for safety before use. Equipments, when not in use, should be switched off. Proper precautions should be assessed by the person(s) involved. Keep the area well ventilated. Immediately disconnect the power and examine the circuit / components to find out what is wrong. 2. Contact Injury – cuts, abrasions, Proper inspection of materials / burns, slips etc. components to be used. Implementation of risk assessment for the tools and components, as well as the proper maintenance of it. Being careful while soldering. Keeping the area dry at all times. 3. Damaged components – due to Examine the components after soldering or by other processes soldering. performed during the project 4. Electrical equipment – shocks, All equipment must be tested for burns from using faulty equipment electrical safety, as well as the components to be used if it is in good condition. Check for cracks, cuts, or abrasions on cables, wires and cords and check for any defects. Defective components and tools must be recognized, and must be taken out of use until repair has been effected. 5. Malfunction Troubleshooting of the components for the project, such as the sensors and components.