Академический Документы
Профессиональный Документы
Культура Документы
Installation Manual
MKTG-IM-TP-02-EN-1112
74929RevA - MANUAL TP1-2
Installation Manual | TP Series
Do not allow bare ends of the wires to touch each other or grounded metal
parts while connected to the controller. This will damage the controller.
3 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
Parts Provided
Battery Enclosure
Tenon Adaptor
Battery Enclosure
Channel (bracket)
Top of Pole
Mount Bracket
TPM Mount
Fastener Set A (4-8)
Controller
Tenon Fastener
Set B (3)
Tenon Fastener
Set C (3)
Battery Harness
Battery Enclosure Channel
PV Panel Harness Fastener Set D (2)
Batteries (1, 2 or 3)
Battery Enclosure Channel
Battery Cables Fastener Set E (4)
(1 per battery)
Fastener Set F (2)
4 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
2.0 Assembling
2.1 PV Panel Assembly - Single or Dual Panels (Lay PV panels side
by side on cardboard packaging to protect surface)
Orientation of
PV J-boxes
should be at
top end of
panel
Fastener Set A
(4-8)
5 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
Flat end of
mount faces up
Secure screw in
mounting hole (only 4X
screws required)
6 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
Helpful Hint
Tilt angle for the PV panel is: Latitude + 15 degrees, i.e. if installed at
32nd latitude the tilt angle is 32+15=47 Therefore set to 45 degrees.
Fastener Set B
b (2)
15°
30°
45°
60°
7 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
Do Not Exceed
Working Load
Limit
PV Modules always
face EQUATOR
(South in Northern
Hemisphere)
8 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
2.6 Match Drill Hole in Tenon with Tenon Adaptor and Secure
b
Fastener Set B
(1)
Fastener Set C
3x 3/8-16 x 1/2” cup
point set screws
9 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
4.25” below
10 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
2.8 Drill Arm Mounting & Access Holes; Route Fixture Harness
Access hole
for Luminaire
harness. Drill
thru one side
@ 1.25” Dia.
Note: If mounting two arm mounts, connect both using the same
bolts.
11 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
PV Harness
Fastener Set E
Fastener Set D 4x 1/4”–20 x 1/2” hex
2x 3/4-10 x 12” bolts head bolts/washers
Luminaire Harness
Note: Before attaching Battery Enclosure Channel, fish Luminaire
Harness down pole through access hole for arm.
12 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
13 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
14 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
15 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
Solar Panels
Fuse
Battery Harness
Batteries (1-3)
16 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
2.16 Test
17 MKTG-IM-TP12-03-EN-1112
Installation Manual | TP Series
18 MKTG-IM-TP12-03-EN-1112
Sol Inc. | 3210 SW 42nd Avenue | Palm City, Florida 34990
www.solarlighting.com
E-mail support: support@solarlighting.com
Phone: +1.772.286.9461 | Toll: 800.959.1329 (USA & Canada)
Fax: +1.772.286.9616
Office Hours: Monday - Friday: 8:30 am to 5:00 pm (EST)