Академический Документы
Профессиональный Документы
Культура Документы
1
2
3
6 5 4
EXTRUDER-DRYER
7
The Processing Advantage to increase barrel life. Flanged barrel ends with
The Model R-120 Extruder-Dryer gives you mating dowels allow perfect alignment.
predictable process control and mechanical Other features include:
reliability. Machine components are engineered • Barrel segments and bushings identical
for minimal wear and easy maintenance. in design. Interchangeable for ease of
1. The Main Drive That’s Best For You replacement.
The R-120 can be supplied with your preference • Breaker pins extend into the machine to
of a standard single-speed motor with Gyrol fluid improve material flow.
drive or variable speed motor. • Bushing area to support main shaft. Inner
2. Heavy-Duty Gear Box diameter hardcoated with Colmonoy #69 for
Ground tooth, hardened, Class 10 helical gears wear resistance. Rockwell C60 hardness.
with crown and tip relief for maximum strength, Designed to wear before bearing worm.
efficiency and quiet operation. Gears have a 2.0 • Rotating worm inside bushing area hard-
service factor. All bearings have a minimum L10 coated with Colmonoy #72 for long life.
life of 100,000 hours for long-lasting service.
Gearbox equipped with forced lubrication 5. Long-Lasting Main Drive Shaft
system. Includes built-in dual basket 100-mesh Constructed of high-strength 17-4 PH stainless
strainer, pump and oil cooler. Oversized thrust steel. Keyed into hollow, low-speed gearbox
bearing for heavy-duty service handles the most shaft. Flight segments fit onto shaft, held in
challenging conditions. place by keyway. Worm flights, rotated at 45°
from previous worm, distribute flight opening
3. 316L Feed Hopper over 360°. This balances side loading when
Precision cast CF3M construction (316L). flight openings are in line.
Designed to accept feed material, the feed
hopper also acts as a connection between 6. Die Plate
the gearbox and main barrel. This provides Constructed of 316 stainless steel. Precision
mechanical efficiency and stability to absorb and drilled to accept die button inserts. Inserts are
transmit thrust loads while supporting the main available in a wide configuration of hole sizes.
barrel. Wedgewire feed hopper bottom allows 7. Heavy-Duty Support Base
easy drainage of free moisture from dewatering Heavy-duty fabricated base provides integral
machine feed. support and allows easy instillation.
4. Segmented Main Barrel Unique Configuration
The R-120 features three barrel segments with French will design special configurations such
wear bushings. Extruder-type barrel segments
French Oil Mill Machinery Co.
as lower L/D ratio and high corrosion-resistant
designed with corrosion and wear-resistant lining Piqua,
alloys to meet your unique Ohio, U.S.A. · 937-773-3420
requirements.
www.frenchoil.com/dryingpress.shtml
R-120 EXTRUDER DRYER
SIDE VIEW
Information in this bulletin was correct at the time of printing; French reserves the right to make design and dimension changes and improvements. ©2011 FOMMCO. All rights reserved.