Академический Документы
Профессиональный Документы
Культура Документы
MISMO
Juan Rojas-Delgado, Andrés Verdugo-Ochoa, Astrid Zaruma-Mora
UNIVERSIDAD DEL AZUAY
ABSTRAC
The current project describes the design, construction and testing of the thermal performance of a
solar collector in the form of a hermetically sealed rectangle for heating water or other liquids for
domestic use. (Pless, 2009) The absorbent plate was constructed from an accessible material (glass)
that is located on the upper face of the collector with measures of (23cmx33cm), the side walls
including the base are made of plywood; two (20cmx33cm), two (20cmx33cm) and base
(23cmx33cm) whose interior faces are lined with aluminum foil which, by means of solar radiation,
transmits the heat to the surface of the collector, absorbing it and storing it inside for its respective
heating. Measurements of temperature that was carried out 50 times with 2 glasses of different
structural materials (glass - aluminum) giving us different values in each one of the data takings, by
means of the use of digital thermometers that determine the initial and final temperature of the water
in the glass in a time of 2.5 hours. The temperature of the water taken and obtained at the end of the
day averaged between a range of 36.3 ° C to 41.3 ° C with both vessels. Then we took the glass with
the most water heated and we timed the time in which the water temperature initially increases 7 ° C,
this process is done 15 times. This design of solar water heater is well adapted, taking advantage of
the high intensity of the solar radiation, sealed preventing the escape of heat being this rectangular; It
is also easily billable hand, at low cost, starting from simple materials.
PROMEDIO
19
TEMPERATURA °C
18.506
18.5
17.98
18
17.5
1
ALUMINIO VIDRIO
91
84 Varianza, 80.6577
77
TEMPERATURA °C
70
63
56
49
42
35 Media, 18.506 Desviación Estándar,
28 Moda, 13 8.98096
21 Mediana, 19.25
14
7
0
0 1 2 3 4 5 6
Tabla.3. Indicadores estadísticos del vaso de aluminio.
98
91 Varianza, 91.4869
84
77
TEMPERATURA °C
70
63
56
49 Desviación Estándar,
42 9.56488
35
28 Media, 17.98
21 Mediana, 17.85
14
7
0
0 0.5 1 1.5 2 2.5 3 3.5 4 4.5
DISCUSIÓN Y CONCLUSIÓN
Los resultados experimentales discutidos concluir de acuerdo a los datos tomados en
señalan algunos descensos en la temperatura, diferentes ciudades, dependiendo las altitudes
de los datos por lo tanto estos toman valores de cada uno de estos puntos: Cuenca que se
negativos. La temperatura del vaso de vidrio encuentra a una elevación aproximada de
durante el periodo de insolación calienta más 2583m.s.n.m (Garcés, 2013),Cañar con una
el agua que contiene, con respecto al vaso de altitud aproximada de 3160 m.s.n.m (GNU,
aluminio ya que el vidrio mantiene por un 2012), Zaruma con una altitud aproximada de
periodo más prolongado el calor. Se observó 1200m.s.n.m (ACADEMIC, 2000). De
mediante el promedio estadístico que los acuerdo a los datos tomados en dichas
valores finales de ambos vasos, tienen una ciudades se comparó las diferentes
diferencia pequeña en sus niveles; por temperaturas y se observó que los datos
consiguiente, se procedió a realizar el tercer tomados varían entre si dependiendo la altitud.
experimento, en el vaso de vidrio. Se puede
MATERIAL ADJUNTO
Aplicación de toma de temperatura Ambiente