Вы находитесь на странице: 1из 5

3/16/2016 Flow of Liquids and Viscosity Solved Examples | askIITians

Solved  Examples  on  Flow  of  Liquids


and Viscosity:­

Question 1:­
Water  is  pumped  steadily  out  of  a  flooded  basement  at  a  speed  of
5.30  m/s  through  a  uniform  hose  of  radius  9.70  mm.  The  hose
passes out through a window 2.90 m above the water line. How much
power is supplied by the pump?

Concept:­
The kinetic energy of the water per unit mass when it leaves from the
uniform hose through the window is

K = ½ v2

Here, mass of the flow of water is  and speed of the water flow is v.

The corresponding potential energy per unit mass of the flow of water
through the window is

U = gh

Here,  acceleration  due  to  gravity  of  the  Earth  is g and  height  of  the
window from the basement is h.

The  volume  rate  of  the  flow  of  water  from  the  hose  through  the
window is

R = vA

Here,  cross­sectional  area  of  the  hose  is A  and  speed  of  the  water
flow is v.

The mass rate of the flow of water is

Rm = ρR

Here, density of the water is ρ.

The power supplied by the pump is given by

P = (K+U) Rm

Solution:­
The cross­sectional area of the hose is

A = πr2

Here, radius of the hose is r.

Insert the values of  in the equation R = vA  gives

2
http://www.askiitians.com/revision­notes/physics/flow­of­liquids­and­viscosity/solved­examples­on­flow­of­liquids­and­viscosity/ 1/5
3/16/2016 Flow of Liquids and Viscosity Solved Examples | askIITians

R = v (πr2)

Using the above values in the equation Rm = ρR

gives

Rm = ρv (πr2)

Substitute  the  values  of  K,  U  and  Rm  in  the  equation  P  =
(K+U) Rmgives

P = [(1/2) v2 + gh] [ρv (πr2)]

To obtain the power supplied by the pump, substitute 5.30 m/s  forv,
9.8 m/s2 for g, 2.90 m  for h,  1000  kg/m3 for ρ and  9.70  mm  for  rin
the above equation gives

 P = [(1/2) v2 + gh] [ρv (πr2)]

   = [(1/2) (5.30 m/s)2 + (9.8 m/s)2 (2.90 m)] [(1000 kg/m3) (5.30 m/s)
(3.14) (9.70 mm)2 (10­3 m/1 mm)2]

   = (14.045 m2/s2 + 28.42 m2/s2) (1.56584578 kg/s)

   = (66.494 kg.m2/s) [1 W/(1kg.m2/s)]

   = 66.494 W

Rounding  off  to  three  significant  figures,  the  power  supplied  by  the
pump is 66.5 W.

_______________________________________________________
_______________________

Question 2:­
A  hollow  tube  has  a  disk  DD  attached  to  its  end  as  shown  in  the
below figure. When air of density ρ is blown through the tube, the disk
attracts the card CC.  Let  the  area  of  the  card  be A and let  v  be  the
average  air  speed  between  the  card  and  the  disk.  Calculate  the
resultant  upward  force  on  CC.  Neglect  the  card’s  weight;  assume
that v0<<v, where v0 is the air speed in the hollow tube.

Concept:­
According to Bernoulli’s equation, the total energy of the steady flow

http://www.askiitians.com/revision­notes/physics/flow­of­liquids­and­viscosity/solved­examples­on­flow­of­liquids­and­viscosity/ 2/5
3/16/2016 Flow of Liquids and Viscosity Solved Examples | askIITians

of air in the hollow tube remains constant.

It is given as

p+ ½ ρv2 + ρgh = constant

Here, pressure of the flow of air is p, density of the air is ρ, speed of
the air in the hollow tube is v, acceleration due to gravity of the earth
at the point of observation is g and position of the flow of air from the
ground is h.

The resultant upward force on the card CC is equal to the difference
in the pressure times the area of the card CC.

Solution:­
Apply  Bernoulli’s  equation  just  before  it  leaves  the  hollow  tube,  the
total energy of the flow of air is

p1+ ½ ρv02 + ρgy1 = constant

Here, pressure of the flow of air just before it leaves the hollow tube
is p1, speed of the air in the hollow tube is v0, and position of the flow
of air from the ground before the air leaves the hollow tube is y1.

On the upper surface of the card CC,  the  total  energy  of  the  flow  of


air is

p2+ ½ ρv2 + ρgy2 = constant

Here, pressure of the flow of air above the car CC is p2, speed of the
air  above  the  card CC is v,  and  position  of  the  flow  of  air  above  the
card CC from the ground is y2.

The  total  energy  for  the  flow  of  air  remains  the  same  when  it  flows
from the hollow tube to the card CC.

Thus,

p1+ ½ ρv02 + ρgy1 = p2+ ½ ρv2 + ρgy2

The position of the flow of air is same for the same flow of air.

Thus,

y1 = y2

Also, it is given that v0<<v.

So, the speed in the hollow tube v0 can be neglected.

Insert  y1  =  y2      and  neglecting  v0  in  the  equation    p1+
½ ρv02 + ρgy1 =p2+ ½ ρv2 + ρgy2

Gives

p1+ ½ ρv02 + ρgy1 = p2+ ½ ρv2 + ρgy2

2
http://www.askiitians.com/revision­notes/physics/flow­of­liquids­and­viscosity/solved­examples­on­flow­of­liquids­and­viscosity/ 3/5
3/16/2016 Flow of Liquids and Viscosity Solved Examples | askIITians

p1 ­ p2 = ½ ρv2

Now, the resultant upward force on the card CC is

F = (p1­p2) A

Substitute ½ ρv2 for p1­p2 in the above equation gives

F = (p1­p2) A

  = ½ ρv2A

Therefore, the resultant upward force on the CC is ½ ρv2A.

_______________________________________________________
__________________

Question 3:­
A siphon is a device for removing liquid from a container that is not to
be tipped. It operates as shown in below figure. The tube must initially
be filled, but once this has been done the liquid will flow until its level
drops  below  the  tube  opening  at  A.  The  liquid  has  density  ρ  and
negligible viscosity. (a) With what speed does the liquid emerge from
the  tube  at C? (b) What  is  the  pressure  in  the  liquid  at  the  topmost
point B? (c) What is the greatest possible height h that a siphon may
lift water?

Concept:­
From  Torricelli’s  law,  the  speed  of  the  water  emerges  from  a
depthh through a hole in a tank is

v =√2gh

Here, acceleration due to gravity is g.

The pressure at the depth h is

p = p0+ρgh

Here,  pressure  at  the  surface  of  the  water  is  p0  and  density  of  the
water is ρ.
http://www.askiitians.com/revision­notes/physics/flow­of­liquids­and­viscosity/solved­examples­on­flow­of­liquids­and­viscosity/ 4/5
3/16/2016 Flow of Liquids and Viscosity Solved Examples | askIITians

Solution:­
(a)  Water  will  flow  in  the  pipe  and  emerges  from  the  point  C.  It  is
considered that water flows from depth equal to the d+h2.

Here, the equivalent depth of the water is

h = d+ h2        

From equation v =√2gh, the speed of the water is

v =√2gh

  =√2g(d+h2)

Therefore,  the  speed  of  the  water  emerges  from  the  point  C  is
√2g(d+h2).

(b) The pressure at the point C is

pC = ρg (h1+d+h2)

 Now, the pressure at the point B is

 pB = p0 – pC

Insert pC = ρg (h1+d+h2) in the above equation gives

pB = p0 – pC

    = p0 ­ ρg (h1+d+h2)

Therefore, the pressure at the point B is p0 ­ ρg (h1+d+h2).

(c) Now, the maximum possible height is obtained as

p0 = ρgh

h = p0/ρg

Substitute  1.01×105  kg/m.s2  for  p0,  1000  kg/m3  for  ρ  and  9.8
m/s2for g in   the above equation gives

h = p0/ρg

= (1.01×105 kg/m.s2)/( 1000 kg/m3) (9.8 m/s2)

= 10.306 m

Rounding off to three significant figures, the greatest possible height
that the siphon may lift water is 10.3 m.

http://www.askiitians.com/revision­notes/physics/flow­of­liquids­and­viscosity/solved­examples­on­flow­of­liquids­and­viscosity/ 5/5

Вам также может понравиться