cHUCK
Mount Specifications
Taper Specifications
Tool Shank Standards
TECUMICAL
INFORMATIONTECHNICAL INFORMATION
a Tm UD
The tables below reproduce and
PUTT classify the normal dimensions of
Jacobs® tapers and mounts. They
also observe the generally accepted
designation. In effect, the range of
increasing values for diameter D
contains two No. 2 tapers, the first
of which is No. 2 short taper.
Between the tapers 2 and 3, there
are two interpolated tapers which
bear the out-of-series numbers 33
and 6 respectively.
acobs
ooo 635) O84 same) OSOTAE 503,
ogeso 97st 03884 nao 06525 Hays ZnAST
o5tes _tsol0 047s __raste_— 075000 tam50__ sree __2aasr
05880 41s 04878 12.86 0875002205 OsTRGI__24as7
ges 5880 OSS t4zs7 «0000 5am) TENA 10353,
ogys0__i7s70__osz4t__tsase 1.00000 25.0092 15.822
Osti0 208% 07461 —_tasst 121875 some On 16250
11240-28580 1.0072 26ske 185825 omy BS STS
14130 958001961 nee taT50 arts asa 18773
aL EL ail ‘