Академический Документы
Профессиональный Документы
Культура Документы
positive and negative rotation, timing, limiting, speed regulation and other functions, Suitable for 42 / 57
stepping in 3A phase / four phase / four wire / six wire stepper motor, not suitable
for more than 3A stepper motor,Using TB6560AHQNew original chipThere are low
voltage shutdown, overheat shutdown and over-current protection circuit to ensure
the best performance
2:Module interface description:
1,DC+External DC power supply positive pole 2,DC-External DC power supply negative pole
3,IN1:Forward/Limit4,IN2:Reversal/Limit5,IN3:Function/Stop it
3:Operatingvoltage:DC 10V-35V
4Time range:minimum0.01Seconds, Max999Seconds are adjustable
5Function description:
P-1:
F-0: inching
F-1: self locking
F-2: fixed point: to signal 1, is moving to set time automatically stop, give the signal 2, turn back to set time automatically
stop
P-2:
F-0: press the start button, turn to the limit, stop, and then press the start button to reverse, stop to the
limit
F-1: press the start button, turn to the limit, stop for a period of time to reverse, and then to the limit, stop
for some time, turn, reciprocating cycle, then press the start button to pause
F-2: press the start button, turn to the end of the limit, stop for a period of time reversal, and then to the
starting point limit stop, in the process press the start button to pause
P-3:
F-0: to signal 1: turn forward, turn to reverse after setting time, then turn to stop after setting time
F-1: to signal 1: forward, reverse, forward, reverse, and wireless.... Signal 2: reverse, positive, reverse,
positive, wireless....
F-2: to signal 1: forward, stop, reverse, stop, forward, stop, reverse, wireless loop.... To signal 2: reverse,
stop, forward, stop, reverse, stop, turn, wireless loop...
5Setting instructions:
Press the settings button to enter mode selection, press shortSet the key to enter the time setting
When the digital tube flashes: "^" key: adjust the time plus
"V" key:Adjustment time minus
When you display "0-.-" or "1-.-";"^" key:Adjust the decimal point position of the first set of time