Академический Документы
Профессиональный Документы
Культура Документы
QUIZ-1: INTRODUCTION
1. A simply supported beam 5 m in span has a cross-section of 200mm width x420 mm depth. The steel covering is 60 mm from the center
of the reinforcement. Use fc’ = 28MPa and fy = 276 MPa.
a. Determine the required steel ratio of the beam if it is to carry 10 kN/m total dead load and 20 KN/m live load.
b. Determine the number of 30 mm diameter bars needed for the beam. Also check for steel ratio requirement. Assume ɸ = 0.90.
c. Determine the actual reduction factor.
d. Determine the actual capacity of the beam using the number of reinforcement solve in “b”.
e. Determine the additional live load that the beam could carry considering the moment capacity solve in “d”.
1. A simply supported beam 5 m in span has a cross-section of 200mm width x420 mm depth. The steel covering is 60 mm from the center
of the reinforcement. Use fc’ = 28MPa and fy = 276 MPa.
a. Determine the required steel ratio of the beam if it is to carry 10 kN/m total dead load and 20 KN/m live load.
b. Determine the number of 30 mm diameter bars needed for the beam. Also check for steel ratio requirement. Assume ɸ = 0.90.
c. Determine the actual reduction factor.
d. Determine the actual capacity of the beam using the number of reinforcement solve in “b”.
e. Determine the additional live load that the beam could carry considering the moment capacity solve in “d”.
1. A simply supported beam 5 m in span has a cross-section of 200mm width x420 mm depth. The steel covering is 60 mm from the center
of the reinforcement. Use fc’ = 28MPa and fy = 276 MPa.
a. Determine the required steel ratio of the beam if it is to carry 10 kN/m total dead load and 20 KN/m live load.
b. Determine the number of 30 mm diameter bars needed for the beam. Also check for steel ratio requirement. Assume ɸ = 0.90.
c. Determine the actual reduction factor.
d. Determine the actual capacity of the beam using the number of reinforcement solve in “b”.
e. Determine the additional live load that the beam could carry considering the moment capacity solve in “d”.
1. A simply supported beam 5 m in span has a cross-section of 200mm width x420 mm depth. The steel covering is 60 mm from the center
of the reinforcement. Use fc’ = 28MPa and fy = 276 MPa.
a. Determine the required steel ratio of the beam if it is to carry 10 kN/m total dead load and 20 KN/m live load.
b. Determine the number of 30 mm diameter bars needed for the beam. Also check for steel ratio requirement. Assume ɸ = 0.90.
c. Determine the actual reduction factor.
d. Determine the actual capacity of the beam using the number of reinforcement solve in “b”.
e. Determine the additional live load that the beam could carry considering the moment capacity solve in “d”.