Академический Документы
Профессиональный Документы
Культура Документы
KOCA4PWB.XLS
. . . . . . . CONTRACTOR AREA
. . . . . . . FACILITY UPGRADE & RELOCATION OF U/G PROCESS PIPING
. . . . . . . Petrofac FOR GC 3, 4, 6, 7, 8, 21, 23, BS 140 & BS 150 (GROUP A)
A For Review RD VK PK MA 25/12/2005 Sample Design Calculations of Block Foundations for
REV. AMENDMENTS PRPD CKD APPD APPD DATE PREPARED . CHECKED . APPROVED . Vibrating Equipment
KOC APPROVALS APPROVED . DATE . SCALE NA CONTRACTOR DOC. No. REV. K.O.C. DOC. No. REV.
DEPARTMENT SIGNATURE DESIGNATION DATE PROJECT - FACILITY UPGRADE & RELOCATION OF U/G PROCESS PIPING
JI-180-000-ECV-CAL-XXX A XXX-XX-XXX A
FOR GC 3, 4, 6, 7, 8, 21, 23, BS 140 & BS 150 (GROUP A)
MATHEMATICAL BACKGROUND :-
The basic equation of motion considered for the analysis are as follows.
VERTICAL DIRECTION:-
In vertical direction the foundation is considered as rigid lumped mass having single degree
of freedom when :-
wz = kz
m
d z= (P0/kz)Sin w mt
[(1-r2)2-(2Dr)2]0.5
The analysis in this case is done based on coupled horizantal and rocking mode when the equation
of motion considered for the the eigen solution and time history response is as follows
Cxx −Cxx { Z̄
¿
−Cxx { Z̄
¿
Kxx −Kxx { Z̄
¿
−Kxx { Z̄
¿
[ mxx
0
0
J θx ][ ]
ẍ [
θ̈ [] P Sinωm t
+ ¿C θ +Cxx { Z̄¿¿ 2 −W Z̄ ¿ ] ẋ + [ ¿ Kθ+Kxx { Z̄¿ ¿ 2 −W Z̄ ¿ ] x = 0
θ̇ θ [][
M 0 Sinωm t ]
mxx= Mass of foundation and machine in horizontal X direction
Jx= Mass moment of inertia about X axes
Kxx,Kx, Cxx,Cx= Stiffness and Damping property of soil respectively
W= Weight of foundation Plus the machine
Z = C.G. of foundation in vertical direction
P0, M0= Dynamic load vector acting as a harmonic load
As the Damping matrix as mentioned above is not proportional and does not de-couple on
orthogonal transformation, i.e. on operation
Soil Parameters
The coefficient of uniform compression Cz is usually from field investigaion based on cyclic plate load
test.
While dynamic shear modulus is usually obtained from block vibration test or seismic cross-hole test.
Based on the above two parameters the equivalent spring values of soil are calculated as shown here
after.
Spring Value Barkan Richart/Lysmer Wolf Remarks
Kz Cz.Af 4Gr0/(1-n) 4Gr0/(1-n)
Kx Ct.Af 32(1-n)Gr0/(7-8n) 8Gr0/(2-n)
Kx Cx.Iyy 8Grx3/3(1-n) 8Grx3/3(1-n)
Ky Cy.Ixx 8Gry3/3(1-n) 8Gry3/3(1-n)
Ky Cy.Izz 16Gry /3
3
16Gry3/3
Damping
Ratio
0.425/(Bz)0.5 Czz=(0.85kzr0)/Vs
where
Not
Bz=(1-n)m/rr03
xz applicable
xx Do 0.288/(Bx)0.5 Cxx=(0.58kzr0)/Vs
where
Bx=[(7-
8n)m]/[32(1-
n)rr03]
Virtual mass
of soil
Not
mzz applicable Not applicable 0.27kzr02/Vs2
mxx Do Do 0.095kzr02/Vs2
fx Do Do 0.24kqxrqx2/Vs2
fy Do Do 0.24kqyrqy2/Vs2
fy Do Do 0.045kyyryy2/Vs2
Reference:-
1) Dynamics of Bases and foundations- D.D Barkan
2) Analysis and design foundation for vibration- P.J Moore (Ed/)
3) Dynamic soil strucuture interaction in time domain - John .P. Wolf
4) Vibration of structures and foundations - S Arya,M O'Neil, G Pincus
5) Finite Element Analysis in Engineering Procedure- Klaus Juergen Bathe
PROJECT TITLE : FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING
UNIT = SI
Machine Data
Unbalanced Force/Moment
Force P1 ( Refer figure) = 0.01 KN (negligible forces considered for calculating displacements)
Ht at which it acts above fdn = 0.51 m
Force P2( Refer figure) = 0.01 KN (Unbalanced force acts along X-axis)
Ht at which it acts above fdn = 0.51 m (Ht =Height of center line of shaft above fdn. Level)
Pz( Vertical force) = 0.01 KN
Moment about x axes = KN.m
Moment about y axes = KN.m
C. L. OF SHAFT
Ht
1.25 z
X
ELEVATION
A = Pump
D B = Diesel Engine
C C = Battery
D = Hydraulic Starter
B
E = Controller
E
P2
A
Y
X
C L OF SHAFT
PLAN
02/13/2019
PROJECT TITLE : FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING
Bearing Capacity of Soil = 112.5 KN/m2 (as per page 26 of 67 of Civil & Structural Design Philosophy:- JI-180-ECV-SPE-001).
Foundation Data
No of foundation parts = 1 P1
P2 2545
Overall Size of foundation Y
Length of the foundation = 1.315 m
Material Property
Allowable soil bearing pressue for dynamic loads = 56.25 kN /m2 (50 % of soil bearing pressure)
02/13/2019
PROJECT TITLE: FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING FOR GC's BS's PPD BY RPD 25/12/05
TITLE: Design Cals. of block found. for vibrating equipment CHKD BY VKK 25/12/05
JOB NO:- 180 DOC NO JI-180-000-ECV-CAL-XXX(Rev A)
● Barkan's Spring
● Richart's Spring
Wolfe's Spring
mi(xoi2+zoi2)
m/12(lx2+lz2)
Lx Ly Lz mass(m) xi yi zi mxi myi mzi xoi=xc-xi zoi=zc-zi
Sl No
1 1.06 0.6575 1.188 1.632 0.70 1.26 1.73 0.00 0.00 -0.92 0.89
2 0.00 0 0 0 0.00 0.00 0.00 0.00 0.66 0.72 0.00
3 0.00 0 0 0 0.00 0.00 0.00 0.00 0.66 0.72 0.00
4 0.00 0 0 0 0.00 0.00 0.00 0.00 0.66 0.72 0.00
5 0.00 0 0 0 0.00 0.00 0.00 0.00 0.66 0.72 0.00
6 0.00 0 0 0 0.00 0.00 0.00 0.00 0.66 0.72 0.00
7 1.32 2.55 1.25 10.66 0.66 1.27 0.63 7.01 13.57 6.66 2.92 0.00 0.09 0.09
8 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
9 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
10 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
11 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
12 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
13 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
14 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
15 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
16 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.66 0.72 0.00
11.72 7.71 14.83 8.39 2.92 0.98
ecc in x direction = 0 %
02/13/2019
PROJECT TITLE: FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING FOR GC's BS's PPD BY RPD 25/12/05
TITLE: Design Cals. of block found. for vibrating equipment CHKD BY VKK 25/12/05
JOB NO:- 180 DOC NO JI-180-000-ECV-CAL-XXX(Rev A)
Natural frequency in vertical direction = 386.562 rad/sec 3691 r.p.m
{M}= 11.72 0 {C}= 2170.2864534 -1554.1005031 {K}= 1426067.261 -1021179.4 {P}= 0.01
0 3.90 -1554.100503 1268.90654301 -1021179 1515909.1285 0.0104391918
02/13/2019
PROJECT TITLE: FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING FOR GC's BS's PPD BY RPD 25/12/05
TITLE: Design Cals. of block found. for vibrating equipment CHKD BY VKK 25/12/05
JOB NO:- 180 DOC NO JI-180-000-ECV-CAL-XXX(Rev A)
Sl No Time Step R1(t) R2(t) (R1t+t-R1(t))(R2t+t-R2(t)) R"1(t) R"2(t) X"1(disp) X"2(disp) x1(disp) x1(vel) x1(acc) x2(disp) x2(vel) x2(acc)
271 0.33875 -0.0038268 -0.0039949 0.004541927 0.0047414046 -0.210072313 -0.1371841614 -9.463E-09 -1.5178E-08 -4.33E-09 -1.04E-05 4.34E-04 -1.20E-08 -6.73E-06 1.20E-03
272 0.34 -5.513E-15 -5.7549E-15 0.005357568 0.005592868 -0.5119489118 -0.1651004457 -2.1017E-08 -2.1396E-08 -1.67E-08 -9.11E-06 1.67E-03 -1.93E-08 -4.77E-06 1.93E-03
273 0.34125 0.0038268 0.00399491 0.005357568 0.005592868 -0.735894432 -0.1678943474 -2.9372E-08 -2.4359E-08 -2.65E-08 -6.41E-06 2.65E-03 -2.36E-08 -2.10E-06 2.36E-03
274 0.3425 0.0070711 0.00738162 0.004541927 0.0047414046 -0.847868074 -0.1451509493 -3.3258E-08 -2.3616E-08 -3.23E-08 -2.73E-06 3.23E-03 -2.44E-08 8.99E-07 2.43E-03
275 0.34375 0.0092388 0.00964456 0.003034819 0.0031681053 -0.830868529 -0.1003408456 -3.2085E-08 -1.9282E-08 -3.32E-08 1.35E-06 3.31E-03 -2.14E-08 3.76E-06 2.14E-03
276 0.345 0.01 0.01043919 0.001065687 0.0011124906 -0.687518887 -0.040291218 -2.6033E-08 -1.2017E-08 -2.90E-08 5.23E-06 2.90E-03 -1.52E-08 6.04E-06 1.52E-03
277 0.34625 0.0092388 0.00964456 -0.00106569 -0.0011124906 -0.439664916 0.0258538431 -1.6025E-08 -2.9289E-09 -2.04E-08 8.32E-06 2.04E-03 -6.70E-09 7.41E-06 6.66E-04
278 0.3475 0.0070711 0.00738162 -0.00303482 -0.0031681053 -0.12504801 0.088025476 -3.5832E-09 6.6E-09 -8.74E-09 1.01E-05 8.69E-04 2.83E-09 7.64E-06 -2.86E-04
279 0.34875 0.0038268 0.00399491 -0.00454193 -0.0047414046 0.2084406273 0.1367627133 9.3973E-09 1.5119E-08 4.27E-09 1.04E-05 -4.31E-04 1.19E-08 6.72E-06 -1.20E-03
280 0.35 6.189E-15 6.4609E-15 -0.00535757 -0.005592868 0.5100498617 0.1646523702 2.0941E-08 2.1332E-08 1.66E-08 9.10E-06 -1.66E-03 1.92E-08 4.77E-06 -1.92E-03
281 0.35125 -0.0038268 -0.0039949 -0.00535757 -0.005592868 0.7338928944 0.1674569925 2.9293E-08 2.4295E-08 2.64E-08 6.40E-06 -2.65E-03 2.35E-08 2.10E-06 -2.36E-03
282 0.3525 -0.0070711 -0.0073816 -0.00454193 -0.0047414046 0.8459301797 0.144759204 3.3182E-08 2.3557E-08 3.22E-08 2.74E-06 -3.22E-03 2.43E-08 -8.95E-07 -2.43E-03
283 0.35375 -0.0092388 -0.0096446 -0.00303482 -0.0031681053 0.8291481806 0.1000244254 3.2018E-08 1.9232E-08 3.31E-08 -1.35E-06 -3.31E-03 2.14E-08 -3.75E-06 -2.14E-03
284 0.355 -0.01 -0.0104392 -0.00106569 -0.0011124906 0.6861458442 0.0400724835 2.598E-08 1.1981E-08 2.89E-08 -5.22E-06 -2.89E-03 1.52E-08 -6.03E-06 -1.52E-03
285 0.35625 -0.0092388 -0.0096446 0.001065687 0.0011124906 0.4387353372 -0.0259613792 1.5989E-08 2.9078E-09 2.04E-08 -8.30E-06 -2.04E-03 6.67E-09 -7.39E-06 -6.65E-04
286 0.3575 -0.0070711 -0.0073816 0.003034819 0.0031681053 0.1246181133 -0.0880178643 3.5673E-09 -6.6045E-09 8.72E-09 -1.01E-05 -8.68E-04 -2.84E-09 -7.63E-06 2.87E-04
287 0.35875 -0.0038268 -0.0039949 0.004541927 0.0047414046 -0.208357404 -0.1366454785 -9.3928E-09 -1.5107E-08 -4.27E-09 -1.04E-05 4.30E-04 -1.19E-08 -6.71E-06 1.19E-03
288 0.36 -6.865E-15 -7.1668E-15 0.005357568 0.005592868 -0.509482123 -0.1644396612 -2.0918E-08 -2.1306E-08 -1.66E-08 -9.08E-06 1.66E-03 -1.92E-08 -4.76E-06 1.92E-03
289 0.36125 0.0038268 0.00399491 0.005357568 0.005592868 -0.732907182 -0.1671700708 -2.9253E-08 -2.4256E-08 -2.64E-08 -6.39E-06 2.64E-03 -2.35E-08 -2.09E-06 2.35E-03
290 0.3625 0.0070711 0.00738162 0.004541927 0.0047414046 -0.844623979 -0.1444244224 -3.3129E-08 -2.351E-08 -3.22E-08 -2.73E-06 3.22E-03 -2.43E-08 9.01E-07 2.43E-03
291 0.36375 0.0092388 0.00964456 0.003034819 0.0031681053 -0.827640721 -0.0996708808 -3.1957E-08 -1.9181E-08 -3.30E-08 1.35E-06 3.31E-03 -2.13E-08 3.75E-06 2.13E-03
292 0.365 0.01 0.01043919 0.001065687 0.0011124906 -0.684567537 -0.0397295489 -2.5917E-08 -1.193E-08 -2.89E-08 5.22E-06 2.89E-03 -1.51E-08 6.03E-06 1.51E-03
293 0.36625 0.0092388 0.00964456 -0.00106569 -0.0011124906 -0.437216759 0.0262664411 -1.5929E-08 -2.8613E-09 -2.03E-08 8.30E-06 2.03E-03 -6.63E-09 7.39E-06 6.63E-04
294 0.3675 0.0070711 0.00738162 -0.00303482 -0.0031681053 -0.123279446 0.0882620136 -3.5146E-09 6.6432E-09 -8.66E-09 1.01E-05 8.66E-04 2.88E-09 7.62E-06 -2.89E-04
295 0.36875 0.0038268 0.00399491 -0.00454193 -0.0047414046 0.2094156434 0.1368115809 9.4341E-09 1.5135E-08 4.32E-09 1.04E-05 -4.33E-04 1.20E-08 6.70E-06 -1.20E-03
296 0.37 7.542E-15 7.8728E-15 -0.00535757 -0.005592868 0.5101863662 0.1645176203 2.0945E-08 2.1321E-08 1.66E-08 9.07E-06 -1.66E-03 1.92E-08 4.75E-06 -1.92E-03
297 0.37125 -0.0038268 -0.0039949 -0.00535757 -0.005592868 0.7332156078 0.1671573444 2.9264E-08 2.4259E-08 2.64E-08 6.38E-06 -2.64E-03 2.35E-08 2.08E-06 -2.35E-03
298 0.3725 -0.0070711 -0.0073816 -0.00454193 -0.0047414046 0.8445285374 0.1443259056 3.3124E-08 2.35E-08 3.22E-08 2.71E-06 -3.22E-03 2.43E-08 -9.11E-07 -2.43E-03
Maximum Displacements = 0.0001 mm 0.0000
02/13/2019
PROJECT TITLE : FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING
FOR GATHERING CENTERS AND BOOSTERS STATIONS
PREPARED BY RPD DATE 12/25/2005
Title : Sample Design Calculations of Block Found. for Vib. Equip. CHECKED BY VKK DATE 12/25/2005
JOB. NO. - 180 DOC NO. JI-180-000-ECV-CAL-XXX REV A
386.56233
7.292E-06
Time History plot for the Block Foundation
Horizontal
Horizontal Amplitude at
1.00E-04 Amplitude at top of
Vertical amplitude base level foundation
0 0 0 0.00E+00 0.00E+00
1
2
8.00E-05
0.00125
0.0025
0.000003388
6.000139008E-06
-9.29E-08
-5.86E-07
3.60E-07
2.65E-06
3 0.00375 7.238430733E-06 -1.18E-06 7.73E-06
4
5
6.00E-05
0.005
0.00625
6.81928599E-06
4.838679419E-06
-1.15E-06
1.48E-07
1.54E-05
2.45E-05
6 0.0075 1.750125003E-06 2.88E-06 3.35E-05
7 0.00875
8
4.00E-05
0.01
-1.73916834E-06
-4.83023159E-06
6.66E-06
1.06E-05
4.05E-05
4.39E-05
9 0.01125 -6.81528135E-06 1.38E-05 4.23E-05 Vertical amplitude
Amplitude
02/13/2019
38 0.0475 -3.41789232E-06 -1.83E-05 -3.01E-05
02/13/2019
PROJECT TITLE : FACILITY UPGRADE AND RELOCATION OF U/G PROCESS PIPING
Summary of result
Allowable
Design Value
Sl. No Item value Remarks
1 Frequency Check
Ratio of Actual
Frequency to Natural
frequency
Frequency in veritcal
1.1 direction :- 1.23 0.8,1.2 Foundation Safe
Frequency in horz.
1.2 direction :- 0.737 0.8,1.2 Foundation Safe
Frequency in rocking
1.3 mode :- 2.15 0.8,1.2 Foundation Safe
2 Amplitude Check
Amplitude in vertical
2.1 direction (mm) 0.000007 0.00006 Foundation Safe
Amplitude in horz.
direction at top
2.2 of foundation in (mm) 0.00008 0.00009 Foundation Safe
Amplitude in rocking
2.3 mode (deg.) 0.000042