Академический Документы
Профессиональный Документы
Культура Документы
shows the current mileage on the dashboard, so its 8813 x 10 = 88130km, it has an
option to change the field that says 8813 and save it. Would this change the mileage on
the dash board? How is it possible to do this with vag-com, I thought it wasnt made for
such things.
Ross-Tech is not responsible for any damage or problems that may result from following these
instructions. They are to be used at your own risk.
This procedure details how to install a NEW Instrument Cluster in VW/Audi vehicles that do not
have Immobilizer. This is mainly US/Canadian VW's produced before MY 2000 and
US/Canadian Audi vehicles produced before 2001.
Immo-3 knows your car's VIN. Access 17-Instruments (or separate 25-Immobilizer on vehicles
that are set up that way) and look at the first "Extra" field.
If you see something like: "Immo-ID VWZ7Z0W0648696" You've got Immo-2 (or maybe even
Immo-1 in earlier non-US models).
1. With the OLD Instrument Cluster in the vehicle, write down the current mileage.
3. [Select]
[17 - Instruments]
Write down the 5 digit number from the "Soft. Coding" field, make note that is
the Instrument Cluster coding.
[Close Controller, Go Back - 06]
6. [Select]
[17 - Instruments]
[Recode - 07]
Enter the 5 digit number that you wrote down as the Instrument Cluster coding.
[Do It!]
7. If you are live in a market where the odometer reading is in miles, you should
change to km before entering the mileage. To do this, consult the Factory
Repair Manual for your vehicle. Here is an example:
[Select]
[17 - Instruments]
[Recode - 07]
Enter the 5 digit number that you wrote down as the Instrument Cluster coding.
[Do It!]
Confirm that the odometer in the car now shows kilometers, not miles.
8. [Login - 11]
Enter a value of 13861 (May not be required on all clusters)
[Do It!]
9. [Adaptation - 10]
Enter "channel number" 09 to select channel
Put in the number of km divided by 10. Example: If old cluster had 50,357 km,
put in 5036.
[Test]
Observe the Instrument Cluster and make sure the mileage displayed is
correct. Once you save this value, you will be unable to change the mileage
EVER!
[Save]
10. If you are live in a market where the odometer reading is in miles, you should
now change back to miles. To do this, consult the Factory Repair Manual for
your vehicle. Here is an example:
[Select]
[17 - Instruments]
[Recode - 07]
Change the 3rd digit from a "3" (Canada) to a "2" (US)
[Do It!]
Confirm that the odometer in the car now shows miles, not kilometers. Make
sure that the mileage reading is correct.