Вы находитесь на странице: 1из 111

ENGLISH

DVD RECEIVER WITH MONITOR KD-AV7100

ESPAÑOL
RECEPTOR DVD CON MONITOR KD-AV7100

For installation and connections, refer to the separate manual.


Para la instalación y las conexiones, refiérase al manual separado.

INSTRUCTIONS
MANUAL DE INSTRUCCIONES

LVT1822-003C
[JW]

Cover_LVT1822-003C.indd 2 08.6.24 4:04:47 PM


Thank you for purchasing a JVC product.
Please read all instructions carefully before operation, to ensure your complete understanding and to obtain the best
possible performance from the unit.
ENGLISH

IMPORTANT FOR LASER PRODUCTS


1. CLASS 1 LASER PRODUCT
2. CAUTION: Do not open the top cover. There are no user serviceable parts inside the unit; leave all servicing to
qualified service personnel.
3. CAUTION: Visible and/or invisible class 1M laser radiation when open. Do not view directly with optical
instruments.
4. REPRODUCTION OF LABEL: CAUTION LABEL, PLACED OUTSIDE THE UNIT.

WARNINGS: Cautions on the monitor:


To prevent accidents and damage
• The monitor built in this unit has been produced
• DO NOT install any unit or wire any cable in a with high precision, but it may have some
location where; ineffective dots. This is inevitable and is not
– it may obstruct the steering wheel and malfunction.
gearshift lever operations. • Do not expose the monitor to direct sunlight.
– it may obstruct the operation of safety devices • Do not operate the touch panel using a ball-point
such as air bags. pen or similar tool with the sharp tip.
– it may obstruct visibility. Touch the buttons on the touch panel with your
• DO NOT operate the unit while driving. finger directly (if you wear a glove, take it off).
If you need to operate the unit while driving, be • When the temperature is very cold or very hot...
sure to look around carefully. – Chemical changes occur inside, causing
• The driver must not watch the monitor while malfunction.
driving. – Pictures may not appear clearly or may move
• The driver must not put on the headphones while slowly. Pictures may not be synchronized with
driving. the sound or picture quality may decline in
such environments.

[European Union only]

AV7100_inst[JW].indb 2 08.5.19 11:11:41 PM


How to reset your unit Contents

ENGLISH
INTRODUCTION
Basic operations—Main unit ........... 4
2
Basic operations—
Remote controller (RM-RK253) ...... 6
Playable disc type ............................ 8
OPERATIONS
Clock setting ................................... 9
1 Common operations ........................ 10
• Your preset adjustments will also be erased. Listening to the radio ...................... 12
Disc operations ................................ 15
SD operations .................................. 31
USB operations ................................ 33
EXTERNAL DEVICES
Listening to the iPod........................ 35
Using other external components ..... 38
SETTINGS
Sound adjustments .......................... 39
Menu operations ............................. 41
REFERENCES
For safety...
• Do not raise the volume level too much, as this will
Maintenance ................................... 46
block outside sounds, making driving dangerous. More about this unit ........................ 47
• Stop the car before performing any complicated Troubleshooting .............................. 51
operations.
Specifications .................................. 54
Temperature inside the car...
If you have parked the car for a long time in hot or cold
weather, wait until the temperature in the car becomes
normal before operating the unit.

3 INTRODUCTION

AV7100_inst[JW].indb 3 08.5.19 11:11:48 PM


Basic operations — Main unit
ENGLISH

Operations are explained mainly using the touch panel; however, you can use the buttons on the unit and remote
controller if they have the same or similar names or marks.

Display window (☞ page 5)


1 2 3 4

5 6 7 8 9 p q w e r t

1 “TUNER” :
• Performs Auto Storing (AS).
• Performs Preset Scanning (PS) if pressed and
held. y i
2 Selects the bands.
u
3 Changes the information on the display window
or monitor.
4 Opens/closes the monitor panel.
5 Disc loading slot
6 • Turns on the power. r Detaches the control panel.
• Adjusts the volume if turned (while the power t Ejects the disc.
is on). y AUX input jack
• Mutes the sound if the power is on.*1 u SD card slot
• Turns off the power if pressed and held. i USB terminal
7 Selects the source.
8 • “TUNER” : Performs Auto Search. *1 Muting is automatically canceled as you change the
• “DISC/USB/SD/iPod”: Reverse skip/forward skip source.
9 Remote sensor *2 Use these buttons when the monitor panel is opened.
p “DISC/USB/SD/iPod”: Plays/pauses.
q Changes the source to “DISC” (and starts This unit contains a magnet. Do not bring the
playback). following objects close to the unit:
w*2 Displays or exits “Main Menu” of the unit. • Watches
e*2 • Displays the audio setting screen. • Magnetic stripe cards such as credit cards
• Displays the speaker adjustment screen while • Magnetic tapes such as casette tapes and video
enjoying multi-channel surround playback. tapes

EN01_KD-AV7100_JW.indd 4 08.6.9 0:16:01 PM


When the monitor panel is opened

ENGLISH
o ; a s

o Monitor s • “TUNER/DISC/USB/SD/iPod”: Displays the


• The touch panel operations are available. current station/track information on the
; Slides the monitor panel forward/backward. monitor.
a • Changes the angle of the monitor panel. • Displays the brightness adjustment bar or
• Adjusts the brightness of the monitor when “Picture Menu” if pressed and held.
the adjustment bar is displayed.
• Adjusts the picture from the external
components when “Picture Menu” is displayed.

Display window 1 23 4

1 Main display (See below.) 4 Lights when receiving an FM stereo broadcast


2 Lights up when Local Tuning for FM is with sufficient signal strength.
activated. (☞ page 12)
3 Lights up when Loudness is activated. (☞ • When the monitor panel is opened, the display
page 40) window turns off.
To change the information on the main display:
On the unit: Ex.: For CD Text
Track number/playing time

On the remote: Track title scrolls.

Source
Available display information varies according to the
playback source.
• Each time you press the button, the information Clock
on the main display changes to show the various
information.
(back to the beginning)

5 INTRODUCTION

EN01_KD-AV7100_JW.indd 5 08.7.8 2:11:33 PM


Basic operations — Remote controller (RM-RK253)
ENGLISH

When you use the remote controller for the first time, Before using the remote controller:
pull out the insulation sheet. • Aim the remote controller directly at the remote
sensor on the unit.
• DO NOT expose the remote sensor to bright light
(direct sunlight or artificial lighting).

If the range of effectiveness of the remote controller


decreases, replace the battery.
Insulation sheet
To replace the battery:

Warning:
To prevent accidents and damage
• Do not install any battery other than CR2025 or its
equivalent.
• Do not leave the remote controller in a place
(such as dashboards) exposed to direct sunlight
for a long time.
• Store the battery in a place where children cannot
reach.
• Do not recharge, short, disassemble, or heat the
battery or dispose of it in a fire.
• Do not leave the battery with other metallic
materials.
• Do not poke the battery with tweezers or similar
tools.
• Wrap the battery with tape and insulate when
throwing away or saving it.

Caution:
Battery shall not be exposed to excessive heat such
as sunshine, fire or the like.

AV7100_inst[JW].indb 6 08.5.19 11:11:50 PM


Main elements and features 5 DVD: Displays the disc menu.
6 • “TUNER”: Performs Auto Search.
• “DISC/USB/SD/iPod”: Reverse skip/forward

ENGLISH
skip.
1 8 7 “DISC/USB/SD“: Enlarges the playback picture.
9 8 • Turns on the power.
• Mutes the sound if the power is on.*1
2 p
• Turns off the power if press and held.
9 Opens/closes the monitor panel.
q p Adjusts the volume level.
w q • Changes the information on the display when
e the monitor panel is closed.
3 r • “TUNER/DISC/USB/SD/iPod”: Displays the
t current station/track information on the
4 y
monitor when the monitor is opened.
5 u w*2 • Displays the audio setting screen.
i
6 o • Displays the speaker adjustment screen while
enjoying multi-channel surround playback.
7 ; e • “TUNER”: Selects the bands.
• “DISC/USB/SD/iPod“: Stops playback.
r*2 Displays the brightness adjustment bar or
“Picture Menu.”
t*2 Displays or exits “Main Menu” of the unit.
y “DISC/USB/SD“: Performs A-B Repeat.
u “DISC/USB/SD/iPod”: Selects Repeat Mode.
Operations are explained mainly using the touch i • DVD: Displays the disc menu.
panel; however, you can use the buttons on the • VCD: Turns on/off the PBC function.
unit and remote controller if they have the same or o • “TUNER”: Performs Manual Search
similar names or marks. • “DISC/USB/SD/iPod”: Reverse search/forward
search
1 Selects the source. ; • DVD Video: Selects audio language ( ),
2 • Enters numbers. subtitles ( ), and angle ( ).
• “TUNER”: Selects the preset stations. • VCD: Selects audio channel ( ).
• DVD/VCD: Performs title/chapter (track)/time
search.
• DivX/MPEG/JPEG/CD/MP3/WMA, “USB/SD/ *1 Muting is automatically canceled as you change the
iPod”: Selects track. source.
3 Returns to the previous screen. *2 Use these buttons when the monitor panel is opened.
4 • : Selects items/options.
• ENT: Confirms the selection/setting.
• “DISC/USB/SD/iPod“: 6: Plays/pauses.

7 INTRODUCTION

EN01_KD-AV7100_JW.indd 7 08.7.8 11:22:40 AM


Playable disc type
ENGLISH

Disc type Recording format, file type, etc. Playable


DVD DVD Video (Region Code: 4)*1

DVD Audio
DVD-ROM
DVD Recordable/Rewritable DVD Video
(DVD-R/-RW*2, +R/+RW*3) DivX*4/MPEG1/MPEG2
• DVD Video: UDF bridge JPEG
• DivX/MPEG1/MPEG2/JPEG/MP3/ MP3/WMA
WMA: ISO 9660 level 1, level 2, WAV/AAC
Romeo, Joliet
MPEG4
DVD-VR/DVD+VR
DVD-RAM
DualDisc DVD side
Non-DVD side
CD/VCD Audio CD/CD Text (CD-DA)
VCD (Video CD)
DTS-CD
SVCD (Super Video CD)
CD-ROM
CD-I (CD-I Ready)
CD-G
CD Recordable/Rewritable CD-DA
(CD-R/-RW) MP3/WMA
• ISO 9660 level 1, level 2, Romeo, JPEG
Joliet DivX/MPEG1/MPEG2
WAV/AAC
MPEG4
*1 If you insert a DVD Video disc of an incorrect Region Code, “Disc region incorrect” appears on the monitor.
*2 DVD-R recorded in multi-border format is also playable (except for dual layer discs).
DVD-RW dual layer discs are not playable.
*3 It is possible to play back finalized +R/+RW (Video format only) discs.
+RW double layer discs are not playable.
*4 DivX Ultra is not playable.

Caution for DualDisc playback


The Non-DVD side of a “DualDisc” does not comply with the “Compact Disc Digital Audio” standard. Therefore,
the use of Non-DVD side of a DualDisc on this product may not be recommended.

AV7100_inst[JW].indb 8 08.6.24 3:10:31 PM


Clock setting

ENGLISH
Before operating the unit, set the clock. 3 Adjust the clock.
• If no operation is done for about 15 seconds, the Ex.: When setting to “3:45 PM”
menu operation will be canceled.
SETUP MENU BACK

Indication language: General Language


Radio : S-Amer1
In this manual, English indications are used Clock : 12:00 AM
for purpose of explanation. You can select the Clock Mode : 12Hr
TFT Auto Open : Off
indication language on the monitor. (☞ page 42) Version B/E:901.04.1.080512
Audio ASP MISC

On the touch panel only:


1 3 = 4 = 5 = OK
SETUP MENU BACK

General Language
3 : 45
1 2 3
4 5 6
7 8 9
1 2 1
0 OK
Audio ASP MISC
2
Cancels the last entry.

2 TUNER 12:00 AM
SETUP MENU BACK
ST FM-1 87.5 MHz
General Language
P-01 87.7 MHz
Radio : S-Amer1
P-02 89.9 MHz
Clock : 03:45 AM
P-03 97.9 MHz
Clock Mode : 12Hr
P-04 105.9 MHz
TFT Auto Open : Off
P-05 107.9 MHz
Version B/E:901.04.1.080512
AS PS SCAN DX DISP
Audio ASP MISC

Return to the previous screen. AM PM

Main Menu BACK


4 Finish the procedure.
(twice)
SETUP MENU BACK
TUNER DISC AUX IN AV-IN
General Language
LOCK

USB iPod SD CAMERA


Radio : S-Amer1
Clock : 03:45 PM
MONITOR Clock Mode : 12Hr
SET UP
OFF TFT Auto Open : Off
Version B/E:901.04.1.080512
Audio ASP MISC

9
OPERATIONS

EN02_KD-AV7100_JW.indd 9 08.6.9 0:16:55 PM


Common operations
ENGLISH

Selecting the playback source Adjusting the volume level


• Available sources differ depending on the external On the unit:
devices or components you have connected and
media you have inserted.
1 TUNER 3:45 PM

ST FM-1 87.5 MHz

P-01 87.7 MHz


P-02 89.9 MHz
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz
On the remote:
AS PS SCAN DX DISP

2 Current source *
Main Menu BACK

Volume level indication


TUNER DISC AUX IN AV-IN
TUNER 3:45 PM
LOCK

USB iPod SD CAMERA


ST FM-1 87.5 MHz

P-01 87.7 MHz


MONITOR
OFF P-02 89.9 MHz
SET UP
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz
Touch the target source.
AS PS SCAN DX DISP

On the unit: On the remote:

10

• Each time you press the button, the source Playback picture
changes as follows:
“DISC” = “AV-IN” = “TUNER” = “USB” =
“iPod” = “SD” = “CAMERA” * = “AUX IN”
15
= (back to the beginning)

* When the source is “CAMERA”...


– The sound of the source selected previously is
emitted from the speakers.
– Pressing SOURCE or SRC will change the source to
the one selected previously.

10

AV7100_inst[JW].indb 10 08.6.24 3:10:33 PM


Adjusting the monitor On the remote:
brightness 1

ENGLISH
1 Display the adjustment bar.

P-04 105.9 MHz 3


P-05 107.9 MHz

AS PS SCAN DX10 DISP

• If no operation is done for about 5 seconds, the


adjustment bar will disappear. Turning off the monitor
2 Adjust the brightness. On the touch panel only:
1 TUNER 3:45 PM

ST FM-1 87.5 MHz

P-01 87.7 MHz

3 Finish the procedure.


P-02 89.9 MHz

2 Main Menu BACK

TUNER DISC AUX IN


LOCK
AV-IN

USB iPod SD CAMERA

Picture adjustment for “AV-IN” and “CAMERA” MONITOR


OFF
When the source is “AV-IN” or “CAMERA” and SET UP

video signals are coming in, “Picture Menu” screen


appears in step 1 above. To turn on the monitor, touch the monitor.
Press PICTURE on the unit or on the remote to • Pressing any button will also turn on the monitor.
select an item to adjust, then adjust it by following
step 2 above. Dimmer function
Sharpness Adjust the sharpness. According to the use of the dimmer function,
Color Adjust the color of the picture— connect the ILLUMI lead as follows:
lighter or darker. • For Auto Dimmer: Connect it to the car
headlight switch. When you turn on the car
Contrast Adjust the contrast.
lights, dimmer starts working—Auto Dimmer
Brightness Adjust if the picture is too bright or • For Constant Dimmer: Connect it to the car
too dark. battery (constant 12 V). Dimmer works whenever
Tint Adjust the tint if the human skin you turn on the power.
color is unnatural. • For Dimmer Off: Connect it to nowhere.
See also the Installation/Connection Manual
(separate volume).
11
OPERATIONS

EN02_KD-AV7100_JW.indd 11 08.7.8 2:12:08 PM


Listening to the radio
ENGLISH

~ ! ST indicator Current band/frequency

TUNER 3:45 PM

ST FM-1 87.5 MHz


Ÿ P-01 87.7 MHz Display the preceding page.
P-02 89.9 MHz
P-03 97.9 MHz Preset list
P-04 105.9 MHz
P-05 107.9 MHz Display the succeeding page.
AS PS SCAN DX DISP

☞ page 13 ☞ page 14 ☞ below ☞ page 14


☞ page 13

~ Select “TUNER” for the source.


(☞ page 10)
Ÿ Select the band.
• You can also use BAND on the unit and remote.
! Search for a station—Auto Search.
• Manual Search: Press 1 or ¡ repeatedly.
• The ST indicator lights up when receiving an FM stereo broadcast with sufficient signal strength.

Tuning in to stations with sufficient signal strength


This function works only for FM bands. Once you have activated this function, it always works when searching for FM
stations.
P-04 105.9 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

LOC DX
The button changes to LOC and only stations with sufficient signal strength will be detected.
• Each time you press the button, the button alternates between DX and LOC.

12

AV7100_inst[JW].indb 12 08.5.19 11:11:54 PM


Automatic Storing—AS Selecting stored stations
You can store 6 stations for each band.

ENGLISH
TUNER 3:45 PM

TUNER 3:45 PM ST FM-1 92.5 MHz

ST FM-1 87.5 MHz P-01 1


87.7 MHz
P-02 89.9 MHz
P-01 1
87.7 MHz P-03 97.9 MHz
P-02 89.9 MHz P-04 92.5 MHz
P-03 97.9 MHz P-05 107.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz AS PS SCAN 2DX DISP

AS PS SCAN DX DISP

2 • You can also tune in to a stored station by its preset


number.
Local stations with the strongest signals are searched P-05 107.9 MHz
and stored automatically in the selected band. AS PS SCAN DX DISP
• After storing stations, the unit tunes in to preset
number 1.
To stop Auto Storing, press AS again.
TUNER 3:45 PM

ST FM-1 87.5 MHz


Manual storing 1
––
2 3

1 Tune in to a station you want to store. 4 5 6

☞ page 12 7 8 9 1
0 OK
2 Select a preset number. AS PS SCAN DX DISP
2
TUNER 3:45 PM

ST FM-1 92.5 MHz


Cancels the last entry.
P-01 87.7 MHz
P-02 89.9 MHz
P-03 97.9 MHz On the remote:
P-04 105.9 MHz
P-05 107.9 MHz 1
AS PS SCAN DX DISP

TUNER 3:45 PM
2
ST FM-1 92.5 MHz
or
P-01 87.7 MHz
P-02 89.9 MHz
P-03 97.9 MHz
P-04 92.5 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

The station selected in step 1 is now stored in


preset number 4.

13
OPERATIONS

AV7100_inst[JW].indb 13 08.5.19 11:11:55 PM


Scanning stations Changing the information on the
You can search for a station broadcasting the program monitor
ENGLISH

you want to listen to by previewing stations.


TUNER 3:45 PM

To scan all stations of the selected band ST FM-1 87.5 MHz

P-01 87.7 MHz


TUNER 3:45 PM
P-02 89.9 MHz
ST FM-1 87.5 MHz P-03 97.9 MHz
P-04 105.9 MHz
P-01 1
87.7 MHz P-05 107.9 MHz
P-02 89.9 MHz
AS PS SCAN DX DISP
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

2 TUNER 3:45 PM

ST FM-1 87.5 MHz


The unit searches for the available stations.
• When a station is detected, the unit tunes in to this FM-1

station for about 10 seconds (the frequency on the 87.5 MHz


monitor flashes), then start searching for the next
available station.
AS PS SCAN DX DISP
To stop scanning, press SCAN again.

To scan only the preset stations of the


selected band
TUNER 3:45 PM

ST FM-1 87.5 MHz

P-01 1
87.7 MHz
P-02 89.9 MHz
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

2
The unit tunes in to the preset stations for about 10
seconds per station.
• After tuning in to all preset stations, the unit tunes in
to preset number 1.
To stop scanning, press PS again.

14

AV7100_inst[JW].indb 14 08.5.19 11:11:55 PM


Disc operations

ENGLISH
The disc type is automatically detected, and playback starts automatically (for some discs: automatic start depends
on its internal program).
• Playback will stop after playing back all chapters/tracks on the disc.

If “ ” appears on the monitor, the unit cannot accept the operation you have tried to do.
• In some cases, without showing the message, operations will not be accepted.

Ÿ
Label side

~ Insert a disc. Caution on volume setting:


• Without turning on the power, you cannot Discs produce very little noise compared with other
insert the disc. sources. Lower the volume before playing a disc
Ÿ Open the monitor panel. to avoid damaging the speakers by the sudden
increase of the output level.

• If “TFT Auto Open” is set to “On,” the monitor automatically comes out when you turn on the unit. (☞ page 42)
• For the space required for monitor ejection, see page 55.

15 OPERATIONS

AV7100_inst[JW].indb 15 08.5.19 11:11:56 PM


Basic touch operations
You can use the following 3 types of touch panel operations for disc playback.
ENGLISH

• Touch operation on playback pictures


For

While playing back a picture, you can perform some operation just touch the specified area of the screen. (☞
below)
• Operation using the on-screen buttons
For

While playing back a picture, you can use the basic operation buttons displayed on the playback picture. (☞
page 17)
• Operation on the list screen
For

You can use the buttons on the list screen. (☞ pages 18 and 19)
• For DivX/MPEG/JPEG, the list screen appears while playback is stopped.

Touch operation on playback pictures

Playback picture

A Displays “Main Menu” of the unit.


B Skips to the previous chapter/track.
A E
C Displays the playback information.
C (☞ page 24)
D Displays the on-screen buttons.
(☞ page 17)
B F E Displays the Search Screen.*1
D (☞ page 22)
F Skips to the next chapter/track.

• This function may not be available while displaying the main


menu of DVD Video.

16

AV7100_inst[JW].indb 16 08.5.19 11:11:56 PM


Operations using the on-screen buttons
• If no operation is done for about 15 seconds, the on-screen buttons disappear.

ENGLISH
Playback picture Displays the main menu of DVD Video*2

Selects the subtitle


language.*2 (☞ page 21)

Selects audio language/


channel. (☞ page 21)
Selects Repeat Mode. (☞
Stops playback. Performs A-B Repeat. (☞ page 26) page 23)

Reverse search*3 Forward search*3


Starts playback/pauses.

*4
Playback picture

*4

Performs A-B Repeat.


(☞ page 26)
Reverse search*3 Selects Repeat Mode. (☞ page 23)
Starts playback/pauses. Stops playback.
Forward search*3

*4 Playback picture

Rotates the picture by 90°.

Displays the thumbnail. (☞ page 21) Stops playback.

*1 Only for DVD Video/VCD


*2 Only for DVD Video
*3 Search speed: x2 ] x4 ] x8 ] x16 ] (normal playback)
To resume normal playback during search, press 6.
*4 Each time you press the on-screen button, the on-screen buttons disappear. To repeat the procedure, display the
on-screen button again.

17 OPERATIONS

EN03_KD-AV7100_JW.indd 17 08.7.1 11:14:05 AM


Operation on the list screen
To select track, touch the desired track name on the list.
ENGLISH

While stopped...

Track No./Total track No. in the current folder Where playback has been stopped

Displays “Main Menu” of


7 Stop CD-R
DISC DivX 3:45 PM
the unit.
01/14 00:01:35
3 : Starts playback.*1
1 ¡ 4 ¢ : *2 . .Current Folder Name Displays the
File Name preceding page.
File Name
File Name
File Name Displays the
succeeding page.
*2 7 SCAN DISP

Displays the contents of


*2 Displays/hides the folder/track
the next/previous folder. Displays the on-screen number buttons. list.
(☞ page 20) Selects Repeat Mode. (☞ page 23)
*2

While stopped...
3 : Starts playback (Slide show).*1
Displays “Main Menu” of the unit. 1 ¡ 4 ¢ : *2

7 Stop
DISC JPEG 3:45 PM

. .Current Folder Name Displays the


File Name preceding page.
File Name
File Name
Displays the
File Name
succeeding page.
7 SCAN DISP
*2

Displays the contents of the next/ *2 *2 Displays/hides the folder/track


previous folder. (☞ page 20) list.
Displays the on-screen number buttons.
Selects Repeat Mode. (☞ page 23)

18

AV7100_inst[JW].indb 18 08.6.24 3:10:38 PM


Displays “Main Menu” of the unit.

ENGLISH
Track No./Total track No. Playing time

DISC CDDA 3:45 PM


8 : Pauses.*3 01/14 01:35
1¡:
Reverse/forward Track Title Displays the
search*4 Track Title preceding page.
4¢: Track Title
Selects track. Track Title
Track Title
Displays the
*5 succeeding page.
Stops playback. 7 SCAN DISP

Activates/deactivates Scan Mode. (☞ page 23) Displays the disc text. (☞ page 24)
Displays the on-screen number buttons.
Selects Repeat Mode. (☞ page 23) Activates/deactivates Shuffle Mode.
(☞ page 23)

Displays “Main Menu” of the unit. File type (MP3/WMA)


Track No./Total track No. in the current folder

DISC MP3 3:45 PM

8 : Pauses.* 3 01/14 01:35 Playing time


1¡:
. .Current Folder Name Displays the
Reverse/forward
File Name preceding page.
search*4
File Name
4¢:
File Name
Selects track. File Name Displays the
succeeding page.
Stops playback.*1 7 SCAN DISP

Displays the Tag information.


Displays the contents of the next/previous folder.
(☞ page 24)
(☞ page 20)
Activates/deactivates Shuffle Mode.
Activates/deactivates Scan Mode. (☞ page 23)
(☞ page 23)
Displays the on-screen number buttons. Selects Repeat Mode. (☞ page 23)

*1 When you start playback next time, playback will start from the first track of the current folder.
*2 These buttons do not work.
*3 While playback is paused or stopped, or during reverse/forward search, this button changes to 3 (play).
*4 Search speed: x2 ] x4 ] x8 ] x16 ] (normal playback)
To resume normal playback during search, press 3.
*5 Track number appears for conventional CDs (ex.: “Track08.CDA”).

19 OPERATIONS

AV7100_inst[JW].indb 19 08.5.19 11:11:59 PM


Selecting a track To select a track by its track number
To select a track in other folders
ENGLISH

For DivX/MPEG/JPEG: While stopped

For DivX/MPEG/JPEG: While stopped


1 DISC MP3 3:45 PM
• Available only when folder/track list is displayed. 01/14 01:35

1 Select a folder. . .Current Folder Name


• To select the next folder: File Name
File Name
File Name File Name
File Name
7 SCAN DISP
7 SCAN DISP

• To select the previous folder:


File Name
2 Enter the desired track number.
7 SCAN DISP
• For DivX/MPEG/JPEG/MP3/WMA: Specify the
track number in the current folder.
DISC MP3 3:45 PM
• To select the folder of the upper level: 01/14 01:35
––––
DISC MP3 3:45 PM .. 1 2 3
File Name
01/14 01:35 4 5 6
File Name
. .Current Folder Name
7
File Name 8 9 1
File Name File Name 0 OK
File Name 7 SCAN DISP
File Name 2
File Name
7
Cancels the last entry.
SCAN DISP

The contents of the folder containing the folder


touched are displayed.
2 Select a track.
DISC MP3 3:45 PM

01/14 01:35

. .Current Folder Name


File Name
File Name
File Name
File Name
7 SCAN DISP

20

AV7100_inst[JW].indb 20 08.5.19 11:11:59 PM


Selecting the subtitle language 2 Ex.: When a disc has 3 audio languages

ENGLISH
1 Touch this area. (☞ page 16)

1/3 D 5.1Ch Eng

D 5.1Ch Eng D 5.1Ch Fre


D 5.1Ch Spa

2 Ex.: When a disc has 3 subtitle languages


Selecting a picture from the
thumbnail

1/3 Eng You can use thumbnail screen to select a picture.


1 Touch this area. (☞ page 16)

Eng Fre Spa

Selecting the audio language/


channel
2
1 Touch this area. (☞ page 16)

The pictures in the current folder are displayed.


3

Slide show starts from the selected picture.


21 OPERATIONS

EN03_KD-AV7100_JW.indd 21 08.6.26 1:32:59 PM


Using the Search Screen
Ex.: When searching for a track by its number
ENGLISH

While playing back...


Ex.: When searching for a chapter by its number
Touch this area. (☞ page 16)
While playing back...
Touch this area. (☞ page 16)

Search
Search 1 Track ---
1 Title --- 2 Time - -:- -:- -

2 Chapter ---
3 Time - -:- -:- -

1 Track search by its number


1 Title search by its number
2 Track time search (Specify a certain scene by
2 Chapter search by its number
entering time in the track.)
3 Time search (Specify a certain scene by entering
time.)

Search
Track ---
Search 1 2 3
Time - -:- -:- -
Title --- 1 4 5 6
1 2 3
Chapter ---
Time - -:- -:- - 1 4 5 6 7 8 9 2
7 8 9 2 0 OK

0 OK
3
3
Cancels the last entry.
Cancels the last entry.

On the remote:
1 Display the search screen. 3
2 Select an item. 4 Finish the procedure.

22

AV7100_inst[JW].indb 22 08.6.24 3:10:41 PM


Selecting playback modes
You can use only one of the following playback Ex.: When activating “Repeat single” for MP3

ENGLISH
modes—Scan/Repeat/Shuffle. DISC MP3 Repeat single3:45 PM
• For DVD/VCD, display the on-screen buttons first. (☞
02/14 01:35
page 16)
. .Current Folder Name
File Name
DISC MP3 3:45 PM
File Name
02/14 01:35 File Name
File Name
. .Current Folder Name
7 SCAN DISP
File Name
File Name
File Name
File Name
7 SCAN DISP single Folder all off

Scan Mode Shuffle Mode


Repeat Mode* The playback mode icon of the selected mode is
displayed.
DISC MP3 S 3:45 PM
* You can also use the remote controller.
02/14 01:35

To cancel, select “off.”


Disc type Scan Repeat Shuffle
Chapter: Repeats current
— chapter. —
Title: Repeats current title.
single: Repeats current track
— (PBC not in use). —
all: Repeats all tracks.
On (SCAN): Plays the first 10 single ( ): Repeats current Shuffle ( ): Shuffles all
seconds of each track. track. tracks and play them
all ( ): Repeats all tracks. randomly.
On (SCAN): Plays the first 10 single ( ): Repeats current Shuffle ( ): Shuffles all
seconds of each track. track. tracks of the current folder
Folder ( ): Repeats all and play them randomly,
tracks of the current then tracks of next folders.
folder.
all ( ): Repeats all tracks.
single ( ): Repeats current
track.
Folder ( ): Repeats all
— —
tracks of the current
folder.
all ( ): Repeats all tracks.

23 OPERATIONS

AV7100_inst[JW].indb 23 08.5.19 11:12:02 PM


Displaying the playback For VCD
1 9
information VCD2.0 Time 13:24/ 25:15
ENGLISH

PBC On

0
1 Disc type/File type
2 Current title (folder) No./total title (folder) No.
You can display the playback information. 3 Playing time/remaining time
4 Subtitle selection
On the unit: 5 Angle selection
6 Current chapter (track) No./total chapter (track)
or No.
7 Current bit rate
8 Audio selection (audio signal and language)
On the remote: 9 Playing time/remaining time of the track
0 PBC On (Current track No./total track No. when PBC
is off.)

• Touch operation is also available. (☞ page 16) Changing the information on the
monitor
While playing back...
For DVD
1 2 3 4
DVD Video Time 00:13:24/01:25:15 DISC MP3 3:45 PM
Title 1/3 Subtitle 2/3 French
Chapter 4/12 Audio 1/3 D 5.1Ch Eng 02/14 01:35
Angle 1/3 Bitrate 7.3Mbps
. .Current Folder Name
5 6 7 8 File Name
File Name
For DivX File Name
File Name
1 3
7 SCAN DISP
DivX 5.x Time 00:13:24/01:25:15
Track 10/12 Audio 1/3 MP3 2 Ch
Subtitle Off

6 4 8
DISC MP3 3:45 PM
For MPEG
02/14 01:35
1 3
MPEG Time 00:13:24/01:25:15
Name: Track Title
Track 10/12
Artist: Artist Name
Album: Album Name
6
7 SCAN DISP
For JPEG
1 6
JPEG Track 10/12 • “Unknown” appears for conventional CDs or when
the file does not have Tag information.

24

EN03_KD-AV7100_JW.indd 24 08.6.25 11:50:26 AM


Restricting playback 4 Enter a 4-digit number for your password.
You can restrict playback of DVD Video containing SETUP MENU BACK

ENGLISH
violent scenes and those unsuitable for your family
General Language
members.
TS Calibrate : No
• Playback of discs containing higher level than Set Password :----
Parental control : PG-13
the selected level will be restricted. Some discs Aspect Ratio : 16:9
may not be played back at all, and others may be Screen saver : On
Audio ASP MISC
played back with higher level scenes skipped.
• This setting takes effect only for a DVD Video
containing restriction level information. SETUP MENU BACK
Enter Password

1 Touch this area (☞ page 16) General Language


__
1 2 3
4 5 6
7 8 9 1
0 OK
Audio ASP MISC
2
Main Menu BACK
Cancels the last entry.

TUNER DISC AUX IN AV-IN “Enter Password Again” appears.


5 Enter the password again.
LOCK

USB iPod SD CAMERA


“Locked” appears for “Set Password,” and you
MONITOR cannot select “Parental control.”
OFF
SET UP • You need to enter the password to change the
restriction level or password
2 SETUP MENU BACK • Without entering the password in this step, the
settings you have made are stored.
General Language
TS Calibrate : No 6 Finish the procedure.
Set Password :---- (twice)
Parental control : 8. Adult
Aspect Ratio : 16:9 SETUP MENU BACK
Screen saver : On
General Language
Audio ASP MISC
TS Calibrate : No
Set Password : Locked
3 Set the restriction level. Parental Control : 4. PG-13

• For details about the restriction level, see page


45.
SETUP MENU BACK

General Language
TS Calibrate : No
Set Password :---- 4. PG-13
Parental control : 8. Adult 5. PG-R
Aspect Ratio : 16:9 6. R 2
Screen saver 1
: On
Audio ASP MISC

Displays more options.


25 OPERATIONS

AV7100_inst[JW].indb 25 08.5.19 11:12:04 PM


Operations using the remote controller—RM-RK253
ENGLISH

Stops playback.

Starts playback/pauses (if pressed during playback).

Reverse/forward search*1 (No sound can be heard.)


Selects chapter (during playback or pause).

Title/chapter/time search (☞ page 22)


Selects Repeat Mode. (☞ page 23)
Selects audio language.
Selects subtitle language.
Selects view angle.
Zooms in.*2

Using menu driven features


1 Display the disc menu.

2 Select an item you want to play back.

Repeating the desired portion—A-B Repeat


1 Select the start position (A)*3.

2 Select the end position (B)*3.

To cancel A-B Repeat:

26

AV7100_inst[JW].indb 26 08.6.24 3:10:45 PM


ENGLISH
Stops playback. Stops playback.
Starts playback/pauses (if pressed Starts playback/pauses (if
during playback). pressed during playback).
Reverse/forward search*1 Reverse/forward search*1. (No
sound can be heard.)
Selects track.
Selects track.
Selects track (within the same
folder).
Selects Repeat Mode. (☞ page
Track/time search (☞ page 22)
23)
Selects Repeat Mode. (☞ page 23)
Zooms in.*2
Selects audio channel (ST: stereo,
L: left, R: Right). Repeating the desired portion—A-B Repeat
Zooms in.*2 1 Select the start position (A)*3.

Cancels/resumes PBC playback.


2 Select the end position (B)*3.
During PBC playback...
To cancel A-B Repeat:
= :
Select an item on the menu.

:
Move to the next/previous page of the current
menu.

Repeating the desired portion—A-B Repeat


1 Select the start position (A)*3.

2 Select the end position (B)*3.

To cancel A-B Repeat:

*1 Search speed: x2 ] x4 ] x8 ] x16 ] (normal playback)


To resume normal playback during search, press 6.
*2 Magnification: +1 ] +2 ] +3 ] Off
*3 The start/end position actually played may be different from the selected position by a few seconds.

27 OPERATIONS

AV7100_inst[JW].indb 27 08.6.24 3:10:46 PM


ENGLISH

Stops playback. Stops playback.


Starts playback. (Slide show: Starts playback/pauses (if
each file is shown for a few pressed during playback).
seconds.)
Reverse/forward search*2
Reverse/forward skip
Selects track.
Selects track (within the same
folder). Selects track (within the same
folder).
Selects Repeat Mode. (☞ page
23) Selects Repeat Mode. (☞ page
23)
Zooms in.*1
Repeating the desired portion—A-B Repeat
1 Select the start position (A).

Stops playback. 2 Select the end position (B).


Starts playback/pauses (if
pressed during playback). To cancel A-B Repeat:
Reverse/forward search*2
Selects track.
Selects track.
Selects Repeat Mode. (☞
page 23)

Repeating the desired portion—A-B Repeat


1 Select the start position (A).

2 Select the end position (B).

To cancel A-B Repeat:

*1 Magnification: +1 ] +2 ] +3 ] Off
*2 Search speed: x2 ] x4 ] x8 ] x16 ] (normal playback)
To resume normal playback during search, press 6.
28

AV7100_inst[JW].indb 28 08.5.19 11:12:07 PM


Enjoying 5.1-channel surround 4 Select the speaker size.
• For details about speaker size, see page 43.
sounds

ENGLISH
• Without activating center/surround speakers, no
You can enjoy multi-channel surround playback sound comes out of these speakers.
through the front, center, surround speakers for multi- Ex.: Activating the center speaker
channel sources encoded with Dolby Digital*.
SETUP MENU BACK
* Manufactured under license from Dolby Laboratories.
Dolby, Pro Logic, and the double-D symbol are General Language

trademarks of Dolby Laboratories. DownMix : FULL 6CH


Front Speakers : Large Large
1 Touch this area. (☞ page 16) Center Speaker
Sur Speakers
: None
: None
Small
None
Subwoofer : None 1 2
Audio ASP MISC

5 Finish the procedure.


(twice)
Return to the previous screen. SETUP MENU BACK

Main Menu BACK General Language


DownMix : FULL 6CH
TUNER DISC AUX IN AV-IN
LOCK

USB iPod SD CAMERA


To adjust the speaker output level
MONITOR
While enjoying multi-channel surround playback, you
SET UP
OFF
can adjust the speaker output level within the range of
–10 to +10.

2 SETUP MENU BACK


Return to the previous screen.
General Language
DownMix : DownMix
6CH Audio
Front Speakers : Large
Center Speaker : None VOL 15 – +
Sur Speakers : None
LEFT 0 – +
Subwoofer : None
RIGHT 0 – +
Audio ASP MISC
S.Left 0 – +
S.Right 0 – +
Center 0 – +
3 Activate 5.1-channel surround (“FULL 6CH”). SUB.W 0 – +

SETUP MENU BACK


• VOL: Volume level (0 to 40).
General Language • LEFT: Left front speaker level (–10 to +10).
DownMix : DownMix • RIGHT: Right front speaker level (–10 to +10).
Front Speakers : Large FULL 6CH
Center Speaker 1
: None DownMix
• S.Left: Left surround speaker level (–10 to +10).
Sur Speakers : None 2 • S.Right: Right surround speaker level (–10 to +10).
Subwoofer : None
• Center: Center speaker level (–10 to +10).
Audio ASP MISC
• SUB.W: Subwoofer level (–10 to +10).
• For “DownMix,” see page 43.

29 OPERATIONS

AV7100_inst[JW].indb 29 08.5.19 11:12:08 PM


Enjoying Pro Logic II modes 2 Activate the selected Pro Logic II mode.
You can use Dolby Pro Logic II modes for reproducing SETUP MENU BACK
ENGLISH

spacious sound from 2 channel sources except DivX/


General Language
MPEG1/MPEG2 discs.
Down sampling : On
Decode Mode : Pro Logic
Follow the steps 1 and 2 on page 29, then... Panorama : Off
Dim Ctrl : Off
1 Select the Pro Logic II mode. C W Ctrl : Off
Audio ASP MISC
SETUP MENU BACK

General Language
DownMix : DownMix SETUP MENU BACK
Front Speakers : Large
Center Speaker : None General Language
Sur Speakers : None
Test tones : Off
Subwoofer : None
Center delay : No delay Off
Audio ASP MISC Surr delay : No delay On
Night Mode
Pro Logic
: Off
: Off
Auto
2

SETUP MENU BACK


Audio ASP 1 MISC

General Language • Off: Deactivates the Pro Logic II mode.


Down sampling : On • On: Activates the selected Pro Logic II mode.
Decode Mode : Off Off
Panorama : Off Pro Logic • Auto: Activates appropriate Pro Logic II mode
Dim Ctrl 1: Off PLII Matrix
2 for the playback source (Pro Logic/PLII Matrix/
C W Ctrl : Off
Audio ASP MISC
PLII Movie/PLII Music).
3 Finish the procedure.
Displays more options. (twice)
• Off: Applies no effect.
SETUP MENU BACK
• Pro Logic: Selects Pro Logic; suitable for sources
encoded with Dolby Surround. General Language

• PLII Matrix: Selects Pro Logic II Matrix; suitable Test tones : Off

for monaural sound or for playing selected


audio channel of, for example, Karaoke VCD. • When “PLII Music” is activated (“On” or “Auto”), you
• PLII Movie: Selects Pro Logic II Movie; suitable can add or adjust the effect—Panorama, Center
for movie. Width, Dimension control. (☞ page 44)
• PLII Music: Selects Pro Logic II Music; suitable
for music.

30

AV7100_inst[JW].indb 30 08.5.19 11:12:09 PM


SD operations

ENGLISH
This unit can play the MPEG/JPEG/MP3/WMA files stored in an SD card.
• You can operate the SD card in the same way you operate the files on discs. (☞ pages 17 to 28)
• Playback will stop after playing back all tracks in the SD card.
• If you start playback again after changing the source or turning off the unit, the playback starts from the first track.
• Make sure all important data has been backed up.

~ Open the front cover. Caution:


Ÿ Insert an SD card. • Push the center of the end when inserting an SD
Push in the SD card until you hear a clicking sound. card.
! Select “SD” for the source. • For more details about SD operations, ☞ page
48
(☞ page 10)
• Open the monitor if necessary.

To eject the SD card


Push in the SD card lightly, then pull the card out.

31 OPERATIONS

EN03_KD-AV7100_JW.indd 31 08.7.14 2:40:55 PM


Selecting playback modes
You can use only one of the following playback Ex.: When activating “Repeat single” for MP3
ENGLISH

modes—Scan/Repeat/Shuffle. SD MP3 Repeat single3:45 PM

SD MP3 3:45 PM 02/14 01:35

02/14 01:35 . .Current Folder Name


File Name
. .Current Folder Name File Name
File Name File Name
File Name File Name
File Name
7 SCAN DISP
File Name
7 SCAN DISP

single Folder all off


Scan Mode Shuffle Mode
Repeat Mode*

The playback mode icon of the selected mode is


* You can also use the remote controller. displayed.
SD MP3 S 3:45 PM

02/14 01:35

To cancel, select “off.”

File type Scan Repeat Shuffle


On (SCAN): Plays the first 10 single ( ): Repeats current Shuffle ( ): Shuffles all
seconds of each track. track. tracks of the current folder
Folder ( ): Repeats all and play them randomly,
tracks of the current then tracks of next folders.
folder.
all ( ): Repeats all tracks.
Track ( ): Repeats current
track.
Folder ( ): Repeats all
— —
tracks of the current
folder.
all ( ): Repeats all tracks.

32

AV7100_inst[JW].indb 32 08.5.19 11:12:10 PM


USB operations

ENGLISH
You can connect a USB mass storage class device such as a USB memory, Digital Audio Player, etc. to the unit.
This unit can play the JPEG/MPEG1/MPEG2*/MP3/WMA files stored in USB mass storage class device.
• You can operate the USB device in the same way you operate the files on discs. (☞ pages 17 to 28)
• Playback will stop after playing back all tracks in the USB mass storage class device.
• If you start playback again after changing the source or turning off the unit, the playback starts from the first track.
• Make sure all important data has been backed up.
* Except for MPEG2 files recorded by JVC Everio camcorder (extension code <.mod>).

~ • You cannot connect a computer to


the USB ( ) terminal of the unit.

~ Open the front cover.


Ÿ Connect a USB mass storage class device.
! Select “USB” for the source.
(☞ page 10)
• Open the monitor if necessary.

Caution:
• Avoid using the USB device if it might hinder your safety driving.
• Do not pull out and attach the USB device repeatedly while “Reading...” is displayed on the monitor screen.
• Do not start the car engine if a USB device is connected.
• Stop playback before disconnecting a USB device.
• Do not leave a USB device in the car, expose to direct sunlight, or high temperature to avoid deformation or
cause damages to the device.
• For more details about USB operations, ☞ page 49

33 OPERATIONS

EN03_KD-AV7100_JW.indd 33 08.7.14 2:41:37 PM


Selecting playback modes
You can use only one of the following playback Ex.: When activating “Repeat single” for MP3
ENGLISH

modes—Scan/Repeat/Shuffle. USB MP3 Repeat single3:45 PM

02/14 01:35
USB MP3 3:45 PM

02/14 01:35 . .Current Folder Name


File Name
. .Current Folder Name File Name
File Name File Name
File Name File Name
File Name 7 SCAN DISP
File Name
7 SCAN DISP

single Folder all off


Scan Mode Shuffle Mode
Repeat Mode*

* You can also use the remote controller. The playback mode icon of the selected mode is
displayed.
USB MP3 S 3:45 PM

02/14 01:35

To cancel, select “off.”

File type Scan Repeat Shuffle


On (SCAN): Plays the first 10 single ( ): Repeats current Shuffle ( ): Shuffles all
seconds of each track. track. tracks of the current folder
Folder ( ): Repeats all and play them randomly,
tracks of the current then tracks of next folders.
folder.
all ( ): Repeats all tracks.
Track ( ): Repeats current
track.
Folder ( ): Repeats all
— —
tracks of the current
folder.
all ( ): Repeats all tracks.

34

AV7100_inst[JW].indb 34 08.5.19 11:12:12 PM


Listening to the iPod

ENGLISH
You can connect iPod using the supplied special cable for iPod.
• For connection, see the Installation/Connection Manual (separate volume).
• For details, refer also to the manual supplied for your iPod.

Caution:
Special cable for iPod
(supplied) • Avoid using the iPod if it might hinder your safety
while driving.
• Make sure all important data has been backed up
to avoid losing the data.

~ Connect an iPod.
Playback starts automatically from where it had been paused previously.
• If an iPod has been connected, select “iPod” for the source. (☞ page 10)
Ÿ Adjust the volume.
(☞ page 10)
! Adjust the sound as you want.
(☞ page 39)
Displays the “Main Menu” of the unit. Track No./Total track No.

iPod 3:45 PM

01/57 01:35 Playing time


8 : Pauses.*
1¡: Track Title Displays the preceding
Reverse/forward Track Title page.
search Track Title
4¢: Track Title
Selects track. Track Title Displays the succeeding
page.
SCAN DISP

Turns on the video mode. Changes the information on the


Activates/deactivates Scan Mode. monitor (☞ page 37)
(☞ page 37) Activates/deactivates Shuffle Mode. (☞ page 37)
Displays the music menu of the iPod. Selects Repeat Mode. (☞ page 37)
Goes to the previous screen. Displays the on-screen number buttons.

* When playback is paused, or during reverse/forward search, this on-screen button changes to 3 (play).

35 EXTERNAL DEVICES

AV7100_inst[JW].indb 35 08.6.24 3:10:53 PM


Selecting a track from the list Selecting a track by its number
1 1
ENGLISH

Track Title Track Title

SCAN DISP SCAN DISP

2 Select the desired list. 2 Enter the track number.


iPod 3:45 PM iPod 3:45 PM

01/57 01:35 01/57 01:35


–––
Artists 1 2 3
Albums
4 5 6
Songs
Genres 7 8 9 1
Composers 0 OK
SCAN DISP SCAN DISP
2
3 Select an item. Cancels the last entry.
Ex.: When selecting “Albums” in step 2
iPod 3:45 PM Enjoying video playback
01/57 01:35 To watch the video playback on the monitor of the unit,
Album Name set “TV Out” to “TV On” on the iPod.
Album Name • See the instructions supplied for the iPod.
Album Name
Album Name
Album Name
1 Turn on the video mode.
SCAN DISP Track Title
SCAN DISP

• Repeat the procedure to select the desired track.

To go back to the previous screen iPod 3:45 PM

0/0 00:00
Track Title
SCAN DISP

Waiting for Video Signal

SCAN DISP

2 Operate the iPod to play a video source.

To turn off the video mode


iPod 3:45 PM

01/57 01:35

Waiting for Video signal


Audio playback resumes and you can operate the iPod
from the unit.
36

AV7100_inst[JW].indb 36 08.5.19 11:12:14 PM


Selecting playback modes Changing the information on the
You can use only one of the following playback monitor

ENGLISH
modes—Scan/Repeat/Shuffle.
Track Title iPod 3:45 PM

SCAN DISP 01/57 01:35

Track Title
Track Title
Scan Mode Shuffle Mode Track Title
Repeat Mode* Track Title
Track Title

* You can also use the remote controller. SCAN DISP

Ex.: When activating “Repeat single”


iPod Repeat single 3:45 PM iPod 3:45 PM
01/57 01:35 01/57 01:35

Track Title
Track Title Name: Track Title
Track Title Artist: Artist Name
Track Title
Track Title Album: Album Name

SCAN DISP SCAN DISP

single all off

The playback mode icon of the selected mode is


displayed.
iPod S 3:45 PM

01/57 01:35

To cancel, select “off.”

Scan On (SCAN): Plays the first 10 seconds of


each track listed.
Repeat single ( ): Repeats current track.
all ( ): Repeats all tracks listed.
Shuffle Shuffle ( ): Shuffles all tracks and play
them randomly.

37 EXTERNAL DEVICES

AV7100_inst[JW].indb 37 08.5.19 11:12:14 PM


Using other external components
ENGLISH

AV-IN / AUX IN / CAMERA


You can connect the following external components:
• Audio/video playback component to the AV IN plugs on the rear of the unit
• Audio playback component (such as a portable audio player) to the AUX input jack on the front panel
• Rear view camera to the CAMERA plug on the rear of the unit

Connection to the AUX jack

Stereo mini-plug

1 Select the source.


(☞ page 10)
• When the reverse lamp lead is connected (see the Installation/Connection Manual), the source is
automatically changed to “CAMERA” when you shift the gear to reverse (R) position.
2 Turn on the connected component and start playing the source.
3 Adjust the volume level.

38

EN04_KD-AV7100_JW.indd 38 08.7.14 11:05:47 AM


Sound adjustments

ENGLISH
You can select a preset sound mode for 2-channel Adjusting bass/treble
sources. (For multi-channel source, the sound mode is When “User” is selected for “EQ” (☞ left column)...
temporarily canceled.)
1 To adjust bass (–7 to 7):
AUDIO SETTING
Selecting sound mode EQ < User >
1 Display the audio setting screen. BASS
Treble
3
0


+
+
BAL 0 L R
FADE 0 R F
SW 0 – +
• During multi-channel surround playback, LOUD < Off >
pressing this button displays the speaker
adjustment screen. (☞ page 29) To adjust treble (–7 to 7):
2 AUDIO SETTING AUDIO SETTING

EQ < Jazz > EQ < User >


BASS – + BASS 3 – +
Treble – + Treble 5 – +
BAL 0 L R BAL 0 L R

FADE 0 R F FADE 0 R F

SW 0 – + SW 0 – +
LOUD < Off > LOUD < Off >

• For preset bass and treble values: ☞ page 50 2 Finish the procedure.
• When “User” is selected, you can adjust bass and AUDIO SETTING
treble. (☞ right column) EQ < User >
3 Finish the procedure. BASS 3 – +
Treble 5 – +
AUDIO SETTING
EQ < Rock >
BASS – +
Treble – +
BAL 0 L R
On the remote:
FADE
SW
0
0
R

F
+
1 Display the audio setting screen.
LOUD < Off >

• If no operation is done for about 15 seconds, the


screen will disappear. 2 Select an item, then adjust it.

3 Finish the procedure.

39 SETTINGS

AV7100_inst[JW].indb 39 08.5.19 11:12:15 PM


Adjusting sound On the remote:
You can adjust the sound elements as follows.
1
ENGLISH

Display the audio setting screen.


BAL (balance) L9 (Left speaker only) to R9
(Right speaker only)
FADE (fader) F9 (Front speaker only) to R9
(Rear speaker only)
2 Select an item, then adjust it.
SW (subwoofer –7 to 7
output level)*
LOUD (Loudness) On/Off 3 Finish the procedure.

* This subwoofer level setting takes effect only when


surround is activated. (☞ also page 29)

1 Display the audio setting screen.


☞ page 39
2 Adjust the sound as you want.
Ex.: When adjusting “FADE”
AUDIO SETTING
EQ < Jazz >
BASS – +
Treble – +
BAL 0 L R
FADE F3 R F
SW 0 – +
LOUD < Off >

3 Finish the procedure.


AUDIO SETTING
EQ < Jazz >
BASS – +
Treble – +
BAL 0 L R
FADE F3 R F
SW 0 – +
LOUD < Off >

40

AV7100_inst[JW].indb 40 08.5.19 11:12:16 PM


Menu operations

ENGLISH
The following steps are one of the fundamental 4 SETUP MENU BACK
procedures.
• If no operation is done for about 15 seconds, the General Language

menu operation will be canceled. Language : English


DVD menu : English English
Subtitle : English French
Ex. Changing the “Subtitle” setting Audio
1 : English Spanish

1 Audio ASP MISC


2
TUNER 3:45 PM

ST FM-1 87.5 MHz


Displays more options.
P-01 87.7 MHz
P-02 89.9 MHz
SETUP MENU BACK
2 Return to the previous screen. General Language

Main Menu BACK Language : English


DVD menu : English
Subtitle : Spanish
Audio : English
TUNER DISC AUX IN AV-IN
LOCK

Audio ASP MISC


USB iPod SD CAMERA

SET UP
MONITOR
OFF 5 Finish the procedure.
(twice)
SETUP MENU BACK

3 SETUP MENU BACK General Language


Language : English
General Language DVD menu : English
Language : English Subtitle : Spanish
DVD menu : English Audio : English
Subtitle : English
Audio : English Audio ASP MISC

Audio ASP MISC

On the remote: 4 Select the desired option.


1 Display “Main Menu,” then select “SET UP.”

To cancel the selection:


2 Select a tab.

To finish the procedure:


3 Select an item, then display its option. or

41 SETTINGS

AV7100_inst[JW].indb 41 08.5.19 11:12:17 PM


Initial: Underlined
General
ENGLISH

Menu items Selectable settings, [reference page]


Radio Select an appropriate area for receiving FM/AM (☞ “Tuner frequency range/interval
for each area“ on page 50).
USA, S-Amer1, Europe, Other
Clock Initial 12:00 AM, ☞ [9]
Clock Mode Select either 12-hour system or 24-hour system.
12Hr, 24Hr
TFT Auto Open On : The monitor panel automatically comes out when you turn on the unit.
Off : The monitor panel does not come out until you press OPEN/CLOSE.
Version The software version of this unit is shown.

Language
Menu items Selectable settings, [reference page]
Language Select the indication language shown on the monitor.
English, French, Spanish, Chinese, Korean, Russian
DVD menu Select the initial disc menu language.
English, French, Spanish, Chinese, Korean, Russian
Subtitle Select the initial subtitle language.
English, French, Spanish, Chinese, Korean, Russian, Auto, Off
Audio Select the initial audio language.
English, French, Spanish, Chinese, Korean, Russian

42

AV7100_inst[JW].indb 42 08.5.19 11:12:18 PM


Initial: Underlined
Audio

ENGLISH
Menu items Selectable settings, [reference page]
DownMix* 1
Activates or deactivates surround, ☞ [29]
FULL 6CH : Select to reproduce the multi-channel surround sound.
DownMix : Select to downmix the multi-channel signals to 2-channel signals.
Front Speakers*2, You can adjust the speaker size setting.
Center Speaker*2, • Front speakers : Large, Small
Sur Speakers*2, • Center Speaker : Large, Small, None
Subwoofer*2 • Sur Speakers: Large, Small, None
• Subwoofer: None, Present
• Speaker size: “Large” for 13-cm diameter or more; “Small” for 13 cm or less.
• If you select “Large” or “Small” for non-connected speakers, the incoming signals
for the non-connected speakers will not come out of any other speakers.
• For front and surround speakers: You cannot adjust the setting of the left and right
separately.
Test tones Select a speaker to emit test tone.
Off, Left, Right, Center*2, Left surr.*2, Right surr.*2, Subwoofer*2
• To turn off test tone, select “Off.”
Center delay, Surr. You can adjust the speaker output timing of the center speaker and surround
delay speakers. Select the speaker distance from the listening position.
• Center delay : No Delay, 0.3m, 0.6m, 1m, 1.4m, 1.7m
• Surr. delay : No Delay, 1m, 2m, 3m, 4m, 5.1m
Night Mode You can enjoy a powerful sound at a low volume level while playing Dolby Digital
software.
Off: Select to turn off this function.
On: Select to apply the effect to multi-channel encoded software.
Pro Logic Activates or deactivates the selected Pro Logic II mode (Pro Logic, PLII Matrix, PLII
Movie, PLII Music), ☞ [30]
Off, On, Auto
Down sampling Normally select “Off.” If the sound is distorted, select “On.”
Decode Mode*3 Select the Pro Logic II mode you want, ☞ [30]
Off, Pro Logic, PLII Matrix, PLII Movie, PLII Music

*1 This setting takes effect only for Dolby Digital multi-channel encoded discs.
*2 Not available when “DownMix” is set to “DownMix.”
*3 Available only for a 2-channel source on a disc except for DivX/MPEG1/MPEG2 discs.

Continued on the next page


43 SETTINGS

EN05_KD-AV7100_JW.indd 43 08.6.26 2:29:13 PM


Initial: Underlined
Audio (continued)
ENGLISH

Menu items Selectable settings, [reference page]


Panorama Activates or deactivates wraparound sound effect (Panorama).
Off, On
Dim Ctrl Adjust the sound localization pattern (0 to 6). As the number increases, the sound
(Dimension Control) localization moves towards forward (normally select “3”).
0 to 6; Initial 3
C W Ctrl Adjust the center image so it may be heard only from the center speaker, only from
(Center Width the left/right front speaker as a “phantom” center image, or various combination of
Control) these speakers. As the number increases, the “phantom” effect becomes stronger
(normally select “3”).
0 to 6; Initial 3

ASP
Menu items Selectable settings, [reference page]
Bass Freq Select the frequency for the bass sound adjustment.
60Hz, 80Hz, 100Hz, 200Hz
Treble Freq Select the frequency for the Treble sound adjustment.
10kHz, 12.5kHz, 15kHz, 17kHz
Bass Q-Factor Adjust the Q-slope for bass sound.
1.0, 1.25, 1.5, 2.0
iPod Gain, AuxIn Gain, Adjust and store auto-adjustment volume level for each source. The volume level will
DVD Gain*1*2, Tuner automatically increase or decrease when you change the source.
Gain –7 to +7; Initial 0

44

EN05_KD-AV7100_JW.indd 44 08.7.8 11:34:08 AM


Initial: Underlined
MISC

ENGLISH
Menu items Selectable settings, [reference page]
TS Calibrate Correct the accuracy of the touch sensor (see “Calibration” below).
No, Yes
Set Password*3 Enter the password (4-digit), ☞ [25]
Parental control Select the restriction level for DVD Video playback, ☞ [25]
Kid Safe (most restrictive), G, PG, PG-13, PG-R, R, NC-17, Adult (least restrictive)
Aspect Ratio Select the aspect ratio of the picture.
4:3, 16:9
Screen saver Activate/deactivate the screen saver.
Off, On
Load Factory*4 Select “Yes” to reset the unit.
No, Yes
• When you select “Yes,” the confirmation message appears. Select “Yes.” The unit
turns off, then turn on again.
DivX Registration This unit has its own Registration Code. Once you have played back a file with which
the Registration Code recorded, this unit’s Registration Code is overwritten for
copyright protection.

Calibration A D
After selecting “Yes” for “TS Calibrate,” the guidance for calibration appears
on the monitor as described on the right.
Touch “ “ which appears at each corner (A – D) in turn. Please press point A at upper left corner
• Touch “ “ slowly and carefully. Touch “ “ repeatedly until the next
marker appears if it does not appear by touching once.
• When the unit detects that you have touched all “ “ accurately, the
unit exits the calibration screen. B C

*1 You cannot change the “DVD Gain” setting when “DownMix” is set to “FULL 6CH.” (☞ page 43)
*2 The setting for “DVD Gain” is applied also to SD and USB.
*3 Remember your password or make a note of it. You need to enter the password to change the setting or cancel
restriction.
*4 The settings for the clock (“Clock”) and parental control (“Set Password” and “Parental control”) are not
initialized.

45 SETTINGS

EN05_KD-AV7100_JW.indd 45 08.7.8 11:27:25 AM


Maintenance
ENGLISH

Cleaning of the monitor How to handle discs


If the monitor does become dirty, wipe it using the When removing a disc from Center holder
supplied cleaning cloth. its case, press down the center
holder of the case and lift the
disc out, holding it by the
edges.
• Always hold the disc by the
edges. Do not touch its recording surface.
When storing a disc into its case, gently insert the
disc around the center holder (with the printed surface
facing up).
• Make sure to store discs into the cases after use.
Caution:
Do not use any solvent (for example, thinner, To keep discs clean
benzine, etc.), detergent, or insecticide. This may A dirty disc may not play correctly.
damage the monitor or the unit. If a disc does become dirty, wipe it
with a soft cloth in a straight line
How to clean the connector from center to edge.
• Do not use any solvent (for
Frequent detachment will deteriorate the connectors.
example, conventional record cleaner, spray, thinner,
To minimize this possibility, periodically wipe the
benzine, etc.) to clean discs.
connectors with a cotton swab or cloth moistened with
alcohol, being careful not to damage the connectors.
To play new discs
Connectors
New discs may have some rough
spots around the inner and outer
edges. If such a disc is used, this
unit may reject the disc.
To remove these rough spots, rub
the edges with a pencil or ball-point pen, etc.

Do not use the following discs:


Moisture condensation Single CD— Warped disc
8 cm disc
Moisture may condense on the lens inside the unit in
the following cases: Sticker and Stick-on label
• After starting the heater in the car. sticker residue
• If it becomes very humid inside the car.
Unusual shape C-thru Disc (semi-
Should this occur, the unit may malfunction. In this
transparent disc)
case, eject the disc and leave the unit turned on for a
few hours until the moisture evaporates. Transparent or semi-transparent parts
on its recording area

46

EN06_KD-AV7100_JW.indd 46 08.6.25 10:52:55 PM


More about this unit

ENGLISH
Basic operations Playing Recordable/Rewritable discs
Turning off the power • This unit can recognize a total of 1 500 files and 200
folders (a maximum of 1 500 files per folder).
• If you turn off the power while playing a disc, USB
• Use only “finalized” discs.
device, or SD card, playback will automatically start
• This unit can play back multi-session discs; however,
next time you turn on the power.
unclosed sessions will be skipped while playing.
• This unit can recognize a total of 24 characters for
FM/AM file/folder names.
Storing stations in memory • Some discs or files may not be played back due to
• When Auto Search is over, received stations are their characteristics or recording conditions.
preset in “P-01” (lowest frequency) to “P-06”
(highest frequency). Restricting playback
• If you enter a wrong password, “Password Error”
Disc appears. Enter the correct password.
General
Enjoying surround sounds
• In this manual, words “track” and “file” are
interchangeably used. • The surround playback is available only for “DISC.”
• The unit can play back a disc on which several type • You cannot activate surround for MPEG multi-
of files are recorded. The files are played back by the channel DVD Video, DivX 2-channel and MPEG 2-
order of the recording. channel sources. Regardless of the surround setting
• The unit can play back a disc on which CD (CD-DA) (“DownMix” and “Pro Logic”), stereo sounds are
files and audio/video files are recorded. emitted only through the front speakers.
• When a disc is inserted upside down or has no
playable files, “Please Eject” appears on the monitor. File playback
Eject the disc. Playing DivX files
• If the ejected disc is not removed within 10 seconds,
• This unit can play back DivX files with the extension
the disc is automatically inserted again into the
code <.divx>, <.div>, <.avi> (regardless of the
loading slot to protect it from dust.
letter case—upper/lower).
• Audio stream should conform to MP3 or Dolby Digital.
• The file encoded in the interlaced scanning mode
may not be played back correctly.
• The maximum bit rate for video signals (average) is
4 Mbps.

47 REFERENCES

EN06_KD-AV7100_JW.indd 47 08.6.24 3:53:19 PM


Playing MPEG1/MPEG2 files • This unit can show ID3 Tag Version
• This unit can play back MPEG1/MPEG2 files with the 1.0/1.1/2.2/2.3/2.4 (for MP3).
• This unit can also show WMA Tag.
ENGLISH

extension code <.mpg> or <.mpeg>.


• The stream format should conform to MPEG system/ • This unit can play back files recorded in VBR (variable
program stream. bit rate).
The file format should be MP@ML (Main Profile at • Files recorded in VBR have a discrepancy in elapsed
Main Level)/SP@ML (Simple Profile at Main Level)/ time indication.
MP@LL (Main Profile at Low Level). • This unit cannot play back the following files:
• Audio streams should conform to MPEG1 Audio – MP3 files encoded with MP3i and MP3 PRO
Layer-2 or Dolby Digital. format.
• The maximum bit rate for video signals (average) is – MP3 files encoded with Layer 1/2.
4 Mbps. – WMA files encoded with lossless, professional,
and voice format.
Playing JPEG files – WMA files which are not based upon Windows
Media® Audio.
• This unit can play back JPEG files with the extension – WMA files copy-protected with DRM.
code <.jpg>, or <.jpeg>. – Files which have the data such as AIFF, ATRAC3,
• It is recommended that you record a file at 720 x 576 etc.
resolution.
• This unit can play back baseline JPEG files.
Progressive JPEG files or lossless JPEG files cannot be
SD
played. • When the SD card has no playable files, or has not
• When you rotate a picture by 90° or 270°, the picture been formatted correctly, “Bad card” appears on the
shrinks vertically to fit into the screen. monitor. In this case, replacing or reformatting the SD
• You can see up to 9 pictures in thumbnails. If the card may solve the problem. (All data in the SD card
folder includes more pictures than 9, the current are erased when you reformat it. Make sure to back
picture and the following 8 pictures are displayed in up the data before reformatting.)
thumbnails. • Do not pull out or attach the SD card while
“Reading...” is displayed on the monitor.
Playing MP3/WMA files • This unit can recognize a total of 1 500 files and 200
folders (a maximum of 1 500 files per folder).
• This unit can play back files with the extension
• This unit can recognize a total of 14 characters for
code <.mp3> or <.wma> (regardless of the letter
file/folder names.
case—upper/lower).
• This unit may be unable to play back some SD cards
• This unit can play back the files meeting the
or some files due to their characteristics or recording
conditions below:
conditions.
– Bit rate: 32 kbps — 320 kbps
– Sampling frequency:
48 kHz, 44.1 kHz, 32 kHz (for MPEG1)
24 kHz, 22.05 kHz, 16 kHz (for MPEG2)
48 kHz, 44.1 kHz, 32 kHz, 22.05 kHz (for WMA)
• This unit may be unable to play back some files due
to their characteristics or recording conditions.

48

EN06_KD-AV7100_JW.indd 48 08.7.8 1:52:25 PM


USB iPod
• When the USB device has no playable files, or has not • Controllable iPod:

ENGLISH
been formatted correctly, an error message appears – iPod (Click Wheel)
on the monitor. In this case, replacing or reformatting – iPod mini
the USB device may solve the problem. (All data in – iPod photo
the USB device are erased when you reformat it. – iPod nano
Make sure to back up the data before reformatting.) – iPod with video
• The unit cannot recognize a USB device whose rating • If the iPod does not play correctly, update your iPod
is other than 5 V and exceeds 500 mA. software to the latest version. For details about
• While playing from a USB device, the playback order updating your iPod, visit <http://www.apple.com>.
may differ from other players. • When you turn on this unit, the iPod is charged
• This unit may be unable to play back some USB through the unit.
devices or some files due to their characteristics or • You can control the iPod from this unit when “JVC” or
recording conditions. “ ” appears on the iPod display after connection.
• USB devices equipped with special functions such as • The song order displayed on the monitor of the unit
data security functions cannot be used with the unit. may differ from that of the iPod.
• Do not use a USB device with 2 or more partitions. • The text information may not be displayed correctly:
• Depending on the shape of the USB devices and – Some characters such as accented letters cannot
connection ports, some USB devices may not be be displayed correctly on the monitor.
attached properly or the connection might be loose. – Communication between the iPod and the unit is
• When connecting a USB device, refer also to its not stable.
instructions. • This unit can recognize a total 20 characters.
• Connect only one USB device to the unit at a time. Do
not use a USB hub. Notice:
• This unit may not recognize a USB device connected When operating an iPod, some operations may not
through a USB card reader. be performed correctly or as intended. In this case,
• This unit may not play back files in a USB device visit the following JVC web site: <http://www.
properly when using a USB extension cord. jvc-victor.co.jp/english/car/>
• This unit cannot assure proper functions or supply
power to all types of the devices.
• This unit can recognize a total of 1 500 files and 200
folders (a maximum of 1 500 files per folder).
• This unit can recognize a total 14 characters for file/
folder names.
• For MPEG1/2 files: The maximum bit rate for video
signals (average) is 2 Mbps.

49 REFERENCES

EN06_KD-AV7100_JW.indd 49 08.7.8 1:52:27 PM


Sounds emitted through the rear Preset bass/treble values
terminals Sound mode Bass Treble
ENGLISH

• For multi-channel signals: Flat 0 0


– When “DownMix” is set to “FULL 6CH,” multi- Jazz 6 4
channel signals are emitted. (The AV OUT Pop 4 6
terminals emit the same signal as the FRONT Classical 4 4
terminals.) Rock 6 6
– When “DownMix” is set to “DownMix,” multi- News –2 –2
channel signals are downmixed. Urban 4 5
• For 2-channel signals: Rave 5 6
2-channel signal is emitted. Movie 3 –2
Techno 5 3
User 0 0
• DTS sound cannot be reproduced.
• No sound comes out of the deactivated speakers.

Tuner frequency range/interval for • “DVD Logo” is a trademark of DVD Format/Logo


each area Licensing Corporation registered in the US, Japan
Selected and other countries.
Frequency range/interval • “Official DivX Certified™ product” “DivX, DivX
area
FM 87.5 MHz – 107.9 MHz/200 kHz Certified, and associated logos are trademarks of
USA DivX, Inc. and are used under license.”
AM 530 kHz – 1 710 kHz/10 kHz
FM 87.5 MHz – 107.9 MHz/100 kHz • Microsoft and Windows Media are either
S-Amer1 registered trademarks or trademarks of Microsoft
AM 530 kHz – 1 710 kHz/10 kHz
FM 87.50 MHz – 108.00 MHz/50 kHz Corporation in the United States and/or other
Europe countries.
AM 522 kHz – 1 620 kHz/9 kHz
FM 87.50 MHz – 108.00 MHz/50 kHz • iPod is a trademark of Apple Inc., registered in
Other the U.S. and other countries.
AM 531 kHz – 1 602 kHz/9 kHz
• This product incorporates copyright protection
technology that is protected by U.S. patents
and other intellectual property rights. Use of
this copyright protection technology must be
authorized by Macrovision, and is intended for
home and other limited viewing uses only unless
otherwise authorized by Macrovision. Reverse
engineering or disassembly is prohibited.

50

AV7100_inst[JW].indb 50 08.5.19 11:12:23 PM


Troubleshooting

ENGLISH
What appears to be trouble is not always serious. Check the following points before calling a service center.
• For operations with the external components, refer also to the instructions supplied with the adapters used for the
connections (as well as the instructions supplied with the external components).

Symptoms Remedies/Causes
• No sound comes out of the center speaker. • Center speaker is not activated. (☞ page 43)
• Center speaker is used only for surround playback. No
sound comes out for stereo playback.
• No sound comes out of the rear speakers, and Rear speakers and subwoofer are not activated. (☞ page
subwoofer. 43)
• The monitor is not clear and legible. Sunshine from the windshield may cause this symptom.
General

Adjust the monitor brightness. (☞page 11)


• “SD Loading Error” appears on the monitor. The SD card is not inserted fully. Fully insert it into the slot
to close the door.
• “No Signal” appears. • Change the source.
• Check the cords and connections.
• Signal input is too weak.
• The unit does not work at all. Reset the unit. (☞ page 3)
• AS (Auto Storing) does not work. Store stations manually. (☞page 13)
FM/AM

• Static noise while listening to the radio. Connect the antenna firmly.
• Disc can be neither recognized nor played . Change the disc.
• Recordable/Rewritable discs cannot be • Insert a finalized disc.
played back. • Finalize the discs with the component which you used
• Tracks on the Recordable/Rewritable discs for recording.
Disc in general

cannot be skipped.
• Playback does not start. • Insert the disc correctly again.
• The format of files is not supported by the unit.
• Playback of DVD Video does not start. Playback is restricted. Release the restriction. (☞ page 25)
• The playback picture is not clear and legible. Adjust the monitor brightness. (☞page 11)
• Sound and pictures are sometimes • Stop playback while driving on rough roads.
interrupted or distorted. • Change the disc.

51 REFERENCES

AV7100_inst[JW].indb 51 08.5.19 11:12:24 PM


Symptoms Remedies/Causes
• No playback picture appears on the monitor. Parking brake lead is not connected properly.
ENGLISH

(☞Installation/Connection Manual)
• No picture appears on the external monitor. • Connect the video cord correctly.
Disc in general

• Select the correct input on the external monitor.


• While playing back a disc other than DVD Video, no
picture will appear on the external monitor.
• “Eject Error” or “Loading Error” appears on Reset the unit. (☞ page 3)
the monitor.
• “Disc region incorrect” appears on the Region code is not correct. (☞page 8)
monitor when you insert a DVD Video.
• Disc cannot be played back. • Change the disc.
DivX/MPEG1/MPEG2/JPEG/MP3/WMA

• Record the tracks using a compliant application on the


appropriate discs. (☞page 8)
• Add appropriate extension codes to the file names.
• Noise is generated. The track played back is not a playable file format. Skip to
another file.
• Tracks are not played back as you have Playback order may differs from the one played back using
intended them to play. other players.
• Elapsed playing time is not correct. This sometimes occurs during playback. This is caused by
how the tracks are recorded.
• “Not Supported file” appears on the monitor The track is unplayable.
and track skips.
• Noise is generated. The track played back is not a playable file format. Skip to
another file.
• Tracks are not played back as you have Playback order may differs from the one played back using
intended them to play. other players.
• “Reading...” keeps displayed on the monitor. • Readout time varies depending on the SD card/USB
device.
SD/USB

• Do not use too many hierarchy and folders.


• Turn off the power then on again.
• “No USB Device” flashes on the monitor. • No USB device is connected.
• The USB device is not connected firmly.
• Correct characters are not displayed (e.g. Some characters are not available on this unit.
album name).
• While playing a track, sound is sometimes The tracks are not properly copied into the SD card/USB
interrupted. device. Copy tracks again, and try again.

52

AV7100_inst[JW].indb 52 08.5.19 11:12:24 PM


Symptoms Remedies/Causes
• The iPod does not turn on or does not work. • Check the connecting cable and its connection.

ENGLISH
• Update the firmware version.
• Charge the battery.
• The sound is distorted. Deactivate the equalizer either on this unit or the iPod.
• Playback stops. The headphones are disconnected during playback. Turn off
the unit’s power and turn on it again.
iPod

• No sounds can be heard when connecting an • Disconnect the headphones from the iPod nano.
iPod nano. • Update the firmware version of the iPod nano.
• “No Files” appears on the monitor. No tracks are stored. Import tracks to the iPod.
• The iPod’s controls do not work after Reset the iPod.
disconnecting from this unit.
• “Cannot play” appears on the monitor. Communication error occurs. Disconnect and connect the
cable to the iPod again.
• “NO VIDEO SIGNAL” appears on the monitor. • Turn on the video component if it is not on.
• Connect the video component correctly.
AV-IN

• Playback picture is not clear and legible. Adjust the monitor brightness. (☞page 11)
• No sounds can be heard. Check the connecting cable and its connection.

53 REFERENCES

AV7100_inst[JW].indb 53 08.5.19 11:12:25 PM


Specifications
ENGLISH

Maximum Power Output: Front/Rear: 50 W per channel


Continuous Power Output Front/Rear: 20 W per channel into 4 Ω, 40 Hz to
(RMS): 20 000 Hz at no more than 0.8% total
harmonic distortion
Load Impedance: 4 Ω (4 Ω to 8 Ω allowance)
Tone Control Range: Bass: ±14 dB (60 Hz, 80 Hz, 100 Hz, 200 Hz)
Treble: ±14 dB (10 kHz, 12.5 kHz, 15 kHz,
17 kHz)
AMPLIFIER

Q (Q-slope) Q1.0, Q1.25, Q1.5, Q2.0


Signal-to-Noise Ratio: 70 dB
Audio Output Level Line-Out Level/Impedance: 4.0 V/20 kΩ load (full scale)
FRONT/REAR/CENTER/ Output Impedance: 1 kΩ
SUB WOOFER:
Color System: NTSC
Video Output (composite): 1 Vp-p/75 Ω
Other Terminals: Input: AV IN, CAMERA, AUX (auxiliary) input
jack, USB input terminal, Antenna input
Output: AV OUT
Others: iPod, OE REMOTE*
Frequency Range: ☞ “Tuner frequency range/interval for each area” on page 50
FM Tuner Usable Sensitivity: 11.3 dBf (1.0 μV/75 Ω)
FM/AM TUNER

50 dB Quieting Sensitivity: 16.3 dBf (1.8 μV/75 Ω)


Alternate Channel Selectivity (400 kHz): 65 dB
Frequency Response: 40 Hz to 15 000 Hz
Stereo Separation: 35 dB
AM Tuner Sensitivity/Selectivity: 20 μV/35 dB
Signal Detection System: Non-contact optical pickup (semiconductor laser)
Frequency Response: DVD, fs=48 kHz: 16 Hz to 22 000 Hz
DVD/CD

VCD/CD: 16 Hz to 20 000 Hz
Dynamic Range: 93 dB
Signal-to-Noise Ratio: 95 dB
Wow and Flutter: Less than measurable limit

* Not used for this unit.

54

EN07_KD-AV7100_JW.indd 54 08.7.1 9:51:02 AM


Compatible File System: FAT 32
SD

Capacity 2 Gbytes

ENGLISH
Data Transfer Rate Maximum 10 Mbps
USB Standards: USB 1.1
Data Transfer Rate Full Speed: Maximum 12 Mbytes
Low Speed: Maximum 1.5 Mbytes
USB

Compatible Device: Mass storage class


Compatible File System: FAT 32/16/12
Max. Current: Less than 500 mA/5 V
Screen Size: 7 inch wide liquid crystal display
Number of Pixel: 336 960 pixels: 480 x 3 (horizontal) × 234 (vertical)
MONITOR

Drive Method: TFT (Thin Film Transistor) active matrix format


Color System: NTSC
Aspect Ratio: 16:9 (wide)
Power Requirement: Operating Voltage: DC 14.4 V (11 V to 16 V allowance)
Grounding System: Negative ground
Allowable Storage Temperature: –10°C to +60°C
GENERAL

Allowable Operating Temperature: 0°C to +50°C


Dimensions (W × H × D): Installation Size (approx.): 182 mm × 53 mm × 159 mm
• With trim plate and Panel Size (approx.): 188 mm × 58 mm × 13 mm
sleeve attached
Detachable Panel Size (approx.): 134 mm × 22 mm × 19 mm
Mass (approx.): 2.5 kg (including trims and sleeve)

Required space for the monitor ejection


136

33
CAUTION: When ejecting the monitor, keep an open space 2.5
for the monitor to come out. If not, the monitor may obstruct
the steering wheel and gearshift lever operations, as this may
result in a traffic accident.

110˚
167
50˚

43
Unit: mm
44

Design and specifications are subject to change without notice.


55 REFERENCES

AV7100_inst[JW].indb 55 08.5.19 11:12:26 PM


Muchas gracias por la compra de un producto JVC.
Como primer paso, por favor lea detenidamente este manual para comprender a fondo todas las instrucciones y
obtener un máximo disfrute de esta unidad.

IMPORTANTE PARA PRODUCTOS LÁSER


1. PRODUCTO LÁSER CLASE 1
2. PRECAUCIÓN: No abra la tapa superior. En el interior de la unidad no hay piezas que pueda reparar el usuario;
ESPAÑOL

encargue el servicio a personal técnico cualificado.


3. PRECAUCIÓN: Radiación láser de clase 1M visible y/o invisible cuando ésta abierto. No mirar directamente con
instrumental óptico.
4. REPRODUCCIÓN DE LA ETIQUETA: ETIQUETA DE PRECAUCIÓN, COLOCADA EN EL EXTERIOR DE LA UNIDAD.

ADVERTENCIAS: Precauciones sobre el monitor:


Para evitar daños y accidentes
• El monitor incorporado a esta unidad ha sido
• NO instale ningún receptor o tienda ningún cable fabricado con tecnología de alta precisión, pero
en una ubicación donde; puede contener algunos puntos inefectivos. Estos
– puede obstaculizar las maniobras del volante es inevitable y no es ningún signo de anomalía.
de dirección y de la palanca de cambios. • No exponga el monitor a la luz directa del sol.
– puede obstaculizar la operación de los • No opere el panel táctil utilizando un bolígrafo o
dispositivos de seguridad, como por ejemplo, una herramienta similar puntiaguda.
bolsas de aire. Toque los botones del panel táctil directamente
– Donde pueda obstruir la visibilidad. con su dedo (sáquese el guante, si lo tiene
• NO opere la unidad mientras maneja. puesto).
Si es necesario operar la unidad mientras maneja, • Cuando la temperatura sea muy baja o muy alta...
asegúrese de mirar atentamente en todas las – Ocurren cambios químicos en el interior,
direcciones. produciendo un mal funcionamiento.
• El conductor no debe mirar el monitor mientras – Puede suceder que las imágenes no aparezcan
conduce. claramente o que se muevan con lentitud.
• El conductor no deberá ponerse los auriculares En tales entornos, puede suceder que las
mientras conduce. imágenes no estén sincronizadas con el sonido,
o que la calidad del sonido se deteriore.

[Sólo Unión Europea]

SP_AV7100[JW]f.indb 2 5/22/08 5:17:19 PM


Cómo reposicionar su unidad Contenido
INTRODUCCIÓN
Operaciones básicas—
2
Unidad principal ........................... 4
Operaciones básicas—

ESPAÑOL
Control remoto (RM-RK253)........... 6
Tipo de disco reproducible ................ 8
OPERACIONES
1 Ajuste del reloj ................................ 9
• También se borrarán los ajustes preestablecidos por Operaciones comunes ...................... 10
usted. Para escuchar la radio ...................... 12
Operaciones de los discos ................. 15
Operaciones de SD ........................... 31
Operaciones de USB ......................... 33
DISPOSITIVOS EXTERNOS
Para escuchar el iPod ....................... 35
Uso de otros componentes externos ... 38
AJUSTES
Ajustes del sonido ............................ 39
Operaciones de los menús ................ 41
REFERENCIAS
Para fines de seguridad...
• No aumente demasiado el nivel de volumen pues es Mantenimiento ............................... 46
muy peligroso conducir si no se escuchan los sonidos Más sobre este receptor ................... 47
exteriores.
• Detenga el automóvil antes de efectuar cualquier
Localización de averías..................... 51
operación complicada. Especificaciones............................... 54

Temperatura dentro del automóvil...


Si ha dejado el automóvil estacionado durante largo
tiempo en un sitio cálido o frío, no opere la unidad hasta
que se normalice la temperatura del habitáculo.

3 INTRODUCCIÓN

SP_AV7100[JW]f.indb 3 5/22/08 5:17:33 PM


Operaciones básicas — Unidad principal
Las operaciones se explican utilizando principalmente el panel táctil, no obstante, podrá utilizar los botones de la
unidad principal y control remoto si tienen nombres y marcas iguales o similares.

1 2 Ventanilla de visualización (☞ página 5) 3 4


ESPAÑOL

5 6 7 8 9 p q w e r t

1 “TUNER”:
• Realiza el almacenamiento automático (AS).
• Realiza el escaneo programado (PS) si lo pulsa
y mantiene pulsado.
2 Selecciona las bandas. y i
3 Cambia la información mostrada en la ventana de u
visualización o el monitor.
4 Abre/cierra el panel del monitor.
5 Ranura de carga del disco
6 • Enciende la unidad.
• Controla el volumen girándolo (mientras el r Desengancha el panel de control.
sistema está encendido). t Expulsa el disco.
• Silencia el sonido si el sistema está y Toma de entrada AUX
encendido.*1 u Ranura para tarjeta SD
• Desconecta la alimentación si lo pulsa y i Terminal USB
mantiene pulsado.
7 Seleccione la fuente. *1 El silenciamiento se cancela automáticamente cuando
8 • “TUNER”: Efectúa la búsqueda automática. usted cambia la fuente.
• “DISC/USB/SD/iPod”: Salto hacia atrás/salto *2 Utilice estos botones cuando el panel del monitor está
hacia adelante abierto.
9 Sensor remoto
p “DISC/USB/SD/iPod”: Reproduce/pone en pausa. Esta unidad contiene un imán. Evite acercar los
q Cambia la fuente a “DISC” (e inicia la siguientes objetos a la unidad:
reproducción). • Relojes
w*2 Se muestra o sale de “Main Menu” en la unidad. • Tarjetas con banda magnética, como tarjetas de
e*2 • Visualiza la pantalla de ajuste de audio. crédito
• Visualiza la pantalla de ajuste de altavoces • Cintas magnéticas, como cintas cassette y cintas
durante la reproducción surround multicanal. de vídeo

SP02-08_KD-AV7100[JW]ff.indd 4 11/6/08 9:41:34 am


Cuando se abre el panel del monitor

ESPAÑOL
o ; a s
o Monitor s • “TUNER/DISC/USB/SD/iPod”: Visualiza la
• Están disponibles las operaciones del panel táctil. información de la emisora/pista actual en el
; Desliza el panel del monitor hacia adelante/hacia monitor.
atrás. • Visualiza la barra de ajuste de brillo o “Picture
a • Cambia el ángulo del panel del monitor. Menu”, si lo pulsa y mantiene pulsado.
• Ajusta el brillo del monitor cuando se visualiza
la barra de ajuste.
• Ajusta la imagen procedente de los
componentes externos cuando se visualiza
“Picture Menu”.
Ventanilla de visualización 1 23 4

1 Pantalla principal (Ver abajo.) 4 Se enciende cuando se recibe una radiodifusión


2 Se enciende cuando se activa la sintonización FM estéreo con una intensidad de señal
local FM. (☞ página 12) suficiente.
3 Se enciende cuando se activa la sonoridad. (☞
página 40) • La ventana de visualización se apaga cuando se
abre el panel del monitor.
Para cambiar la información en pantalla principal:
En la unidad: Ej.: Para CD Text
Número de pista/tiempo de reproducción

En el control remoto: Se desplaza el título de la pista

Fuente
La información en pantalla disponible varía según la
fuente de reproducción.
• Cada vez que pulsa el botón, la información Reloj
mostrada en la pantalla principal cambia para
mostrarle diversas informaciones.
(vuelta al comienzo)

5 INTRODUCCIÓN

SP02-08_KD-AV7100[JW]ff.indd 5 7/14/08 3:05:43 PM


Operaciones básicas — Control remoto (RM-RK253)
Retire la lámina aislante cuando utilice el control Antes de utilizar el control remoto:
remoto por primera vez. • Apunte el control remoto directamente hacia el
sensor remoto del receptor.
• NO exponga el sensor remoto a una luz brillante (luz
solar directa o iluminación artificial).
ESPAÑOL

Si disminuye el rango de efectividad del control remoto,


cambie la pila.
Lámina aislante
Para cambiar la pila:

Advertencia:
Para evitar daños y accidentes
• No instale ninguna otra pila distinta de CR2025 o
su equivalente.
• No deje el control remoto en un lugar expuesto
a la luz directa del sol (como los cubretableros)
durante un tiempo prolongado.
• Guarde la pila fuera del alcance de los niños.
• Evite recargar, cortocircuitar, desarmar, o calentar
la pila, o arrojarla al fuego.
• No deje la pila con otros objetos metálicos.
• No toque la pila con pinzas u otras herramientas
similares.
• Enrolle la pila con una cinta y aíslela antes de
desecharla o guardarla.

Precaución:
No deje las pilas expuestas a altas temperaturas,
como, por ejemplo, a la luz del sol, al fuego u otras
condiciones similares.

SP_AV7100[JW]f.indb 6 5/22/08 5:17:35 PM


Elementos principales y 5 DVD: Visualiza el menú de disco.
6 • “TUNER”: Efectúa la búsqueda automática.
funciones • “DISC/USB/SD/iPod”: Salto hacia atrás/salto
hacia adelante.
7 “DISC/USB/SD”: Amplía la imagen reproducida.
1 8 • Enciende la unidad.
8
9 • Silencia el sonido si el sistema está
encendido.*1

ESPAÑOL
2 p • Desconecta la alimentación si lo pulsa y
mantiene pulsado.
q 9 Abre/cierra el panel del monitor.
w p Ajusta el nivel de volumen.
e q • Cambia la información mostrada en la pantalla
3 r cuando se cierra el panel del monitor.
t • “TUNER/DISC/USB/SD/iPod”: Visualiza la
4 y información de la emisora/pista actual en el
5 u monitor cuando se abre el monitor.
i w*2 • Visualiza la pantalla de ajuste de audio.
6 o • Visualiza la pantalla de ajuste de altavoces
7 ; durante la reproducción surround multicanal.
e • “TUNER”: Selecciona las bandas.
• “DISC/USB/SD/iPod”: Pare la reproducción.
r*2 Visualiza la barra de ajuste de brillo o “Picture
Menu”.
t*2 Se muestra o sale de “Main Menu” en la unidad.
y “DISC/USB/SD”: Realiza la repetición A-B.
u “DISC/USB/SD/iPod”: Selecciona el modo de
Las operaciones se explican utilizando principalmente
repetición.
el panel táctil, no obstante, podrá utilizar los botones
i • DVD: Visualiza el menú de disco.
de la unidad principal y control remoto si tienen
• VCD: Activa/desactiva la función PBC.
nombres y marcas iguales o similares.
o • “TUNER”: Realiza la búsqueda manual
• “DISC/USB/SD/iPod”: Búsqueda hacia atrás/
1 Seleccione la fuente.
búsqueda hacia adelante
2 • Introduce números.
; • DVD Vídeo: Selecciona el idioma de audio
• “TUNER”: Selecciona las emisoras preajustadas.
( ), subtítulos ( ), y ángulo ( ).
• DVD/VCD: Efectúa la búsqueda del título/
• VCD: Selecciona el canal de audio ( ).
capítulo (pista)/tiempo.
• DivX/MPEG/JPEG/CD/MP3/WMA, “USB/SD/
iPod”: Selecciona la pista.
*1 El silenciamiento se cancela automáticamente cuando
3 Vuelve a la pantalla anterior.
usted cambia la fuente.
4 • : Selecciona los elementos/opciones.
*2 Utilice estos botones cuando el panel del monitor está
• ENT: Confirma la selección/ajuste.
abierto.
• “DISC/USB/SD/iPod”: 6: Reproduce/pone
en pausa.

7 INTRODUCCIÓN

SP02-08_KD-AV7100[JW]ff.indd 7 7/14/08 3:06:30 PM


Tipo de disco reproducible
Tipo de disco Formato de grabación, tipo de archivo, etc. Reproducible
DVD DVD Vídeo (Códigos regionales: 4)*1
ESPAÑOL

DVD Audio
DVD-ROM
DVD Grabable/reescribible DVD Vídeo
(DVD-R/-RW*2, +R/+RW*3) DivX*4/MPEG1/MPEG2
• DVD Vídeo: Puente UDF JPEG
• DivX/MPEG1/MPEG2/JPEG/MP3/
MP3/WMA
WMA: ISO 9660 Nivel 1, Nivel 2,
WAV/AAC
Romeo, Joliet
MPEG4
DVD-VR/DVD+VR
DVD-RAM
Dual Disc Lado DVD
Lado no-DVD
CD/VCD CD de audio/CD Text (CD-DA)
VCD (Vídeo CD)
DTS-CD
SVCD (Súper Vídeo CD)
CD-ROM
CD-I (CD-I Ready)
CD-G
CD Grabable/reescribible CD-DA
(CD-R/-RW) MP3/WMA
• ISO 9660 Nivel 1, Nivel 2, JPEG
Romeo, Joliet
DivX/MPEG1/MPEG2
WAV/AAC
MPEG4
*1 Si inserta un disco DVD Vídeo de un código de región incorrecto, aparecerá “Disc region incorrect” en el monitor.
*2 Un DVD-R grabado en formato de múltiples bordes también es reproducible (excepto los discos de doble capa).
Los discos DVD-RW de doble capa no se pueden reproducir.
*3 Es posible reproducir discos finalizados +R/+RW (sólo formato de vídeo).
Los discos +RW de doble capa no se pueden reproducir.
*4 DivX Ultra no se puede reproducir.

Precaución sobre la reproducción de DualDisc


El lado no DVD de un “DualDisc” no es compatible con la norma “Compact Disc Digital Audio”. Por consiguiente,
no se recomienda usar el lado no DVD de un DualDisc en este producto.
8

SP02-08_KD-AV7100[JW]ff.indd 8 7/3/08 5:51:14 PM


Ajuste del reloj
Antes de utilizar la unidad, ponga el reloj en hora. 3 Ponga el reloj en hora.
• Si no se efectúa ninguna operación durante Ej.: Cuando se ajusta a “3:45 PM”
aproximadamente 15 segundos, la operación del
SETUP MENU BACK
menú se cancela.

ESPAÑOL
General Language

Idioma para las indicaciones: Radio : S-Amer1


Clock : 12:00 AM
En este manual, se utilizan indicaciones en inglés Clock Mode : 12Hr
TFT Auto Open : Off
para las explicaciones. Podrá seleccionar el idioma de Version B/E:901.04.1.080512
indicación que desea en el monitor. (☞ página 42) Audio ASP MISC

En el panel táctil solamente:


3 = 4 = 5 = OK
1 SETUP MENU BACK

General Language
3 : 45
1 2 3
4 5 6
7 8 9
1
0 OK
1 2 Audio ASP MISC
2
Cancela la última entrada

2 TUNER 12:00 AM
SETUP MENU BACK

General Language
ST FM-1 87.5 MHz
Radio : S-Amer1
P-01 87.7 MHz Clock : 03:45 AM
P-02 89.9 MHz Clock Mode : 12Hr
P-03 97.9 MHz TFT Auto Open : Off
P-04 105.9 MHz Version B/E:901.04.1.080512
P-05 107.9 MHz Audio ASP MISC
AS PS SCAN DX DISP

AM PM
Vuelve a la pantalla anterior. 4 Finalice el procedimiento.
(dos veces)
Main Menu BACK
SETUP MENU BACK

General Language
TUNER DISC AUX IN AV-IN
Radio : S-Amer1
LOCK

Clock : 03:45 PM
USB iPod SD CAMERA Clock Mode : 12Hr
TFT Auto Open : Off
MONITOR Version B/E:901.04.1.080512
OFF
SET UP
Audio ASP MISC

9
OPERACIONES

SP09-14_KD-AV7100[JW]ff.indd 9 11/6/08 9:31:34 am


Operaciones comunes
Selección de la fuente de Ajuste del nivel de volumen
reproducción En la unidad:
• Las fuentes disponibles difieren según los dispositivos
externos o componentes conectados, y el tipo de
ESPAÑOL

medio que ha insertado.


1 TUNER 3:45 PM

ST FM-1 87.5 MHz

P-01 87.7 MHz


P-02 89.9 MHz En el control remoto:
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

2 Fuente actual *
Main Menu BACK Indicación de nivel de volumen
TUNER 3:45 PM
TUNER DISC AUX IN AV-IN
ST FM-1 87.5 MHz
LOCK

P-01 87.7 MHz


USB iPod SD CAMERA P-02 89.9 MHz
P-03 97.9 MHz
MONITOR P-04 105.9 MHz
OFF
SET UP P-05 107.9 MHz

AS PS SCAN DX DISP
Toque la fuente de destino.

En la unidad: En el control
remoto:
10

Imagen reproducida

• Cada vez que pulse el botón, la fuente cambia


como sigue:
15
“DISC” = “AV-IN” = “TUNER” = “USB” =
“iPod” = “SD” = “CAMERA” * = “AUX IN”
= (vuelta al comienzo)

* Cuando la fuente es “CAMERA”...


– El sonido de la fuente seleccionada previamente se
emite a través de los altavoces.
– Si presiona SOURCE o SRC, se cambiará a la fuente
seleccionada previamente.
10

SP09-14_KD-AV7100[JW]ff.indd 10 7/3/08 5:51:52 PM


Ajuste del brillo del monitor En el control remoto:
1 Visualice la barra de ajuste. 1

ESPAÑOL
P-04 105.9 MHz
P-05 107.9 MHz 3
AS PS SCAN DX10 DISP

• Si no se efectúa ninguna operación durante


aproximadamente 5 segundos, la barra de ajuste Desactivación del monitor
desaparece.
En el panel táctil solamente:
2 Ajuste el brillo.
1 TUNER 3:45 PM

ST FM-1 87.5 MHz

P-01 87.7 MHz


P-02 89.9 MHz

3 Finalice el procedimiento.
2 Main Menu BACK

TUNER DISC AUX IN AV-IN

LOCK

USB iPod SD CAMERA

MONITOR
OFF
SET UP

Ajuste de imagen para “AV-IN” y “CAMERA”


Para encender el monitor, toque el monitor.
Cuando la fuente es “AV-IN” o “CAMERA” y se • Si pulsa cualquier botón también encenderá el monitor.
introducen señales de vídeo, aparece “Picture Menu”
en el paso 1 descrito arriba. Función del atenuador de luminosidad
Conecte el conductor ILLUMI de la siguiente manera,
Pulse PICTURE en la unidad o en el mando
de acuerdo al uso de la función del atenuador de
a distancia para seleccionar la opción que desea luminosidad:
ajustar, y luego proceda con el paso 2 descrito arriba. • Para el atenuador de luminosidad
Sharpness Ajusta la nitidez. automático: Conéctelo al interruptor de
Color Ajusta el color de la imagen—más los faros del vehículo. Al encender los faros,
se activará el atenuador de luminosidad—
clara o más oscura.
Atenuador de luminosidad automático
Contrast Ajusta el contraste. • Para el atenuador de luminosidad
Brightness Ajusta la imagen si es demasiado constante: Conéctelo a la batería del automóvil
brillante u oscura. (12 V constante). El atenuador de luminosidad
Tint Ajusta el matiz si la tez de las funciona cada vez que enciende el sistema.
• Para desactivación del atenuador de
personas no es natural. luminosidad: Conéctelo aquí.
Consulte también el manual de instalación/
conexión (volumen separado).
11
OPERACIONES

SP09-14_KD-AV7100[JW]ff.indd 11 7/18/08 9:08:17 AM


Para escuchar la radio
~ ! Indicador ST Banda/frecuencia actual

TUNER 3:45 PM

ST FM-1 87.5 MHz


ESPAÑOL

Ÿ P-01 87.7 MHz Visualiza la página anterior.


P-02 89.9 MHz
P-03 97.9 MHz Lista de preajustes
P-04 105.9 MHz
P-05 107.9 MHz Visualiza la página siguiente.
AS PS SCAN DX DISP

☞ página 13 ☞ página 14 ☞abajo ☞ página 14


☞ página 13

~ Seleccione “TUNER” para la fuente.


(☞ página 10)
Ÿ Seleccione la banda.
• También puede usar BAND en la unidad y el control remoto.
! Búsqueda de una emisora—Búsqueda automática.
• Búsqueda manual: Pulse 1 o ¡ repetidamente.
• El indicador ST se enciende al recibir una radiodifusión FM estéreo con una intensidad de señal
suficientemente potente.

Para sintonizar emisoras con un señal suficientemente fuerte


Esta función funciona sólo para las bandas FM. Una vez activada, esta función siempre funcionará al efectuar la
búsqueda de emisoras FM.
P-04 105.9 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

LOC DX

El botón cambia a LOC y solamente se detectan las emisoras con una señal suficientemente fuerte.
• Cada vez que pulsa el botón, la fuente cambia entre DX y LOC.

12

SP_AV7100[JW]f.indb 12 5/22/08 5:17:40 PM


Almacenamiento automático— Selección de emisoras
AS almacenadas
Se pueden almacenar seis emisoras para cada banda.

TUNER 3:45 PM
TUNER 3:45 PM
ST FM-1 92.5 MHz
ST FM-1 87.5 MHz

ESPAÑOL
P-01 1
87.7 MHz
P-01 1
87.7 MHz P-02
P-03
89.9
97.9
MHz
MHz
P-02 89.9 MHz
P-03 97.9 MHz P-04 92.5 MHz
P-04 105.9 MHz P-05 107.9 MHz
P-05 107.9 MHz AS PS SCAN 2DX DISP
AS PS SCAN DX DISP

2 • También puede sintonizar una emisora almacenada


por el número de preajuste.
Las emisora locales con las señales más fuertes serán
P-05 107.9 MHz
exploradas y almacenadas automáticamente en la
banda seleccionada. AS PS SCAN DX DISP

• Luego de almacenar las emisoras, la unidad sintoniza


la del número de preajuste 1.
Para detener el almacenamiento automático,
TUNER 3:45 PM
pulse AS otra vez.
ST FM-1 87.5 MHz
––

Almacenamiento manual 1
4
2
5
3
6
1 Sintonice la emisora que desea almacenar. 7 8 9 1
☞ página 12 0 OK
AS PS SCAN DX DISP
2 Seleccione un número de preajuste. 2
TUNER 3:45 PM Cancela la última entrada.
ST FM-1 92.5 MHz

P-01 87.7 MHz


P-02 89.9 MHz
En el control remoto:
P-03 97.9 MHz
P-04 105.9 MHz 1
P-05 107.9 MHz

AS PS SCAN DX DISP

2
TUNER 3:45 PM

ST FM-1 92.5 MHz o


P-01 87.7 MHz
P-02 89.9 MHz
P-03 97.9 MHz
P-04 92.5 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

La emisora seleccionada en el paso 1 ha sido


almacenada en el número de preajuste 4.
13
OPERACIONES

SP09-14_KD-AV7100[JW]f.indd 13 26/5/08 9:30:39 pm


Escaneo de emisoras Cambio de la información en el
Es posible efectuar la búsqueda de la emisora que monitor
está transmitiendo el programa que desea escucha
mediante la previsualización de emisoras. TUNER 3:45 PM

ST FM-1 87.5 MHz

Para escanear todas las emisoras de la banda P-01 87.7 MHz


P-02 89.9 MHz
seleccionada
ESPAÑOL

P-03 97.9 MHz


P-04 105.9 MHz
TUNER 3:45 PM
P-05 107.9 MHz
ST FM-1 87.5 MHz AS PS SCAN DX DISP

P-01 1
87.7 MHz
P-02 89.9 MHz
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz
TUNER 3:45 PM
AS PS SCAN DX DISP
ST FM-1 87.5 MHz
2
FM-1

La unidad efectúa la búsqueda de las emisoras 87.5 MHz


disponibles.
• Al detectar una emisora, la unidad la sintoniza
AS PS SCAN DX DISP
durante aproximadamente 10 segundos (la
frecuencia parpadea en el monitor), y luego inicia la
búsqueda de la siguiente emisora disponible.
Para detener el escaneo, pulse SCAN otra vez.

Para escanear solamente las emisoras


preajustadas de la banda seleccionada
TUNER 3:45 PM

ST FM-1 87.5 MHz

P-01 1
87.7 MHz
P-02 89.9 MHz
P-03 97.9 MHz
P-04 105.9 MHz
P-05 107.9 MHz

AS PS SCAN DX DISP

2
La unidad sintoniza las emisoras preajustadas durante
aproximadamente 10 segundos por emisora.
• Luego de sintonizar todas las emisoras preajustadas,
la unidad sintoniza la del número de preajuste 1.
Para detener el escaneo, pulse PS otra vez.

14

SP_AV7100[JW]f.indb 14 5/22/08 5:17:42 PM


Operaciones de los discos
El tipo de disco se detecta automáticamente, y la reproducción se inicia automáticamente (para algunos discos: el
inicio automático depende de su programa interno).
• La reproducción se detiene después que se reproduzcan todos los capítulos/pistas del disco.

ESPAÑOL
Si aparece “ ” en el monitor, significa que la unidad no puede aceptar la operación intentada.
• En algunos casos, puede suceder que no se acepte la operación sin que se visualice el mensaje.

Ÿ
Lado de la etiqueta

~ Inserte un disco. Precaución sobre el ajuste de volumen:


• No es posible insertar el disco si la unidad no Los discos producen muy poco ruido al compararse
está encendida. con otras fuentes. Antes de reproducir un disco, baje
Ÿ Abra el panel del monitor. el volumen para evitar daños a los altavoces debido
a un repentino aumento del nivel de salida.

• Si “TFT Auto Open” está ajustado a “On”, el monitor sale automáticamente al encender la unidad. (☞ página 42)
• Si desea información sobre el espacio requerido para la expulsión del monitor, consulte la página 55.

15 OPERACIONES

SP_AV7100[JW]f.indb 15 5/22/08 5:17:42 PM


Operaciones táctiles básicas
Para la reproducción del disco, puede utilizar los siguientes 3 tipos de operaciones del panel táctil.
• Operación táctil en las imágenes de reproducción
Para

Mientras se reproduce una imagen, es posible realizar algunas operaciones con sólo tocar el área especificada de
la pantalla. (☞ debajo)
ESPAÑOL

• Operaciones mediante los botones en pantalla


Para

Mientras se reproduce una imagen, es posible utilizar los botones de operaciones básicas visualizados sobre la
imagen reproducida. (☞ página 17)
• Operaciones en la pantalla de lista
Para

Puede utilizar los botones de la pantalla de lista. (☞ páginas 18 y 19)


• Para DivX/MPEG/JPEG, la pantalla de lista aparece mientras la reproducción está detenida.

Operación táctil en las imágenes de reproducción

Imagen reproducida

A Se visualiza “Main Menu” en la unidad.


B Salta al capítulo/pista anterior.
A E
C Visualiza la información sobre la
C reproducción.
(☞ página 24)
D Visualiza los botones en pantalla.
B F (☞ página 17)
D E Visualice la pantalla de búsqueda.*1
(☞ página 22)
F Salta al capítulo/pista siguiente.
• Es posible que no se pueda disponer de esta función mientras se
está visualizando el menú principal de DVD Vídeo.

16

SP15-34_KD-AV7100[JW]f.indd 16 23/5/08 3:59:38 pm


Operaciones mediante los botones en pantalla
• Si no se efectúa ninguna operación durante aproximadamente 15 segundos, los botones en pantalla desaparecen.

Imagen reproducida Visualiza el menú principal de DVD Vídeo*2

Selecciona el idioma de los

ESPAÑOL
subtítulos.*2 (☞ página 21)

Selecciona el idioma/canal de
audio. (☞ página 21)
Selecciona el modo de
Detiene la reproducción. Realiza la repetición A-B. (☞ página 26) repetición. (☞ página 23)
Búsqueda regresiva*3 Búsqueda progresiva*3
Comienza la reproducción/pausa.

*4
Imagen reproducida

*4

Realiza la repetición A-B.


(☞ página 26)
Búsqueda regresiva*3 Selecciona el modo de repetición. (☞ página 23)
Comienza la reproducción/pausa. Detiene la reproducción.
Búsqueda progresiva*3

*4 Imagen reproducida

Gire la imagen a 90°.

Visualiza la vista en miniatura. (☞ página 21) Detiene la reproducción.

*1 Sólo para DVD Vídeo/VCD


*2 Sólo para DVD Vídeo
*3 Velocidad de búsqueda: x2 ] x4 ] x8 ] x16 ] (Reproducción normal)
Para reanudar la reproducción normal durante la búsqueda, pulse 6.
*4 Cada vez que pulsa el botón en pantalla, los botones en pantalla desaparecen. Para repetir el procedimiento,
visualice de nuevo el botón en pantalla.

17 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 17 7/3/08 5:52:34 PM


Operaciones en la pantalla de lista
Para seleccionar una pista, toque en la lista el nombre de la pista que desea.

En situación de parada...

Nº de pista actual/Nº total de pistas en la carpeta actual Mientras la reproducción está detenida
ESPAÑOL

Se visualiza “Main Menu”


7 Stop CD-R
DISC DivX 3:45 PM
en la unidad.
01/14 00:01:35
3 : Inicia la reproducción.*1
1 ¡ 4 ¢ : *2 . .Current Folder Name Visualiza la página
File Name anterior.
File Name
File Name
File Name Visualiza la página
siguiente.
*2 7 SCAN DISP
Visualiza el contenido
de la carpeta siguiente/ *2 Visualiza/oculta la lista de
anterior. (☞ página 20) Visualiza los botones de los números en pantalla. carpetas/pistas.
Selecciona el modo de repetición. (☞ página 23)
*2

En situación de parada...
3 : Inicia la reproducción (Slide show).*1
Se visualiza “Main Menu” en la unidad. 1 ¡ 4 ¢ : *2

7 Stop
DISC JPEG 3:45 PM

. .Current Folder Name Visualiza la página


File Name anterior.
File Name
File Name
Visualiza la página
File Name
siguiente.
7 SCAN DISP
*2

Visualiza el contenido de la carpeta siguiente/anterior. *2 *2 Visualiza/oculta la lista de


(☞ página 20) carpetas/pistas.
Visualiza los botones de los números en pantalla.
Selecciona el modo de repetición. (☞ página 23)

18

SP15-34_KD-AV7100[JW]f.indd 18 7/3/08 5:52:43 PM


Se visualiza “Main Menu” en la unidad.
Nº de pista/Nº total de pistas Tiempo de reproducción

DISC CDDA 3:45 PM

8: Pone en pausa.*3 01/14 01:35


1¡:

ESPAÑOL
Búsqueda hacia atrás/ Track Title Visualiza la página
adelante*4 Track Title anterior.
Track Title
4¢:
Track Title
Selecciona la pista. Visualiza la página
Track Title
*5 siguiente.
Detiene la reproducción. 7 SCAN DISP

Activa/desactiva el modo de escaneo. (☞ página 23) Visualiza el texto del disco.


Visualiza los botones de los números en pantalla. (☞ página 24)
Selecciona el modo de repetición. (☞ página 23) Activa/desactiva el modo Shuffle
(aleatorio). (☞ página 23)

Se visualiza “Main Menu” en la unidad. Tipo de archivo (MP3/WMA)


Nº de pista actual/Nº total de pistas en la carpeta actual

DISC MP3 3:45 PM

8: Pone en pausa.*3 01/14 01:35 Tiempo de reproducción


1¡:
. .Current Folder Name Visualiza la página
Búsqueda hacia atrás/
File Name anterior.
adelante*4 File Name
4¢: File Name
Selecciona la pista. File Name Visualiza la página
siguiente.
Pare la reproducción.*1 7 SCAN DISP

Visualiza la información de la
Visualiza el contenido de la carpeta siguiente/anterior.
etiqueta. (☞ página 24)
(☞ página 20)
Activa/desactiva el modo Shuffle
Activa/desactiva el modo de escaneo. (☞ página 23) (aleatorio). (☞ página 23)
Visualiza los botones de los números en pantalla. Selecciona el modo de repetición. (☞ página 23)
*1 La próxima vez que inicie la reproducción, se realizará desde la primera pista de la carpeta actual.
*2 Estos botones no funcionan.
*3 Mientras la reproducción está en pausa o detenida, o durante la búsqueda hacia atrás/hacia adelante, este botón
cambia a 3 (reproducción).
*4 Velocidad de búsqueda: x2 ] x4 ] x8 ] x16 ] (Reproducción normal)
Para reanudar la reproducción normal durante la búsqueda, pulse 3.
*5 Aparece el número de pista para los CDs convencionales (por ej.: “Track08.CDA”).
19 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 19 26/5/08 9:30:14 pm


Selección de una pista Para seleccionar una pista por su número
Para seleccionar una pista en otras carpetas
Para DivX/MPEG/JPEG: En situación de parada

Para DivX/MPEG/JPEG: En situación de parada


1
• Sólo está disponible cuando se visualiza una lista de DISC MP3 3:45 PM
ESPAÑOL

carpetas/pistas. 01/14 01:35

1 Seleccione una carpeta. . .Current Folder Name


File Name
• Para seleccionar la carpeta siguiente: File Name
File Name File Name
File Name
7 SCAN DISP
7 SCAN DISP

• Para seleccionar la carpeta anterior: 2 Introduzca el número de la pista deseada.


File Name
• Para DivX/MPEG/JPEG/MP3/WMA: Especifique el
7 SCAN DISP
número de pista de la carpeta actual.
DISC MP3 3:45 PM

• Para seleccionar la carpeta del nivel superior: ––––


01/14 01:35

DISC MP3 3:45 PM .. 1 2 3


File Name
4 5 6
01/14 01:35 File Name
7
File Name 8 9 1
. .Current Folder Name File Name 0 OK
File Name
7 SCAN DISP
File Name
File Name
2
File Name
Cancela la última entrada.
7 SCAN DISP

Se visualiza el contenido de la carpeta que


contiene a la carpeta que ha tocado.
2 Seleccione una pista.
DISC MP3 3:45 PM

01/14 01:35

. .Current Folder Name


File Name
File Name
File Name
File Name
7 SCAN DISP

20

SP15-34_KD-AV7100[JW]f.indd 20 26/5/08 10:32:37 pm


Selección del idioma para los 2 Ej.: Cuando el disco tiene 3 idiomas de audio
subtítulos

1 Toque este área. (☞ página 16)


1/3 D 5.1Ch Eng

ESPAÑOL
D 5.1Ch Eng D 5.1Ch Fre
D 5.1Ch Spa

2 Ej.: Cuando el disco tiene 3 idiomas de subtítulos


Selección de una imagen desde
la vista en miniatura

Puede usar la pantalla de vistas en miniatura para


seleccionar una imagen.
1/3 Eng 1 Toque este área. (☞ página 16)

Eng Fre Spa

Selección del idioma/canal de


audio 2

1 Toque este área. (☞ página 16)


Se visualizan las imágenes de la carpeta actual.
3

La presentación de diapositivas comienza desde la


imagen seleccionada.
21 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 21 7/3/08 5:52:52 PM


Uso de la pantalla de búsqueda
Ej.: Cuando se efectúa la búsqueda de pista por su
número
Ej.: Cuando se efectúa la búsqueda de capítulo por su
Mientras se está reproduciendo...
número
Mientras se está reproduciendo... Toque este área. (☞ página 16)
Toque este área. (☞ página 16)
ESPAÑOL

Search
Search 1 Track ---
1 Title --- 2 Time - -:- -:- -
2 Chapter ---
3 Time - -:- -:- -

1 Búsqueda de pista por su número


1 Búsqueda de título por su número
2 Búsqueda por tiempo de la pista (Especificar una
2 Búsqueda de capítulo por su número
cierta escena ingresando el tiempo de la pista.)
3 Búsqueda por tiempo (Especificar una cierta escena
ingresando el tiempo.)
Search
Track ---
Search Time - -:- -:- - 1 2 3
Title ---
1 4 5 6
1 2 3
Chapter ---
7 8 9 2
Time - -:- -:- - 1 4 5 6
0 OK
7 8 9 2
0 OK 3
3
Cancela la última entrada.
Cancela la última entrada.

En el control remoto:
1 Visualice la pantalla de búsqueda. 3
2 Seleccione una opción. 4 Finalice el procedimiento.

22

SP15-34_KD-AV7100[JW]f.indd 22 7/3/08 5:53:02 PM


Selección de los modos de reproducción
Puede utilizar solamente uno de los siguientes modos Ej.: Cuando se activa “Repeat single” para MP3
de reproducción—Por escaneo/Repetida/Shuffle. DISC MP3 Repeat single3:45 PM
• Para DVD/VCD, visualice primero los botones en 02/14 01:35
pantalla. (☞ página 16)
. .Current Folder Name
File Name
DISC MP3 3:45 PM
File Name

ESPAÑOL
02/14 01:35 File Name
File Name
. .Current Folder Name
7 SCAN DISP
File Name
File Name
File Name
File Name
7 SCAN DISP single Folder all off

Modo de escaneo Modo Shuffle


Modo de repetición* Se visualiza el icono del modo de reproducción del
modo seleccionado.
DISC MP3 S 3:45 PM
* También podrá usar el control remoto.
02/14 01:35

Para cancelar, seleccione “off”.


Tipo de
Scan Repeat Shuffle
disco
Chapter: Repite el capítulo actual.
— —
Title: Repite el título actual.
single: Se repite la pista actual (PBC
— no está en uso). —
all: Se repiten todas las pistas.
On (SCAN): Se reproducen single ( ): Repetir la pista actual. Shuffle ( ): Mezcla todas
los primeros 10 all ( ): Se repiten todas las pistas. las pistas y las reproduce
segundos de cada pista. aleatoriamente.
On (SCAN): Se reproducen single ( ): Repetir la pista actual. Shuffle ( ): Mezcla todas
los primeros 10 Folder ( ): Se repiten todas las las pistas de la carpeta
segundos de cada pista. pistas de la carpeta actual. actual y las reproduce
all ( ): Se repiten todas las pistas. aleatoriamente, luego
continúa con las pistas de
las siguientes carpetas.
single ( ): Repetir la pista actual.
Folder ( ): Se repiten todas las
— pistas de la carpeta actual. —
all ( ): Se repiten todas las pistas.

23 OPERACIONES

SP_AV7100[JW]f.indb 23 5/22/08 5:17:50 PM


Visualización de la información Para VCD
1 9
sobre reproducción VCD2.0
PBC On
Time 13:24/ 25:15

0
1 Tipo de disco/tipo de archivo
2 Nº de título actual (carpeta)/Nº total de títulos
Puede visualizar la información sobre reproducción. (carpetas)
ESPAÑOL

3 Tiempo de reproducción/tiempo restante


En la unidad: 4 Selección de subtítulos
5 Selección del ángulo
o 6 Nª de capítulo (pista) actual/Nº total de capítulos
(pistas)
7 Velocidad de bits actual
En el control remoto: 8 Selección de audio (señal de audio e idioma)
9 Tiempo de reproducción/restante de la pista
0 PBC activado (Nª de pista actual/Nº total de pistas
cuando el PBC está desactivado.)
• También está disponible la operación táctil. (☞
página 16) Cambio de la información en el
monitor
Mientras se está reproduciendo...
Para DVD
1 2 3 4
DISC MP3 3:45 PM
DVD Video Time 00:13:24/01:25:15
Title 1/3 Subtitle 2/3 French 02/14 01:35
Chapter 4/12 Audio 1/3 D 5.1Ch Eng
Angle 1/3 Bitrate 7.3Mbps . .Current Folder Name
File Name
5 6 7 8 File Name
Para DivX File Name
File Name
1 3
7 SCAN DISP
DivX 5.x Time 00:13:24/01:25:15
Track 10/12 Audio 1/3 MP3 2 Ch
Subtitle Off

6 4 8
DISC MP3 3:45 PM
Para MPEG
02/14 01:35
1 3
MPEG Time 00:13:24/01:25:15 Name: Track Title
Track 10/12
Artist: Artist Name
Album: Album Name

6
7 SCAN DISP
Para JPEG
1 6
JPEG Track 10/12
• Aparece el mensaje “Unknown” para los CD
convencionales o cuando el archivo no posee
información de etiqueta.
24

SP15-34_KD-AV7100[JW]f.indd 24 7/3/08 5:53:10 PM


Restricción de reproducción 4 Introduzca un número de 4 dígitos para su
Podrá restringir la reproducción de DVD Vídeo con contraseña.
escenas violentas o que no sean apropiadas para los SETUP MENU BACK
miembros de su familia.
General Language
• Se restringirá la reproducción de los discos TS Calibrate : No
que tengan un nivel superior al seleccionado. Set Password :----
Parental control : PG-13
Es posible que algunos discos no se puedan Aspect Ratio : 16:9

ESPAÑOL
reproducir en absoluto, y que otros se Screen saver : On
reproduzcan omitiendo escenas de nivel superior. Audio ASP MISC
• Este ajuste sólo tiene efecto en los DVD Vídeo
que contienen información sobre el nivel de
restricción. SETUP MENU Enter Password BACK

1 Toque este área (☞ página 16)


General Language
__
1 2 3
4 5 6
7 8 9 1
0 OK
Audio ASP MISC
2
Main Menu BACK Cancela la última entrada.
Aparece “Enter Password Again”.
TUNER DISC AUX IN AV-IN
5 Introduzca de nuevo la contraseña.
Aparece “Locked” (bloqueado) para “Set Password”
LOCK

USB iPod SD CAMERA


(Configurar contraseña) y no podrá seleccionar
MONITOR
OFF
“Parental control” (Control para padres).
SET UP
• Necesitará introducir la contraseña para cambiar
el nivel de restricción o la contraseña.
2 SETUP MENU BACK • Sin ingresar la contraseña, en este paso, se
General Language guardan los ajustes que ha realizado.
TS Calibrate
Set Password
: No
:----
6 Finalice el procedimiento.
Parental control : 8. Adult
(dos veces)
Aspect Ratio : 16:9 SETUP MENU BACK
Screen saver : On
Audio ASP MISC General Language
TS Calibrate : No
Set Password : Locked
3 Ajuste el nivel de restricción. Parental Control : 4. PG-13
• Si desea información acerca del nivel de
restricción, consulte la página 45.
SETUP MENU BACK

General Language
TS Calibrate : No
Set Password :---- 4. PG-13
Parental control : 8. Adult 5. PG-R
Aspect Ratio : 16:9 6. R 2
Screen saver : On1
Audio ASP MISC

Visualiza más opciones.


25 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 25 26/5/08 10:33:01 pm


Operaciones utilizando el control remoto—RM-RK253

Detiene la reproducción.
Comienza la reproducción/pausa (si lo pulsa durante la
reproducción).
ESPAÑOL

Búsqueda hacia atrás/adelante*1 (El sonido no se


escucha.)
Selecciona un capítulo (durante la reproducción o la
pausa).

Búsqueda de título/capítulo/tiempo. (☞ página 22)


Selecciona el modo de repetición. (☞ página 23)
Selecciona el idioma de audio.
Selecciona el idioma de los subtítulos.
Selecciona el ángulo de visión.
Amplía con el zoom.*2

Usando las funciones de control por menú


1 Visualiza el menú de disco.

2 Seleccione la opción que desea reproducir.

Repetición del pasaje deseado—Repetición A-B


1 Seleccione la posición de inicio (A)*3.

2 Seleccione la posición de fin (B)*3.

Para cancelar la repetición A-B:

26

SP15-34_KD-AV7100[JW]f.indd 26 7/3/08 5:53:19 PM


Detiene la reproducción. Detiene la reproducción.
Comienza la reproducción/pausa (si Comienza la reproducción/
lo pulsa durante la reproducción). pausa (si lo pulsa durante la
Búsqueda hacia atrás/adelante*1 reproducción).

ESPAÑOL
Búsqueda hacia atrás/
Selecciona la pista. adelante*1. (El sonido no se
escucha.)
Selecciona la pista.
Selecciona la pista (dentro de la
Búsqueda de pista/tiempo. misma carpeta).
(☞ página 22)
Selecciona el modo de
Selecciona el modo de repetición. repetición. (☞ página 23)
(☞ página 23)
Selecciona el canal de audio (ST: Amplía con el zoom.*2
estéreo, L: izquierdo, R: derecho).
Repetición del pasaje deseado—Repetición A-B
Amplía con el zoom.*2
1 Seleccione la posición de inicio (A)*3.
Cancela/reanuda la reproducción
de PBC.
2 Seleccione la posición de fin (B)*3.
Durante la reproducción PBC...
= : Para cancelar la repetición A-B:

Seleccione una opción en el menú.

:
Se desplaza a la página siguiente/anterior del
menú actual.

Repetición del pasaje deseado—Repetición A-B


1 Seleccione la posición de inicio (A)*3.

2 Seleccione la posición de fin (B)*3.

Para cancelar la repetición A-B:

*1 Velocidad de búsqueda: x2 ] x4 ] x8 ] x16 ] (Reproducción normal)


Para reanudar la reproducción normal durante la búsqueda, pulse 6.
*2 Ampliación: +1 ] +2 ] +3 ] Off
*3 En la práctica, la posición de inicio/fin de la reproducción puede ser diferente de la posición seleccionada durante
algunos segundos.
27 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 27 7/3/08 5:53:28 PM


Detiene la reproducción. Detiene la reproducción.
Inicia la reproducción. (Slide Comienza la reproducción/
show: se muestra cada archivo pausa (si lo pulsa durante la
durante unos segundos.) reproducción).
ESPAÑOL

Salto hacia atrás/adelante. Búsqueda hacia atrás/


adelante.*2
Selecciona la pista (dentro de la
misma carpeta). Selecciona la pista.
Selecciona el modo de Selecciona la pista (dentro de la
repetición. (☞ página 23) misma carpeta).
Amplía con el zoom.*1 Selecciona el modo de
repetición. (☞ página 23)

Repetición del pasaje deseado—Repetición A-B


1 Seleccione la posición de inicio (A).
Detiene la reproducción.
Comienza la reproducción/ 2 Seleccione la posición de fin (B).
pausa (si lo pulsa durante la
reproducción).
Para cancelar la repetición A-B:
Búsqueda hacia atrás/
adelante.*2
Selecciona la pista.
Selecciona la pista.
Selecciona el modo de
repetición. (☞ página 23)

Repetición del pasaje deseado—Repetición A-B


1 Seleccione la posición de inicio (A).

2 Seleccione la posición de fin (B).

Para cancelar la repetición A-B:

*1 Ampliación: +1 ] +2 ] +3 ] Off
*2 Velocidad de búsqueda: x2 ] x4 ] x8 ] x16 ] (Reproducción normal)
Para reanudar la reproducción normal durante la búsqueda, pulse 6.
28

SP_AV7100[JW]f.indb 28 5/22/08 5:17:56 PM


Cómo disfrutar de sonidos 4 Seleccione el tamaño de los altavoces.
• Si desea detalles sobre el tamaño de los
Surround de 5.1 canales altavoces, consulte la página 43.
Podrá disfrutar de una reproducción Surround • El sonido no saldrá de los altavoces central/
multicanal a través de los altavoces delanteros, central,
surround, si no están activados.
surround para fuentes multicanal con codificación
Ej.: Activación del altavoz central
Dolby Digital*.
* Fabricado bajo licencia de Dolby Laboratories. Dolby, SETUP MENU BACK

ESPAÑOL
Pro Logic y el símbolo de la doble D son marcas General Language
comerciales de Dolby Laboratories. DownMix : FULL 6CH
Front Speakers : Large Large
1 Toque este área. (☞ página 16) Center Speaker : None Small
Sur Speakers : None None
Subwoofer : None 1 2
Audio ASP MISC

5 Finalice el procedimiento.
(dos veces)
Vuelve a la pantalla anterior. SETUP MENU BACK

General Language
Main Menu BACK
DownMix : FULL 6CH

TUNER DISC AUX IN AV-IN

Para ajustar el nivel de salida de los


LOCK

USB iPod SD CAMERA altavoces


MONITOR
OFF
Mientras está escuchando la reproducción Surround
SET UP
multicanal, podrá ajustar el nivel de salida de los
altavoces dentro del rango de –10 a +10.
2 SETUP MENU BACK

General Language
Vuelve a la pantalla anterior.
DownMix : DownMix
Front Speakers : Large
Center Speaker : None 6CH Audio
Sur Speakers : None
Subwoofer : None VOL 15 – +

Audio ASP MISC


LEFT 0 – +
RIGHT 0 – +
S.Left 0 – +
3 Active Surround de 5.1 canales (“FULL 6CH”). S.Right
Center
0
0


+
+
SETUP MENU BACK
SUB.W 0 – +
General Language
DownMix : DownMix
• VOL: Nivel de volumen (0 a 40).
Front Speakers : Large FULL 6CH • LEFT: Nivel del altavoz delantero izquierdo (–10 a +10).
Center Speaker 1
: None DownMix
Sur Speakers : None 2 • RIGHT: Nivel del altavoz delantero derecho (–10 a +10).
Subwoofer : None • S.Left: Nivel del altavoz Surround izquierdo (–10 a +10).
Audio ASP MISC • S.Right: Nivel del altavoz Surround derecho (–10 a +10).
• Center: Nivel del altavoz central (–10 a +10).
• Si desea información sobre “DownMix”,
consulte la página 43. • SUB.W: Nivel de subwoofer (–10 a +10).
29 OPERACIONES

SP_AV7100[JW]f.indb 29 5/22/08 5:17:57 PM


Cómo disfrutar de los modos 2 Active el modo Pro Logic II seleccionado.
Dolby Pro Logic II SETUP MENU BACK

Puede usar los modos Dolby Pro Logic II para General Language
reproducir un sonido espacioso desde las fuentes de 2 Down sampling : On
canales, excepto para discos DivX/MPEG1/MPEG2. Decode Mode : Pro Logic
Panorama : Off
Dim Ctrl : Off
Efectúe los pasos 1 y 2 de la página 29 y luego... C W Ctrl : Off
ESPAÑOL

Audio ASP MISC


1 Seleccione el modo Pro Logic II .
SETUP MENU BACK
SETUP MENU BACK
General Language
General Language
DownMix : DownMix
Front Speakers : Large Test tones : Off
Center Speaker : None Center delay : No delay Off
Sur Speakers : None Surr delay : No delay On
Subwoofer : None Night Mode
Pro Logic
: Off
: Off
Auto
2
Audio ASP MISC
Audio ASP 1 MISC

SETUP MENU BACK • Off: Desactiva el modo Pro Logic II .


General Language
• On: Activa el modo Pro Logic II seleccionado.
Down sampling : On
• Auto: Activa el modo Pro Logic II apropiado
Decode Mode : Off Off para la fuente de reproducción (Pro Logic/PLII
Panorama : Off Pro Logic
Dim Ctrl 1 : Off PLII Matrix
Matrix/PLII Movie/PLII Music).
2
C W Ctrl
Audio
: Off
ASP MISC
3 Finalice el procedimiento.
(dos veces)
Visualiza más opciones. SETUP MENU BACK
• Off: No se aplica ningún efecto. General Language
• Pro Logic: Selecciona Pro Logic; adecuado para Test tones : Off
fuentes codificadas con Dolby Surround.
• PLII Matrix: Selecciona Pro Logic II Matrix,
adecuado para sonido monoaural o para • Cuando se activa “PLII Music” (“On” o “Auto”), puede
reproducir el canal de audio seleccionado de, añadir o ajustar el control del efecto—Panorama,
por ejemplo, VCD de Karaoke. Center Width, Dimension. (☞ página 44)
• PLII Movie: Selecciona Pro Logic II Movie;
adecuado para películas.
• PLII Music: Selecciona Pro Logic II Music;
adecuado para música.

30

SP_AV7100[JW]f.indb 30 5/22/08 5:17:58 PM


Operaciones de SD
Esta unidad puede reproducir archivos MPEG/JPEG/MP3/WMA guardados en una tarjeta SD.
• Puede manipular la tarjeta SD tal como lo hace con los archivos de los discos. (☞ páginas 17 – 28)
• La reproducción se detiene después que se reproduzcan todas las pistas de la tarjeta SD.
• Si vuelve a iniciar la reproducción luego de cambiar la fuente o de apagar la unidad, la reproducción se iniciará
desde la primera pista.

ESPAÑOL
• Asegúrese de tener una copia de respaldo de todos los datos importantes.

~ Abra la cubierta delantera. Precaución:


Ÿ Inserte una tarjeta SD. • Presione la parte central del borde al insertar una
Introduzca la tarjeta SD hasta que oiga un tarjeta SD.
chasquido. • Si desea más información acerca de las
! Seleccione “SD” para la fuente. operaciones de SD, ☞ página 48.
(☞ página 10)
• Abra el monitor, si es necesario.

Para expulsar la tarjeta SD


Empuje ligeramente la tarjeta SD, y luego extraiga la tarjeta.

31 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 31 7/18/08 9:10:22 AM


Selección de los modos de reproducción
Puede utilizar solamente uno de los siguientes modos Ej.: Cuando se activa “Repeat single” para MP3
de reproducción—Por escaneo/Repetida/Shuffle. SD MP3 Repeat single3:45 PM

SD MP3 3:45 PM 02/14 01:35

02/14 01:35 . .Current Folder Name


File Name
. .Current Folder Name File Name
ESPAÑOL

File Name File Name


File Name File Name
File Name
7 SCAN DISP
File Name
7 SCAN DISP

single Folder all off


Modo de escaneo Modo Shuffle
Modo de repetición*

Se visualiza el icono del modo de reproducción del


* También podrá usar el control remoto. modo seleccionado.
SD MP3 S 3:45 PM

02/14 01:35

Para cancelar, seleccione “off ”.

Tipo de
Scan Repeat Shuffle
archivo
On (SCAN): Se reproducen los single ( ): Repetir la pista Shuffle ( ): Mezcla todas
primeros 10 segundos de actual. las pistas de la carpeta
cada pista. Folder ( ): Se repiten todas actual y las reproduce
las pistas de la carpeta aleatoriamente, luego
actual. continúa con las pistas de
all ( ): Se repiten todas las las siguientes carpetas.
pistas.
Track ( ): Repetir la pista
actual.
Folder ( ): Se repiten todas
— las pistas de la carpeta —
actual.
all ( ): Se repiten todas las
pistas.

32

SP_AV7100[JW]f.indb 32 5/22/08 5:18:00 PM


Operaciones de USB
Puede conectar a la unidad, un dispositivo de clase de almacenamiento masivo USB tal como una memoria USB,
reproductor de audio digital, etc.
Esta unidad puede reproducir archivos JPEG/MPEG1/MPEG2*/MP3/WMA almacenados en un dispositivo de clase de
almacenamiento masivo USB.
• Puede accionar el dispositivo USB tal como lo hace con los archivos de los discos. (☞ páginas 17 – 28)

ESPAÑOL
• La reproducción se detiene después que se reproduzcan todas las pistas del dispositivo de clase de
almacenamiento masivo USB.
• Si vuelve a iniciar la reproducción luego de cambiar la fuente o de apagar la unidad, la reproducción se iniciará
desde la primera pista.
• Asegúrese de tener una copia de respaldo de todos los datos importantes.
* Excepto archivos MPEG2 grabados mediante la cámara JVC Everio (código de extensión <.mod>).

~ • No es posible conectar un computador


al terminal ( ) USB de la unidad.

~ Abra la cubierta delantera.


Ÿ Conecte un dispositivo de clase de almacenamiento masivo USB.
! Seleccione “USB” para la fuente.
(☞ página 10)
• Abra el monitor, si es necesario.

Precaución:
• Evite usar el dispositivo USB si puede amenazar la seguridad de conducción.
• No extraiga ni fije repetidas veces el dispositivo USB mientras “Reading...” se encuentra visualizado en la
pantalla del monitor.
• No ponga en marcha el motor del coche si hay un dispositivo USB conectado.
• Detenga la reproducción antes de desconectar un dispositivo USB.
• No deje el dispositivo USB en el coche expuesto a la luz directa del sol o a altas temperaturas pues se podrá
producir deformación o daños en el dispositivo.
• Si desea más información acerca de las operaciones USB, ☞ página 49
33 OPERACIONES

SP15-34_KD-AV7100[JW]f.indd 33 7/18/08 9:12:53 AM


Selección de los modos de reproducción
Puede utilizar solamente uno de los siguientes modos Ej.: Cuando se activa “Repeat single” para MP3
de reproducción—Por escaneo/Repetida/Shuffle. USB MP3 Repeat single3:45 PM

02/14 01:35
USB MP3 3:45 PM

02/14 01:35 . .Current Folder Name


File Name
. .Current Folder Name File Name
ESPAÑOL

File Name File Name


File Name File Name
File Name 7 SCAN DISP
File Name
7 SCAN DISP

single Folder all off


Modo de escaneo Modo Shuffle
Modo de repetición*

* También podrá usar el control remoto. Se visualiza el icono del modo de reproducción del
modo seleccionado.
USB MP3 S 3:45 PM

02/14 01:35

Para cancelar, seleccione “off”.

Tipo de
Scan Repeat Shuffle
archivo
On (SCAN): Se reproducen los single ( ): Repetir la pista Shuffle ( ): Mezcla todas
primeros 10 segundos de actual. las pistas de la carpeta
cada pista. Folder ( ): Se repiten todas actual y las reproduce
las pistas de la carpeta aleatoriamente, luego
actual. continúa con las pistas de
all ( ): Se repiten todas las las siguientes carpetas.
pistas.
Track ( ): Repetir la pista
actual.
Folder ( ): Se repiten todas
— las pistas de la carpeta —
actual.
all ( ): Se repiten todas las
pistas.

34

SP_AV7100[JW]f.indb 34 5/22/08 5:18:02 PM


Para escuchar el iPod
Puede conectar el iPod mediante el cable especial suministrado para el iPod.
• Para la conexión, consulte el Manual de instalación/conexión (volumen separado).
• Si desea más información, consulte, también, el manual suministrado con el iPod.

Precaución:

ESPAÑOL
Cable especial para iPod
(suministrado) • Evite utilizar el iPod si esto puede poner en
peligro su seguridad cuando conduce.
• Para evitar el borrado accidental, asegúrese
de sacar copia de respaldo de todos los datos
importantes.

~ Conecte un iPod.
La reproducción se inicia automáticamente desde el punto de detención anterior.
• Si ha conectado un iPod, seleccione “iPod” para la fuente. (☞ página 10)
Ÿ Ajuste el volumen.
(☞ página 10)
! Ajuste el sonido según se desee.
(☞ página 39)
Se visualiza “Main Menu” en la unidad. Nº de pista/Nº total de pistas

iPod 3:45 PM

01/57 01:35 Tiempo de reproducción


8 : Pone en pausa.*
1¡: Track Title Visualiza la página
Búsqueda hacia Track Title anterior.
atrás/adelante Track Title
4¢: Track Title
Selecciona la pista. Track Title Visualiza la página
siguiente.
SCAN DISP

Cambia la información en el monitor


Activa el modo de vídeo. (☞ página 37)
Activa/desactiva el modo de escaneo. Activa/desactiva el modo Shuffle (aleatorio).
(☞ página 37) (☞ página 37)
Visualiza el menú de música del iPod. Selecciona el modo de repetición. (☞ página 37)
Vuelve a la pantalla anterior. Visualiza los botones de los números en pantalla.

* Cuando se pausa la reproducción, o durante una búsqueda hacia atrás/hacia delante, este botón en pantalla
cambia a 3 (reproducir).
35 DISPOSITIVOS EXTERNOS

SP35-38_KD-AV7100[JW]f.indd 35 7/3/08 5:54:12 PM


Selección de una pista desde la Selección de una pista por su
lista número
1 Track Title
1 Track Title
SCAN DISP
SCAN DISP

2 Introduzca el número de la pista.


ESPAÑOL

2 Seleccione la lista deseada.


iPod 3:45 PM
iPod 3:45 PM
01/57 01:35
–––
01/57 01:35
1 2 3
Artists 4 5 6
Albums
Songs 7 8 9 1
Genres 0 OK
Composers
SCAN DISP
SCAN DISP
2
Cancela la última entrada.
3 Seleccione una opción.
Cómo disfrutar de la
Ej.: Cuando selecciona “Albums” en el paso 2
iPod 3:45 PM
reproducción de vídeo
Si desea ver la reproducción de vídeo en el monitor de la
01/57 01:35
unidad, ajuste “TV Out” a “TV On” en el iPod.
Album Name
Album Name
• Consulte las instrucciones suministradas con el iPod.
Album Name
Album Name
1 Active el modo de vídeo.
Album Name Track Title

SCAN DISP SCAN DISP

• Repita el procedimiento para seleccionar la pista


deseada. iPod 3:45 PM

0/0 00:00
Para volver a la pantalla anterior
Track Title Waiting for Video Signal
SCAN DISP

SCAN DISP

2 Accione el iPod para reproducir una fuente de


vídeo.
Para desactivar el modo de vídeo
iPod 3:45 PM

01/57 01:35

Waiting for Video signal


Se reanuda la reproducción de audio y puede operar el
iPod desde el equipo.
36

SP_AV7100[JW]f.indb 36 5/22/08 5:18:04 PM


Selección de los modos de Cambio de la información en el
reproducción monitor
Puede utilizar solamente uno de los siguientes modos
iPod 3:45 PM
de reproducción—Por escaneo/Repetida/Shuffle.
01/57 01:35
Track Title
Track Title
SCAN DISP
Track Title

ESPAÑOL
Track Title
Track Title
Modo de escaneo Modo Shuffle Track Title

Modo de repetición* SCAN DISP

* También podrá usar el control remoto.

Ej.: Cuando se activa el “Repeat single” (repetir único) iPod 3:45 PM

iPod Repeat single 3:45 PM 01/57 01:35

01/57 01:35
Name: Track Title
Track Title Artist: Artist Name
Track Title
Album: Album Name
Track Title
Track Title
SCAN DISP
Track Title
SCAN DISP

single all off

Se visualiza el icono del modo de reproducción del


modo seleccionado.
iPod S 3:45 PM

01/57 01:35

Para cancelar, seleccione “off”.

Scan On (SCAN): Reproduce los primeros 10


segundos de cada pista de la lista.
Repeat single ( ): Repetir la pista actual.
all ( ): Repite todas las pistas de la
lista.
Shuffle Shuffle ( ): Mezcla todas las pistas y
las reproduce aleatoriamente.

37 DISPOSITIVOS EXTERNOS

SP35-38_KD-AV7100[JW]f.indd 37 26/5/08 9:31:14 pm


Uso de otros componentes externos
AV-IN / AUX IN / CAMERA
Puede conectar los siguientes componentes externos:
• Componente de audio/vídeo a las clavijas AV IN de la parte trasera de la unidad
• Componente de reproducción de audio (como un reproductor de audio portátil) al jack de entrada AUX del panel
ESPAÑOL

frontal
• Cámara de retrovisión a la clavija CAMERA de la parte trasera de la unidad

Conexión al jack AUX

Mini-clavija estéreo

1 Seleccione la fuente.
(☞ página 10)
• Cuando se conecta el conductor de la lámpara de marcha atrás (consulte el manual de instalación/conexión),
la fuente cambia automáticamente a “CAMERA” al poner el engranaje en la posición de marcha atrás (R).
2 Encienda el componente conectado y comience a reproducir la fuente.
3 Ajuste el nivel de volumen.

38

SP35-38_KD-AV7100[JW]f.indd 38 7/18/08 9:14:30 AM


Ajustes del sonido
Puede seleccionar un modo de sonido preajustado para Ajuste de los graves/agudos
las fuentes de 2 canales. (Para la fuente multicanal, el Cuando se selecciona “User” para “EQ” (☞ columna
modo de sonido será cancelado temporalmente.) izquierda)...
1 Para ajustar los graves (–7 a 7):
Selección del modo de sonido

ESPAÑOL
AUDIO SETTING

1 Visualice la pantalla de ajuste de audio. EQ < User >


BASS 3 – +
Treble 0 – +
BAL 0 L R
FADE 0 R F
• Si pulsa este botón durante la reproducción SW 0 – +
Surround multicanal, se visualizará la pantalla de LOUD < Off >
ajuste de los altavoces. (☞ página 29)
2 Para ajustar los agudos (–7 a 7):
AUDIO SETTING
EQ < > AUDIO SETTING
Jazz
BASS – + EQ < User >
Treble – + BASS 3 – +
BAL 0 L R Treble 5 – +
FADE 0 R F BAL 0 L R

SW 0 – + FADE 0 R F

LOUD < Off > SW 0 – +


LOUD < Off >
• Para preajustar los valores graves y agudos:
☞ página 50 2 Finalice el procedimiento.
• Los graves y agudos se pueden ajustar cuando se AUDIO SETTING
selecciona “User”. (☞ en la derecha) EQ < User >

3 Finalice el procedimiento. BASS


Treble
3
5


+
+
AUDIO SETTING
EQ < Rock >
BASS – + En el control remoto:
Treble – +
BAL 0 L R 1 Visualice la pantalla de ajuste de audio.
FADE 0 R F
SW 0 – +
LOUD < Off >

• Si no se efectúa ninguna operación durante 2 Seleccione un elemento, y luego ajústelo.


aproximadamente 15 segundos, la pantalla
desaparece.
3 Finalice el procedimiento.

39 AJUSTES

SP_AV7100[JW]f.indb 39 5/22/08 5:18:06 PM


Ajuste del sonido En el control remoto:
Podrá ajustar los elementos de sonido, de la siguiente
manera.
1 Visualice la pantalla de ajuste de audio.

BAL (balance) L9 (altavoz izquierdo


solamente) a R9 (altavoz
derecho solamente)
2 Seleccione un elemento, y luego
FADE (fader) F9 (altavoz delantero
ESPAÑOL

ajústelo.
solamente) a R9 (altavoz trasero
solamente)
SW (nivel –7 a 7 3 Finalice el procedimiento.
de salida del
subwoofer)*
LOUD Activado/desactivado
(sonoridad)

* Este ajuste de nivel del subwoofer sólo tiene efecto


cuando Surround se encuentra activado. (☞ también
página 29)

1 Visualice la pantalla de ajuste de audio.


☞ página 39
2 Ajuste el sonido según se desee.
Ej.: Cuando se ajusta “FADE”
AUDIO SETTING
EQ < Jazz >
BASS – +
Treble – +
BAL 0 L R
FADE F3 R F
SW 0 – +
LOUD < Off >

3 Finalice el procedimiento.
AUDIO SETTING
EQ < Jazz >
BASS – +
Treble – +
BAL 0 L R
FADE F3 R F
SW 0 – +
LOUD < Off >

40

SP_AV7100[JW]f.indb 40 5/22/08 5:18:07 PM


Operaciones de los menús
Los pasos siguientes constituyen uno de los 4 SETUP MENU BACK
procedimientos fundamentales.
• Si no se efectúa ninguna operación durante General Language
aproximadamente 15 segundos, la operación del Language : English
menú se cancela. DVD menu : English English

ESPAÑOL
Subtitle : English French
Audio : English Spanish
Ej.: Cambio del ajuste “Subtitle” 1
2
1 TUNER 3:45 PM
Audio ASP MISC

ST FM-1 87.5 MHz Visualiza más opciones.


P-01 87.7 MHz
P-02 89.9 MHz
SETUP MENU BACK

2 Vuelve a la pantalla anterior. General Language


Language : English
Main Menu BACK DVD menu : English
Subtitle : Spanish
Audio : English
TUNER DISC AUX IN AV-IN

Audio ASP MISC


LOCK

USB iPod SD CAMERA

MONITOR
OFF
5 Finalice el procedimiento.
SET UP (dos veces)
SETUP MENU BACK

3 SETUP MENU BACK


General Language
Language : English
General Language DVD menu : English
Subtitle : Spanish
Language : English
Audio : English
DVD menu : English
Subtitle : English
Audio : English Audio ASP MISC

Audio ASP MISC

En el control remoto: 4 Seleccione la opción deseada.


1 Visualice “Main Menu”, luego seleccione
“SET UP”.

Para cancelar la selección:


2 Seleccione una pestaña.

Para finalizar el procedimiento:


3 Seleccione un elemento, y luego visualice o
esta opción.

41 AJUSTES

SP_AV7100[JW]f.indb 41 5/22/08 5:18:08 PM


Inicial: Subrayado
General
Opciones del menú Configuraciones seleccionables, [página de referencia]
Radio Seleccione un área apropiado para la recepción de FM/AM (☞ “Rangos/intervalos de
frecuencias del sintonizador para cada área” en la página 50).
USA, S-Amer1, Europe, Other
ESPAÑOL

Clock (Reloj) Inicial 12:00 AM, ☞ [9]


Clock Mode (Modo Seleccione sistema de 12 horas o bien sistema de 24 horas.
reloj) 12Hr, 24Hr
TFT Auto Open On: El panel del monitor sale automáticamente al encender la unidad.
(Apertura autom.TFT) Off: El panel del monitor no saldrá hasta que usted pulse OPEN/CLOSE.
Version (Versión) Se muestra la versión de software de esta unidad.

Language (Idioma)
Opciones del menú Configuraciones seleccionables, [página de referencia]
Language (Idioma) Seleccione el idioma para las indicaciones mostradas en el monitor.
English, French, Spanish, Chinese, Korean, Russian
DVD menu (Menú Selecciona el idioma inicial del menú de disco.
DVD) English, French, Spanish, Chinese, Korean, Russian
Subtitle (Subtítulo) Seleccione el idioma de subtítulos inicial.
English, French, Spanish, Chinese, Korean, Russian, Auto, Off
Audio Selecciona el idioma de audio inicial.
English, French, Spanish, Chinese, Korean, Russian

42

SP_AV7100[JW]f.indb 42 5/22/08 5:18:09 PM


Inicial: Subrayado
Audio
Opciones del menú Configuraciones seleccionables, [página de referencia]
DownMix (Mezc. a 2)* 1
Activa o desactiva Surround, ☞ [29]
FULL 6CH: Selecciónelo para reproducir el sonido Surround multicanal.
DownMix: Selecciónelo para mezclar las señales multicanal para generarlas como
señales de 2 canales.

ESPAÑOL
Front Speakers (Altv/ Puede ajustar el tamaño de los altavoces.
delanteros)*2, • Front speakers: Large, Small
Center Speaker (Altv/ • Center Speaker: Large, Small, None
central)*2, • Sur Speakers: Large, Small, None
Sur Speakers (Altv/ • Subwoofer: None, Present
surround)*2, • Speaker size: “Large” para 13 cm de diámetro o más; “Small” para 13 cm o menos.
Subwoofer*2 • Si selecciona “Large” o “Small” para altavoces no conectados, las señales entrantes
para los altavoces no conectados no serán emitidas por los demás altavoces.
• Para los altavoces delanteros y Surround: No es posible realizar separadamente el
ajuste izquierdo y derecho.
Test tones (Ruido Seleccione un altavoz para que se emita el tono de prueba.
Rosa) Off, Left, Right, Center*2, Left surr.*2, Right surr.*2, Subwoofer*2
• Para desactivar el tono de prueba, seleccione “Off”.
Center delay (Retr/ Puede ajustar la sincronización de salida del altavoz central y los altavoces Surround.
ctral.), Surr. delay Seleccione la distancia de los altavoces desde la posición de escucha.
(Retr/surround) • Center delay: No Delay, 0.3m, 0.6m, 1m, 1.4m, 1.7m
• Surr. delay: No Delay, 1m, 2m, 3m, 4m, 5.1m
Night Mode (Modo Podrá disfrutar de un sonido potente a bajos niveles de volumen mientras se
nocturno) reproduce un software Dolby Digital.
Off: Selecciónelo para desactivar esta función.
On: Selecciónelo para aplicar el efecto al software codificado multicanal.
Pro Logic Activa o desactiva el modo Pro Logic II (Pro Logic, PLII Matrix, PLII Movie, PLII Music),
☞ [30]
Off, On, Auto
Down sampling Normalmente seleccione “Off”. Si el sonido está distorsionado, seleccione “On”.
(Submuestreo)
Decode Mode (Modo Seleccione el modo Pro Logic II que desea, ☞ [30]
decodif.)*3 Off, Pro Logic, PLII Matrix, PLII Movie, PLII Music

*1 Este ajuste sólo tiene efecto para los discos con codificación multicanal Dolby Digital.
*2 No está disponible cuando “DownMix” está ajustado a “DownMix”.
*3 Disponible solamente para una fuente de 2 canales de disco, excepto para discos DivX/MPEG1/MPEG2.

Continúa en la página siguiente


43 AJUSTES

SP39-45_KD-AV7100[JW]f.indd 43 7/3/08 5:54:51 PM


Inicial: Subrayado
Audio (continúa)
Opciones del menú Configuraciones seleccionables, [página de referencia]
Panorama Activa o desactiva el efecto de sonido envolvente (Panorama).
Off, On
Dim Ctrl Ajuste el patrón de localización del sonido (0 a 6). Conforme aumenta el número, la
ESPAÑOL

(Ctrl/atenuac.) localización del sonido se mueve hacia adelante (normalmente seleccione “3”).
0 a 6; Inicial 3
C W Ctrl Ajuste la imagen central de manera que pueda escucharse sólo del altavoz central,
(Ctrl/anch/ctral.) sólo por los altavoces delanteros izquierdo/derecho como una imagen “fantasma”, o
de diversas combinaciones de estos altavoces. Conforme aumenta el número, el efecto
“fantasma” se intensifica (normalmente seleccione “3”).
0 a 6; Inicial 3

ASP
Opciones del menú Configuraciones seleccionables, [página de referencia]
Bass Freq (Frec/bajos) Seleccione la frecuencia para el ajuste de los sonidos graves.
60Hz, 80Hz, 100Hz, 200Hz
Treble Freq (Frec/ Seleccione la frecuencia para el ajuste de los sonidos agudos.
agudos) 10kHz, 12.5kHz, 15kHz, 17kHz
Bass Q-Factor (Factor Ajusta la pendiente de calidad (Q-slope) para los sonidos graves.
Q/graves) 1.0, 1.25, 1.5, 2.0
iPod Gain, AuxIn Gain, Ajusta y almacena el nivel de volumen de ajuste automático para cada fuente. El nivel
DVD Gain*1*2, Tuner de volumen aumenta o disminuye automáticamente al cambiar la fuente.
Gain –7 a +7; Inicial 0

44

SP39-45_KD-AV7100[JW]f.indd 44 7/14/08 3:22:13 PM


Inicial: Subrayado
MISC
Opciones del menú Configuraciones seleccionables, [página de referencia]
TS Calibrate (Calibrac. Corrija la precisión del panel táctil (consulte “Calibración” debajo).
TS) No, Yes
Set Password (Config. Introduzca la contraseña (4 dígitos), ☞ [25]

ESPAÑOL
Contraseña)*3
Parental control Seleccione el nivel de restricción para la reproducción de DVD Vídeo. ☞ [25]
Kid Safe (más restrictivo), G, PG, PG-13, PG-R, R, NC-17, Adult (menos restrictivo)
Aspect Ratio (Nitidez Seleccione la relación de aspecto de la imagen.
de TV) 4:3, 16:9
Screen saver (Protec. Activa/desactiva el salvapantalla.
pantalla) Off, On
Load Factory (Cargar Seleccione “Yes” para reinicializar la unidad.
fábrica)*4 No, Yes
• Cuando selecciona “Yes”, aparece el menú de confirmación. Seleccione “Yes”. La
unidad se apaga, y se vuelve a encender.
DivX Registration Esta unidad dispone de su propio código de registro. Una vez que se reproduzca un
(Registro de DivX) archivo que tenga grabado el código de registro, el código de registro de esta unidad
será sobrescrito para protección de los derechos de autor.

Calibración A D
Tras seleccionar “Yes” para “TS Calibrate”, la guía de calibración aparecerá
en el monitor, tal como se describe a la derecha.
Toque “ ” que aparece en cada esquina (A – D), uno tras otro. Please press point A at upper left corner
• Toque “ “ lentamente y con cuidado. Toque repetidamente “ “ hasta
que aparezca la siguiente marca cuando no aparece mediante un solo
toque.
• Cuando la unidad detecta que usted ha tocado correctamente todas las B C
partes “ “, se cierra la pantalla de calibración.

*1 No es posible cambiar el ajuste “DVD Gain” cuando “DownMix” esté ajustado a “FULL 6CH”. (☞ página 43)
*2 El ajuste para “DVD Gain” también se aplica a SD y USB.
*3 Recuerde su contraseña o apúntela en algún sitio. Necesitará introducir la contraseña para cambiar el ajuste o
cancelar la restricción.
*4 Los ajustes para el reloj (“Clock”) y el control paterno (“Set Password” y “Parental control”) no se inicializan.

45 AJUSTES

SP39-45_KD-AV7100[JW]f.indd 45 7/18/08 9:16:19 AM


Mantenimiento
Limpieza del monitor Cómo manejar los discos
Si el monitor está sucio, límpielo utilizando el paño Cuando saque un disco de su Sujetador central
limpiador suministrado. estuche, presione el sujetador
central del estuche y extraiga el
disco hacia arriba, agarrándolo
ESPAÑOL

por los bordes.


• Siempre sujete el disco por
sus bordes. No toque la superficie de grabación.
Cuando guarde un disco en su estuche, insértelo
suavemente alrededor del sujetador central (con la
superficie impresa hacia arriba).
• Asegúrese de guardar los discos en sus estuches
después del uso.

Para mantener los discos limpios


Precaución:
Un disco sucio podría no
No utilice solventes (como, por ejemplo, diluyente, reproducirse correctamente.
bencina, etc.), detergentes o insecticidas. Podrían Si se llegara a ensuciar un disco,
dañar el monitor o la unidad. límpielo con un lienzo suave, en
línea recta desde el centro hacia
el borde.
Cómo limpiar el conector • No utilice ningún tipo de solvente (por ejemplo,
Un desmontaje frecuente producirá el deterioro de los limpiador de discos convencional, pulverizadores,
conectores. diluyente, bencina, etc.) para limpiar los discos.
Para reducir esta posibilidad al mínimo, limpie
periódicamente los conectores con un palillo de Para reproducir discos nuevos
algodón, teniendo cuidado de no dañar los conectores. Los discos nuevos podrían
Conectoress presentar ciertas irregularidades
en sus bordes interior y exterior.
Si intenta utilizar un disco en tales
condiciones, el receptor podría
rechazar el disco.
Elimine las irregularidades raspando los bordes con un
lápiz o bolígrafo, etc.
No utilice los siguientes discos:
CD simple— Disco alabeado
Condensación de humedad disco de 8 cm
Podría condensarse humedad en el lente del interior de Pegatinas Rótulo
la unidad, en los siguientes casos: y restos de autoadhesivo
• Después de encender el calefactor del automóvil. pegatina
• Si hay mucha humedad en el habitáculo. Forma irregular C-thru Disc (disco
Si se produce condensación, la unidad podría no semitransparente)
funcionar correctamente. En este caso, saque el disco y
deje el receptor encendido durante algunas horas hasta Partes transparente o semitransparentes
en el área de grabación
que se evapore la humedad.
46

SP46-50_KD-AV7100[JW]f.indd 46 7/4/08 10:54:03 AM


Más sobre este receptor
Operaciones básicas Reproducción de discos grabables/
Apagado de la unidad reescribibles
• Si apaga la unidad mientras está reproduciendo un • Esta unidad puede reconocer un total de 1 500
disco, dispositivo USB o tarjeta SD, la reproducción archivos y 200 carpetas (un máximo de 1 500 archivos
por carpeta).

ESPAÑOL
se iniciará automáticamente la próxima vez que
• Utilice sólo discos “finalizados”.
encienda la unidad.
• Este receptor puede reproducir discos multisesión;
FM/AM no obstante, las sesiones no cerradas serán omitidas
durante la reproducción.
Cómo almacenar emisoras en la memoria • Esta unidad puede reconocer un total de 24 caracteres
• Al finalizar la búsqueda automática, las emisoras para los nombres de archivos/carpetas.
recibidas se preajustan en “P-01” (frecuencia más • Es posible que algunos discos o archivos no se puedan
baja) a “P-06” (frecuencia más alta). reproducir debido a sus propias características o
condiciones de grabación.
Disco
Restricción de la reproducción
General • Si introduce una contraseña incorrecta, aparece
• En este manual, las palabras “pista” y “archivo” se “Password Error”. Ingrese la contraseña correcta.
utilizan indistintamente.
• La unidad puede reproducir un disco en el que se han Cómo disfrutar de sonidos Surround
grabado diferentes tipos de archivos. Los archivos se • La reproducción surround sólo se encuentra
reproducen en el orden en el cual fueron grabados. disponible para “DISC”.
• La unidad puede reproducir un disco que contenga • No podrá activar Surround para DVD Vídeo MPEG
archivos CD (CD-DA) y archivos de audio/vídeo. multicanal, y fuentes DivX de 2 canales y MPEG
• Cuando se inserta un disco al revés o un disco que de 2 canales. Los sonidos estéreo se emiten
no tenga archivos reproducibles, aparecerá “Please solamente a través de los altavoces delanteros,
Eject” en el monitor. Saque el disco. independientemente del ajuste Surround
(“DownMix” y “Pro Logic”).
• Si no saca el disco expulsado en el lapso de 10
segundos, será reinsertado automáticamente en la Reproducción de archivo
ranura de carga para protegerlo contra el polvo.
Reproducción de archivos DivX
• Esta unidad puede reproducir archivos DivX con el
código de extensión <.divx>, <.div>, <.avi> (sin
distinción de caja—mayúsculas/minúsculas).
• “Audio stream” debe cumplir con MP3 o Dolby
Digital.
• Puede suceder que el archivo codificado en el modo
de escaneo entrelazado no se pueda reproducir
correctamente.
• La máxima velocidad de bit para las señales de vídeo
es 4 Mbps (promedio).

47 REFERENCIAS

SP46-50_KD-AV7100[JW]f.indd 47 7/3/08 5:55:32 PM


Reproduciendo archivos MPEG1/MPEG2 • Esta unidad peude mostrar etiqueta ID3 Versión
• Esta unidad puede reproducir archivos MPEG1/MPEG2 1.0/1.1/2.2/2.3/2.4 (para MP3).
con el código de extensión <.mpg> o <.mpeg>. • Esta unidad también puede mostrar la etiqueta WMA.
• El formato de flujo debe cumplir con el flujo de • Este receptor puede reproducir archivos grabados en
sistema/programa MPEG. VBR (velocidad variable de bits).
El formato de archivo debe ser MP@ML (Main Profile • Los archivos grabados en VBR presentan una
en Main Level)/SP@ML (Simple Profile en Main discrepancia en la indicación del tiempo transcurrido.
Level)/MP@LL (Main Profile en Low Level). • Este receptor no puede reproducir los siguientes
ESPAÑOL

• “Audio streams” (flujos de audio) deben cumplir con archivos:


MPEG1 Audio Layer-2 o Dolby Digital. – Archivos MP3 codificados con formato MP3i y
• La máxima velocidad de bit para las señales de vídeo MP3 PRO.
es 4 Mbps (promedio). – Archivos MP3 codificados con Layer 1/2.
– Archivos WMA codificados con formatos sin
Reproducción de archivos JPEG pérdida, profesional, y de voz.
• Esta unidad puede reproducir archivos JPEG con el – Archivos WMA no basados en Windows Media®
código de extensión <.jpg> o <.jpeg>. Audio.
• Se recomienda grabar un archivo a una resolución de – Archivos formateados WMA protegidos contra
720 x 576. copia por DRM.
• Esta unidad sólo puede reproducir archivos JPEG de – Archivos que disponen de datos tales como AIFF,
línea base. No se pueden reproducir archivos JPEG ATRAC3, etc.
progresivos ni archivos JPEG sin pérdida.
• Cuando gire una imagen en 90° ó 270°, la imagen se
SD
reduce verticalmente para que quepa en la pantalla. • Cuando la tarjeta SD no tiene archivos reproducibles,
• Puede ver un máximo de 9 imágenes en miniatura. o que no han sido formateados correctamente,
Si la carpeta incluye más de 9 imágenes, la imagen aparece “Bad card” en el monitor. En tal caso, el
actual y las 8 siguientes se visualizan como vistas en reemplazo o el reformateo de la tarjeta SD podría
miniatura. resolver el problema. (Todos los datos de la tarjeta SD
se borran al volverla a formatear. Antes de proceder,
Reproducción de archivos MP3/WMA asegúrese de respaldar los datos).
• No extraiga ni instale la tarjeta SD mientras se
• Esta unidad puede reproducir archivos con el código
visualiza “Reading...” en el monitor.
de extensión <.mp3> o <.wma> (sin distinción de
• Esta unidad puede reconocer un total de 1 500
caja—mayúsculas/minúsculas).
archivos y 200 carpetas (un máximo de 1 500 archivos
• Este receptor puede reproducir archivos que cumplan
por carpeta).
con las siguientes condiciones:
• Esta unidad puede reconocer un total de 14 caracteres
– Velocidad de bit: 32 kbps — 320 kbps
para los nombres de archivos/carpetas.
– Frecuencia de muestreo:
• Debido a las características de algunas tarjetas SD o
48 kHz, 44,1 kHz, 32 kHz (para MPEG1)
archivos o de las condiciones de grabación, puede
24 kHz, 22,05 kHz, 16 kHz (para MPEG2)
suceder que esta unidad no pueda reproducirlas.
48 kHz, 44,1 kHz, 32 kHz, 22,05 kHz (para WMA)
• Debido a las características de algunos archivos o de
las condiciones de grabación, puede suceder que esta
unidad no pueda reproducirlos.

48

SP46-50_KD-AV7100[JW]f.indd 48 7/14/08 3:25:04 PM


USB iPod
• Cuando el dispositivo USB no tiene archivos • iPod controlable:
reproducibles, o que no han sido formateados – iPod (rueda de clic)
correctamente, aparece un mensaje de error en el – iPod mini
monitor. En tal caso, el reemplazo o el reformateo del – iPod photo
dispositivo podría resolver el problema. (Todos los datos – iPod nano
del dispositivo USB se borran al volverlo a formatear. – iPod con Vídeo

ESPAÑOL
Antes de proceder, asegúrese de respaldar los datos). • Si el iPod no puede reproducir correctamente, sírvase
• La unidad no puede reconocer ningún dispositivo USB actualizar el software de su iPod a la versión más
que tenga un régimen distinto de 5 V y que exceda de reciente. Si desea información sobre cómo actualizar
500 mA. su iPod, visite <http://www.apple.com>.
• Mientras se reproduce desde un dispositivo USB, el • Al encender esta unidad, el iPod se carga a través de
orden de reproducción puede ser diferente de otros la unidad.
reproductores. • Puede controlar el iPod desde la unidad cuando en la
• Puede suceder que esta unidad no pueda reproducir pantalla del iPod aparezca “JVC” o “ ” después de la
algunos dispositivos USB o algunos archivos debido a conexión.
sus características o a las condiciones de grabación. • El orden de las canciones mostrado en el monitor de
• Los dispositivos USB equipados con funciones la unidad puede diferir del que se encuentra en el
especiales, como por ejemplo, funciones de seguridad iPod.
de datos, no se pueden usar con esta unidad. • La información de texto podría no visualizarse
• No utilice un dispositivo USB con 2 o más particiones. correctamente:
• Dependiendo la forma de los dispositivos USB y de los – Las letras con acento y ciertos caracteres no se
puertos de conexión, puede suceder que algunos de pueden visualizar correctamente en el monitor.
ellos no puedan conectarse correctamente o que haya – La comunicación entre el iPod y la unidad no es
flojedad en la conexión. estable.
• Cuando conecte un dispositivo USB, consulte también • Esta unidad puede reconocer hasta un total de 20
sus correspondientes instrucciones. caracteres.
• Conecte a la unidad un solo dispositivo por vez. No
utilice un hub USB. Nota:
• Puede suceder que esta unidad no pueda reconocer Cuando opera un iPod, algunas operaciones pueden
un dispositivo USB conectado a través de un lector de no funcionar correctamente o como se desea. En tal
tarjetas USB. caso, visite el siguiente sitio web de JVC: <http://
• Puede suceder que esta unidad no pueda reproducir www.jvc-victor.co.jp/english/car/>
correctamente archivos en un dispositivo USB cuando
se utilice un cable prolongador USB.
• Esta unidad no puede asegurar un correcto
funcionamiento o suministro de alimentación a todos
los tipos de dispositivos.
• Esta unidad puede reconocer un total de 1 500
archivos y 200 carpetas (un máximo de 1 500 archivos
por carpeta).
• Esta unidad puede reconocer un total de 14 caracteres
para los nombres de archivos/carpetas.
• Para archivos MPEG1/2: La máxima velocidad de bit
para las señales de vídeo es 2 Mbps (promedio).
49 REFERENCIAS

SP46-50_KD-AV7100[JW]f.indd 49 7/14/08 3:25:05 PM


Sonidos emitidos a través de los Valores de preajuste de graves/
terminales traseros agudos
• Para señales multicanal: Modo de sonido Graves Agudos
– Las señales multicanal se emiten cuando Flat 0 0
“DownMix” está ajustado a “FULL 6CH”. (Los Jazz 6 4
terminales AV OUT emiten la misma señal que los Pop 4 6
terminales FRONT.) Classical 4 4
ESPAÑOL

– Las señales multicanal se mezclan cuando Rock 6 6


“DownMix” está ajustado a “DownMix”. News –2 –2
• Para señales de 2 canales: Urban 4 5
Se emite la señal de 2 canales. Rave 5 6
Movie 3 –2
• El sonido DTS no se puede reproducir. Techno 5 3
• No sale sonido de los altavoces desactivados. User 0 0

Rangos/intervalos de frecuencias del


• “DVD Logo” es una marca comercial de DVD
sintonizador para cada área Format/Logo Licensing Corporation registrado en
Área los EE.UU., Japón y otros países.
Rangos/intervalos de frecuencias
seleccionada • “Producto con certificación DivX™ Certified
FM 87,5 MHz – 107,9 MHz/200 kHz oficial” “DivX, DivX Certified, y los logotipos
USA
AM 530 kHz – 1 710 kHz/10 kHz asociados son marcas comerciales de DivX, Inc., y
FM 87,5 MHz – 107,9 MHz/100 kHz deben utilizarse en virtud de una licencia”.
S-Amer1
AM 530 kHz – 1 710 kHz/10 kHz • Microsoft y Windows Media son marcas
FM 87,50 MHz – 108,00 MHz/50 kHz registradas o bien marcas comerciales de
Europe
AM 522 kHz – 1 620 kHz/9 kHz Microsoft Corporation en los Estados Unidos y/u
FM 87,50 MHz – 108,00 MHz/50 kHz otros países.
Other
AM 531 kHz – 1 602 kHz/9 kHz • iPod es una marca comercial de Apple Inc.,
registrada en los EE.UU. y otros países.
• Este producto incorpora tecnología de protección
de los derechos de autor que está protegida por
patentes de EE.UU. y otros derechos de propiedad
intelectual. La utilización de esta tecnología de
protección de los derechos de autor debe ser
autorizada por Macrovision y está destinada
únicamente para uso doméstico y otras formas
limitadas de visionado, a menos que Macrovision
lo autorice expresamente. Está prohibida la
ingeniería inversa o desmontaje del aparato.

50

SP_AV7100[JW]f.indb 50 5/22/08 5:18:17 PM


Localización de averías
Lo que aparenta ser una avería podría resolverse fácilmente. Verifique los siguientes puntos antes de llamar al centro
de servicio.
• En cuanto a las operaciones con los componentes externos, consulte asimismo las instrucciones suministradas
con los adaptadores utilizados para las conexiones (así como las instrucciones suministradas con los componentes
externos).

ESPAÑOL
Síntomas Soluciones/Causas
• El sonido no sale del altavoz central. • El altavoz central no está activado. (☞ página 43)
• El altavoz central se utiliza sólo para la reproducción
Surround. El sonido no sale para la reproducción en
estéreo.
• No sale sonido de los altavoces traseros y del Los altavoces traseros y el subwoofer no están activados.
subwoofer. (☞ página 43)
• El monitor no está claro ni legible. Este síntoma puede ser causado por los reflejos de la luz del
General

sol en el parabrisas.
Ajuste el brillo del monitor. (☞ página 11)
• Aparece “SD Loading Error” en el monitor. La tarjeta SD no está completamente insertada. Insértela
completamente en la ranura para cerrar la puerta.
• Aparece “No Signal”. • Cambia la fuente.
• Inspeccione los cables y las conexiones.
• La señal de entrada es muy débil.
• El receptor no funciona en absoluto. Reinicialice la unidad. (☞ página 3)
• El AS (Almacenamiento automático) no Almacene manualmente las emisoras. (☞ página 13)
FM/AM

funciona.
• Ruidos estáticos mientras se escucha la radio. Conecte firmemente la antena.
• Los discos no se pueden reconocer ni Cambie el disco.
reproducir.
• No se pueden reproducir los discos grabables/ • Inserte un disco finalizado.
reescribibles. • Finalice los discos con el componente utilizado por usted
• No se pueden saltar las pistas de los discos para la grabación.
grabables/reescribibles.
Discos en general

• La reproducción no se inicia. • Inserte correctamente el disco otra vez.


• El formato de los archivos no es compatible con la
unidad.
• La reproducción de DVD Video no se inicia. La reproducción está restringida. Cancele la restricción.
(☞ página 25)
• La imagen reproducida no es clara ni legible. Ajuste el brillo del monitor. (☞ página 11)
• El sonido y las imágenes se interrumpen o se • Detenga la reproducción mientras conduce por caminos
distorsionan algunas veces. accidentados.
• Cambie el disco.
51 REFERENCIAS

SP_AV7100[JW]f.indb 51 5/22/08 5:18:18 PM


Síntomas Soluciones/Causas
• No aparece ninguna imagen de reproducción El cable del freno de estacionamiento no está
en el monitor. correctamente conectado.
(☞ Manual de Instalación/Conexión)
Discos en general

• No aparece la imagen en el monitor externo. • Conecte correctamente el cable de vídeo.


• Seleccione una entrada correcta en el monitor externo.
• Durante la reproducción de un disco que no sea DVD
ESPAÑOL

Video, la imagen no aparecerá en el monitor externo.


• Aparece “Eject Error” o “Loading Error” en el Reinicialice la unidad. (☞ página 3)
monitor.
• “Disc region incorrect” aparece en el monitor El código de región no es correcto. (☞ página 8)
cuando se inserta un DVD Video.
• No se puede reproducir el disco. • Cambie el disco.
• Grabe las pistas en los discos apropiados, utilizando una
DivX/MPEG1/MPEG2/JPEG/MP3/WMA

aplicación compatible. (☞ página 8)


• Añada códigos de extensión apropiados a los nombres
de archivos.
• Se generan ruidos. La pista reproducida no es un formato de archivo
reproducible. Salte a otro archivo.
• Las pistas no se reproducen de la manera El orden de reproducción puede ser diferente del orden
intentada por usted. empleado con otros reproductores.
• El tiempo de reproducción transcurrido no Esto sucede a veces durante la reproducción. Esto depende
escorrecto. de cómo fueron grabadas las pistas en el disco.
• Aparece “Not Supported file” en el monitor y La pista no se puede reproducir.
se omiten las pistas.
• Se generan ruidos. La pista reproducida no es un formato de archivo
reproducible. Salte a otro archivo.
• Las pistas no se reproducen de la manera El orden de reproducción puede ser diferente del orden
intentada por usted. empleado con otros reproductores.
• “Reading...” permanece visualizado en el • El tiempo de lectura varía según la tarjeta SD/dispositivo
monitor. USB.
• No utilice demasiadas jerarquías y carpetas.
SD/USB

• Apague la unidad y vuélvala a encender.


• Parpadea “No USB Device” en el monitor. • No hay un dispositivo USB conectado.
• El dispositivo USB no está conectado firmemente.
• No se visualizan los caracteres correctos (por Algunos caracteres no se encuentran disponibles en esta
ej.: nombre del álbum). unidad.
• El sonido se interrumpe algunas veces Las pistas no han sido copiadas correctamente en la tarjeta
mientras se reproduce una pista. SD/dispositivo USB. Copia otra vez las pistas, e intente de
nuevo.

52

SP_AV7100[JW]f.indb 52 5/22/08 5:18:19 PM


Síntomas Soluciones/Causas
• El iPod no se enciende o no funciona. • Verifique el cable de conexión y su conexión.
• Actualice la versión de firmware.
• Cargue la pila.
• El sonido está distorsionado. Desactive el ecualizador en esta unidad o en el iPod.
• La reproducción se detiene. Los auriculares están desconectados durante la

ESPAÑOL
reproducción. Desconecte la alimentación y vuélvala a
conectar.
iPod

• No se escucha ningún sonido al conectar un • Desconecte los auriculares del iPod nano.
iPod nano. • Actualice la versión de firmware del iPod nano.
• Aparece “No Files” en el monitor. No hay pistas almacenadas. Importe pistas al iPod.
• Los controles del iPod no funcionarán Reinicialice el iPod.
después de desconectarlo de esta unidad.
• Aparecerá “Cannot play” en el monitor. Ha ocurrido un error de comunicación. Desconecte y vuelva
a conectar el cable al iPod.
• Aparece “NO VIDEO SIGNAL” en el monitor. • Encienda el componente de vídeo, si no está encendido.
• Conecte correctamente el componente de vídeo.
AV-IN

• La imagen reproducida no es clara ni legible. Ajuste el brillo del monitor. (☞ página 11)
• El sonido no se escucha. Verifique el cable de conexión y su conexión.

53 REFERENCIAS

SP_AV7100[JW]f.indb 53 5/22/08 5:18:19 PM


Especificaciones
Máxima potencia de salida: Delantera/Trasera: 50 W por canal
Potencia de salida continua Delantera/Trasera: 20 W por canal en 4 Ω, 40 Hz a 20 000
(RMS): Hz con una distorsión armónica total no
mayor que 0,8%
Impedancia de carga: 4 Ω (tolerancia de 4 Ω a 8 Ω)
ESPAÑOL

Gama de control de tono: Graves: ±14 dB (60 Hz, 80 Hz, 100 Hz, 200 Hz)
Agudos: ±14 dB (10 kHz, 12,5 kHz, 15 kHz,
17 kHz)
AMPLIFICADOR

Q (Q-slope, pendiente de calidad): Q1,0, Q1,25, Q1,5, Q2,0


Relación señal a ruido: 70 dB
Nivel de Salida de Audio Nivel/impedancia salida línea: 4,0 V/20 kΩ de carga (plena escala)
FRONT/REAR/CENTER/SUB Impedancia de salida: 1 kΩ
WOOFER:
Sistema de Color: NTSC
Salida de Vídeo (compuesto): 1 Vp-p/75 Ω
Otros terminales: Entrada: AV IN, CAMERA, toma de entrada AUX,
terminal de entrada de USB, entrada
de antena
Salida: AV OUT
Otros: iPod, OE REMOTE*
Gama de frecuencias: ☞ “Rangos/intervalos de frecuencias del sintonizador para cada área” en la
página 50
SINTONIZADOR FM/AM

Sintonizador de FM Sensibilidad útil: 11,3 dBf (1,0 μV/75 Ω)


50 dB sensibilidad de silenciamiento: 16,3 dBf (1,8 μV/75 Ω)
Selectividad de canal alternativo 65 dB
(400 kHz):
Respuesta de frecuencias: 40 Hz a 15 000 Hz
Separación estereofónica: 35 dB
Sintonizador de AM Sensibilidad/Selectividad: 20 μV/35 dB
Sistema de detección de señal: Captor óptico sin contacto (láser semiconductor)
Respuesta de frecuencias: DVD, fs=48 kHz: 16 Hz a 22 000 Hz
VCD/CD: 16 Hz a 20 000 Hz
DVD/CD

Gama dinámica: 93 dB
Relación señal a ruido: 95 dB
Lloro y trémolo: Inferior al límite medible

* No utilizado para esta unidad.

54

SP50-55_KD-AV7100[JW]f.indd 54 7/3/08 5:56:05 PM


Sistema de archivo FAT 32
compatible:
SD

Capacidad 2 Gbytes
Velocidad de transferencia Máximo 10 Mbps
de datos
Normas USB: USB 1.1
Velocidad de transferencia Toda velocidad: Máximo 12 Mbytes

ESPAÑOL
de datos Baja velocidad: Máximo 1,5 Mbytes
USB

Dispositivo compatible: Clase de almacenamiento masivo


Sistema de archivo FAT 32/16/12
compatible:
Corriente máx.: Menos de 500 mA/5 V
Tamaño de la pantalla: Pantalla de cristal líquido de 7 pulg. de ancho
Número de píxeles: 336 960 pixeles: 480 x 3 (horizontal) × 234 (vertical)
MONITOR

Método de mando: Formato de matriz activa TFT (Transistor de película delgada)


Sistema de Color: NTSC
Relación de aspecto: 16:9 (ancha)
Requisitos de potencia: Voltaje de funcionamiento: 14,4 V CC (tolerancia de 11 V a 16 V)
Sistema de puesta a tierra: Negativo a masa
Temperatura de almacenamiento admisible: –10°C a +60°C
Temperatura de funcionamiento admisible: 0°C a +50°C
GENERAL

Dimensiones (An × Al × Pr): Tamaño de instalación (aprox.): 182 mm × 53 mm × 159 mm


• Con la placa Tamaño del panel (aprox.): 188 mm × 58 mm × 13 mm
embellecedora y la funda Tamaño del panel desmontable 134 mm × 22 mm × 19 mm
instaladas (aprox.):
Peso (aprox.): 2,5 kg (incluyendo embellecedores y fundas)

Espacio requerido para la expulsión del monitor


136

PRECAUCIÓN: Cuando se expulsa el monitor, asegúrese 33


de tener espacio libre suficiente para poder sacarlo. De lo 2,5
contrario, el monitor podría obstaculizar la maniobra del
volante de dirección y las operaciones del cambio de
engranajes, con el consiguiente riesgo de accidentes de tráfico.
110˚
167
50˚

43
Unidad: mm 44

El diseño y las especificaciones se encuentran sujetos a cambios sin previo aviso.

55 REFERENCIAS

SP_AV7100[JW]f.indb 55 5/22/08 5:18:21 PM


Having TROUBLE with operation?
Please reset your unit
Refer to page of How to reset your unit

¿Tiene PROBLEMAS con la operación?


Por favor reinicialice su unidad
Consulte la página de Cómo reposicionar su unidad

EN, SP
© 2008 Victor Company of Japan, Limited 0508MNMMDWSKP

Rear_LVT1822-003A.indd 2 08.5.20 8:14:16 AM


Instructions DVD RECEIVER WITH MONITOR KD-AV7100

Вам также может понравиться