Академический Документы
Профессиональный Документы
Культура Документы
26 m
Effective length of corbel = 2.9 m
Depth d1 = 0.45 m d1
Depth d2 = 0.6 m d2
self weight of corbel = 45.68 kN
Doubly
Result - Design of Section as
Reinforced
Bottom Reinforcement
Dia of bar used mm 20
Area of Steel Required (Ast1) mm2 853
-
m
kN/m2
Mpa
Mpa
N/mm2
Location (m)
ANNEXURE-IIC
N OF BEAM RESTING ON CORBEL
ANNEXURE-IIC
N OF BEAM RESTING ON CORBEL
OK
d < L/350 for other beams
Material Data:
Characteristic strength of concrete fck = 25
Characteristic strength of steel fy = 500
Clear cover to main reinforcement d' = 25
Design Input:
Overall Depth D= 250
Overall width considered b= 1000
Diameter of main Reinforcement bar = 16
Effective depth available d= 217
Depth required = 158
Effective depth available is more, Hence OK
Design forces from STAAD
Mx My SQx SQy
S. No. Plate No. L/c Remarks
kNm/m N/mm2
1 27191 104 68.133 35.411 0.019 0.065 @ bottom
2 27175 104 -83.162 -29.716 -0.31 -0.306 @ top
3 27203 102 65.62 46.911 -0.026 -0.004 @ bottom
4 27240 145 -49.024 -40.961 -0.293 -0.232 @ top
5 27240 139 -60.7 -38.684 -0.386 -0.267 -
6 27278 123 -38.81 -14.693 0.344 -0.142 -
7 27186 102 -81.159 -30.428 -0.321 0.45 -
8 27098 147 -16.412 15.361 -0.126 -0.399 -
Note: Concentrated stresses in plates under column, walls and point loads are not considered in the above
table. Punching shear check is performed for concentrated loads due to equipment
However, it is observed from the shear stress contours that the stresses is within the permissible limits in
most of the area. There are higher shear stresses in some localized area and these are neglected.
Check for punching
length of equipment mm
foundation 300 Node L/c Fy (kN)
Width of equipment mm
foundation 300 - - 120 (Assumed)
mm
mm
mm
mm
mm
Pt
0.46
0.26
Pt
0.46
0.26
N/mm2
%
N/mm2
he section is SAFE
e permissible limits in
are neglected.