Академический Документы
Профессиональный Документы
Культура Документы
TEST PLAN
Testing Requirements
Descripition Size Tensile Chemical Hardness Proof Load Microstructure Coating Thk Testing as per Std
Bolt ≤ M6 X √ √ X √ √
ISO 898-1
(Gr 8.8 & 10.9)
≥ M8 √ √ √ X √ √
Nut ≤ M6 X √ √ X √ √
ISO 898-2
(Gr 8 & 10)
≥ M8 X √ √ √ √ √
Washers As per the
Any X √ √ X √ √
(200 & 300HV) description std
As per the
≤ M6 X √ √ X X X description std
SS Bolts
As per the
≥ M8 √ √ √ X X X description std
As per the
≤ M6 X √ √ X X X description std
SS Nuts
As per the
≥ M8 X √ √ X X X description std
As per the
SS Washers X √ X X X X description std
As per the
Galv Screws X √ √ X X √ description std
As per the
SS Screws X √ X X X X description std
Note:- 1) If 10.9 Grade Fasteners HDG / GALV are not supplied from August friedberg, Max Mothes & Peiner then DO NOT use the same.
2) If in certain cases the Tensile testing is not possible then kindly perform the Ultimate load check.
3) If for one bolt size different lengths are available of "SAME MAKE" then randomly select 3~4 samples & perform the test.