Академический Документы
Профессиональный Документы
Культура Документы
STV-09-170-WI001
Work instruction Revision No. 1.0
Revision Date 17.10.16
Inspection instruction at final inspection
SUN-TECH.VINA PAGE 1/1
No. 4 1)Remove pull tab scrap for every product need to remove
excess paper of terminal side, checking holes on product.
Checking hole,
2) torn paper, not yet cut ears , ears paper cut off error
pull tab of
terminal side 3) Checking punch holes yet or not, check burr in hole
Burr remain
Burr in hole Property paper remains
No. 5 1) Tape is not cut completely and if mark of knife cutting off
ears is regarded as NG
Checking up
side and bottom 2) Some product have to take out completely ears of paper
side of the paper should not have missed
Burr remain
2) If there is bias cut, offset printing, offset paper, NG part < 1mm
Cutting check cause by cutting wrong which the length from circuit to out
line cutting less than 1mm.
terminal
Final check
terminal
Kiểm NG
tra
lần 2
NG
Biên soạn Kiểm tra Duyệt
항목 검사순서
1.필름 종류의 틀
림: 검사시 옆 사진 OK
L
과 같이 R, L글자
보이면 잘 못 붙인
다(NG).
R
NG
2차
2. 필름 편심불량.
필름이 편심하면 OK
불량이다.
NG
작성 검사 승인