Академический Документы
Профессиональный Документы
Культура Документы
Key word :
Version:v2.0.3p6t2
author: huang.fuming
Description:
Analysis:
MSAG635:
The site can't be managed. We go to site with ET engineer. We find that the control board is
problem on slot 10 shelf 0.It impact the whole site. And the services are interrupted. After pulled
out the fault board of slot 10 the site is restored.
MSAG637:
The services are interrupted. ET putted 1 control board on master shelf from site 691 long time
ago. Because the control board is damaged on site 637. But the configuration is the same in site
691 and site 637. So the management IP and voice IP will be conflicted.This will impact the
services on both sites. The management and voice is fine after changed the IP address. But the
VLAN information is still confused. So we suggest ET to modify the VLAN information.
Solution:
Summary:
MGID: 1
<以上所有信息均为中兴通讯股份有限公司所有,不得外传> 第1页
All Rights reserved, No Spreading abroad without Permission of ZTE
内部公开 Internal Use Only▲
PROTYPE: H248
VERSION: 1
ENCODETP: TEXT
MGIP: 10.208.40.87
MGMASK: 255.255.255.0
MGPORT: 2944
TRANSLAY: IP
TRANSPRO: UDP
DOMNAME:
MGINFO: USE IP
MGCID1: 1
MGCID2: 2
MGCID3: 0
MGCID4: 0
SELFEXCHANGE: disable
PROTECTCALL: disable
DISASTERPROT: disable
CURMGCID: 2
-------------------------------------------------------------------------------
-
1 rows are effected
protocol state
H.248 Break
1 rows are effected
MSAG691(ag)$ get-protocolstate protocol 1
protocol state
H.248 Break
1 rows are effected
MSAG691(ag)$
<以上所有信息均为中兴通讯股份有限公司所有,不得外传> 第2页
All Rights reserved, No Spreading abroad without Permission of ZTE
内部公开 Internal Use Only▲
protocol state
H.248 OK
1 rows are effected
MSAG691(ag)$
MSAG691(ag)$
MSAG691(ag)$
MSAG691(ag)$ exit
MSAG691$ route interface ipaddress 10.208.42.67 mask 255.255.255.0 vid 2301
ERROR: TmsL3 IpSubnet already exist.
Subnet Ip Table
------------------
IP Mask VID COS Descrip
------------------------------------------------------
168.10.0.1 255.255.0.0 -- -- outband_mng
10.208.42.87 255.255.255.0 2301 0 (inband)
MSAG691$
MSAG691$ hostname MSAG637
MSAG637$
MSAG637$
MSAG637$ show route
Subnet Ip Table
------------------
IP Mask VID COS Descrip
------------------------------------------------------
168.10.0.1 255.255.0.0 -- -- outband_mng
10.208.42.67 255.255.255.0 2301 0 (inband)
--------------------------------------------------------------------------
MSAG637$ show mac slot 1/14
mac-count-total: 0
mac-count macaddress vlan-id shelf/slot/port/pvc(onu) state
--------------------------------------------------------------------------
MSAG637$ show mac slot 1/15
mac-count macaddress vlan-id shelf/slot/port/pvc(onu) state
--------------------------------------------------------------------------
1/15,card can not action
MSAG637$ show mac slot 1/16
mac-count-total: 0
mac-count macaddress vlan-id shelf/slot/port/pvc(onu) state
--------------------------------------------------------------------------
MSAG637$ show mac slot 1/15
mac-count macaddress vlan-id shelf/slot/port/pvc(onu) state
--------------------------------------------------------------------------
1/15,card can not action
MSAG637$ show mac vlan 1211
mac-count-total: 2
mac-count macaddress vlan-id shelf/slot/port/pvc state
--------------------------------------------------------------------------
1 00:d0:d0:c0:04:80 1211 0/9/2/-- dynamic
2 00:25:12:da:aa:3a 1211 1/3/0/0 dynamic
MSAG637$
MSAG637$ show port 0/9/2
portName : ETH_0/9/2
portType : optical_1000M
manageState : enable
portProtect : disable
portFlowcontrol : disable
ethernetLinkState : up
portLinkStatusTrap : disable
portRateThresholdTrap: disable
portRateThresholdValue( %): 100
duplexspeedConfig : full-1000M
duplexspeedState : full-1000M
mdi : auto
pvid : 1
input rate : 13.636 Mbps output rate : 5.928 kbps
input Peak rate : 17.686 Mbps output Peak rate : 133.152 kbps
input bytes : 1489950038 output bytes : 874064
MSAG637$
MSAG637$ save
Are you sure to save configure data? [y/n]y
MSAG637$
0x1389>unit 3
-------------------------------------------------------------------------------
Unit_Type : 20
Unit_State : UNIT_Main_Used
Unit_Func : 0x0
Unit_Port : 2, 0
Left-Right Port : 2, 0
Main_Port : 2
Mate_Port : 0
Unit_Chg : 1
all_sunits_init_f : 1
last_chg_reason : 1
has_ut_alm : 0x28599cb
<以上所有信息均为中兴通讯股份有限公司所有,不得外传> 第8页
All Rights reserved, No Spreading abroad without Permission of ZTE
内部公开 Internal Use Only▲
0x1389>unit 3
-------------------------------------------------------------------------------
Unit_Type : 20
Unit_State : UNIT_Main_Used
Unit_Func : 0x0
Unit_Port : 2, 0
Left-Right Port : 2, 0
Main_Port : 2
Mate_Port : 0
Unit_Chg : 1
all_sunits_init_f : 1
last_chg_reason : 1
has_ut_alm : 0x28599cb
alarmflag : 0x10, 0x0
Sunit_Num : 13
-------------------------------------------------------------------------------
No SunitSpn ConfigType SunitState Alarm Reason ScanType CfgState
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
1 1-2-01 76( POW) Main_Used 0x00 0x00 76( POW) -----
3 1-2-03 81( GILCA) Main_Used 0x00 0x00 81( GILCA) done
4 1-2-04 81( GILCA) Out_Used 0x01 0xff 81( GILCA) -----
5 1-2-05 81( GILCA) Main_Used 0x00 0x00 81( GILCA) done
6 1-2-06 81( GILCA) Main_Used 0x00 0x00 81( GILCA) done
<以上所有信息均为中兴通讯股份有限公司所有,不得外传> 第9页
All Rights reserved, No Spreading abroad without Permission of ZTE
内部公开 Internal Use Only▲
0x1389>
0x1389>
0x1389>
0x1389>unit 6
-------------------------------------------------------------------------------
Unit_Type : 24
Unit_State : UNIT_Out_Used
Unit_Func : 0x0
Mpr_HdType : MPRB
Unit_Port : 129, 0
Left-Right Port : 129, 0
Main_Port : 0
Mate_Port : 0
Unit_Chg : 1
all_sunits_init_f : 0
last_chg_reason : 1
has_ut_alm : 0x285a649
alarmflag : 0x80, 0x0
Sunit_Num : 3
-------------------------------------------------------------------------------
No SunitSpn ConfigType SunitState Alarm Reason ScanType CfgState
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
1 1-0-11 1( DTMF) Init_Used 0x00 0x00 0(UNKNOW) -----
2 1-0-11 2( TONE) Init_Used 0x00 0x00 0(UNKNOW) -----
3 1-0-11 51( IPSMPRB) Init_Used 0x00 0x00 0(UNKNOW) -----
-------------------------------------------------------------------------------
0x1389>unit 7
-------------------------------------------------------------------------------
Unit_Type : 24
Unit_State : UNIT_Main_Used
Unit_Func : 0x0
Mpr_HdType : MPRB
Unit_Port : 130, 0
<以上所有信息均为中兴通讯股份有限公司所有,不得外传> 第 10 页
All Rights reserved, No Spreading abroad without Permission of ZTE
内部公开 Internal Use Only▲
0x1389>
<以上所有信息均为中兴通讯股份有限公司所有,不得外传> 第 11 页
All Rights reserved, No Spreading abroad without Permission of ZTE