Академический Документы
Профессиональный Документы
Культура Документы
The vacuum pump can be installed inside the dental office in a room aside of the main working or in a room proper for the installation of The well functioning and durability of the gnatus dental set are directly influenced by the pre-installation,
machinery. It’s important that the room to be protected from humidity, direct exposure to the sun rays and with good ventilation. which should done according to instructions in this plant.
G - WATER- PVC tube welding acceptable Ø 20 mm, glove at the Directions to preparing the pre-installation of the dentist’s this division, imagine the face of a clock, trace the concentric circuits
LOCATION OF CONNECTION POINTS tip with tin plug of Ø 20 X 1/2 ” in contact with the floor connected to (A),(B),(C) with its radius of 0.5, 1.0, 1.5 meters respectively,
the water supply. office considering the center as the patient’s mouth lying on the chair.
In order to ensure the correct operation of the dentist’s office, we
H - SUCTION- PVC tube welding acceptable Ø 25 mm, glove at recommend that a qualified technician perform the pre-installation.
the tip with tin plug of Ø 25 x 3/4” in contact with the floor connected Any damage to the equipment caused by a failure (electrical, Cautions when installing the compressed air
to the point “H” of the connection box. hydraulic or pneumatic) in the pre-installation will not be covered by We recommend that the air used to activate the equipment be
the warranty. filtered to avoid oil, humidity and solid particles be introduced in the
I - DRAINING- PVC tube welding acceptable Ø 40 mm, glove at interior of the it affecting important internal parts such as valves, etc.
This procedure helps to maintain internal components and hand
the tip with tin plug of Ø 25 x 3/4” in contact with the floor connected Dear customer pieces in good shape.
to the inspection box (with a minimum decline of 2%). Congratulations. You have made a good choice when you
It’s important the drain to be independent from the other tubing It’s very important to choose the compressor specifications well
decided to buy a GNATUS QUALITY product comparable to the best
system as to avoid reflux. to assure the best possible performance of all the equipment.
products available in the World. This manual is a general
presentation of your product and it will give you important details
J – SUCTION CONTROLS– Flexible electro duct of Ø 20 mm We must also point out to you our chain of authorized dealers. • Ideal working pressure for a Gnatus dental set = 80 PSI
ending at 50 mm above the floor with wires of 3 x 0,75 mm² (different Only dealers that make part of this chain will be able to keep your • Maximum air consuption of a Gnatus dental set = 80 l/min
colors), 200 mm above the electro duct connected to the point J of equipment constantly new for they count on technical assistants
the connection box. who have been trained and on spedific tools for the correct
maintenance of your equipment.
POWER OUTLET – Wires of 3x2,5mm² (live wire/ground). Doubts and information: GNATUS Call center (55-16) 2102-
5000.
Electrical installation orientation.
To ensure a proper functioning of the Equipment, please be Dental set ergonomic installation
aware of the voltage and the wires diameter specified by factory. To obtain the best office space distribution, the place must be
chosen to provide comfort to the operator in order to obtain good
Voltage(V) Cable diameter (mm²) Distance (m) productivity.
IV For this reason the equipment installation must be done under
C 12 7 2,5 Up to 20
A the strict recommendations by the I.S.O.(International Standards
-V
O
I 12 7 4 OF 21 up to 40 Organization) and the I.D.F. (International Dental Federation).
B
To asses the equipment installation the I.S.O./I.D.F. made as a
22 0 2,5 Up to 50
standard to divide the room in areas (see illustration). To perform POWER RATING
Voltage(V) Cable diameter (mm²) Distance (m)
I
TOP VIEW
(MEASUREMENTS IN MILIMETERS) C
A
127 2,5 Up to 30
V
-
SYNCRUS DENTAL CHAIR 200 VA
127 4,0 OF 31 up to 50
IO
B
220 2,5 Up to 50 SYNCRUS GL DENTAL CHAIR 200 VA
NOTES:
PERSUS L DENTAL LIGHT 55 VA
• The distance specified on the table above is from the distribution
box up to the installation of the equipment.
• The diameter of the wires that feed the main distribution box PERSUS GL DENTAL LIGHT 55 VA
must be larger than the ones specified above.
STORUS GLX DENTAL LIGHT 60 VA
of the hand pieces). This room should also have two stools.
AMALGAMIX II 110 VA
41 41
ni ar dti nu r et a W- t ni o P- D* r ot c enno C- 11
sl ort no C noi t c u S - t ni o P- J* r et pada es oh " 2/ 1 Ø- 01 ni ar dti nu r et a W- t ni o P- D * el ppi n dedaer ht " 4/ 3 - 80
r et a W- t ni o P- G* noi t c ennoc t el ni r et a w" 2/ 1 Ø- 90 r et a W- t ni o P- G * wobl e " 4/ 3 º 09- 70
ni ar D- t ni o P- I * el ppi n dedaer ht " 4/ 3- 80
noi t c u S- t ni o P- H* wobl e " 4/ 3 º 09- 70 kr o wt en yti ci rt c el E- ni darroDc-r tenw
io
oPP-- I1 *
4 rreect u
pdae
dra" e
2/s1o-h" "4/4/33LLØ-- 60
50
” 2/ 1 ot ” 4/ 3 r ec uder el badaer h T- 71 r et pada es oh " 4/ 3 Ø- 60 noi t c u S – " 2/ 1 Ør A muc aVl v S, es o H- 31 ni ar dti nu r et a W– " 4/ 3 Ør A muc aVl v S, es o H- 40
) et udl aci rt c el E( l ort noc noi t c u S – s eri w² mm57, 0 Ø 3 - 61* ni ar dti nu r et a W– " 4/ 3 Ør A muc aVl v S, es o H- 40 ni ar D- " 4/ 3 Ør A muuc aVl v S, es o H- 21 r et a W- mm5, 8x 0, 6 neer G u P, eso H- 30
kr o wt en yti ci rt c el E- dr oc r e wo P- 41 r et a W- mm 5, 8x 0, 6 neer G u P, es o H- 30 r ot c enno C- 11 noi t c u S- " 4/ 3 Ør A muc aVl v S, es o H- 20
noi t c u S – " 2/ 1 Ør A mucaVl v S, es o H- 31 noi t c u S- " 4/ 3 Ør A muc aVl v S, es o H- 20 noi t c ennoc t el ni r et a w" 2/ 1 Ø- 90 l ort noc noi t c u S – s eri w² mm57, 0 Ø 3- 10
ni ar D- " 4/ 3 Ør A muuc aVl v S, es o H- 21 l ort noc noi t c u S – s eri w² mm57, 0 Ø 3- 10
s ut a n Gy b deil ppust onl ai r et a M* at a Dl ar ene G
s ut a n Gy b deil ppust onl ai r et a M* at a Dl ar ene G I
61 J D 80
90 G J H D
G 70
60
G 80 70
H 61 40
40 90
71 11 11 30 30
90 30 10 31
01
31 I
50
60 60 20
60
20
21 11
30 10 10
10 21
41
41
ECI FF OS’ TSI T NE DE HT E DI S T UO NOI TALL ATS NI II C A V OI B ECI FF OS’ TSI T NE DE HT E DI S NI NOI TALL ATS NI II C A V OI B
BIO VAC IV INSTALLATION OUTSIDE THE DENTIST’S OFFICE INTERNAL CONNECTION POINTS (CONNECTION BOX)
BIO VAC IV INSTALLED IN THE WATER UNIT AIR (POINT A) ELECTRICAL (POINT B) W A TE R ( P O I NT G ) SU C T I O N C O NT R O L S
01 08 BIO-VAC (POINT J)
04 02
02 09
05
02 11 10
05
02
12
06 13
14 03 07
20 f aeL
L A U NA M NOI TALL ATS NI - E RP