Академический Документы
Профессиональный Документы
Культура Документы
____________ are the electron in the outermost shells and the movement of it in a
conductor is the essence of electric
______________are materials where electrons easily move from one atom to another.
_____________source of power, wherein power comes from cells, batteries, power adaptor
_____________an acid reacts with the metal electrodes to produce voltage such as when
chemical energy is converted to electrical energy.
_____________go back and forth or to rotate inside a coil or the coil rotates around a
magnet.
______________is the amount of opposition which limits or opposed the flow of electron
How much current flows in a fluorescent lamp with a resistance of 20 ohms and
connected in a 220 volts power source?
What is the applied voltage to a ten amps bulb with resistance of 6 ohms?
What is the resistance or the amount of opposition to a incandescent bulb with a current
flow of twelve amps to a onehundred ten volts line?
_______________formula;
_______________ A 0.10 amperes LED bulb is connected in a 50 volts line. What is the
electrical power consumption of the LED bulb?
_______________is a unit used for measuring electrical power consumption by engine or
any large machine operated equipment like escalator, elevator, etc.
1horsepower=________watts
_______________is a complete and continuous flow of current through path from the
source to the load and back to the source.
______________a conductor composed of two or more line which supplies passage for
current from the source going to the load.
______________type of circuit where loads are connected end to end along the path in a
single closed loop. Example is Christmas light.
______________a type of circuit where load are connected side by side across the path of
current.
______________ a condition when the amount of total current flowing in circuit is higher
than the ampacity or current capacity of the conductors.
______________a condition when one exposed conductor touches the metal part of the
appliances which may cause voltage drain and brings electrocution when touched.
______________a condition when an exposed conductor from line one and two of circuit
contact with each other without passing any load and makes resistance of the load
becomes unnecessary low. This is one of the most dangerous because it makes the flow of
current very high which cause heat and fire.
______________part of the wiring system extends baryon the final current device protecting
the circuit.
_______________refers to all conductor between service equipment, or the generator
switch board of an isolated plant, and the final branch circuit over current device.
______________it is the overhead service conductor from the last pole connecting to the
service entrance conductor at the building or structures.
Circuit Breaker:___________
_______________these have tapered jaws for making terminal hooks and for making
electrical joints.
______________there are use for cutting wire conductors from no.8 to no. ten. It is also use
for joining big conductors.
_______________these have an oblique cutting jaws for cutting small conductors in cramp
places.
______________a tool used to measure heights for switches and outlets. Also used to center
lighting fixture boxes.
______________a small drilling machine with a chuck capacity of one/fourth to 3/8 inch
used to making holes on metal sheets.
______________this is used for nailing work aside from a lot of other uses. It is used in all
methods of wiring.
______________used for cutting pipes, raceways, and cables. It is also used for cutting big
conductors.
______________ used for removing burrs on newly cut conduits. It is available in different
sizes.
______________used to measure very small distance and it is also used to measure small
diameter and thickness of cable.
_____________these are used for driving wood screws, straightening wires, and tightening
lock nuts.
___________ electrical device which hold incandescent or fluorescent lamps.
___________ a electric device that automatically melts in case of abnormal conditions like
overload and short circuits.
___________device which connects and disconnects the circuit from the line.
___________contains the wiring intersection that allow the wiring in the home or public
building to interface with the main power supply provided by a local utility.
___________a duplex stranded wire used for temporary wiring installation and commonly
used in extension cord assembly.
___________metal or plastic pipes where electrical wires run through. It protects the wires
and usually used in exposed locations such as along the outer surface of the wall.
___________used for fitting resembling a pipe or box with a removal cover for access to
electric conduits.
_____________________ tools in good condition and can execute their regular functions.
__________________failure to meet the required power supply malfunction will occur in the
part of hand tools or equipment.