Академический Документы
Профессиональный Документы
Культура Документы
Version 5.8.0.5
If you are reading this you have successfully unzipped the files necessary to
update a HN7740. The directory in which the files were unzipped will be the
default directory for the operations that follow.
The intent of this fallback updater is to convert the version of the HN7740
fallback image to 5.8.0.5. The intent of this utility is to update the fallback
image on units that are already manufactured.
The fallback updater is primarily intended for use in the field at installation
time. The fallback updater swaps only a small number of files in the flash file
system of the unit. It is robust and safe to use.
(The corresponding PID updater burns the entire 16 Mbyte image of the flash device,
but if used incorrectly can easily cause the unit to become inoperable. Thus PID
updater is reserved for internal HNS use only.)
REQUIRED EQUIPMENT
You can set up any number of stations to do this repair. Each station must
have:
• Ethernet hub
REQUIRED SOFTWARE
Results
STEP 1
User Input: Type in the IP address of the HN7740 and press OK.
STEP 2
STEP 4
User Input: None
After the above operation is completed, the unit would be rebooted and the user
interface would automatically exit. After the unit boots up, verify that the
banner date of the software is correct.
DIAGNOSTICS:
• Check the LAN connectivity if the user interface displays any of the
messages shown below.
The LAN connectivity can be verified by using the command “ping <IP address of
the HN7740>” from a DOS prompt window on the PC. If the ping is unsuccessful:
• Verify that the cable connecting the HN7740 to the PC is properly plugged
in.
• Verify that the PC has the IP address 192.168.0.2.
After the connectivity has been successfully established, the HN7740 should be
power cycled and the DirecWay Updater program should be restarted. You may also
need to manually terminate the DirecWay Updater user interface (Refer the
section - known issues).
KNOWN ISSUES: