Академический Документы
Профессиональный Документы
Культура Документы
Since June 2008 supplies have now been harmonised across UK and Europe at 230V (+/- 10%) i.e. 207 to 253V
However, the average voltage across the UK is 242V due mainly to the constraints of the supply networks resulting in
electrical equipment and plant operating well above the necessary voltage causing higher energy costs, excessive kw/h
losses and reduced life of electrical and electronic components.
®
By carefully controlling the voltage supplied to a premises or site by installing can yield
significant savings in the cost of operating electrical equipment without compromising the operational effectiveness of
plant and equipment.
A proven technique which has been understood for many years and reduces incoming voltage levels in a controlled way
is loosely termed as Voltage Optimisation.
Voltage
The graph shows that nominal and minimum
260 voltage requirements have fallen and this is where
the opportunity to reduce energy costs by reducing
250
voltage levels lies. It can be seen that the ideal
240 target voltage would be 220V depending on the
load and operational profile of electrical equipment
230 Voltage
on any particular site or premises.
220
In 1996 The Institute of Electrical Engineers (IEE)
210
recommends that for safety, all electrical equipment
200 is tested across the range 198V to 253V and should
UK UK EU Ideal UK /E U
Max
Aver age No m inal N om inal T arget
UK m in
m in
be capable of working within these voltage levels.
Voltage 253 24 2 2 40 230 220 216 20 7
EnergyAce Benefits and Savings
Power Efficient Systems Ltd have the knowledge and experience to analyse the relevant data,
identify significant savings and invite you to take this opportunity forward.
STEP
1 You send to us:
• Total kWh consumption – half hourly data in electronic format for the last
12 months (available form your electricity supplier)
• Last three electricity bills
• If possible the Sites voltage (measured)
We send to you:
• A report identifying potential savings and costs for each supply
STEP
2 If the outcome of Step 1 is to your liking, we will send you a single phase data
logger so that we can gather a trend of the voltage profile over a 1 week period.
STEP
3 On receipt of the returned data logger, we may request additional information
and visit your site in order to send you a detailed proposal and fixedinstallation
costs indicating the guaranteed savings available through the installation of
®
STEP 4
On receipt of an official order, our team will liaise with you to arrange for a mutually
convenient date for preliminary installation works to begin and plan a schedule of
works to minimise any potential inconvenience and shutdown of around 2 hours.
Lighting Circuit Energy Reduction
®
Maximum savings are usually gained on the more common types of lighting and while the technology
works on all types of lighting, it is less likely to return substantial savings on high frequency lighting
circuits.
Contact Power Efficient Systems now for a FREE demonstration on how Power Factor Correction and Voltage
Optimisation would benefit your organisation and return substantial monthly savings on your investment.
www. pesgroupltd.co.uk
Company Registered in England No: 4362110