Вы находитесь на странице: 1из 2

20/12/2016

OL 18.20
Our packed bed reactor runs the gas phase reaction A → R at 10 atm and
336"C, and gives 90% conversion of a pure A feed. However, the catalyst
salesman guarantees that in the absence of any pore diffusion resistance
our reaction will proceed on his new improved porous catalyst (De =
2E−6 m3/m cat·s) with a rate given by
TUTORIAL KATALIS BERPORI
− ′′′ = 0.88 CA

Okta Bani, MT which is much better than what we now can do. The catalyst is rather
Departemen Teknik Kimia expensive, since it is formulated of compressed kookaburra droppings
Universitas Sumatera Utara
and it is sold by weight. Still, we'll try it when we next replace our
catalyst. What diameter of catalyst balls should we order?

JAWABAN OL18.20 OL 18.21


Agar laju reaksi sesuai dengan klaim penjual, katalis harus bebas dari A reaction A → R is to take place on a porous catalyst pellet (dp = 6 mm,
hambatan difusi, sehingga De = 10−6 m3/m cat·s). How much is the rate slowed by pore diffusional
resistance if the concentration of reactant bathing the particle is 100
MT = mL = ≤ 0,4 mol/m3 and the diffusion-free kinetics are given by

Untuk bola, gunakan L = R/3 = dp/6 sehingga − ′′′ = 0.1



dp ≤ 2,4 = 2,4 = 3,62 E-3 m cat
,

dp ≤ 0,36 cm

JAWABAN OL18.21 OL 18.22


Penurunan kecepatan reaksi dapat dicari dengan menggunakan nilai ε In the absence of pore diffusion resistance a particular first-order gas-
phase reaction proceeds as reported below.
Untuk bola, gunakan L = dp/6 sehingga
− ′′′ = 10−6 mol/cm3 cat·s
( )
MT = at CA = 10−5 mol/cm3, at 1 atm and 400°C
What size of spherical catalyst pellets (De = 10−3 cm3/cm cat·s) would
∙ , ∙
MT = = = 3,9 ensure that pore resistance effects do not intrude to slow the rate of

reaction?
ε = tanh(MT )/MT
ε = tanh(3,9)/3,9 = 0,26
Berarti reaksi diperlambat 74%

1
20/12/2016

JAWABAN OL18.22 FOGLER EX. 12-3


Agar bebas difusi pori, maka The first-order reaction A → B was carried out over two different-sized
pellets. The pellets were contained in spinning basket reactor that was
operated at sufficiently high rotation speeds that external mass transfer

dp ≤ 2,4 = 2,4 resistance was negligible. The results of two experiment runs made under
, ∙ identical conditions are as given in Table E12-3.1.
dp ≤ 0,24 cm (a) Estimate the Thiele modulus and effectiveness factor for each pellet.
(b) How small should the pellets be made to virtually eliminate all
internal diffusion resistance?

JAWABAN FOGLER EX.12-3 (A)


Laju yang diamati: −rA,obs = − rA·ε Kombinasi * dan ** diperoleh
Perbandingan kedua laju menghasilkan perbandingan ε1/ε2 = 3/15 = 0,2 2 tanh(MT2) = tanh(10MT2)
Perbandingan faktor keefektifan juga bisa dicari dengan Penyelesaian pers. di atas: MT2 = 0,55
ε1/ε2 = MT2/MT1 tanh(MT1)/tanh(MT2)…* Nilai MT dan ε tiap pellet:

( )
Ambil modulus Thiele = MT ε
1 0.55 0.910
Pada kondisi identik, seluruh suku dalam fungsi modulus Thiele saling 2 5.50 0.182
menghilangkan, kecuali L sehingga
diinginkan 0.40 0.950
MT1/MT2 = L1/L2 = R1/R2 = 0,01/0,001 = 10…**

JAWABAN FOGLER EX.12-3 (B) DD EX 6.3.2


Agar bebas difusi pori The rate constant for the first-order cracking of cumene on a silica-
alumina catalyst was measured to be 0.80 cm3/(s·gcat) in a laboratory
MTd/MT2 = Rd/R2 reactor:
Sehingga
Rd = (MTd/MT2)·R2 = 0,4/0,55·0,001 = 0,72E−3 m
Radius pellet harus di bawah 0,72 mm Is the observed rate constant the true rate constant or is there influence of
pore diffusion?
*Catatan: versi jawaban di atas berbeda dengan versi Fogler karena
definisi modulus Thiele yang berbeda (ϕ = 3MT ) dan penggunaan Additional data:
formulasi faktor keefektifan berdasarkan katalis bulat. Untuk mendapat Rp = 0.25 cm
jawaban yang sama, nilai MTd yang digunakan harus 0,3.
ρ = 1.2 gcat cm−3
Untuk lebih jelas, silakan lihat di Buku Fogler Bab 12. De = 1.0 × 10−3 cm2 s−1

Вам также может понравиться