Академический Документы
Профессиональный Документы
Культура Документы
MAINTENANCE MANUAL
EFFECTIVITY: ALL
1. General
A. This task gives the procedure to do the visual inspection of the high-stage bleed-valve filter.
B. The high-stage bleed-valves are installed in the LH and RH bleed ducting on the outboard side of
the engines.
TASK 36-11-01-210-801-A
EFFECTIVITY: ALL
(1) This task gives the procedure to do the visual inspection of the high-stage bleed-valve filter.
B. References
REFERENCE DESIGNATION
C. Job Set-Up
WARNING: MAKE SURE THAT THE AIRCRAFT IS IN A SAFE CONDITION BEFORE YOU DO THE
MAINTENANCE PROCEDURES. THIS IS TO PREVENT INJURY TO PERSONS AND/
OR DAMAGE TO THE EQUIPMENT.
WARNING: DO NOT TOUCH THE DUCTS OR COMPONENTS OF THE AIR BLEED SYSTEM
IMMEDIATELY AFTER THE SYSTEM STOPS ITS OPERATION. THE HIGH AIR
TEMPERATURE CAN CAUSE INJURY TO PERSONS.
(2) Do the procedure to make the aircraft safe for maintenance of the powerplant (AMM
TASK 71-00-00-910-801-A/200 ).
SUBTASK 020-001-A
(3) Remove the high-stage bleed-valve filter (AMM TASK 36-11-01-000-802-A/400 ).
(2) Do a check of the internal passages to be sure that they are clean and not blocked.
NOTE: Do the cleaning procedure of the high-stage bleed-valve filter (AMM TASK
36-11-01-130-801-A/700 ) if the filter is dirty and/or blocked.
(3) Do a check of the threads for rough edges and defects. Make sure that the threaded
fits are satisfactory.
(4) If the filter is not in good conditions, you must replace it (AMM TASK
36-11-01-000-802-A/400 /AMM TASK 36-11-01-400-802-A/400 ).
E. Job Close-Up
SUBTASK 420-001-A
(1) Install the high-stage bleed-valve filter (AMM TASK 36-11-01-400-802-A/400 ).
EFFECTIVITY: ALL
High-Stage Bleed-Valve Filter - Component Location
Figure 601
PACKING
FILTER
SERVO LINE
LOCKWIRE HPRSOV
EM170MPP360146A.DGN