Академический Документы
Профессиональный Документы
Культура Документы
1 Organisms carried in ballast wáter which survive on discharge can multiply and cause serious
enviromental problems.
True
2 Ballast wáter can carry disease from one part of the world to another
True
3 In order to replace approcimately 95% of ballast water in tank using the flow/through method
of exchange, the amount of water pumped through the tank must be
3 x The tanks volume
4 Before starting bunkering operations, which one of the following precautions would you
attend to first?
Plug the scuppers
6 The tank gauge can indicate a false measurement, depending on the vessels trim
True
7 Bunker fuel is used in the auxiliary engines as well as the main engines
True
8 The PSC officers will always want to start the inspection with
A thorought check of the ships documents
18 The IMO intact stability criteria require that the area under the curve of righting levers from
30 degrees heel to the angle of flooding or 40 degrees /whichever is smaller/ should not be less
than
0.03 metre radian
20 How would you increase the GM of a ship, loaded with a timber deck cargo, that has become
“unstable”?
By filling the small divided bottom tanks on the lower side, whilst jettisoning the deck
cargo from the higher side.
21 What is the “range of stability” on a statical curve?
Angles of heel where all gz levers are positive
22 If the bending stress in the keel is tensible, the ship has ____
A sagging bending moment
23 A ship is in unstable equilibrium when upright if the centre of gravity is above the _______
Metacentre
24 If a ship is poised on a wave with the crests at the ends and a trough amidships, the ship will
have___
a sagging bending moment
25 at constant displacement, the moment to change trim 1 cm is proportional to ______
the longitudinal metacentric height
30 How many “grades” of officer of the watch (OOW) certification are provided for under
STCW?
Three
34 The problems with mechanical treatment of ballast water are water are expense and
maintenance of the filters
True
35 Correctly carried out, ballast water exchange at sea is a complete solution to the problem
False
36 The imo ballast water guidelines contain a specimen format for a ballast water water
reporting form, which of the items of information listed does this form contain?
Vessel information
Voyage information
Ballast water management information(number of tanks discharged)
All the above
37 The use of clean, treated fresh water for ballast solves the potential problems with ballast
water.
True
38 Which of the ítems listed is not included in the section of the IMO Ballast Water Guideline
dealing with ships operational procedures?
Training and education
39 What is the MARPOL Annex VI máximum Sulphur Emission Control Area (SECA)?
0.015
40 The tank gauge can indicate a false measurement, depending on the vesse’s trim.
True
42 A member of the ship’s engine deparment should board the barge to be in overall control of
the bunkering operation.
False
43 Which of the actions listed is not one that the PSC Officer can request following an
inspection?
Rectify the deficiency at the next survey
48 The present Safety of Life at Sea (SOLAS) regulations, unless expressly provided otherwise,
applies only to
Cargo ships in excess of 500 gross tonnage
56 In the probabilistic method of determining damage stability requirements for a ship, the
required stability index R depends on
The lenght of the ship
The displacement of the ship
The gross tonnage of the ship
The speed of the ship
2 The diference between the displacement and the deadweight is equal to the…
Steel weight
Cargo weight
Machinery weight
Light weight
3 Increasing the bilge radius and the rise of floor will cause the midship section coeficient to….
Decrease
4 If a vessel has a prismatic coefficient exactly equal to 1, the hull under wáter has…
A rectangular cross section varying along the lenght
A constant cross section along the lenght
A constant waterplane along the draught
A triangular cross sectionof varying área along the lenght
5 What do the letters MCTC stand for
The moment to change trim one centimetre
7 The "weather criterion” in the intact stability criteria is related to the heeling moment caused
by….
Storm waves
Gusts of wind
Stability after damage
Stability in good weather
9 If a ship in poised on a wave with the crest at the ends and a through amidships, the ship will
have…..
A torsional moment
A hogging bending moment
A sagging bending moment
Zero bending moment
11 what is the threshold gross tonnage that requires a ship to comply with the ISM code_
500gt
12 the PARIS MOU covers the conduct of classification societies
TRUE
False
13 Which of the IMO Convention listed is not relevant for PSC inspection
Loadlines
SOLAS
MARPOL
COLREG Convention
14 Whats is the period of validity of the cargo ship safety radio certificate_
5 years
15 if a vessel has a block coefficient exactly equal to 1, the hull under wáter has the shape of
a……
Rectangular block
Triangular Block
Circular Cylinder
Elliptical cylinder
16 If the trim of a ship changes so that the increase in draught at the forward perpendicular is
more than the decrease in draught at the after perpendicular, the centre of flotation is……
Forward of amidships
Aft of amidships
At amidships
At the location of the centre of gravity
17 If the centre of flotation is abaft amidships, the change in draught due to trim at the forward
perpendicular will be…..
Equal to that at the after perpendicular
Equal to that at the midship section
Greater than that at the after perpendicular
Smaller than that at the after perpendicular
45 The present Safety of Life at Sea (SOLAS) regulations, unless expressly provided otherwise
applies only to.
Cargo ships in excess of 500 gross tonnage
47 The distance between the centre of buoyancy and the transverse metacentre is proportional
to the
Breadth draught ratio multiplied by breadth
Breadth draught ratio
Length breadth ratio
Depth draught ratio
48 The International Maritime Organisation (IMO) Intact Stability Criteria require that the initial
metacentric height should not be less than
0.15 m
49 What is bilging?
When a vessel has suffered a breach in its hull
51 If a vessel has block coefficient exactly equal to 1, the hull under wáter has the shape of a
Rectangular block
Triangular block
Circular cylinder
Elliptical cylinder
59 organisms carried in ballast water which survive on discharge can multiply and cause serious
environmental problems.
True
60 Ballast water can carry disease from one part of the world to another
True
61 in order to replace approximately 95% of ballast water in a tank using the flow through
method of exchange, the amount of water pumped through the tank must be:
3x the tank´s volume
62 before starting bunkering operations, wich one of the following precautions would you
attend to first?
Plug the scuppers
64 The Tank Gauge can indicate a false measurement, depending on the vessels trim
True
False
65 Bunker fuel is used in the auxiliary engines as well as the main engines
True
False
66 The PSC Officers will always want to start the inspections with
A thorough check os the ships documents
74 The IMO intact stability criteria require that area under the curve of righthing
levers from 30 degrees heel to angle of flooding or 40 degrees (whichever is smaller) should not
be less than_____
0.03 metre radian
75 The air resistance of a ships depends upon____
The air resistance of the ship
The relative wind velocity
The displacement
The wetted surface
76 how would you increase the GM of a ship, loaded with a timber deck cargo, that has
become unestable?
By filling the small divided double bottom tanks on the lower side, whilst jettingson deck
cargo from the higher side
77 what is the range of stability on a statical stability curve
Angles of heel where all GZ levers are positive
78 if the bending stress in the keel is tensile, the ship has___
A sagging bending moment
79 a ship is unstable equilibrium when upright if the centre of gravity is above the___
Metacentre
80 at constant displacement, the moment to change trim 1 cm is proporcional to_____
The transverse moment of inertia of the waterplane
The transverse metacentric height
The longitudinal metacentric height…
The longitudinal centre of flotacion
81 What is the centre of flotation or tipping centre of a vessel
It is the exact mid point of the ship, around which the vessel trims as weights are added
or taken away
It is the fixed known point on the longitudinal metacentre
It is the point on which the vessel initially rest, when being drydocked
It is the geometrical centre of the waterplane and also the point about which the vessel
trims
82 if the forward draught of a vessel is greater than the aft draught, what state of trims is the
vessel in?
The vessel is trimmed by the head
83 Wich of the items listed is not regulated by MARPOL annex VI?
Answer not found
84 how many grades of OoW certification are provided for under STCW
Three
85 the thrust power is the product of the____
Thrust and speed of advance
Resistance and ship speed
Thrust and RPM
Torque and RPM
86 the specific loading conditions for which stability particulars must be given in the stability
booklet include
Light weight condition
Half load condition
Loaded to the winter north atlantic load line
Ballast departure condition
87 The natural pitching period of a ship depends on___
The transverse metacentric height
The longitudinal centre of buoyancy
The longitudinal centre of flotation
The longitudinal metacentric height
88 The problems with mechanical treatment of ballast water are expense and maintenance of
the filters
TRUE
89 the use of clean, treated fresh water for ballast solves the potential problems with ballas
water
True
90 The IMO Ballast water guidelines contain a specimen format for a ballast water reporting
form. Which of the items information listed does this form contain?
All the above
91 the position of the hose should never be change once the bunkering transfer has started
False
92 Which information about the bunker fuel oil has been delivered does the bunker delivery
note, not included?
Fifth option…
93 Which annex of MARPOL regulates the prevention of pollution by garbage from ships?
Annex V
94 what is the primary legislation on which all other legislation concerning the operation of the
ISM code is Based?
SOLAS Chapter IX- management for the safe operation of ships
95 Which MARPOL Annex relates to the carriage of Noxious Liquid substances?
Annex II
96 All seaferers must get which minimum amount of rest in any one 24 hr period
10 hours
97 which authority issues a dangerous goods document of compliances
Flag state
98 if a ship trims without a change in displacement, the draught does not change at the location
of__
The centre of flotation
The centre of buoyancy
The centre of gravity
Amidships
99 the range of stability____
The range of heel angles for which the righthing lever is positive
The range from zero to the angle of vanishing stability
The range from zero to the angle at which the righting lever is maximum
The range from zero to the angle of loll
100 the maximum shear force on the hull girder generally occur near__
The ends of the ship
Amidships
About a quarter of the lenghth from amidships on either side
At the point at which bending moment is zero
101 The winter north atlantic load line is required in_____
Ship Less than 100m in length
102 What is the maximum IMO GZ Value for a vessel carrying timber deck cargo
0.25
103 deadweight in a ship refers to
The weight of cargo, fuel and other non permanent weights in the ship
104 When stowing a bulk cargo what is the maximum amount of cargo that can be stowed in
any one space?
0.9
0.85
0.8
0.75
105 The block coefficient, the midship section coefficient, the water area coefficient and the
prismatic coefficient of a vessel are all equal to 1. The hull of the vessel has a__
Rectangular ship shape
106 Where would you put the ballast if correcting an angle of loll?
On the low side
107 What does fresh water allowance of FWA mean?
The amount the laden fresh water draft must be reduced by, to equal the maximum
allowed laden salt water draft.
108 to obtain the tonnes per cm immersion in fresh water the tonnes per cm immersion in sea
water must be multiplied by:
The specific gravity of fresh water
109 Ballast water exchange at sea can have a serious effect on the ships structural integrity
False
110 The Bunker delivery note must be kept on board for at least
3
111 What dangerous gas may be present during bunkering?
Hydrogen Sulphide
112 Regulations concerning crew living and working conditions as well as the social rights of
seaferers are specified in a convention developed by:
ILO
113 Wich ships require an international load line cert?
All ships above 24m in length
114 Absence of valid ISM certification will lead to a detention
TRUE
115 which of the conditions listed would not constitute clear grounds for more detailed PSC
inspection?
The crew accommodation is untidy and dirty
116 The MARPOL annex I regulation of pollution by oil apply to chich ships?
All ships, unless expressly provided otherwise
117 which of the following in not a special area according to marpol 73/78 annex I
Caribbean Sea area