Вы находитесь на странице: 1из 4

PA-44 PIPER SEMINOLE CHECKLIST

PRE FLIGHT Propeller........................Check


COCKPIT Fuel...............................Check

PIPER SEMINOLE AROW............................... Check


Landing gear handle.......... Down
Tie down and chock.. Remove
Stall warning vane.........Check
Pitot- Static....................Check
PA44-180 Control lock....................Remove
Battery switch........................ On
Gear light.......................... Check
Light..............................Check
Aileron...........................Check

CHECKLIST Fuel gauge........................ Check


Navigation light................. Check
Flap...............................Check
EMPENNAGE
Pitot heat........................... Check Rudder, Tubs.................... Check
Battery switch........................ Off Stabilizer........................... Check
Trims..........................Set for T/O Tail cone............................ Check
Flap................................... Check Tie down........................Remove
RIGHT WING RIGHT FUSELAGE
Flap................................... Check Drain(2)............................. Check
Aileron............................... Check Baggage door.................... Close
Lights................................ Check
Fuel................................... Check PRE START
Tie down and chock.......Remove Seat....................Adjust and lock
Engine oil.......................... Check Belt,harness................. Fastened
Engine air intake............... Check Brake.....................................Set
Propeller-Check Circuit breakers-....................... n
Engine cowl and door....... Check Landing gear handle.......... Down
Cowl flap........................... Check Avionics.................................. Off
Tire, Brake, Strut, Trunnion......... Cowl flap............................ Open
.......................................... Check Auto pilot................................ Off
NOSE SECTION Fuel selector.......................... On
Carburetor heat...................... Off
Landing light..................... Check
Battery switch........................ On
Well door, Tire, Strut......... Check
Landing gear............Three green
Window shield....................Clean
NICE AIR LEFT WING
Alternators............................. On

Cowl flap........................... Check


Tire, Brake, Strut, Trunnion.........
.......................................... Check
Engine oil.......................... Check
Engine air intake............... Check
Propeller........................... Check
Engine cowl and door....... Check

Nice Air 2575 Robert Fowler Way, San Jose, CA 95148 Nice Air 2575 Robert Fowler Way, San Jose, CA 95148
PA-44 PIPER SEMINOLE CHECKLIST PA-44 PIPER SEMINOLE CHECKLIST

STARTING ENGINE Carburetor heat................. Check Cruise SHUT DOWN


Alternator.......................... Check Power.....................................Set Parking brake.........................Set
LEFT ENGINE
Suction................ 4.8 to 5.2 in-hg Trim........................................Set Avionics.................................. Off
Magneto switches.................. On Throttle....................... 1000 RPM Mixture.............................. Adjust Electrical switch..................... Off
Mixture................................. Rich Annunciator panel............. Check
Propeller.....................High RPM
Engine temp................Monitor Propeller.....................High RPM
Flight instrument............... Check Cowl flap...................As required Throttle....................... 1000 RPM
Throttle.....................1/2 in. Open Flight control.....Free and correct Mixture....................... Idle cut-off
Prime........................As required Flap................................... Check DESCEND
Magnetos............................... Off
Fuel pump.............................. On Engine gauge.................... Green Altimeter.................................Set Battery switch........................ Off
Propeller area.....................Clear Friction.................................Lock Fuel selector.......................... On Alternators............................. Off
Starter.................................... On Radio.....................................Set Cowl flap.......................... Closed Control lock............................Set
Throttle....................... 1000 RPM Doors and windows.............Lock Power........................As required Parking brake......................... Off
Oil pressure..... 25 PSI in 30 sec. Parking brake......................... Off
BEFORE LANDING Tie downs.........................Secure
Ammeter........................... Check
Suction.............................. Check TAKEOFF Seat belt....................... Fastened V-SPEED
Fuel pump.............................. Off Seat belt....................... Fastened Fuel selector.......................... On Vmc-Red line......................56 Kt
RIGHT ENGINE Fuel selector.......................... On Mixture................................. Rich Vyse-Blue line.....................88 Kt
Trim........................................Set Fuel pumps............................ On Vxse....................................82 Kt
Repeat above
Flap........................................Set Auto pilot................................ Off Vsse....................................82 Kt
Mixture.................... Lean for taxi
Mixture...................................Set Landing light.............As required Vy........................................88 Kt
Storobo light........................... On
Prop............................High RPM Gear................................... Down Vx........................................82 Kt
Radio..................................... On
Fuel pumps............................ On Flap...........................As required Vso......................................55 Kt
Transponder ................. Stand by
Transponder............................ Alt Prop............................High RPM Vs1......................................57 Kt
TAXING Takeoff briefing...........Completed GUMPS Va......................................135 Kt
Parking brake......................... Off Normal landing....................80 Kt Vno...................................169 Kt
Brake................................ Check
AFTER TAKEOFF
Short field.............................75Kt Vne....................................202Kt
X feed............................... Check Gear........................................Up
AFTER LANDING Vle......................................140Kt
Flight instruments............. Check Flap.........................................Up
Vfe ................................ 111Kt
Cruise climb.......................105Kt Flap..................................Retract
BEFORE TAKEOFF Throttle................................... 25” Fuel pumps............................ Off
Parking brake.........................Set Prop........................... 2500 RPM Landing light.......................... Off
Cowl flap............................ Open Fuel pumps............................ Off Cowl flap............................ Open
Fuel selector.......................... On Mixture...................................Set Mixture.................... Lean for taxi
Mixture................................. Rich Engine temp.................... Monitor Trim.......................Set for takeoff
Prop............................High RPM Cowl flap...................As required Transponder.................. Stand by
Throttle....................... 1500 RPM
Prop................................Feather
Throttle....................... 2000 RPM
Prop.............................. Exercise
Magnetos.......................... Check
.................. Max drop 175/50 diff.

Nice Air 2575 Robert Fowler Way, San Jose, CA 95148 Nice Air 2575 Robert Fowler Way, San Jose, CA 95148
PA-44 PIPER SEMINOLE CHECKLIST PA-44 PIPER SEMINOLE CHECKLIST

EMERGENCIES EMERGENCIES
ENGINE OUT PROCEDURE RESTARTING INOPERATIVE ENGINE
Heading............................................Rudder and bank Fuel selector............................................................On
Airspeed ...................................................Vyse(88 Kt) Magneto...................................................................On
Mixture........................................................... Both rich Mixture.................................................................. Rich
Prop..................................................... Both high RPM Propeller...................................................... High RPM
Throttle........................................................ Both open Throttle................................................. One inch open
Flap..........................................................................Up Fuel pump................................................................On
Gear.........................................................................Up Starter.............................................................. Engage
Identify dead engine............... Dead foot, dead engine After start.................................. 15” MP and 2000RPM
Verify dead engine............. Dead engine throttle-close Oil pressure ...................................................... Check
Alternator.................................................................On
Check altitude Cowl flap.............................................................Adjust
-below 2000’ AGL.......................... Feather and secure Fuel pump................................................................Off
-above 2000’ AGL...................................Trouble shoot CROSS FEED
Fuel pump................................................................On
-Engine gauge............................. Check Receiving side............................................ Cross feed
-Fuel pump........................................ On Sending side............................................................Off
-Fuel selector...............................X feed Fuel pump................................................................Off
-Primer............................................Lock
-Carb heat......................................... On SINGLE ENGINE LANDING
-Magnetos....................................Check Dead engine.................................................... Feather
-if still dead............ Feather and secure Approach..................................................... As normal
Airspeed.................................... Blue line until on final
SECURE DEAD ENGINE Gear.......................................Up until landing assured
Flap...........................................................Up until final
Fuel pump................................................................Off GUMPS
Mixture.........................................................Idle cut-off
Fuel selector............................................................Off
Magneto...................................................................Off
Alternator.................................................................Off
Carb heat.................................................................Off
Cowl flap............................................................. Close
Good engine cowl flap.........................................Open
Electrical load......................................Monitor, reduce
Fuel management..................... Cross feed as needed

Nice Air 2575 Robert Fowler Way, San Jose, CA 95148 Nice Air 2575 Robert Fowler Way, San Jose, CA 95148
PA-44 PIPER SEMINOLE CHECKLIST PA-44 PIPER SEMINOLE CHECKLIST

EMERGENCIES EMERGENCIES
SINGLE ENGINE GO AROUND LANDING GEAR EMERGENCY EXTENSION
Mixture.................................................................. Rich Master switch...........................................................On
Propeller...................................................... High RPM Circuit breaker................................................Check in
Throttle................................................................Open Navigation light........................................................Off
Gear.........................................................................Up Airspeed................................................. Below 100 Kt
Flap...................................................................Retract Landing gear handle........................................... Down
Airspeed.........................................................Blue line Manual ext. lever................................. Pull and fishtail
Slight bank into good engine Green light......................................................... Check

ENGINE FIRE(Ground) WARNING


Mixture.........................................................Idle cut-off After emergency landing gear extension, do not move any
Starter.............................................. Continue to crank landing gear controls or reset circuit breakers until airplane
Throttle................................................................Open is on jacks.
Fuel selector............................................................Off
Electrical pump........................................................Off PROP OVER SPEED
Throttle............................................................. Closed
ENGINE FIRE(In Flight) Airspeed............................................................. 100Kt
Mixture.........................................................Idle cut-off Propeller.......................................................Low RPM
Fuel selector............................................................Off Throttle......... Open Slowly until governors is engaged
Propeller.......................................................... Feather Prop..... Slowly increase and throttle to desired setting
Fuel pump................................................................Off Continue flight................ At reduced speed and power
Magneto...................................................................Off
Alternator.................................................................Off RUNAWAY ELECTRICAL TRIM
Good engine................................................Full power Apply control pressure as needed for attitude control
Shallow dive to blow out the fire Trim interrupt.................................................. Depress
Trim......................................................................... Set
ELECTRICAL FIRE IN FLIGHT
Battery switch..........................................................Off LOSS OF OIL PRESSURE
Air vent................................................................Open Throttle............................................................. Closed
Cabin heat...............................................................Off Mixture.........................................................Idle cut-off
Land as soon as possible Propeller.......................................................... Feather
Secure engine and continue flight

Nice Air 2575 Robert Fowler Way, San Jose, CA 95148 Nice Air 2575 Robert Fowler Way, San Jose, CA 95148

Вам также может понравиться