Академический Документы
Профессиональный Документы
Культура Документы
➤
➤ ➤
➤ ➤
• High Flow Performance
D NOTE: 1.75 Dia. (44mm) hole required
• Diaphragm Operated Design for panel mounting.
P AT
K 39 5 56 7
A
Drain and 40 Micron Element Standard
EN T
P
C
LL
U
LO
• Panel Mountable
Ordering Information
B 11 — 04 W J C /**
Technical Information
Flow Characteristics Flow Characteristics
B11-04DJ B11 / B12
100 100
Secondary Pressure - PSIG
Secondary Pressure - PSIG
Secondary Pressure - bar
Secondary Pressure - bar
1/2-inch Ports 1/4 & 3/8 Inch Ports
6 100 PSIG (6.9 bar) Primary Pressure 6 100 PSIG (6.9 bar) Primary Pressure
75 75
5 5
50 50
3 3
5 5
1 1 B
0 0 0 0
0 0 0 60 80 100 10 0 0 0 60 80 100 10
Rated Flow - SCFM Rated Flow - SCFM
10 0 30 0 50 60 10 0 30 0 50 60
3 3
Flow - dm /s Flow - dm /s
n n
! WARNING ! CAUTION:
Product rupture can cause serious injury. REGULATOR PRESSURE ADJUSTMENT – The working range
Do not connect regulator to bottled gas. of knob adjustment is designed to permit outlet pressures within
Do not exceed maximum primary pressure rating. their full range. Pressure adjustment beyond this range is also
possible because the knob is not a limiting device. This is a
common characteristic of most industrial regulators, and limiting
devices may be obtained only by special design.
For best performance, regulated pressure should always be set
by increasing the pressure up to the desired setting.
Pneumatic Division
B65 Richland, Michigan
www.wattsfluidair.com