Вы находитесь на странице: 1из 4

ST M3219 STA R0 06/13 M3000/M2000 AUTOMATIC CONTROL VALVE language: english

M3219: SURGE ANTICIPATOR / PRESSURE RELIEF VALVE

OPERATING PRINCIPLE

Designed to protect pumping stations against excess pressure. Senses low pressure condition that precedes
high pressure. Relieves high pressure build-up and protects system from over pressure condition.
The valve shall open on a low or high pressure wave. The valve is equipped with two pilots in parallel. The
low pressure pilot, adjusted below normal system operating pressure, it send the valve toward open position
adjustable by flow limiter during the low pressure period created by the pumps shut-off. The relief pilot setted
above the normal system operating pressure, open the valve and mantain the valve in open position during
the over pressure period. The valve is normally mounted in a by-pass of the main pipe line to discharge the
over flow to the atmosphere or into the suction tank.

ADDITIONAL FEATURES AVAILABLE:


 solenoid On-Off control function. A remote control switch on / off the valve position.

1/4
M3000/M2000 AUTOMATIC CONTROL VALVE

The graph shows the effect of water hammer caused by the abrupt pump shut-off. The peaks showed
in the diagramm are dangerous for the system.

Installing a surge anticipator / pressure relief valve however, it is possible to limit the harmful effect of
abrupt shut-off the pump.

2/4
M3000/M2000 AUTOMATIC CONTROL VALVE

CIRCUIT DESCRIPTION

9b

8b

10 6

11

3
5
4

9a
7 2d

8a 2a 2b 2c 2e 2f

ITEM DESCRIPTION MATERIALS


1 Main Valve GJS400-15 EN1563
2 (a,b,c,d,e,f) Isolating ball valve Ni-plated Brass
3 Y - strainer with calibrated orifice 1.4401 EN10088-3 + Brass
4 Monodirectional needle valve 1.4301 EN10088-3 + Brass
5 Pressure reducer pilot CV100 with remote sensing 1.4301 EN10088-3 + Brass
6 Pressure relief/sustaining pilot CM200 1.4301 EN10088-3 + Brass
7 Flow limiter with manual venting Brass+ 1.4301 EN10088-3
8(a,b) Gauge holder with drainage Ni-plated Brass
9(a,b) Pressure gauge 1.4301 EN10088-3 + Glycerine
10 Distributor Brass
11 Drain needle valve “test” 1.4301 EN10088-3 + Brass
-- Pipe 1.4301 EN10088-3
-- Fittings 1.4401 EN10088-3 + Brass

3/4
M3000/M2000 AUTOMATIC CONTROL VALVE

TYPICAL
INSTALLATION

Valve O
n-Off

To system

To storag
e tank
Valve M
3219

Valve O
n-Off

To system
e re

Valve M
3219
sph
a tmo
To

4/4

Вам также может понравиться