Академический Документы
Профессиональный Документы
Культура Документы
com
VOLVO
S60/S60R/S80
V70/V70R/XC70/XC90
TP 3985202
2005 SUPPLEMENT
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VADIS.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VADIS.
• Do not install any accessories in the areas between the A and B-pillars, the B and C-pillars,
and the C and D-pillars.
Test terminal
Fuse in cargo compartment auxiliary fuse box.
Volvo models are sold in versions adapted for different markets. These
adaptations depend on factors such as legal requirements, taxation, and
market demands.
This manual may therefore include illustrations and text that do not apply to
the vehicles in your country.
The first part is a type number that describes the This manual contains a section with a list of junction
type of component in question, for example 3/xx. points. This list shows all the components which are
connected to each junction point.
The second part of the designation is a serial num-
ber, e.g. x/2. The location of the junction points is shown in the
"Cable harness routing in vehicle" section.
Combined these give a component designation, for
example 3/2. C. Connectors
Connectors provide a bridge between two cable har-
At the end of the manual is a list of components,
nesses and are described in the "Connectors" sec-
where, with the help of the component designation,
tion.
you can read off the name of the component, for
example, 3/2 = light switch.
D. Electrical distribution
List of type numbers Operation of the fuses and relays is shown in the
"Electrical distribution" section.
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
E. Data communication
Today’s cars are equipped with CAN, LIN & MOST
1 Battery networks that transmit information. Connections to
2 Relay these networks are shown in their entirety on the
3 Switch respective wiring diagram. Complete information on
4 Control module Data communication can be found in the section
5 Driver Information Module entitled "Control modules".
6 Electric motor
7 Sensor F. Abbreviations
8 Actuator A number of different abbreviations are used in the
9 Heating element manual. These are explained in the section "Abbre-
10 Light viations".
11 Fuse
15 Electrical distribution rail/box G. Component location
16 Audio
17 Service/diagnostics There is a section at the end of the manual in which
18 Contact reel the appearance and location of components is
19 Meter described in numerical order.
20 Ignition component/shunt
26 Converter
27 Optics
31 Ground connection
53 Junction point
54 Connector
List of symbols
A F C B E D
= System voltage
30+
1 1
11C/7 11C/6
2 2
= Ground connection via wiring
R
3/254
SWM
1 54/13
nent/chassis
= Screened wire
7
LIN = Junction point
R
4/70
53/534
5 1 R
7/149
RSM 54/16
= Electrical connection
1 GN GN 13
1
2 BN BN CAN
2
53/505
LIN
3
4
VO-W
W
3
VO-W
W
VO-W 8
LIN
= Variant
4
20
= CAN communication
4/56
D:11
54/13
= CAN high data signal (CAN H)
CEM W
14
C:31 20 BN BN
D:58
53/503
D:50 = CAN low data signal (CAN L)
D:35
CAN
D:34
D:49
LIN
= LIN communication
BL-W
BN
6/1 1
L H
2 3 = LIN communication
LIN
BN
= Data communication
SB
BN
53/331
BN
= MOST communication