Вы находитесь на странице: 1из 5

Columbia-Southern-University CE 1103

Week 7 Assessment
Get help for Columbia-Southern–University CE 1103 Week 7 Assessment. We provide assignment,
homework, discussions and case studies help for all subjects Columbia-Southern-University for Session
2017-2018.

CE 1103 Week 7 Assessment

• Question 1

With the growing concern over litigation involving the improper use of products, warning
labels are becoming an integral part of the manufacturing process. The labels are intended to warn
users about the potential hazards of the product and may warn against improper use. Which of the
following fundamental legal principles is involved in not labeling a large blade hunting knife?

• Question 2

According to Occupational Health and Safety Advisory Services (OHSAS) 18001, a successful
management system should be based on all of the following EXCEPT:
• Question 3

Which of the following emissions control devices are highly efficient filtration devices that
minimally impede the flow of gases through the device and can easily remove fine particulate
matter, such as dust and smoke, from the air stream?

• Question 4

An OSHA recordable includes which of the following?

• Question 5

A commercial motor vehicle transporting hazardous materials is required to display placards


in which of the following locations?

• Question 6

Which of the following is NOT a required training item under the Occupational Safety and
Health Administration (OSHA) Hazard Communication Standard?

• Question 7

Which of the following most correctly defines the purpose of electrical circuit breakers?
• Question 8

__________ is a common and devastating result of some volcanic eruptions, resulting in fast
moving currents of hot gases and rock at speeds greater than 50 mph/80 kmh with gas temperatures
of 1000°C/1800°F, which hug the ground and travel downhill.

• Question 9

Who provides the required placards when shipping hazardous material?

• Question 10

Which of the following would best relate to the term "privity"?

• Question 12

Which International Organization of Standardization (ISO) standard covers environmental


management?

• Question 13

An employee who works in a manufacturing area where presumed asbestos containing


material (PACM) or asbestos containing material (ACM) is being used requests information on PACM.
The employee is entitled to:
• Question 14

What is the primary consideration when preparing for a potential disaster?

• Question 15

Safety and health management systems, such as BSI 18001 series and ANZI/AIHA Z10-2005,
are built on the principles and processes developed by quality pioneer Edward Deming. Which of the
following accurately describes the systems process?

• Question 16

The most effective way to fix accountability for environmental, safety, and health losses is
to:

• Question 17

According to the National Safety Council (NSC), which of the following is NOT included in
good accident investigation procedures?

• Question 18

Which of the following correctly identifies a DOT oxidizer placard?


• Question 19

When making an environmental audit, it is best to follow a defined set of procedures,


sometimes called a protocol. The protocol has three basic areas. Which of the following is NOT
considered as a part of an environmental protocol?

• Question 20

What are the three basic legal principles that can be used by plaintiffs in product liability
cases?

Get Answer: - https://www.justquestionanswer.com/homework-solution-details/53926/ce-1103-


ce1103-ce-1103-week-7-assessment

Вам также может понравиться