASE-SX
Question21
Refer to the exhibit. All routers in the network are configured with the correct IP
addresses and routing protocol. Host A sends a packet to host B. Which exhibited steps
will be executed on each of the routers in the network?
Question22
Refer to the exhibit. Host C is able to ping 127.0.0.1
successfully, but is unable to communicate with
hosts A and B in the organization. What is the likely
cause of the problem?
Question23
Which application belongs to the category of the
client/server model?
Chọn một phương án trả lời.
printing a document to a locally connected printer
Question24
Which TCP/IP model layer creates additional
overhead on network resources due to
acknowledgments, tracking, and retransmission of
data?
Chọn một phương án trả lời.
transport
application
network access
internet
Question25
What information is contained in the header of Layer
3 to help data delivery?
Chọn một phương án trả lời.
virtual connection identifier
port number
Question26
Which device should be used for enabling a host to
communicate with another host on a different
network?
Chọn một phương án trả lời.
hub
switch
host
router
Question27
Which combination of network id and subnet mask
correctly identifies all IP addresses from
172.16.128.0 through 172.16.159.255?
Chọn một phương án trả lời.
172.16.128.0 255.255.255.224
172.16.128.0 255.255.192.0
172.16.128.0 255.255.255.192
172.16.128.0 255.255.224.0
172.16.128.0 255.255.0.0
Question28
The hosts in the Accounts office are not on the same subnet as the hosts in the Education office.
The IP address at the serial interface of the router is incorrectly configured.
The subnet mask at the fa0/1 interface of the router is incorrectly entered.
Question29
What information can be gathered by using the
command netstat?
Chọn một phương án trả lời.
the locally configured subnet mask
Question30
A network administrator is asked to design a new
addressing scheme for a corporate network. There
are 60 users in the main office, 40 users in the
branch office, 28 users in manufacturing, 12 in the
sales office, and 4 users in the research office. Which
VLSM addressing scheme that uses the
192.168.88.0/24 network will fulfill the requirements
while wasting the fewest addresses?
Chọn một phương án trả lời.
192.168.88.0/26 main
192.168.88.32/26 branch
192.168.88.64/26 manufacturing
192.168.88.96/27 sales
192.168.88.128/28 research
192.168.88.0/27 main
192.168.88.64/28 branch
192.168.88.80/28 manufacturing
192.168.88.96/29 sales
192.168.88.104/30 research
192.168.88.0/26 main
192.168.88.64/26 branch
192.168.88.128/27 manufacturing
192.168.88.160/28 sales
192.168.88.176/29 research
192.168.88.0/27 main
192.168.88.32/27 branch
192.168.88.64/28 manufacturing
192.168.88.80/29 sales
192.168.88.88/30 research
Question31
Refer to the exhibit. Which option correctly identifies the network address, range of host
addresses, and the broadcast address for the network that contains host A?
destination unreachable
route redirection
echo reply
Question33
Refer to the exhibit. Which type of network design is shown?
peer-to-peer
dedicated server
client/server
Question34
Refer to the exhibit. A router, the table of which is
shown, receives a packet that is destined for
192.168.9.4. How will the router treat the packet?
Question35
A network technician is tasked with setting up a
network for six users, but the users should be able to
use their accounts to log on from any of the six
computers. What type of network should be used?
Chọn một phương án trả lời.
workgroup
client-server network
peer-to-peer network
P2P applications
Question36
To send data through a network, what two flags are
used to establish a session? (Choose two.)
Chọn ít nhất một câu trả lời
Ack #
Port #
CRC
SYN
ACK
Seq #
Question37
Which statement is true about the ICMP protocol?
Chọn một phương án trả lời.
If a host does not respond to an ICMP echo request, the host is not functioning.
Question38
Which range of port numbers are reserved for
services that are commonly used by applications that
run on servers?
Chọn một phương án trả lời.
0 to 255
1024 to 49151
0 to 1023
49152 to 65535
Question39
Refer to the exhibit. Communication for hosts X and Y is restricted to the local network.
What is the reason for this?
Question40
packets between two networks?
Chọn một phương án trả lời.
Layer 2
Layer 1
Layer 3
Layer 4
Question41
Refer to the exhibit. The diagram represents the
process of sending e-mail between clients. Which list
correctly identifies the component or protocol used
at each numbered stage of the diagram?
Question42
Which service is used when the nslookup command
is issued on a computer?
Chọn một phương án trả lời.
FTP
DNS
DHCP
Telnet
Question43
Question44
10.1.192.2
10.1.192.54
192.31.7.1
Question45
Refer to the exhibit. Which two layers of the OSI
model describe the same functions as the transport
and internet layers of the TCP/IP model? (Choose
two.)
Chọn ít nhất một câu trả lời
data link layer
session layer
network layer
physical layer
presentation layer
application layer
transport layer
Question46
Which two functions of the OSI model occur at layer
two? (Choose two.)
Chọn ít nhất một câu trả lời
encoding
routing
physical addressing
cabling
Question47
Refer to the exhibit. Each media link is labeled. What type of cable should be used to
connect the different devices?
10.0.0.0 to 10.255.255.255
172.16.0.0 to 172.31.255.255
127.16.0.0 to 127.31.255.255
200.100.50.0 to 200.100.25.255
150.150.0.0 to 150.150.255.255
Question49
Refer to the exhibit. Host A is requesting a web page
from the web server. Which option represents the
socket to which the request is made?
Chọn một phương án trả lời.
www.cisco.com
10.0.0.130
80
10.0.0.130:80
Question50
Refer to the exhibit. A host is using NAT to connect
to the Internet. Which three IP addresses enable this
connection? (Choose three.)
10.1.1.60
10.1.1.37
10.1.1.39
10.1.1.32
10.1.1.63