Академический Документы
Профессиональный Документы
Культура Документы
Use Up or Down Keys (or rotary encoder knob on top) to select “Freq”.
Press <exit> - This places the radio back into service mode.
Use Up or Down Keys (or rotary encoder knob on top) to select step.
Press <exit> - This places the radio back into service mode.
3. Set Receive CTCSS Tone: (note; skip to 5 if using DCS {Digital Coded Squelch} or skip to 7 is
using neither.)
Use Up or Down Keys (or rotary encoder knob on top) to select tone.
Press <exit> - This places the radio back into service mode.
4. Set Transmit CTCSS Tone: (note; skip to 5 if using DCS {Digital Coded Squelch} or skip to 7 is
using neither.)
Use Up or Down Keys (or rotary encoder knob on top) to select tone.
Press <exit> - This places the radio back into service mode.
Use Up or Down Keys (or rotary encoder knob on top) to select group.
Press <exit> - This places the radio back into service mode.
Use Up or Down Keys (or rotary encoder knob on top) to select group.
Press <exit> - This places the radio back into service mode.
Use Up or Down Keys (or rotary encoder knob on top) to select frequency.
Press <exit> - This places the radio back into service mode.
Wouxun KG-UVD1 Quick Programming Guide
8. Set Frequency Shift: (Note; this works with step 7. If step 7 is set incorrectly step 8 will not help)
Use Up or Down Keys (or rotary encoder knob on top) to select Shift. (Use “off” if simplex)
Press <exit> - This places the radio back into service mode.
Use Up or Down Keys (or rotary encoder knob on top) to select frequency.
Press <exit> - This places the radio back into service mode.
10. Now Comes the time to program the memories. The memory does not store offsets. Offset is for
VFO (frequency) mode only. You will need to store the transmit and receive frequencies
separately. (Note; This is where most people buy the cable and download the software however,
If you follow these directions you will find you get quicker at storing freqs in memory.)
This example is for a repeater on 147.120MHz with a + offset (or 147.720MHz Transmit
Frequency. Remember all the other information, tones etc will be stored so make sure they are
right.
Enter - 147120
Enter memory number or Use Up or Down Keys (or rotary encoder knob on top) to select
memory.
Wouxun KG-UVD1 Quick Programming Guide
Press <menu> - This saves the setting. (Radio should prompt with Receive Stored)
Press <exit> - This places the radio back into service mode.
Enter – 147720
Press Menu – This stores transmit freq in same memory as last used. (Radio should prompt
Transmit Stored)
Press <exit> - This places the radio back into service mode.
11. Here is where most people get lost because they do not see the programmed channels. You must
change the radio back to Channel Mode.
Use Up or Down Keys (or rotary encoder knob on top) to select “CH”.
Press <exit> - This places the radio back into service mode.
Please note; There are 3 different channel modes. You Choose what you want.
Enjoy.