Академический Документы
Профессиональный Документы
Культура Документы
RHEOMIX 141
Multi-purpose admixture for cementitious systems. Waterproofs and improves mortars.
Bonding agent.
Standards
Packaging
WRC (Water Research Council) approved for use
RHEOMIX® 141 is supplied in 20 and 200 litre
with potable water.
containers.
Safety precautions
Effects of over dosage
Avoid contact with eyes and prolonged contact
The recommended levels should not be
with skin. During application always wear gloves
exceeded. Gross overdosage at an acceptable
and appropriate clothing to minimise contact. In
workability is not likely, but will result in an
case of contact with eyes, immediately flush with
increase of the polymer properties to the
plenty of water for at least 15 minutes. Should
detriment of the compressive strength.
skin contact occur, wash immediately with soap
Specification clause and water. Seek the advice of a physician should
All cementitious mixes stated shall be modified symptoms persist.
with RHEOMIX® 141, styrene butadiene
Note
copolymer Iatex, manufactured by BASF or similar
Field service, where provided, does not constitute
approved, to the following specification:-
supervisory responsibility. For additional
Composition A milky, white styrene butadiene information contact your local BASF
copolymer latex, specifically made representative.
for use with Portland cement. BASF reserves the right to have the true cause of
pH 10.5. any difficulty determined by accepted test
Specific gravity 1.01.
methods.
Mean particle 0.17 micron.
size Quality and care
Butadiene 40 +/- 1% by weight of RHEOMIX® All products originating from BASF’s Dubai, UAE
content 141 polymer. facility are manufactured under a management
The material shall be used in bonding slurries at system independently certified to conform to the
the rate of approximately 1 volume of RHEOMIX® requirements of the quality, environmental and
141 to 1½ to 2 volumes of OPC cement and in occupational health & safety standards ISO 9001,
cementitious mixes at the rate of 5 or 10 litres per ISO 14001 and OHSAS 18001.
50kg cement, as recommended in the 04/94 BASF_CC-UAE revised 09/2005
manufacturer's literature.
* Properties listed are based on laboratory controlled tests.
Whilst any information contained herein is true, accurate and represents our best knowledge and experience, no warranty is given or implied with
any recommendations made by us, our representatives or distributors, as the conditions of use and the competence of any labour involved in the
application are beyond our control.
As all BASF technical datasheets are updated on a regular basis it is the user's responsibility to obtain the most recent issue.