Академический Документы
Профессиональный Документы
Культура Документы
PRODUCTS
Division of Sierra Corporation Technical Data
ISO 9001:2008 Certified
3
PRODUCTS
3. PRODUCT DESCRIPTION: PERMEABILITY: complete removal of the curing resin.
TK-5329 FLOOR HARDENER & TK-5329 is breathable, and will allow Work TK-5329 FLOOR HARDENER &
DENSIFIER is a colorless, odorless moisture vapor to pass through the treated DENSIFIER into the surface using a soft
blend of 100% active sodium silicate surface. bristle brush or scrub pad. A mechanical
and siliconate chemicals to strengthen, scrubber must be used to increase the
harden, densify and dustproof concrete - A.I.M.Category: Sealer effectiveness of this product. Work TK-
and masonry floors. TK-5329 FLOOR - A.I.M.Definition: A coating that is 5329 into the surface until it begins to gel
HARDENER & DENSIFIER penetrates formulated and recommended for or become slippery, then rewet the surface
into the concrete, sealing the capillaries application to a substrate for one or more and work for another 10 –15 minutes.
and pores and creating a chemical reaction of the following purposes:to prevent As the surface gels or becomes slippery
with the calcium carbonate (or free lime) in subsequent coatings from being absorbed again, squeegee any excess product away
the concrete to produce a hard, mineral film by the substrate; to prevent harm to and damp-mop the entire area, rinsing the
that is resistant to damage caused by water, subsequent coatings by materials in mop with fresh water every 100-200ft2.
for industrial, warehousing, manufacturing efflorescence; to seal fire, smoke or water the surface must remain saturated with TK-
and food service/processing environments. damage; or to condition chalky surfaces. 5329 FLOOR HARDENER & DENSIFIER
-V.O.C.Compliant - Maximum VOC 100 g/l for a minimum of 30 minutes. Very porous
Advantages: (0.83 lb/gallon) or open concrete surfaces may result in
3
- Allows the concrete to breathe. -USDA authorization for use in meat and faster surface drying. If this occurs, you
- Contains no solvent or fumes. poultry processing facilities. must apply additional TK-5329 and leave
- Does not leave a film-like coating. for 30 minutes.
- Can be used on new or existing concrete. 5.APPLICATION PROCEDURES AND
- Waterproofs by densifying the concrete
INSTRUCTIONS Existing Concrete: Work TK-5329
and sealing pores and capillaries.
- Compatible with floor and carpeting Before using this product, read the FLOOR HARDENER & DENSIFIER into
adhesives and most stripping paints. Material Safety Data Sheet for complete the surface using a soft bristle brush or
- Does not make the floor slippery. safety information. Material Safety Data scrub pad. A mechanical scrubber must
- Resists black tire marks. Sheets are available from TK distributors be used to increase the effectiveness
- Short downtime; floors can be put back and the TK office. of this product. Work TK-5329 into the
into service immediately after treatment. surface until it begins to gel or become
Preparation: slippery, then rewet the surface and work
4. TECHNICAL DATA: The surface must be clean and free for another 10 –15 minutes. As the surface
Nontoxic, noncombustible. Complies of dirt, oil, curing compounds or foreign gels or becomes slippery again, squeegee
with all V.O.C. Regulations. materials. Patch all cracks and remove any excess product away and damp-mop
any laitence. Any cleaners need to be the entire area, rinsing the mop with fresh
APPLICABLE STANDARDS: thoroughly rinsed off. The surface can water every 100-200ft2.
- ASTM C-42 IMPACT: increases be damp, but must not have any standing
impact resistance. water as it will dilute TK-5329 and affect its In order for the proper reaction to occur,
- ASTM C-779 ABRASION: 33% performance. the surface must remain saturated with TK-
increase in abrasion resistance. 5329 FLOOR HARDENER & DENSIFIER
- ASTM D-3359 BONDING: 16.7% for a minimum of 30 minutes. Very porous
or open concrete surfaces may result in faster 6. AVAILABILITY
surface drying. If this occurs, you must apply TK-5329 FLOOR HARDENER & FOR INDUSTRIAL USE ONLY
additional TK-5329 and leave for 30 minutes. DENSIFIER is available through TK
If the floor is to be applied with any Distributors. Contact TK Products for for the 02/13
subsequent coatings or carpet or tile nearest distributor.
adhesives, wait 30 minutes then flush with Packaged in: 55-gallon drums, 5-gallon pails
water and squeegee dry. and 1 gallon cans.