Академический Документы
Профессиональный Документы
Культура Документы
3
Application Procedures for 3M™ Scotchkote™
Epoxy Coating 162PWX
Surface Preparation: Steel Surfaces • Airless Spray Minimum 45:1 pump ratio
Coating performance is dependent on the cleanliness of the • Tip pressure typically 4000 psi
substrate surface. It must be clean, dry and free of loose rust • Tip Size 19–25 Thou orifice;
and scale etc.
For small areas, good quality brushes and mohair rollers
Steel surfaces should be abrasive blasted to NACE No 2/ should be used, a material and substrate minimum
SSPC-SP10 near white metal, ISO 8501:1 Grade Sa2½. The temperature of 10°C is advisable when using hand
blast profile is generally specified by the client; a typical application.
profile is 75–100 microns.
Clean all equipment immediately after use with
Application Procedures 3M™ Scotchkote™ Thinners SA65.
Do not apply the product when the relative humidity
Note: When airless spray is being used, excessively high tip
exceeds 90% or when the surface to be coated is less than
spraying pressures should be avoided. The minimum pressure
3°C above the dew point. The minimum temperature of
at the pump conducive with good atomization should be used.
application is 7°C.
Packaging and Storage
Scotchkote Epoxy Coating 162PWX is intended for application
Supplied in 1 litre packs or the Part A (Base) and Part B
in a single coat by plural feed airless spray. A material
(Activator) supplied separately in 18 and 180 litre units, (2 x
temperature of 35–65°C is required, which should be
Part A (Base) + 1 x Part B (Activator).
attained by heating the Part A (Base) and Part B (Activator)
components.
Important Notice
All statements, technical information, and recommendations related to 3M’s products are based on information believed to be reliable, but the accuracy or completeness is
not guaranteed. Before using this product, you must evaluate it and determine if it is suitable for your intended application. You assume all risks and liability associated with
such use. Any statements related to the product which are not contained in 3M’s current publications, or any contrary statements contained on your purchase order shall
have no force or effect unless expressly agreed upon, in writing, by an authorised officer of 3M.
3
Corrosion Protection Products Corrosion Protection Products
3M United Kingdom plc 3M United Kingdom plc
23 Standard Way Industrial Estate 3M Centre
Northallerton Cain Road, Bracknell
North Yorkshire DL6 2XA Berkshire RG12 8HT
United Kingdom Phone: 01344 858000
Phone: +44 (0)1609 780170 Fax: 01344 857970 Please recycle. Printed in UK.
Fax: +44 (0)1609 780438 www.3M.co.uk © 3M 2010. All rights reserved.
www.3M.co.uk/scotchkote 162PWX-1011