Академический Документы
Профессиональный Документы
Культура Документы
NOTE
(Windows only) Connect the USB cable to the same USB port used when installing the Yamaha
Steinberg USB Driver. If you use a different USB port, you will need to install the Yamaha
Steinberg USB Driver once again.
3. Double-click the Cubase series shortcut on your desktop to start the Cubase series application.
4. If the [Select ASIO Driver] window appears while the application is starting, make sure the MG-
XU series console is selected and then click the [OK] button. If this window does not appear, the
application will start normally.
6. Select [VST Audio System] from the list on the left side.
7. For ASIO driver, select [Yamaha Steinberg USB ASIO] (Windows)/[MG-XU] (Mac).
8. Click [OK].
Audio I/O settings
3. If the device port with the bus name [Stereo In] is set to [Not Connected], click to set it to [MG-
XU - 1] (left) and [MG-XU - 2] (right).
4. Click the [Outputs] tab.
5. If the device port with the bus name [Stereo Out] is set to [Not Connected], click to set it to
[MG-XU - 1] (Windows)/[MG-XU L] (Mac) (left) and [MG-XU - 2] (Windows)/[MG-XU R] (Mac)
(right).
6. When these settings are complete, click the X mark in the top right corner to close this window.
This completes the settings.
NOTE
- Connect only one device that supports the Yamaha Steinberg USB Driver.
- (Windows only) Connect the USB cable to the same USB port used when installing the Yamaha
Steinberg USB Driver. If you use a different USB port, you will need to install the Yamaha
Steinberg USB Driver once again.
Windows
Set the ASIO driver to Yamaha Steinberg USB ASIO.
Mac
Select “MG-XU “as the audio interface to use.
This completes the settings.
Mixer settings
For MG20XU/MG16XU/MG12XU
2. Press the [ST] switch for the stereo channel that you set to USB and channels connected to
mics.
3. Turn on all channels to be used, and adjust the levels as necessary.
4. Turn on the [PFL] switch for the stereo channel that you set to USB.
Only this channel can be monitored. Audio from mics connected to other channels will not be
audible.
2. Set the [TO MON/TO ST] switch on channels 9/10 to [TO MON].
3. Adjust the level for channels 9/10 as necessary.
When you turn on the [STEREO MUTE] switch for MONITOR/PHONES, you will not be able to
directly monitor audio from mics, etc. inside the mixer. However, the audio signal passes through
the stereo bus and on to the computer. Audio signals that pass through the DAW software on the
computer are sent to channels 9/10 (set for USB). If you set channels 9/10 to [TO MON], you can
monitor the audio signal from the DAW software. This allows you to monitor only the audio signal
via the DAW software.