Академический Документы
Профессиональный Документы
Культура Документы
Product Family No. 41‐21
TECHNICAL UNIT
BRICO Oil Tools provides a dependable line of Wireline Pressure
Setting Tools for the Wireline industry worldwide. Our engineering, high
quality and service provides a cost effective alternative.
The setting tool assembly should be completely taken apart, thoroughly cleaned,
visually inspected and completely redressed after each run in the well bore
regardless of depth, bottom hole pressure or well bore temperature. All tool
failures are the direct result of poorly maintained downhole tools.
Note: The following chart should be used as a general guideline for periodically
tool inspection.
Page 1 ‐ Revised 01/11/14
Setting Tool Inspection Information
Product Family No. 41‐21
TECHNICAL UNIT
Critical Dimensions For Periodic Inspections
Tool components and parts which have become worn, damaged or out of acceptable diameters should be
recorded and replaced with new parts. When the maximum or minimum acceptable diameters are exceeded on
any part or component of the setting tool then the part should be replaced. Use the following tool component
diameters for tool inspection.
Page 2 ‐ Revised 01/11/14
Setting Tool Inspection Information
Product Family No. 41‐21
TECHNICAL UNIT
Ballistics
#10 Standard Power Charge 66-1210200-00
#10 Slow Set Power Charge 66-1220100-00
Secondary Igniters 66-2200020-00
Primary Igniter (PB3 Style) 66-2200010-00
Page 3 ‐ Revised 01/11/14
Setting Tool Inspection Information
Product Family No. 41‐21
TECHNICAL UNIT
BT#10 Setting Tool
Page 4 ‐ Revised 01/11/14
Setting Tool Inspection Information
Product Family No. 41‐21
TECHNICAL UNIT
Redress Kit
19 1 O-Ring 81-0213000-02
20 14 O-Ring 81-0334000-02
21 2 O-Ring 81-0216000-02
Ballistics
#20 Standard Power Charge 66-1220100-00
#20 Slow Set Power Charge 66-1220200-00
Secondary Igniters 66-2200020-00
Primary Igniter (PB3 Style) 66-2200010-00
Page 5 ‐ Revised 01/11/14
Setting Tool Inspection Information
Product Family No. 41‐21
TECHNICAL UNIT
Page 6 ‐ Revised 01/11/14
Setting Tool Inspection Information
Product Family No. 41‐21
TECHNICAL UNIT
Setting Tool Measuring Instruments
Page 7 ‐ Revised 01/11/14