Вы находитесь на странице: 1из 182

ORDER NO.

CRT5436
AVH-X1600DVD/XNUC

DVD RDS AV RECEIVER

AVH-X1600DVD /XNUC
AVH-X1600DVD/XNEW5
AVH-X1600DVD/XNUW5
AVH-X1650DVD/XNRC
AVH-X1650DVD/XNRD
AVH-X1650DVD/XNRI
AVH-X1690DVD/XNID
This service manual should be used together with the following manual(s):

Model No. Order No. Mech.Module Remarks

CX-3283 CRT4843 LS2 DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly

PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan


PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2013
K-ZZZ SEPT. 2013 Printed in Japan
1 2 3 4

SAFETY INFORMATION

A CAUTION

This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.

WARNING

This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive
B harm.
Health & Safety Code Section 25249.6 - Proposition 65

Where in a manufacturer’s service documentation, for example in circuit diagrams or lists


of components, a symbol is used to indicate that a specific component shall be replaced only
by the component specified in that documentation for safety reasons, the following symbol shall
be used:

- Safety Precautions for those who Service this Unit.


When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable
C results.

Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.

CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.

D CAUTION
This product is a class 1 laser product classi-
fied under the Safety of laser products, IEC
60825-1:2007, and contains a class 1M laser
module. To ensure continued safety, do not re-
move any covers or attempt to gain access to
the inside of the product. Refer all servicing to
qualified personnel.

E CAUTION—CLASS 1M INVISIBLE LASER


RADIATION WHEN OPEN, DO NOT VIEW
DIRECTLY WITH OPTICAL INSTRUMENTS.

WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
F

AVH-X1600DVD/XNUC
2
1 2 3 4
5 6 7 8

A
Laser diode characteristics
Wave length:
DVD:660 nm to 670 nm
CD:780 nm to 800 nm
Focus lens on Maximum output:
CD:6.26 mW(Emitting period :9 sec.)
DVD:1.27 mW (Emitting period : unlimited)

Additional Laser Caution


B
Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD
respectively. When Q1103 or Q1104 is shorted between their terminals,
the laser diodes for DVD or CD will radiate beam. If the top cover is removed
with no disc loaded while such short-circuit is continued, the naked eyes may
be exposed to the laser beam.

CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacturer. C
Discord used batteries according to the manufacturer's instructions.

AVH-X1600DVD/XNUC
5 6 7 8
3
1 2 3 4

CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
A
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 7
2. SPECIFICATIONS ............................................................................................................................................ 8
2.1 SPECIFICATIONS ..................................................................................................................................... 8
2.2 DISC/CONTENT FORMAT ...................................................................................................................... 21
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 22
3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 22
3.2 PCB LOCATIONS .................................................................................................................................... 23
3.3 JIGS LIST ................................................................................................................................................ 24
3.4 CLEANING............................................................................................................................................... 24
4. BLOCK DIAGRAM.......................................................................................................................................... 26
4.1 OVERALL CONNECTION DIAGRAM...................................................................................................... 26
B 4.2 BLOCK DIAGRAM ................................................................................................................................... 28
5. DIAGNOSIS.................................................................................................................................................... 39
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 39
5.2 INSPECTION METHOD OF PICKUP UNIT............................................................................................. 40
5.3 DIAGNOSIS FLOWCHART ..................................................................................................................... 43
5.4 ERROR CODE LIST ................................................................................................................................ 63
5.5 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 67
5.6 EEPROM OPERATION EXPLANATION FOR iPhone 5 .......................................................................... 68
6. SERVICE MODE ............................................................................................................................................ 69
6.1 MONITOR TEST MODE .......................................................................................................................... 69
6.2 DVD TEST MODE ................................................................................................................................... 87
7. DISASSEMBLY .............................................................................................................................................. 92
C
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 96
8.1 DVD ADJUSTMENT ................................................................................................................................ 96
8.2 PCL OUTPUT CONFIRMATION............................................................................................................ 101
9. EXPLODED VIEWS AND PARTS LIST........................................................................................................ 102
9.1 PACKING ............................................................................................................................................... 102
9.2 EXTERIOR (1) ....................................................................................................................................... 106
9.3 EXTERIOR (2) ....................................................................................................................................... 108
9.4 DVD MECHANISM MODULE (1)............................................................................................................110
9.5 DVD MECHANISM MODULE (2)............................................................................................................112
10. SCHEMATIC DIAGRAM..............................................................................................................................114
10.1 MOTHER PCB (ANALOG BLOCK).......................................................................................................114
D 10.2 MOTHER PCB (SYSTEM BLOCK) (GUIDE PAGE) .............................................................................116
10.3 MOTHER PCB (SH BLOCK) (GUIDE PAGE) ...................................................................................... 122
10.4 MOTHER PCB (POWER SUPPLY BLOCK) ........................................................................................ 128
10.5 MOTHER PCB (IN/OUT BLOCK) (GUIDE PAGE)............................................................................... 130
10.6 MOTHER PCB (TUNER BLOCK) ........................................................................................................ 136
10.7 INTERFACE PCB ................................................................................................................................ 138
10.8 DVD CORE UNIT (GUIDE PAGE) ....................................................................................................... 140
10.9 SERVICE UNIT (MONITOR) (GUIDE PAGE) ...................................................................................... 146
10.10 SERVICE UNIT (KEYBOARD)........................................................................................................... 152
10.11 WAVEFORMS .................................................................................................................................... 154
11. PCB CONNECTION DIAGRAM.................................................................................................................. 156
11.1 MOTHER PCB ..................................................................................................................................... 156
E 11.2 INTERFACE PCB................................................................................................................................. 160
11.3 DVD CORE UNIT ................................................................................................................................. 162
11.4 SERVICE UNIT (MONITOR) ................................................................................................................ 164
11.5 SERVICE UNIT (KEYBOARD)............................................................................................................. 168
12. ELECTRICAL PARTS LIST ........................................................................................................................ 169

AVH-X1600DVD/XNUC
4
1 2 3 4
5 6 7 8

1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A

1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and
should keep the safety during servicing by following the safety instructions described in this manual.
2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic
induction.
3. Please be sure to conduct line process to original status if you make assembling after repair.
4. Please be careful of not to imply static charge onto integrated circuits, etc, when you conduct repair work.
Especially, please use soldering iron with its tip grounded.
Also, please use a pair of tweezers with static charge protection capability if there is the possibility of contacting to
device terminals, and avoid the use of metal-made tweezers.
5. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on B
mode may damage the ICs inside the unit.
6. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder)
by referring to "the DISASSEMBLY".
7. Please keep the distance of more than 13 cm from focus lens for safety when you check pickup and make adjustment,
and do not look straight at Laser Beam for more than 10 seconds.
8. Please power adjustment when you replaced mechanical area of DVD Mecha Module or DVD core unit.
9. Graphically-illustrated areas become hot . Be careful not to burn yourself.

Drive
IC

IC1251 Main IC

IC1501

10. On this mechanism, Pickup and Spindle Motor can not be replaced at the service site, because a special facility is
required for the adjustment after replacing them.
So, if Pickup or Spindle Motor is defective, replace the Mechanism Unit.
11. EJECT LOCK MODE for DVD mechanism
In order to change the EJECT LOCK status of the mechanism, please perform following procedure.
[FORWARD] + [EJECT] -> ACC ON
12. The part listed below is difficult to replace as a discrete component part.
When the part listed in the table is defective, replace whole Assy.
E
Mother PCB IC2101 BD9876EFJ Heat pad
Mother PCB IC2011 BD00IA5WEFJ Heat pad
Mother PCB IC1202 337S3959 Because there are few exposed portions of a terminal.

AVH-X1600DVD/XNUC
5 6 7 8
5
1 2 3 4

A 13. area and a heat sink becomes hot areas. Be careful not to burn yourself.
MOTHER PCB
C801
IC341
IC1821 C2172
L2101
C1979

IC501

B IC1302

MOTHER PCB
IC2161 IC251

IC2101

IC1051
C IC1951

IC1901
IC1911
IC1921

1F & 2F Rear Holder

LS2 DVD Mechanism Module Top Case

AVH-X1600DVD/XNUC
6
1 2 3 4
5 6 7 8

1.2 NOTES ON SOLDERING

For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.

Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.

Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
B

The following lead-free solders are available as service parts:


Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.

AVH-X1600DVD/XNUC
5 6 7 8
7
1 2 3 4

2. SPECIFICATIONS
2.1 SPECIFICATIONS
A - AVH-X1600DVD/XNUC

General DVD Player


Power source ................... 14.4 V DC (10.8 V to 15.1 V al- System ............................ DVD video, Video CD, CD,
lowable) WMA, MP3, AAC, DivX,
Grounding system ............ Negative type MPEG player
Backup current ................. 5 mA or less Usable discs .................... DVD video, Video CD, CD, CD-
Maximum current consumption R/RW, DVD-R/RW/RDL
................................... 10.0 A Region number ................ 1
Dimensions(W × H × D): Frequency response......... 5 Hz to 44 000 Hz (with DVD,
D at sampling frequency 96 kHz)
B
Chassis ............................ 178 mm × 100 mm × 165 mm Signal-to-noise ratio ......... 91 dB(1 kHz) (IHF-A network)
(7in. × 3-7/8in. × 6-1/2in.) (RCA level)
Output level:
Nose ................................ 171 mm × 97 mm × 9 mm
Video ............................... 1.0 Vp-p/75 Ω (±0.2 V)
(6-3/4in. × 3-7/8in. × 3/8in.)
Number of channels ........ 2 (stereo)
Weight ............................. 1.7 kg (3.7 lbs)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format .....Ver.7, 7.1, 8, 9, 10, 11, 12(2 ch
Display audio)
(Windows Media Player)
Screen size/aspect ratio... 6.1 inch wide/16:9
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
(effective display area:
only) (.m4a)
C 136.2 mm × 72.0 mm)
(Ver. 10.6 and earlier)
Pixels ............................... 1 152 000 (2 400 × 480)
Display method ................TFT active matrix, driving type DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6
Color system .................... NTSC/PAL/PAL-M/PAL-N/ (Except ultra and HD) (.avi,
SECAM compatible .divx)
Durable temperature range (poweroff) MPEG video decoding format
................................... –4 °F to + 176 °F ................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)

Audio USB
Maximum power output.... 50 W × 4 USB standard specification
D 70 W × 1/2 Ω (forsubwoofer) ................................... USB 1.1, USB 2.0 full speed
Continuous power output (For video files)
................................... 22W × 4 (50 Hz to 15 000 Hz, USB 2.0 high speed (For
5%THD, 4 Ω load,both chan- audio files)
nels driven) Maximum current supply
Load impedance .............. 4 Ω (4Ω to 8Ω (2Ω for 1 ch) ................................... 1.0 A
allowable) USB Class ....................... MSC (Mass Storage Class),
Preoutmaximumoutputlevel MTP (Media Transfer Protocol)
................................... 2.0 V File system....................... FAT16, FAT32
Equalizer (8-Band Graphic Equalizer): MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
E audio)
1 kHz/2.5 kHz/8 kHz/10 kHz
Gain ................................ ±12 dB (Windows Media Player)
HPF: AAC decoding format ....... MPEG-4 AAC (iTunes encoded
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ only)
125 Hz (Ver. 10.6 and earlier)
Slope ............................... –12 dB/oct WAV (MSC Mode only):
Subwoofer(mono): WAV signal format ........... Linear PCM, MS ADPCM
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ (.wav)
125 Hz Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz,
Slope ............................... –18 dB/oct 24 kHz, 32 kHz, 44.1 kHz,
Gain ................................ +6 dB to – 24 dB 48 kHz
F
Phase .............................. Normal/Reverse MS ADPCM:22.05 kHz,
Bass boost: 44.1 kHz
Gain ................................ +12 dB to 0 dB

AVH-X1600DVD/XNUC
8
1 2 3 4
5 6 7 8

JPEG (MSC Mode only):


JPEG decoding format ..... .jpeg, .jpg, .jpe
Pixel Sampling ................. 4:2:2, 4:2:0
Decode Size..................... MAX:8 192 (H) x 7 680 (W),
MIN:32 (H) x 32 (W)
DivX decodingf ormat (MSC Mode only)
................................... Home Theater Ver.3, 4, 5.2, 6
(Except ultra and HD) (.avi,
B
.divx)
MPEG video decoding format (MSC Mode only)
................................... MPEG1, MPEG2, MPEG4
(part 2), MS-MPEG4 (ver.3)

FM tuner
Frequency range .............. 87.9 MHz to 107.9 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
30 dB)
Signal-to-noise ratio ......... 72 dB (analog broadcasting) C
(IHF-A network)

AM tuner
Frequency range .............. 530 kHz to 1 710 kHz (10 kHz)
Usable sensitivity ............. 25 µV(S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (analog broadcasting)
(IHF-A network)

CEA2006 Specifications

Power output................... 14 W RMS × 4 Channels(4 Ω


and 1%THD+N)
S/N ratio.......................... 91 dBA (reference: 1 W into E

4 Ω)

Note
Specifications and the design are subject to
modifications without notice.

AVH-X1600DVD/XNUC
5 6 7 8
9
1 2 3 4

A - AVH-X1600DVD/XNEW5

General Slope................................ –18 dB/oct


Rated power source........... 14.4 V DC Gain .................................. +6 dB to – 24 dB
(allowable voltage range: Phase ............................... Normal/Reverse
10.8 V to 15.1 V DC) Bass boost:
Grounding system.............. Negative type Gain .................................. +12 dB to 0 dB
Backup current ................ 5 mA or less
Maximum current consumption DVD Player
...................................... 10.0 A System .............................. DVD video, Video CD, CD,
Dimensions (W × H × D): WMA, MP3, AAC, DivX,
B
DIN MPEG player
Chassis .............................. 178 mm × 100 mm × Usable discs ..................... DVD video, Video CD, CD,
157 mm CD-R/RW, DVD-R/RW/RDL
Nose ...................................188 mm × 118 mm × Region number ................. 2
17 mm Frequency response.......... 5 Hz to 44 000 Hz (with DVD,
D
Chassis .............................. 178 mm × 100 mm × at sampling frequency
165 mm 96 kHz)
Nose ...................................171 mm × 97 mm × 9 mm Signal-to-noise ratio........... 96 dB (1 kHz) (IEC-A net-
Weight ............................... 1.7 kg work) (RCA level)
Output level:
C Video................................. 1.0 Vp-p/75 Ω (±0.2 V)
Display Number of channels ......... 2 (stereo)
Screen size/aspect ratio..... 6.1 inch wide/16:9 MP3 decoding format ....... MPEG-1 & 2 Audio Layer 3
(effective display area: WMA decoding format ...... Ver.7, 7.1, 8, 9, 10, 11, 12
136.2 mm × 72.0 mm) (2 ch audio)
Pixels ................................ 1 152 000(2 400 × 480) (Windows Media Player)
Display method ................. TFT active matrix, driving AAC decoding format....... MPEG-4 AAC (iTunes en-
type coded only) (.m4a)
Color system..................... NTSC/PAL/PAL-M/PAL-N/ (Ver. 10.6 and earlier)
SECAM compatible DivX decoding format........ Home Theater Ver.3, 4, 5.2,
Durable temperature range (power off) 6 (Except ultra and HD)
D ...................................... –20 °C to + 80 °C (.avi,.divx)
MPEG video decoding format
Audio ...................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)
Maximum power output ..... 50 W × 4
70 W × 1/2 Ω (for subwoo-
fer)
USB
Continuous power output... 22 W × 4 (50 Hz to
USB standard specification
15 000 Hz, 5%THD,
...................................... USB 1.1, USB 2.0 full speed
4 Ω load, both channels dri-
(For video files)
ven)
USB 2.0 high speed (For
Load impedance ............... 4 Ω (4 Ω to 8 Ω (2Ω for 1ch)
E audio files)
allowable)
Maximum current supply ... 1.0 A
Preout maximum output level USB Class......................... MSC (Mass Storage Class),
..................................... 2.0 V MTP (Media Transfer Proto-
Equalizer (8-Band Graphic Equalizer): col)
Frequency......................... 40 Hz/80 Hz/200 Hz/400 Hz/ File system........................ FAT16, FAT32
1 kHz/2.5 kHz/8 kHz/10 kHz MP3 decoding format ....... MPEG-1 & 2 Audio Layer 3
Gain ................................. ±12 dB WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12
HPF: (2 ch audio)
Frequency......................... 50 Hz/63 Hz/80 Hz/100 Hz/ (Windows Media Player)
125 Hz AAC decoding format....... MPEG-4 AAC (iTunes en-
F Slope................................ –12 dB/oct coded only)
Subwoofer (mono): (Ver. 10.6 and earlier)
Frequency......................... 50 Hz/63 Hz/80 Hz/100 Hz/
125 Hz

AVH-X1600DVD/XNUC
10
1 2 3 4
5 6 7 8

WAV (MSC Mode only):


WAV signal format............ Linear PCM, MS ADPCM
(.wav)
Sampling Frequency......... Linear PCM:16 kHz,
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG (MSC Mode only): B
JPEG decoding format....... .jpeg, .jpg, .jpe
Pixel Sampling.................. 4:2:2, 4:2:0
Decode Size..................... MAX:8 192 (H) x 7 680 (W),
MIN:32 (H) x 32 (W)
DivX decoding format (MSC Mode only)
..................................... Home Theater Ver. 3, 4, 5.2,
6 (Except ultra and HD)
(.avi, .divx)
MPEG video decoding format (MSC Mode only)
..................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)
C

FM tuner
Frequency range.............. 87.5 MHz to 108.0 MHz
Usable sensitivity.............. 9 dBf (0.8 µV/75Ω ,mono,
S/N:30 dB)
Signal-to-noise ratio.......... 72 dB(IEC-A network)

MW tuner
Frequency range.............. 531 kHz to 1 602 kHz (9 kHz)
Usable sensitivity.............. 25 µV(S/N:20 dB)
Signal-to-noise ratio.......... 62 dB (IEC-A network)
D

LW tuner
Frequency range................ 153 kHz to 281 kHz
Usable sensitivity.............. 28 µV (S/N:20 dB)
Signal-to-noise ratio.......... 62 dB (IEC-A network)

Note
Specifications and the design are subject to mod- E
ifications without notice.

AVH-X1600DVD/XNUC
5 6 7 8
11
1 2 3 4

A - AVH-X1600DVD/XNUW5

AVH-X1600DVD/XNUC
12
1 2 3 4
5 6 7 8

AVH-X1600DVD/XNUC
5 6 7 8
13
1 2 3 4

A - AVH-X1650DVD/XNRC

General DVD Player


Power source ................... 14.4 V DC(12.0 V to 14.4 V al- System ............................ DVD video,Video CD, CD,
lowable) WMA, MP3, AAC, DivX,
Grounding system ............ Negative type MPEG player
Backup current ................. 5 mA or less Usable discs .................... DVD video, Video CD, CD, CD-
Maximum current consumption R/RW, DVD-R/RW/RDL
................................... 10.0 A Region number ................ 3
Dimensions (W × H × D): Frequency response......... 5 Hz to 44 000 Hz (with DVD,
D at sampling frequency 96 kHz)
B
Chassis ............................178 mm × 100 mm × 165 mm Signal-to-noise ratio ......... 96 dB (1kHz) (IEC-A network)
Nose ................................171 mm × 97 mm × 9 mm (RCA level)
Output level:
Weight .............................1.7 kg
Video ............................... 1.0 Vp-p/75 Ω (±0.2 V)
Number of channels ........ 2 (stereo)
Display MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Screen size/aspect ratio... 6.1 inch wide/16:9 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
(effective display area: audio)
136.2 mm × 72.0 mm) (Windows Media Player)
Pixels ...............................1 152 000(2 400 × 480) AAC decoding format ....... MPEG-4 AAC (iTunes encoded
Display method ................TFT active matrix, driving type only) (.m4a)
C
Color system .................... NTSC/PAL/PAL-M/PAL-N/ (Ver.10.6 and earlier)
SECAM compatible DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6
Durable temperature range (power off) (Except ultra and HD) (.avi,
................................... – 20 °C to + 80 °C .divx)
MPEG video decoding format
................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)
Audio
Maximum power output.... 50 W × 4
70W × 1/2 Ω (for subwoofer)
USB
Continuous power output
D USB standard specification
................................... 22 W × 4 (50 Hz to 15 000 Hz,
................................... USB 1.1, USB2.0 full speed
5%THD, 4 Ω load, both chan-
(For video files)
nels driven)
USB2.0 high speed (For
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch)
audio files)
allowable)
Maximum current supply
Preout maximum output level ................................... 1.0 A
................................... 2.0 V USB Class ....................... MSC (Mass Storage Class),
Equalizer (8-Band Graphic Equalizer): MTP (Media Transfer Protocol)
Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ File system....................... FAT16, FAT32
1 kHz/2.5 kHz/8 kHz/10 kHz MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
E Gain ................................ ±12 dB WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
HPF: audio)
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ (Windows Media Player)
125 Hz AAC decoding format ....... MPEG-4 AAC (iTunes encoded
Slope ............................... –12 dB/oct only)
Subwoofer (mono): (Ver.10.6 and earlier)
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ WAV (MSC Mode only):
125 Hz WAV signal format ........... Linear PCM, MS ADPCM
Slope ............................... –18 dB/oct (.wav)
Gain ................................ +6 dB to –24 dB Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz,
Phase .............................. Normal/Reverse 24 kHz, 32 kHz, 44.1 kHz,
F Bass boost: 48 kHz
Gain ................................ +12 dB to 0 dB MS ADPCM:22.05 kHz,
44.1 kHz

AVH-X1600DVD/XNUC
14
1 2 3 4
5 6 7 8

JPEG (MSC Mode only):


JPEG decoding format ..... .jpeg, .jpg, .jpe
Pixel Sampling ................. 4:2:2, 4:2:0
Decode Size..................... MAX:8 192 (H) x 7 680 (W),
MIN:32 (H) x 32 (W)
DivX decoding format (MSC Mode only)
................................... Home Theater Ver.3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx) B
MPEG video decoding format (MSC Mode only)
................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)

FM tuner
Frequency range .............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
30 dB)
Signal-to-noise ratio ......... 72 dB (IEC-A network)
C

AM tuner
Frequency range .............. 530 kHz to 1 640 kHz (10 kHz)
531 kHz to 1 602 kHz (9 kHz)
Usable sensitivity ............. 25 µV (S/N:20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)

D
Note
Specifications and the design are subject to
modifications without notice.

AVH-X1600DVD/XNUC
5 6 7 8
15
1 2 3 4

A - AVH-X1650DVD/XNRD

General DVD Player


Power source ................... 14.4 V DC (12.0 V to 14.4 V al- System ............................ DVD video, Video CD, CD,
lowable) WMA, MP3, AAC, DivX,
Grounding system............ Negative type MPEG player
Backup current ................. 5 mA or less Usable discs .................... DVD video, Video CD, CD, CD-
Maximum current consumption R/RW, DVD-R/RW/RDL
................................... 10.0 A Region number ................ 4
Dimensions (W × H × D): Frequency response......... 5 Hz to 44 000 Hz (with DVD,
B D at sampling frequency 96 kHz)
Chassis ............................ 178 mm × 100 mm × 165 mm Signal-to-noise ratio ......... 96 dB(1 kHz) (IEC-A network)
Nose ................................ 171 mm × 97 mm × 9 mm (RCA level)
Weight ............................. 1.7 kg Output level:
Video ............................... 1.0 Vp-p/75 Ω (±0.2 V)
Number of channels ........ 2 (stereo)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Display
WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
Screen size/aspect ratio... 6.1 inch wide/16:9
audio)
(effective display area:
(Windows Media Player)
136.2 mm × 72.0 mm)
AAC decoding format....... MPEG-4 AAC (iTunes encoded
Pixels ...............................1 152 000(2 400 × 480)
C
only) (.m4a)
Display method ................TFT active matrix, driving type
(Ver.10.6 and earlier)
Color system.................... NTSC/PAL/PAL-M/PAL-N/
DivX decoding format....... Home Theater Ver.3, 4, 5.2, 6
SECAM compatible
(Except ultra and HD) (.avi,
Durable temperature range (power off)
.divx)
................................... – 20 °C to + 80 °C
MPEG video decoding format
................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)
Audio
Maximum power output... 50 W × 4
70 W × 1/2 Ω (for subwoofer) USB
D Continuous power output USB standard specification
................................... 22 W × 4 (50 Hz to 15 000 Hz, ................................... USB 1.1, USB2.0 full speed
5%THD, 4 Ω load, both chan- (For video files)
nels driven) USB2.0 high speed (For
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) audio files)
allowable) Maximum current supply
Preout maximum output level ................................... 1.0 A
................................... 2.0 V USB Class ....................... MSC (Mass Storage Class),
MTP (Media Transfer Protocol)
Equalizer (8-Band Graphic Equalizer): File system....................... FAT16, FAT32
Frequency........................ 40 Hz/80 Hz/200 Hz/400 Hz/ MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
E 1 kHz/2.5 kHz/8 kHz/10 kHz WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
Gain ................................ ±12 dB audio)
HPF: (Windows Media Player)
Frequency........................ 50 Hz/63 Hz/80 Hz/100 Hz/ AAC decoding format....... MPEG-4 AAC (iTunes encoded
125 Hz only)
Slope ............................... –12 dB/oct (Ver.10.6 and earlier)
Subwoofer (mono): WAV (MSC Mode only):
Frequency........................ 50 Hz/63 Hz/80 Hz/100 Hz/ WAV signal format ........... Linear PCM, MS ADPCM
125 Hz (.wav)
Slope ............................... –18 dB/oct Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz,
Gain ................................ +6 dB to –24 dB 24 kHz, 32 kHz, 44.1 kHz,
F Phase .............................. Normal/Reverse 48 kHz
Bass boost: MS ADPCM:22.05 kHz,
Gain ................................ +12 dB to 0 dB 44.1 kHz

AVH-X1600DVD/XNUC
16
1 2 3 4
5 6 7 8

JPEG (MSC Mode only):


JPEG decoding format ..... .jpeg, .jpg, .jpe
Pixel Sampling ................. 4:2:2, 4:2:0
Decode Size..................... MAX:8 192 (H) x 7 680 (W),
MIN:32 (H) x 32 (W)
DivX decoding format (MSC Mode only)
................................... Home Theater Ver.3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx) B
MPEG video decoding format (MSC Mode only)
................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)

FM tuner
Frequency range.............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
30 dB)
Signal-to-noise ratio ......... 72 dB (IEC-A network)
C

AM tuner
Frequency range.............. 530 kHz to 1 640 kHz (10 kHz)
531 kHz to 1 602 kHz (9 kHz)
Usable sensitivity ............. 25 µV(S/N:20 dB)
Signal-to-noise ratio ......... 62 dB(IEC-A network)

Note
Specifications and the design are subject to
modifications without notice.

AVH-X1600DVD/XNUC
5 6 7 8
17
1 2 3 4

A - AVH-X1650DVD/XNRI

General DVD Player


Power source ................... 14.4 V DC (12.0 V to 14.4 V al- System ............................ DVD video, Video CD, CD,
lowable) WMA, MP3, AAC, DivX,
Grounding system ............ Negative type MPEG player
Backup current ................. 5 mA or less Usable discs .................... DVD video, Video CD, CD, CD-
Maximum current consumption R/RW, DVD-R/RW/RDL
................................... 10.0 A Region number ................ 2
Dimensions (W × H × D): Frequency response......... 5 Hz to 44 000 Hz (with DVD,
DIN at sampling frequency 96 kHz)
B Signal-to-noise ratio ......... 96 dB(1 kHz) (IEC-A network)
Chassis ............................ 178 mm × 100 mm × 157 mm
Nose ................................ 188 mm × 118 mm × 17 mm (RCA level)
D Output level:
Chassis ............................ 178 mm × 100 mm × 165 mm Video ............................... 1.0 Vp-p/75 Ω (±0.2 V)
Number of channels ........ 2 (stereo)
Nose ................................ 171 mm × 97 mm × 9 mm
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Weight ............................. 1.7 kg
WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
Display
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
Screen size/aspect ratio... 6.1 inch wide/16:9
only) (.m4a)
C (effective display area:
(Ver.10.6 and earlier)
136.2 mm × 72.0 mm)
DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6
Pixels ...............................1 152 000 (2 400 × 480)
(Except ultra and HD) (.avi,
Display method ................TFT active matrix, driving type
.divx)
Color system .................... NTSC/PAL/PAL-M/PAL-N/
MPEG video decoding format
SECAM compatible
................................... MPEG1, MPEG2, MPEG4
Durable temperature range (power off)
(part2), MS-MPEG4 (ver.3)
................................... –20 °C to + 80 °C

Audio USB
Maximum power output... 50 W × 4 USB standard specification
D ................................... USB 1.1, USB2.0 full speed
70 W × 1/2 Ω (for subwoofer)
Continuous power output (For video files)
................................... 22 W × 4 (50 Hz to 15 000 Hz, USB 2.0 high speed (For
5%THD, 4 Ω load, both chan- audio files)
nels driven) Maximum current supply
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) ................................... 1.0 A
allowable) USB Class ....................... MSC (Mass Storage Class),
Preout maximum output level MTP (Media Transfer Protocol)
................................... 2.0 V File system....................... FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Equalizer (8-Band Graphic Equalizer):
WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/
E audio)
1 kHz/2.5 kHz/8 kHz/10 kHz
(Windows Media Player)
Gain ................................ ±12 dB
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
HPF:
only)
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/
(Ver.10.6 and earlier)
125 Hz
WAV (MSC Mode only):
Slope ............................... –12 dB/oct
WAV signal format ........... Linear PCM, MS ADPCM
Subwoofer (mono):
(.wav)
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/
Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz,
125 Hz
24 kHz, 32 kHz, 44.1 kHz,
Slope ............................... –18 dB/oct
48 kHz
Gain ................................ +6 dB to – 24 dB
F MS ADPCM:22.05 kHz,
Phase .............................. Normal/Reverse
44.1k Hz
Bass boost:
Gain ................................ +12 dB to 0 dB

AVH-X1600DVD/XNUC
18
1 2 3 4
5 6 7 8

JPEG (MSC Mode only):


JPEG decoding format ..... .jpeg, .jpg, .jpe
Pixel Sampling ................. 4:2:2, 4:2:0
Decode Size..................... MAX:8 192 (H) x 7 680 (W),
MIN:32 (H) x 32 (W)
DivX decoding format (MSC Mode only)
................................... Home Theater Ver.3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx)
B
MPEG video decoding format (MSC Mode only)
................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)

FM tuner
Frequency range .............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
30 dB)
Signal-to-noise ratio ......... 72 dB(IEC-A network)
C

AM tuner
Frequency range .............. 530 kHz to 1 640 kHz (10 kHz)
531 kHz to 1 602 kHz (9 kHz)
Usable sensitivity ............. 25 µV (S/N:20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)

Note
Specifications and the design are subject to
modifications without notice.

AVH-X1600DVD/XNUC
5 6 7 8
19
1 2 3 4

A - AVH-X1690DVD/XNID

General DVD Player


Power source ................... 14.4 V DC (12.0 V to 14.4 V al- System ............................ DVD video, Video CD, CD,
lowable) WMA, MP3, AAC, DivX,
Grounding system ............ Negative type MPEG player
Backup current ................. 5 mA or less Usable discs .................... DVD video, Video CD, CD, CD-
Maximum current consumption R/RW, DVD-R/RW/RDL
................................... 10.0 A Region number ................ 5
Dimensions (W × H × D): Frequency response......... 5 Hz to 44 000 Hz (with DVD,
B D at sampling frequency 96 kHz)
Chassis ............................178 mm × 100 mm × 165 mm Signal-to-noise ratio ......... 96 dB(1 kHz) (IEC-A network)
Nose ................................171 mm × 97 mm × 9 mm (RCA level)
Weight ............................. 1.7 kg Output level:
Video ............................... 1.0 Vp-p/75 Ω (±0.2 V)
Number of channels ........ 2 (stereo)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Display
WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
Screen size/aspect ratio...154.9 mm wide/16:9
audio)
(effective display area:
(Windows Media Player)
136.2 mm × 72.0 mm)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
Pixels ............................... 1 152 000 (2 400 × 480)
C only) (.m4a)
Display method ................TFT active matrix, driving type
(Ver.10.6 and earlier)
Color system .................... NTSC/PAL/PAL-M/PAL-N/
DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6
SECAM compatible
(Except ultra and HD) (.avi,
Durable temperature range (power off)
.divx)
................................... –20 °C to +80 °C
MPEG video decoding format
................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)
Audio
Maximum power output... 50 W × 4
70 W × 1/2 Ω (for subwoofer) USB
Continuous power output USB standard specification
D ................................... USB 1.1, USB 2.0 full speed
................................... 22 W × 4 (50 Hz to 15 000 Hz,
5%THD, 4 Ω load,both chan- (For video files)
nels driven) USB 2.0 high speed (For
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) audio files)
allowable) Maximum current supply
Preout maximum output level ................................... 1.0 A
................................... 2.0 V USB Class ....................... MSC (Mass Storage Class),
Equalizer (8-Band Graphic Equalizer): MTP (Media Transfer Protocol)
Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ File system....................... FAT16, FAT32
1 kHz/2.5 kHz/8 kHz/10 kHz MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Gain ................................ ±12 dB WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch
E audio)
HPF:
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ (Windows Media Player)
125 Hz AAC decoding format ....... MPEG-4 AAC (iTunes encoded
Slope ............................... –12 dB/oct only)
Subwoofer (mono): (Ver.10.6 and earlier)
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ WAV (MSC Mode only):
125 Hz WAV signalf ormat ........... Linear PCM, MS ADPCM
Slope ............................... –18 dB/oct (.wav)
Gain ................................ +6 dB to – 24 dB Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz,
Phase .............................. Normal/Reverse 24 kHz, 32kHz, 44.1 kHz,
Bass boost: 48 kHz
F
Gain ................................+12 dB to 0 dB MS ADPCM:22.05 kHz,
44.1 kHz

AVH-X1600DVD/XNUC
20
1 2 3 4
5 6 7 8

JPEG (MSC Mode only):


JPEG decoding format ..... .jpeg, .jpg, .jpe
Pixel Sampling ................. 4:2:2, 4:2:0
Decode Size..................... MAX:8 192 (H) x 7 680 (W),
MIN:32 (H) x 32 (W)
DivX decoding format (MSC Mode only)
................................... Home Theater Ver.3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx) B

MPEG video decoding format (MSC Mode only)


................................... MPEG1, MPEG2, MPEG4
(part2), MS-MPEG4 (ver.3)

FM tuner
Frequency range .............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
30 dB)
Signal-to-noiseratio ......... 72 dB (IEC-A network)
C

AM tuner
Frequency range .............. 530 kHz to 1 640 kHz (10k Hz)
531 kHz to 1 602 kHz (9 kHz)
Usable sensitivity ............. 25 µV(S/N:20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)

Note
Specifications and the design are subject to
modifications without notice.

2.2 DISC/CONTENT FORMAT

is a trademark of DVD Format/Logo Licensing Corporation.


F

AVH-X1600DVD/XNUC
5 6 7 8
21
1 2 3 4

3. BASIC ITEMS FOR SERVICE


3.1 CHECK POINTS AFTER SERVICING
A
To keep the product quality after servicing, please confirm following check points.

No. Procedures Item to be confirmed


1 Confirm whether the customer complain has The customer complain must not be
been solved. reappeared.
If the customer complain occurs with the Display, video, audio and operations must be
specific media, use it for the operation check. normal.
2 DVD Measure playback error rates at the Deterioration of mecha-drive can be
innermost and outermost tracks by using the checked.
test mode with the following disc. The error rate must be less than the
DVD test disc (TDV-582) threshold value.
B (Refer to the chapter of DIAGNOSIS for the
threshold value.)
3 DVD Play back a DVD. Display, video, audio and operations must be
(Menu operation; Title/chapter search) normal.
4 CD Play back a CD. Display, audio and operations must be
(Track search) normal.
5 FM/AM tuner Check FM/AM tuner action. Display, audio and operations must be
(Seek, Preset) normal. * If the reception sensitivity is poorer
Switch band to check both FM and AM. than normal, the gasket on the FM/AM tuner
unit may be damaged or lost.
C
6 Check whether no disc is inside the product. The media used for the operating check must
be ejected.
7 Appearance check No scratches or dirt on its appearance after
receiving it for service.

For check items concerning image and voice, please refer to the followings:

Check items concerning image Check items concerning voice


Block-noise Distortion
Crosscut noise Noise
Dot noise Low volume
D Distorted image (Image skip) High volume
Low brightness Changes in level
Too bright Pause of sound
Color fading
Partial discoloration

AVH-X1600DVD/XNUC
22
1 2 3 4
5 6 7 8

3.2 PCB LOCATIONS

A Mother PCB A

C DVD Core Unit


E Service Unit (Keyboard)

B
D Service Unit (Monitor) B Interface PCB

A:AVH-X1600DVD/XNUC
B:AVH-X1600DVD/XNEW5
C:AVH-X1600DVD/XNUW5
D:AVH-X1650DVD/XNRC
E:AVH-X1650DVD/XNRD
F:AVH-X1650DVD/XNRI
G:AVH-X1690DVD/XNID
C

Service Unit(Mother I/F)


Consists of
Mother PCB
Interface PCB
Unit Number : CXX6037(A)
Unit Number : CXX6035(B)
Unit Number : CXX6036(C)
Unit Number : CXX6038(D)
Unit Number : CXX6039(E)
Unit Number : CXX6040(F)
Unit Number : CXX6041(G)
D
Unit Name : Service Unit(Mother I/F)
Unit Number : YWX5032
Unit Name : DVD Core Unit
Unit Number : CXX6055
Unit Name : Service Unit(Monitor)
Unit Number : CXX6059
Unit Name : Service Unit(Keyboard)

AVH-X1600DVD/XNUC
5 6 7 8
23
1 2 3 4

3.3 JIGS LIST


DVD Mechanism Module

Interface PCB

GGD1222

Mother PCB

Service Unit (Monitor)

- Jigs List
Name Jig No. Remarks
Disc TDV-582 Skew adjustment, Check points after servicing,
Inspection method of Pickup Unit
Disc TCD-782 Inspection method of Pickup Unit
30P FFC GGD1222 DVD CORE UNIT <–> MOTHER PCB

D - Grease List
Name Jig No. Remarks
Grease GEM1024 DVD Mechanism Module
Grease GEM1038 DVD Mechanism Module
Grease GEM1045 DVD Mechanism Module

3.4 CLEANING

Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools:
Portions to be cleaned Cleaning tools
DVD pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008

AVH-X1600DVD/XNUC
24
1 2 3 4
5 6 7 8

AVH-X1600DVD/XNUC
5 6 7 8
25
1 2 3 4

4. BLOCK DIAGRAM
4.1 OVERALL CONNECTION DIAGRAM
A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST". AEQ MIC IN
AUX IN
WIRED
REMOTE

2
1
3
4
1
2
3

GND
WIREDAD
WIRED

AUXR
AUXL
GNDD

VIDEO
JA3731 JA3641
CKN1106-A
CKS6437-A

B INTERFACE
B C

50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
POWER SUPPLY

WIREDAD

ASENBO
PREOUT

NTOSYS
SXPWR

BTMICN
SXPWR

BTMICP
GNDSX
GNDSX

STOSX
SXTOS
WIRED

GNDD
GNDD
GNDD
GNDA
GNDA
SXEN

GND
SXR

GND
SXL
SWROUT
YEK5001-A

NC
SWLOUT
FROUT
RROUT
2

FLOUT
RLOUT
GNDA
GNDA
16 1
15
14
13
12
11
10

10
11
12
13
14
15
16
17
18
19
20
21
22
23
9

8
7
6
5
4
3
2
1

1
2
3
4
5
6
7
8
9
8
7
6
5
4
3
2
1
BGSENS
GND

MUTE
ACC

B.REM

RR+
C

FR+
RL+
B.UP

RR-
FL+
ILM

FR-
RL-
FL-
JA1631

P.B.
XKB7001-B
JA801
CKM1376-A

CN1952 30 VD8
VD8
1 CN751
A
CKS6025-A 29 2 CKS6025-A

C
28
27
VD8
PGND
3
4
MOTHER P
PGND
26 5
PGND
25 6
24 VD5 7
23 AMUTE 8
22 XRESET 9

A 1/6 AUDIO BLOC


21 IRQPWR 10
20 HSTCMD 11

C 19
18
17
SLVSTS
STANBY
AGND
12
13
14

A 2/6 SYSTEM BL
16 ANA_R_OUT 15
DVD CORE UNIT 15
14
AGND
ANA_L_OUT
16
17
13 AGND 18
12 MOVBS 19
VIDEO_GND

A 3/6 SH BLOCK
11 20
10 WAKEUP 21
9 D- 22
8 D+ 23
7 DGND 24
IECOUT

A 4/6 POWER SU
6 25
5 DGND 26
4 SCL 27
3 SDA 28
2 CPRST 29
D 1 CPRDY 30

A 5/6 IN/OUT BLO


A 6/6 TUNER BLO
CN175
CKS6386-A
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
1
2
3
4
5
6
7
8
9
LCDGND

LCDGND

LCDGND
COMDC

HCLK
VCLK

STV2
OEV
POL

G5
G4
G3
G2
G1
G0
R5
R4
R3
R2
R1
R0

B5
B4
B3
B2
B1
B0
LD
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33

E
CN540
CKS6536-A

D SERVICE UNIT(MONITO

CN5301 CN5001
CKS6536-A
CKS6548-A
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
1

3
4
2

XL
XR
YB
YT

DVDD
AVDD
AVDD
LOAD

HCLK
VR10

STV2
DIO1

DIO2
GND

GND
GND

GND
GND
GND
VR1
VR2
VR3
VR4
VR5
VR6
VR7
VR8
VR9

L/R
NC

G0
G1
G2
G3
G4
G5
R0
R1
R2
R3
R4
R5
B0
B1
B2
B3
B4
B5

TOUCH PANEL TFT LCD


CSX1184
CWX4218

AVH-X1600DVD/XNUC
26
1 2 3 4
44 G4 17
AVDD 27 13 ASENBO 38
43 G3 18
AVDD 26 14 GND 37
42 G2 19
GND 25 15 STOSX 36
41 G1 20
GND 24 16 SXTOS 35
40 G0 21

CKS6536-A
HCLK 17 GNDD 34
23 B5
DVDD 39 22 GNDD VIDEO 1

CN5001
22 B4 18 33
DIO2 38 23 GNDD AUXR 3

CWX4218
21 B3 19 32
GND 37 24 AUXL

TFT LCD
20 20 BTMICP 31 4
36 B2 25 GND

AUX IN

CKN1106-A
GND 19 21 BTMICN 30 2
B1

JA3641
GND 35 26 GND

SH BLOCK
18 B0 22 29
STV2 34 27 NTOSYS

CKS6386-A
AEQ MIC IN
17 LCDGND 23 28

CKS6536-A
UD 33 28 SYSTON

CN1751
16 DIO 24 27

CN5401
OEV 32 29 GND
15 LCDGND 25 26
VCLK 31 30 ONSEI-

AUDIO BLOCK
14 26 25

NIT(MONITOR)
LCDPW

N/OUT BLOCK

TUNER BLOCK
GND 30 31 ONSEI+

MOTHER PCB
13 27 24

CKS6605-A
LPSYNC

CKS6605-A
GND 29 32 GUIDEON NAVI_TO_SYS 26

NTERFACE PCB

SYSTEM BLOCK
CN1701
12 V18HI 28 23
SYS_TO_NAVI

CN3601
POL 28 33 TVON 25
11 LCDGND 29 22
XON 27 34 DTVR VSW5 24
10 PWRVI 30 21
NC 26 35 DTVAG MONON 23
5

9 31 20

5
25 TEMPSENS 36 GUIDEON 22
VEEG-6V 8 32 DTVL 19
24 PWM_G 37 TVON 21
NC 7 33 GND 18
23 PWM_R 38 DSEN 20
VDDG+18V 6 34 CSYNC 17
22 PWM_B 39 19
NC APPPUP CCREM
5 KDT1 35 16
STV1 21 40 ANB GNDRAU 18
4 KDT0 36 15

POWER SUPPLY BLOCK


NC 20 41 GNDSIG REAUL 17
3 RST 37 14
VCOM 19 42 ANG REAUR 16
2 REMIN 38 13
VCOM 18 43 GNDSIG OMSEI- 15
1 LCDGND 39 12
17 44 ANR ONSEI+ 14
MTCHCL 40 11
16 45 GNDSIG GNDD 13
MTCHDA 41 10
15 46 AUXV GNDAU 12
ANODE TPIRQN 42 9
CKS4497-A

1 14 47 AUXVGND CCAUR 11
ANODE KEYGND 43 8
CN3661

2 13 48 AUXL CCAUL 10
ANODE TOUCHGND 44 7
3 12 49 AUXAGND ASENBO 9
NC TPN33 45 6
4 11 50 AUXR 8
K1 BLSYNC 46 5 YS
5 10 51 AUXAGND 7
K2 BLEN 47 4 GNDDVD
6 9 52 BEEP 6
K3 DIMMER 48 3 DVDVBS
7 8 53 BCAMIN 5
K4 BLERR 49 2 GNDSIG

CKS6523-A
NAVI/DTV INTERFACE

8 7 54 BCAMGND 4
NC BLGND 50 1 CSYNC

CN5202
9 6 55 3

BACKLIGHT
NC BLGND CCB
10 5 56 2
BLGND CCG
4 57 1
ILMB CCR
3 58
2 ILMB 59
ILMB 6 SHIELD2
1 60
5 SHIELD1
4 USBGND

6
6

3 USB_D+
BCAMIN 2
CKN1091-A 2 USB_D-

CN5402
BCAMGND
JA1601
INPUT

USB IN

1 USB5V 1

9
8
7
6
5
4
3
2
CKS6063-A 1

11
10
CKB1106-A
JA3621

RST
ILMB

REM
VCR_RG

KDT0
KDT1

LEDB
LEDR
LEDG

TPN33
1

KEYGND
KEYGND
2 VCR_RIN
BACK CAMERA

3 VOUT_G

1
2
3
4
5
6
7
8
9
VOUT

10
11
4
5 VCR_LG
6 VCR_LIN
CKB1110-A

VCR_VG
JA1621

7
8 VCR_VIN

CKS6063-A
RCA V IN OUT

CN4801
22

AVH-X1600DVD/XNUC
1
Consists of

E
1
YKS5041-A
JA451
FM/AM

7
7

MOTHER PCB

ANTENNA

(KEYBOARD)
INTERFACE PCB

SERVICE UNIT
SERVICE UNIT(MOTHER I/F)
8

8
27
E
A

D
C

F
B
1 2 3 4

4.2 BLOCK DIAGRAM

A
A MOTHER PCB (1/3) RCA V IN/OUT

8
6
4
JA1621
VCR_VIN
VCR_LIN
VOUT
CN751 AV SEL
IC1
1 VD8 AK42
2
RCA_V 13
3 VOUT2
7 VD5
VCR_L 33
LIN4
TUN_L TUN_L 27
ANA_L_OUT
H LS_L 36
LIN6
17 LIN3
AUX_L 30
LIN5
iTV_L 40
LIN2
SH_L SH_L 43
TO 2/3 I LIN1

C
iCOMP iCOMP 11
B J VCR_V 9
VIN1
VIN2
CN1952 19
MOVBS LS_V 5
VIN4
AUX_V 7
VIN3
AMUTE BCAMIN 3
8 VIN5
XRESET XRST
9
IRQPWR IRQPW
10
HSTCMD SYSTOLS
11
SLVSTS LSTOSYS
12
STANBY STANBY Q751
13 Q752
D- D- SYS+B
22
23
D+ D+ M TO 2/3
AMUTE

CN1701
AUXL
44
AUXAGND 29
45 GND5
AUXV
42
C BCAMIN
49
105 46
AVSCK SCL
103 45
IC1721 AVSDATA
104 17
SDA
NJM4565V AVSRST RSTN
DTVL 2 17
30 1 iTV_L AMUTE
DTVAG 3 9
29 XRST
16 Q1661
IRQPW
SYSTOLS 7
IC1731 (1/2) TXDVD
IC1731 (2/2) LSTOSYS 8
NJM4565V RXDVD
ONSEI+
NJM4565V STANBY 29
STB
6
25 7 2
ONSEI- 5 1 iNAVI
24 3
35
EVSEL
33
EVSDA
34
Q1721 EVSCK
36 EVSACLK
SYS+B SACLK
120 EVSAOUT
SYSTEM uCOM SAIN
IC601 (1/3)

AEQAUXSW
D
A :PDB117A8
B C D
ANR :PDB118A8
40 L TO 2/3 E F G 62
ANG AEQAUXSW
38 38
ANB SYSMUTE
36 1 OFFSET
CSYNC offset
34
HSYNC
B
33
VSYNC
32
CN3601
Q601
TVON 3
27 RGBARI
A :AVH-X160
GUIDEON 2
26 GUIDEON B :AVH-X160
SYSTON 4
22
NTOSYS 5
TXNAVI C :AVH-X160
21 RXNAVI
E D :AVH-X165
Q1701 E :AVH-X165
ASENBO
11 BUP_1 F :AVH-X165
100
G :AVH-X169
ASENBO

Q1712
APPPUP VDD33
35 SOC33_1

102 68
WREMCONT AMPPW
74 TELMUTE
TELMUTEIN
D E F G PBSENS 75
77
ISENS
WIREDAD 118 76 BGSENS0
BGSENS
1 WIREDAD 111
WIRED 117 ASENS
F 2
BEEP 67
WIRED
110
48 BEEP BSENS

AVH-X1600DVD/XNUC
28
1 2 3 4
5 6 7 8

AUX_L AEQMICIN

AV SELECTOR E.VOL
IC101 IC251
AK4223VQ PML020A MIC SENS
13 18 Q1662
VOUT2 MIC_IN SYS+B
33
LIN4
27 AEQAUXSW
LIN6
36
LIN3
30
LIN5
40
LIN2
43
LIN1 LOUT2
22 AV_LOUT1 8
IN2L
JA1631
61 FLOUT

PREOUT
11 FRONT_L 4
9
VIN1
60 RLOUT B
VIN2 REAR_L 6
5
VIN4 59 SWLOUT
7 PRE_SWL 2
VIN3
3
VIN5
iNAVI 14
IN5L Q1633(1/2) Q1633(2/2) Q1631

RCAMUTE
Q311
54
SYS+B VP BUP_1

SYSMUTE

29
GND5

14 MONVBS C
VOUT1 K TO 2/3 AMP
46
SCL IC341
45
SDA PA2032A
17
RSTN
JA801
11 9 FL+
FLIN RL+ 7
15 7 FL-
Q1661 RLIN RL- 5
EVSEL 32 17 RL+
STB FL+ 8
EVSDA 31
DATA 19 RL-
EVSCK 30 FL- 6
CLK
EVSACLK 28
SACLK
EVSAOUT 27
SAOUT

SACLK
SAOUT

AMPPW 4
AEQAUXSW

STBY D

OFFSET 1 25 B.REM
OFFSET H-SW 11

FFSET

POWER SUPPLY
MUTE
OFFMUTE AMPMUTE
Q301 Q321 22

BUP_1

SYSMUTE
FUSE B.UP
SYS+B BUP_1 16
10A
A :AVH-X1600DVD/XNUC
B :AVH-X1600DVD/XNEW5 TEL MUTE
C :AVH-X1600DVD/XNUW5 TELMUTE Q854 (1/2) MUTE
10
D :AVH-X1650DVD/XNRC E
E :AVH-X1650DVD/XNRD PBSENS
F :AVH-X1650DVD/XNRI PBSENS Q854(2/2) P.B.
9
G :AVH-X1690DVD/XNID
ISENS
Q841
ISENS ILM
12

BGSENS AVH
Q831
BGSENS0 BGSENS
13

ELMUTE
ASENS
ASENS Q871(2/2) ACC
14
GSENS0
BSENS
BSENS
Q871(1/2) F
BUP_1

AVH-X1600DVD/XNUC
5 6 7 8
29
1 2 3 4

A MOTHER PCB (2/3)


A
VIDEO DECODER
IC1051
ML86V7675TBZA3A
MONVBS 59
TO 1/3 K CVBS1

RGB VIDEO ISOLATOR


IC1002
BH7673G
Q1002
ANR 4 1 12
+IN OUT RIN1

IC1004
BH7673G
Q1004
ANG 4 1 1
+IN OUT GIN1
B
iCOMP
IC1003 J TO 1/3
BH7673G
Q1001
TO 1/3 L ANB 4 1 5
+IN OUT BIN1

IC1001
BH7673G
Q1003
CSYNC 4 1 16
+IN OUT CSYNC_A 52 V_SCL0
SCL
51 V_SDA0
SDA

HSYNC 20
CHSI
VSYNC 21
VSI

iPod CP
RF FRONT END IC IC1202
IC501 337S3959
TDA7706
ANTENNA

JA451
FM/AM

VCC
1 5
FMMIXIN1 8
16
PINDIN Q1201
18 57 TUN_L
LNAIN DACOUTL H TO 1/3 SOC33

76
P

D
SDRAM
IC1101
M12L128168A-5TG2N
SYSTEM uCOM
IC601(2/3)
A :PDB117A8
B C D
:PDB118A8
E F G

33 42
FLASH ROM
I2CSDA
34 44
TUNDATA IC1251
I2CSCL TUNCLK A D :CXX5989
31 43
RSTN TUNRST
B C E F G :CXX5991

RESET
E 3

93 88
SOCXRST R

A :AVH-X1600DVD/XNUC
37 68
B :AVH-X1600DVD/XNEW5 SOCSTB
95 77
P
C :AVH-X1600DVD/XNUW5 SOCAMUTE1
30 202
P
TXSOC P
D :AVH-X1650DVD/XNRC RXSOC
31 203
P
94 216
E :AVH-X1650DVD/XNRD SOCIRQPW P

F :AVH-X1650DVD/XNRI
G :AVH-X1690DVD/XNID

AVH-X1600DVD/XNUC
30
1 2 3 4
5 6 7 8

CN1751 (1/2)
10
SH PART uCOM R[0-5] l
IC1302 15
R5S72690RW266FP 16
G[0-5] l
21
22
B[0-5] l
27

191 POL
PG26/LCD_TCON1 2
190 VCLK
PG25/LCD_TCON0 3
44 OEV
PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1 4
43
PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1
STV2
5 B
189 HCLK
PG24/LCD_CLK 7

185 LD
PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2 9
183 DIO
PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4
PJ28/SSISCK5/TIOC1B/RTS7
66 LPSYNC
29
32
D
42 TPIRQN CN5401
PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2 47
239 BLSYNC
PJ27/SGOUT_3/TIOC1A/CTS7 51

223 BLEN
PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0 52
22 DIMMER
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK 53
118 BLERR
PH0/AN0/PINT0 54
CL0
DA0 70 MTCHCK
PE0/SCL0/TCLKA/LCD_EXTCLK 45
71 MTCHDA
PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK 46

PWRVI 35

V_SDA0
V_SCL0
TPN33 50
C
ILMB 58
59
60
TAGGING
IC1301
MX25L8006EM2I-12G

SOC33

76
PE6/SCL3/RxD6

DAC D
IC1151
WM8761BGED

9 SH_L
VOUTL I TO 1/3

16 USBFLG
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
24 USBCNT N TO 3/3
PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD
E
88
RES
USB SW
IC751
BD11600NUX
94 1 JA1601
68 DP
PJ30/SSIDATA5/TIOC2B/IETxD USB_D+
77 8
PE7/SDA3/RxD7 3
202
PF7/SSIRxD0/RxD0/SGOUT_3/CTS1 3
203 93
PF8/A23/TxD0 2
216 DM
PF16/SD_CD_0/FCE/IRQ4/MMC_CD USB_D-
7
2 USB IF
4
221 9
PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
USB5V
USB5 1

F
D+
TO 1/3 M D-

AVH-X1600DVD/XNUC
5 6 7 8
31
1 2 3 4

A MOTHER PCB (3/3)


A

DC/DC CONVERTER
IC1951
AN33012UA
P2151 Q1951
3 1
VD8 RS1 VCC BUP_1
P2152 2
VCC_S1
ILMB
24
VCC_S2
DD8 4
HSD1
7
FB1
8
EN1
P2071 Q1952 12
23 FLAG
VD5 RS2
P2081
PWRVI

B DD5
22
HSD2 SYNC
13
18 9
FB2 EN2

USB5 REG.
IC2161
AN33014UA
24 4
USB5 LX PVCC1 BUP_1
2 5
RSO PVCC2
12 6
FB VCC
8 19 USBFLG
RSIN
FLAG
16 USBCNT N TO 2/3
EN
17
SYNC

C
DDC33 REG.
IC2101
BD9876EFJ
1 8
DDC33 LX VCC BUP_1
4
SOC33 FB
5
SYNC
SOC33_1 6
EN
VDEC33
TPN33
BT33

SOC12 REG.
IC2011
BD00IA5WEFJ
1 8
SOC12 VO VCC SOC33
2 5
FB EN
D

VDD33 REG.
IC1801
NJW4181U3-33B
1 3
VDD33 VOUT VIN BUP_1

VDEC15 REG.
IC2031
NJM2878F3-15
4 5
VDEC15 VOUT VIN VDEC33
1
CONT
E

TUN5REG.
IC1901
NJM2886DL3-05
P1951
4 2
TUN5 VOUT VIN DD8
CONT 1

SYS+B
IC1821
NJM2387ADL3
3 1
SYS+B VOUT VIN BUP_1
4 2
VADJ CONT

AVH-X1600DVD/XNUC
32
1 2 3 4
5 6 7 8

SYSTEM uCOM
IC601 (3/3)
A :PDB117A8
B C D
:PDB118A8
E F G CN1751 (2/2)

70 119 COMDC
VDCNT8 COMDC 1
64 73 LCDPW
DDCERR LCDPW 31
124 TMPSENS
TEMPSEN 36
92 PWM_G
G_PWM 37
B
D
R_PWM 90 PWM_R
38
88 PWM_B
B_PWM 39 CN5401
126 KDT1
KDT1 40
127 KDT0
KDT0 41
112 REMIN
REMIN 43
26 RST
NRST 42

65
DDCCLK

69
VDCNT5

D
A :AVH-X1600DVD/XNUC
B :AVH-X1600DVD/XNEW5
C :AVH-X1600DVD/XNUW5
D :AVH-X1650DVD/XNRC
E :AVH-X1650DVD/XNRD
F :AVH-X1650DVD/XNRI
G :AVH-X1690DVD/XNID

66
SYSPW

AVH-X1600DVD/XNUC
5 6 7 8
33
1 2 3 4

B INTERFACE PCB C DVD CORE UNIT


A
CN3601 FLASH ROM (16M x 2)
BEEP 1 BUZZER
3 BZ3631
IC1401
JA3731 CWW5043
WIREDAD WIREDAD 2
50
49
WIRED WIRED 3 WIRED
GND 1 REMOTE
IC1402
CWW5044

CN3661 RESET
12

ASENBO ASENBO
40 9
NTOSYS NAVI_TO_SYS
30 25
SYSTON SYS_TO_NAVI
29 24 SDRAM
IC1480
B M12L64164A-5TG2Y

MOTOR DRIVER
IC1251
BA5839FP
LECRGM 17 24
WHITE VO4+ OPINSL
LECRGP 18 23
GREEN VO4- OPOUTSL
CN1701

SPDLM 15 22
BLK VO3+ LDIN
ONSEI- ONSEI- SPDLP 16 21
27 14 RED VO3- CNT
26
ONSEI+ ONSEI+
13 NAVI DTV INTERFACE MUTE
9
GUIDEON GUIDEON 7
25 21 OPOUT1
A

TVON TVON 6
24 20 OPIN1-
DTVAG GNDAU 4
22 12 OPOUT2
DTVL CCAUL 3
21 10 OPIN2-
25
CSYNC CCSYNC OPOUT3
17 4 26
APPPUP MONON CN1101 OPIN3-
16 22 T+ 14 1
C 15
ANB CCB
3 1
F- 12
VO2+ VR
2
ANG CCG 2 VO1+ OPIN2+
13 2 F+ 11 5
ANR CCR 3 VO1- OPIN1+
11 1 T- 13 27
4 VO2- OPIN3+

JA3641
AUXAGND GND 2 Q1104 Q1102
6
AUXL AUXL 4 78LD
7 13
AUXR 3 AUX IN
AUXV VIDEO 1
9
Q1103 Q1101
65LD
14
JA3621
BCAMIN BCAMIN 2
2 TEMP
BACK CAMERA 6
F+H/G+H
BCAMGND 1 INPUT 10
E+G/E+F
11
B
16
D A
17
C
18
D
PU (DP11)

19
FE1
20
FE2
21

IMON VR1101
22

VR1102

RF
23

TC

Vref
8

VCC
9 VCC5

AVH-X1600DVD/XNUC
34
1 2 3 4
5 6 7 8

A
OM (16M x 2) SYSTEM uCOM ADAC
IC1501 IC1801
MN2DS0018MA PCM1753DBQ
1401 151 2
W5043 ADOUT DATA
150 3
LRCK LRCK
SRCK
149 1
BCK
CN1952
148 16 7 ANALOG LOUT
DACCK SCK VOUTL 14
57 13
1402 SDODAC
58 14
MD
W5044 SCKDAC MC
56 15
LTDAC ML
12
RESET

75 AMUTE
EXTRG1 23
RAM NRES
70 XRESET
22
1480 IRQPWR
48 IRQPWR
21
64A-5TG2Y 53 HSTCMD B
CMDCOMN 20
54 SLVSTS
STSCOMN 19
191 STANBY

CN751
STANDBY 18
R DRIVER 138 COMPOSITE
12
COMPOSITE
1251 144 D-
9
LOUT
839FP 146 D+
8
ROUT

A
24 67 152 IECOUT
IECOUT 6
OPINSL CRGDRV 47 SCL
23 I2C_SCL 4
OPOUTSL 46 SDA
22 62 I2C_SDA 3
LDIN LDIN 61 RESET
21 63 CP_Reset 2
CNT CONT1
9 64
MUTE CONT2
7 127
OPOUT1 FD
6
OPIN1- VCC5 REG. VD8 30
4 126
OPOUT2 TD IC1002 29
3
OPIN2- S-1133B50-U5
25 66
OPOUT3 MD 4 VD8
26 5 VIN 28
OPIN3- VCC5 VOUT 3
1 110 ON/OFF
VR
2
VHALF VD5 24 C
OPIN2+ VCC5-AU REG.
5
OPIN1+ IC1003
27
OPIN3+ S-1200B50-M5
1
5 VIN
VCC5_AU VOUT 3
ON/OFF
Q1104 Q1102
106
LPCO2 VCC33 REG.
IC1004
NJM2855DL1-33
Q1103 Q1101
104 3 1
LPCO1 VCC33 Vout Vin

122
TEMP
112 VCC12 REG.
F+H_G+H
111 IC1953
E+G_E+F
100
VIN3RF S-1135D12-A6
99 6
D
VIN4RF 1 VIN
98 VCC12 VOUT 4
VIN2RF ON/OFF
97
VIN1RF
115
VIN7
116
VIN8

VR1101 105
CDMPD

VR1102 103
DVDMPD
S1
HOME
96 65
RFINP HOME

IC1951
TC7SZU04FU S3
55
2 4 50 12EJ
USB_CLOCK
E
X1950
121
VDSENS VD8

48MHz
109
VREFH
113
VIN5
114
VIN6
117
VIN3
118
VIN4
119
VIN2
120
VIN1

AVH-X1600DVD/XNUC
5 6 7 8
35
1 2 3 4

D SERVICE UNIT(MONITOR)
A
CN5401

46
| R[0-5]
51
40
| G[0-5]
45
34
| B[0-5]
39

DIO
32
LD
52
HCLK
54
STV2
56
OEV
57
VCLK
58
POL
B 59

COMDC
Q5103
COMDC
60

G
LCD33
TEMPSENS
25

THERMISTOR 4 23
TH5201 VIN LX1
6 24
CE LX2
7
VFB
12
AMPOUT
LCD33 REG.
IC5102 CPVCC
20
MM3479A33P
4 5 22
C LCDPW
PWRVI
1
VDD VOUT LCD33 CPPSW Q5106
30 CE

LCD POWER 21
IC5101 CPP
R1290K103A
1 ILMB
2
A 3
CN1751 11 TPN33
26 PWRVI 17
CPPFB

5
VREF
DTC 10
Q5101 15
CPNFB ILMB
LPSYNC 13 19
29 RT CPN

BLSYSC
10
BLEN
9
DIMMER
8
BLERR
7

MTCHCK
16
MTCHDA
15
TPIRQN
14
E

REMIN
18
RST
19
KDT0
20
KDT1
21
Q5402
PWM_B
22
Q5401
23 PWM_R

PWM_G
24

AVH-X1600DVD/XNUC
36
1 2 3 4
5 6 7 8

TFT LCD
A
CN5001

30
|
35
36
|
41
42
|
47

DIO1 LCD
59
LOAD
29
HCLK 33.3MHz
23
STV2
17
OEV(Low)
15
VCLK
14
POL
11 B

Vcom
2
1

GRADATION VOLTAGE AVDD


27
26

48
VR[1-10] |
57

VDDG +18V
6
VEEG-6V
C
8

DVDD 3.3V
LCD33 22
L/R (Hi)
28
XON (Hi)
10

CN5202

Anode 1
B |
3
LCD BACKLIGHT DRIVER
IC5201
BD81A04EFV-M D
1
28
VCC OUTL
20
17
BACKLIGHT
CS OVP
5 13 K1
SYNC LED1 5
27 14 K2
EN LED2 6
8 15 K3
PMW LED3 7
9 16 K4
FAIL1 LED4 8
10
FAIL2

TOCH PANEL CONTROLLER


IC5301 CN5301
AK4187VN
1 8 XL
SCL XN 4
2
SDA YN
13 YB
3
TOUCH
4
PENIRQN YP
12 YT
1 PANEL E

CN5402
REM
10
RST
9
KDT0
8
KDT1
3

LEDB
6
1
LEDR
E
4 CN4801
LEDG
5

TPN33 7
F
ILMB 2

AVH-X1600DVD/XNUC
5 6 7 8
37
1 2 3 4

E SERVICE UNIT(KEYBOARD)
A
REMOTE CONTROL SENSOR
IC4801
CN4801 PNJ4833M
REM 1
2 VO
VCC
3
TPN33
5

KEY MATRIX
KDT0
4
D KDT1 S4801, S4802, S4803,
9 S4804, S4805, S4806, D4801
RST S4807, S4808, S4809
CN5402 3

LEDB
B 6
LEDG
7
LEDR
8
ILMB
10

AVH-X1600DVD/XNUC
38
1 2 3 4
5 6 7 8

5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A

RESET

VDD50 : pin 24 VDD50=3.3V?

bsens : pin 110 bsens=L?


B

asens : pin 111 asens=L?

socstb : pin 37
socstb=H? C

Standby
ASENBO : pin 100
ASENBO←H

DDCCLK←Clock Out D
DDCCLK : pin 65 (Frequency of 413.9 kHz)

VDCNT5 : pin 69
VDCNT5, VDCNT8←H
VDCNT8 : pin 70

Starts
Communication
with Display microcomputer
E

Source keys operate



Source ON

SYSPW : pin 66 SYSPW←H

AVH-X1600DVD/XNUC
5 6 7 8
39
1 2 3 4

5.2 INSPECTION METHOD OF PICKUP UNIT

A
Disc to be used
CD-DA : TCD-782
DVD-Video : TDV-582(GGV1025)

Exact judgment cannot be performed if the disk to be used has a crack and dirt.
Be careful of handling of a disk enough.

Execution method
Refer to the following page for the details of the check 1 and the check 2.
B

Replace the
START
CRG chassis

Please perform the


PU Lighting?
No usual diagnosis.
RF level check
Check1 Yes

LD current check
C
Check2
Replace the Error rate check
Is it OK?
No CRG chassis
Yes

Is it OK?
No
Yes

RF level check PICK UP Perform lens


D No cleaned? No cleaning
Yes Yes

Replace the
Check2 CRG chassis
Error rate check

Is it OK? PICK UP Perform lens


No cleaned? cleaning
No
Yes Yes

E Replace the
CRG chassis

Ckeck parts
other than PICK UP Finished

AVH-X1600DVD/XNUC
40
1 2 3 4
5 6 7 8

A
Check1 : LD current check

<Check>
Status: [Foucs closed] of TEST MODE
No. Disc Check Point Threshold Remarks: LD current
1 GGV1025 DVDLD1 - VCC5_PU 120 - 780 (mV) 10 - 65 (mA)

DVDLD1 B

C
VCC5_PU

No. Disc Check Point Threshold Remarks: LD current


2 TCD-782 CDLD1 - VCC5_PU 150 - 900 (mV) 10 - 60 (mA)
D

CDLD1

VCC5_PU

Notes: Please pay attention to the laser diode damage by static electricity.

AVH-X1600DVD/XNUC
5 6 7 8
41
1 2 3 4

A
Check : RF level

<Check>
ASMAX value shows the value of RF level.
Status: [Foucs closed] of TEST MODE

No. Disc Check Point Threshold Remarks

1 GGV1025 8 digits value of more than


ASMAX on display 0000 0B00
8 digits value of more than
2 TCD-782 0000 0E00
ASMAX on display
B

Check2 : Error rate check

<Check>
Status: [Tracking Closed] of TEST MODE
D
No. Disc Check Point Threshold Remarks

1 ID:40000 less than


GGV1025
1.000E-3

2 GGV1025 less than


ID:200000
1.000E-3
less than
3 TCD-782 ID:HOME Position 2.500E-3

AVH-X1600DVD/XNUC
42
1 2 3 4
LS2 BACK END section flow
Is VDD5
START (VCC33, VCC12)
power supply voltage OK?
Execute check 2.

Standby
Can the NO OK? NO
5

playback

5
Execute
start? check 1.

YES YES YES

Does the Is the Reset OK?


NO NO Is the image NO Is the iPod play NO USB play NO Is the sound
operation Execute
take time? in error? in error? in error? in error?
check 3.

YES YES YES YES YES YES


Is the
life of flash Is AVCC5 Is the iPod Is 48 MHz Is AVCC5 Is SDRAM Is VSENS
NO NO NO circuit OK? NO NO voltage OK? NO NO
memory OK? voltage OK? OK? IF OK? OK?
Conduct check Execute Execute Execute Execute Execute Execute
item 12. check 8. check 14. check 13. check 8. check 6. check 4.

YES YES YES YES YES YES YES

Go to FE Go to the Is VD8,
Is the video Is DACCLK VCC5 power Is 27 MHz
section check. NO circuit OK? product check. NO NO NO OK?
NO Is the USB normal? supply voltage OK?
Execute circuit OK? Execute Execute Execute
check 11. Execute check 9. check 7. check 5.

6
6

check 14.
5.3 DIAGNOSIS FLOWCHART

YES NO The product YES YES YES


is normal?(iPod YES
attestation IC) Is the audio Go to FE Replace the unit.
NO circuit OK? section check.
Replace the unit.
Execute
YES check 10.

Replace the unit. YES

Product repair

Go to FE
section check.

AVH-X1600DVD/XNUC
Repair the
defective part.

7
7

*1)Note *1) With service, even when exchange of a flash ROM


is required, please replace core unit .
(Since the key etc. are not written in in case of the
flash simple substance)
Normal?

YES Go to FE
section check.
END NO

Is FE section NO Go to FE related
normal? repair process.

YES

Replace the unit.

YES

Normal?
8

8
YES

END

43
E
A

D
C

F
B
1 2 3 4

Check 1: Standby OK?


A

<Check> Check the voltage at the “STANBY” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 STANBY - DGND1 ALL VCC33 - 0.6 V or more V

Side A
B

D
GNDD1

STANBY

Fig 1.1: STANBY check point

AVH-X1600DVD/XNUC
44
1 2 3 4
5 6 7 8

Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK?


A
IC1401 FLASH power supply (Data)
IC1402 FLASH power supply (Program)
VDD5 IC1004 VCC33 (= 3.3V ) IC1480 SDRAM power supply
3.3 V output regulator IC1501 DV5 power supply

IC1953 VCC12 (= 1.2V ) IC1501 DV5 power supply


1.2 V output Regulator

Fig 2.1: Power supply configuration


B

<Check> Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 VDD5_1 - DGND1 ALL 5.0 ± 0.4 V
2 VCC33_1 - DGND1 ALL 3.3 ± 0.033 V
3 VCC12_1 - DGND1 ALL 1.2 ± 0.015 V

Side A C

VCC12

VCC33

VD5-1

DGND1
Fig 2.2: VDD5, VCC33, VCC12 voltage check points

AVH-X1600DVD/XNUC
5 6 7 8
45
1 2 3 4

Check 3: Reset OK?


A

<Check> Check the voltage at the “XRES” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 NRES - DGND1 ALL VCC33 × 0.7 or more V

B
Side A

NRES
DGND1

Fig 3.1: RESET check point


E

AVH-X1600DVD/XNUC
46
1 2 3 4
5 6 7 8

Check 4: Is VSENS OK?


A
CN1952
HOST I/F
IC1501
VD8 R1004 VSENS DV5
R1007

VDD5 IC1004 VCC33


Regulator

B
IC1953 VCC12
1.2 V output
Regulator
STANBY
NRES

Fig 4.1: Power supply configuration and VSENS

C
<Check> Check the voltage at the “VSENS” test point while the power is on.
Use the “DGND1” test point at the reference.

No. Check point Module No. Specification value Unit


1 VSENS - DGND1 ALL 0.95 - 1.07 V
VD8 = 8.0 ± 0.4 V

Side A

VSENS

F
DGND1
Fig 4.2: VSENS check point

AVH-X1600DVD/XNUC
5 6 7 8
47
1 2 3 4

Check 5: 27 MHz Normal?


A
<Outline> Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501).

IC1501
DVD-LSI
X1501 OSCO
27 MHz
crystal OSCI

VCC33 VCC12
B
Fig 5.1: Clock configuration

<Check method> Turn the power on, and check with DGND being the reference.
In case of NG, check the applicable line, periphery of IC1501,
soldering of the peripheral components and defective components.
No. Check point Module No. Specification value Unit
2 IC1501 156pin - DGND1 ALL 27 MHz ± 50 ppm ppm

Specification
value

GND
Fig 5.2: Clock specification value

Side A
D

DGND1

F IC1501 156pin

Fig 5.3: 27 MHz check point

AVH-X1600DVD/XNUC
48
1 2 3 4
5 6 7 8

Check 6: Is SDRAM I/F OK?

<Outline> In order to secure the MPEG stream data as the buffer, A


the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit.
Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501,
namely NCSM, NWE, NCAS, NRAS.

IC1480 MA0 - 11 IC1501


MDQ0 - 15 DV5
SDRAM MCK
XWE(NWE)
XCAS(NCAS)
XRAS(NRAS)
XCSM(NCSM)
DQM0 B
DQM1
BA0
BA1

Fig 6.1: SDRAM I/F

<Check> Check the conductivity at “check point 1” and “check point 2” without power.
In case of NG, check the soldering and defective components throughout the
“output t input” of the applicable section.
C
No. Signal name Check point 1 Check point 2 Specification value
1 MA0 IC1480 23pin IC1501 201pin 56 ohm ± 5%
2 MA1 IC1480 24pin IC1501 203pin 56 ohm ± 5%
3 MA2 IC1480 25pin IC1501 207pin 56 ohm ± 5%
4 MA3 IC1480 26pin IC1501 209pin 56 ohm ± 5%
5 MA4 IC1480 29pin IC1501 208pin 56 ohm ± 5%
6 MA5 IC1480 30pin IC1501 206pin 56 ohm ± 5%
7 MA6 IC1480 31pin IC1501 202pin 56 ohm ± 5%
8 MA7 IC1480 32pin IC1501 200pin 56 ohm ± 5%
9 MA8 IC1480 33pin IC1501 198pin 56 ohm ± 5%
10 MA9 IC1480 34pin IC1501 194pin 56 ohm ± 5%
11 MA10 IC1480 22pin IC1501 199pin 56 ohm ± 5% D
12 MA11 IC1480 35pin IC1501 192pin 56 ohm ± 5%
13 MDQ0 IC1480 2pin IC1501 160pin 56 ohm ± 5%
14 MDQ1 IC1480 4pin IC1501 162pin 56 ohm ± 5%
15 MDQ2 IC1480 5pin IC1501 164pin 56 ohm ± 5%
16 MDQ3 IC1480 7pin IC1501 168pin 56 ohm ± 5%
17 MDQ4 IC1480 8pin IC1501 170pin 56 ohm ± 5%
18 MDQ5 IC1480 10pin IC1501 172pin 56 ohm ± 5%
19 MDQ6 IC1480 11pin IC1501 176pin 56 ohm ± 5%
20 MDQ7 IC1480 13pin IC1501 178pin 56 ohm ± 5%
21 MDQ8 IC1480 42pin IC1501 177pin 56 ohm ± 5%
22 MDQ9 IC1480 44pin IC1501 175pin 56 ohm ± 5%
23 MDQ10 IC1480 45pin IC1501 171pin 56 ohm ± 5% E
24 MDQ11 IC1480 47pin IC1501 169pin 56 ohm ± 5%
25 MDQ12 IC1480 48pin IC1501 167pin 56 ohm ± 5%
26 MDQ13 IC1480 50pin IC1501 163pin 56 ohm ± 5%
27 MDQ14 IC1480 51pin IC1501 161pin 56 ohm ± 5%
28 MDQ15 IC1480 53pin IC1501 159pin 56 ohm ± 5%
29 MCK IC1480 38pin IC1501 183pin 47 ohm ± 5%
30 XWE IC1480 16pin IC1501 181pin 56 ohm ± 5%
31 XCAS IC1480 17pin IC1501 188pin 56 ohm ± 5%
32 XRAS IC1480 18pin IC1501 189pin 56 ohm ± 5%
33 XCSM IC1480 19pin IC1501 190pin 56 ohm ± 5%
34 DQM0 IC1480 15pin IC1501 179pin 56 ohm ± 5%
35 DQM1 IC1480 39pin IC1501 180pin 56 ohm ± 5% F

36 BA0 IC1480 20pin IC1501 193pin 56 ohm ± 5%


37 BA1 IC1480 21pin IC1501 197pin 56 ohm ± 5%

AVH-X1600DVD/XNUC
5 6 7 8
49
1 2 3 4

Side A
A

Check point 1 (IC1480)

C
Check point 2 (IC1501)

Fig 6.2: SDRAM I/F check point

AVH-X1600DVD/XNUC
50
1 2 3 4
5 6 7 8

Check 7: Is VD8, VCC5 power supply voltage OK?


A

VD8_1 F.E. driver


system

VD8_2 VCC5 (= 5.0 V ) Power supply


REG IC
for PU
for VCC 5 V.

Fig 7.1: Power supply configuration


B

<Check> Check the voltage at the “VD8_P, VD8_A and VCC5_1” test point while the power is on.
Use the “PGND1 and AGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 VD8_P - PGND1 ALL 8.0 ± 0.4 V
2 VD8_A - AGND1 ALL 8.0 ± 0.4 V
3 VCC5_1 - AGND1 ALL 5.0 ± 0.05 V C

Side A

AGND1

VCC5_1

PGND1
VD8_A VD8_P

Fig 7.2: VD8, VCC5 voltage check points

AVH-X1600DVD/XNUC
5 6 7 8
51
1 2 3 4

Check 8: Is AVCC5 voltage OK?


A

IC1003 IC1801
VD8 AVCC5 (= 5.0 V )
REG IC
Audio-DAC
for AVCC 5 V.

Fig 8.1: Power supply configuration

<Check> Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus.
B
Check with PGND_3 and GNDAU1 being the reference.
No. Check point Module No. Specification value Unit
1 VD8_A - PGND_3 ALL 8.0 ± 0.4 V
2 AVCC5 - GNDAU1 ALL 5.0 ± 0.05 V

Side A

D PGND3

GNDAU1
AVCC5

VD8_A
E
Fig 8.2: VD8, AVCC5 voltage check points

AVH-X1600DVD/XNUC
52
1 2 3 4
5 6 7 8

Check 9: Is DACCLK normal?


<Outline> DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501). A

IC1501
X1501 DVD-LSI IC1801
DACCLK
27MHz Audio-DAC
crystal

VCC33 VCC12
Fig 9.1: Clock configuration
<Check method>
DVD: DVD-REF-A1 TITLE 1
CD: Playback a normal CDDA.
B
Common to all DVD-V compatible modules.
Check with DGND being the reference.
In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and
defective components.
No. Check point 1 (stylus) Media Specification value 1 Specification value 2 Specification value 3
1 DACCK DVD 2.0 V - VCC33V DGND - 0.8 V 36.8640 MHz ± 300 ppm
2 DACCK CD 2.0 V - VCC33V DGND - 0.8 V 33.8688 MHz ± 300 ppm
Specification
value 1

Specification C
value 2 Specification
value 3

GND
Fig 9.2: Clock specification value

Side A

DGND4 F
Check point 2 (IC1501 148 pin)

Fig 9.3: DACCLK check point

AVH-X1600DVD/XNUC
5 6 7 8
53
1 2 3 4

Check 10: Is the audio circuit OK?


A <Outline> The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio
signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1952).
Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F.
The digital audio signal (IECOUT), output from DVD-LSI (IC1501).

CN1952
HOST I/F
IC1501 IECOUT
DVD-LSI LRCK LO
ADOUT IC1801
SRCK Audio-DAC RO

B GNDAU

Fig 10.1: Audio circuit

<Check method> Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB),
and check with DGND1 being the reference.
In case of NG, check the applicable line, periphery of major components as described in the above drawing,
soldering of the peripheral components and defective components.
No. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform
1 ADOUT VCC33V - 0.6 V or higher 0.4 V or lower Waveform 1
2 SRCK VCC33V - 0.6 V or higher 0.4 V or lower Waveform 2
C 3 LRCK VCC33V - 0.6 V or higher 0.4 V or lower Waveform 3

Specification
Specification value 2
value 1
GND

Fig 10.2: Serial 3 lines specification value

Side A
D

DGND1
151pin ADOUT signal

F 150pin LRCK signal


149pin SRCK signal
Fig 10.3: Serial 3 lines check points

AVH-X1600DVD/XNUC
54
1 2 3 4
5 6 7 8

The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference.

47 kohm 47 kohm

LO GNDAU1 RO

No. Check point 1 (stylus) Specification value (rms) Reference waveform


4 LO 1400 ± 150 mV Waveform 4 B

5 RO 1400 ± 150 mV Waveform 4

Specification value is the root-mean-square value (rms).

Fig 10.4: Analog audio out (LO, RO) specification value.

C
Side A

GNDAU3 RO LO

Fig 10.5: Analog audio out check point

AVH-X1600DVD/XNUC
5 6 7 8
55
1 2 3 4

Check with DGND1 being the reference.


A
No. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform
6 IEC VCC33V - 0.6 V or higher 0.4 V or lower Waveform 5

Specification
value 2
Specification
value 1

10.6: Digital audio signal (IECOUT) specification value

Side A

IEC DGND1

Fig 10.7: Digital audio signal (IECOUT) check point

AVH-X1600DVD/XNUC
56
1 2 3 4
5 6 7 8

Check 11: Is the video circuit OK?


A
<Outline> Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the
HOST I/F (CN1952) via a buffer circuit.
CN1952
HOST I/F
IC1501
DVD_LSI

Video Composite COMPOSITE


DAC
section

Fig 11.1: Video circuit B

<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with
an oscilloscope with GNDV (stylus) being the reference. Set the trigger mode to “TV trigger” and
the trigger line to “150 line”.
No. Check point 1 (stylus) Specification value Reference waveform
1 COMPOSITE 1000 mVpp ± 5% Waveform 6
In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the
peripheral components and defective components.
PEAK C

COMPOSITE signal Reference


value
Color burst
Pedestal level
BOTTOM
Horizontal sync signal

Fig 11.2: Waveform for the case of composite white 100% output

Side A
D

F
GNDV2 COMPOSITE
Fig 11.3: VIDEO signal check point

AVH-X1600DVD/XNUC
5 6 7 8
57
1 2 3 4

Check 12:How to judge whether the flash memory has reached its life or not.
A
If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory
has reached its life.
Make judgment regarding the flash memory life by looking at the display of the LD power on time mode.

1. Let the LD energizing time displayed.


(Refer to the LD power on time mode for the method of displaying the LD energizing time.)
2. If the second digit from the left of the energizing time display is showing E,
such as “ E ”, it means that the flash memory has reached its life.

Example:
B

0E000BB8

AVH-X1600DVD/XNUC
58
1 2 3 4
5 6 7 8

Check 13: 48 MHz Normal?

<Outline> CLOCK of a USB circuit is made using the 48 MHz master crystal oscillator (X1950). A

IC1501
DVD-LSI
X1950
48MHz
crystal USB_CLOCK

VCC33 VCC12
Fig 13.1: Clock configuration

<Check method> Turn the power on, and check with DGND1 being the reference.
In case of NG, check the applicable line, periphery of IC1501,
soldering of the peripheral components and defective components.
No. Check point Module No. Specification value Unit
2 IC1501 50pin - DGND1 ALL 48 MHz ± 200 ppm ppm

Specification
value

GND
Fig 13.2: Clock specification value

Side A D

48 MHz

DGND1
F

Fig 13.3: 48 MHz check point

AVH-X1600DVD/XNUC
5 6 7 8
59
1 2 3 4

Check 14: Is USB Circuit OK?


A <Outline>
The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD.
USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK) in addition to D+ and D-.
CN1952
HOST I/F
IC1501 CP_RESET
DVD-LSI I2C_SDA
I2C_SCL
D+
D-

B
DGND

Fig. 14-1: USB Circuit

<Check Method>
1. USB Memory: Play a song from USB memory and check D+ and D- with the DGND1 standards.
2. iPod: Connect iPod and check CP_RESET, SDATA and SCLOCK with the DGND1 standards until the Pioneer log
appears. When iPod Touch or iPhone is connected, the logo is not displayed but only a check mark is displayed.
Play a song from iPod and check D+/D- with the DGND1 standards.
When it does not conform to the standards, check appropriate line, main parts shown in the above figure,soldering of
peripheral parts and malfunctions in parts.

C No. Checking spot (stylus) Standard value 1 Standard value 2


1 CP_RESET VCC33*0.7 or more
2 SDATA VCC33*0.7 or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod
3 SCLOCK VCC33*0.7 or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod
4 D+ VCC33*0.7 or more VCC33*0.3 or less
5 D- VCC33*0.7 or more VCC33*0.3 or less

Standard
Standard value 2
value 1

D Fig.14.2: USB Circuit Communication Wave

Side A

SDATA

CP_RESET

D- D+ SCLOCK DGND1

AVH-X1600DVD/XNUC
60
1 2 3 4
5 6 7 8

AUDIO

CH1 : LO A
CH1 : ADOUT3 CH2 : RO
Reference voltage:DGND2 1 V/div. 5 μsec/div Reference voltage:GNDAU2 2 V/div. 500 μsec/div

Gt

Gt
Gt

B
Waveform 1 Waveform 4

CH1 : SRCK CH1 : IECOUT


Reference voltage:DGND2 1 V/div. 1 μsec/div Reference voltage:DGND2 1 V/div. 500 nsec/div

Gt
Gt C

Waveform 2 Waveform 5

CH1 : LRCK
Reference voltage:DGND2 1 V/div. 5 μsec/div

Gt

Waveform 3

VIDEO

[WHITE 100IRE] E
CH1 : COMPO
Reference voltage:GNDV1 200 mV/div. 10 μsec/div

GNDV
F

Waveform 6

AVH-X1600DVD/XNUC
5 6 7 8
61
1 2 3 4

USB, IPOD
USB memory USB memory
A D+/D- communication waveform D+/D- communication waveform
It checks with an oscilloscope. It checks with an oscilloscope.
Reference voltage : DGND 1 ms/div 2 V/div Reference voltage : DGND 200 ns/div 2 V/div

D- D-

DGND DGND
DGND
DGND
D+ D+

B
Waveform 7 Waveform 8

IPOD IPOD
D+/D- communication waveform D+/D- communication waveform
It checks with an oscilloscope. It checks with an oscilloscope.
Reference voltage : DGND 1 ms/div 2 V/div Reference voltage : DGND 200 ns/div 2 V/div

D- D-

DGND DGND

C DGND DGND
D+ D+

Waveform 9 Waveform 10

IPOD
CP_RESET signal IPOD
A relation with NRES, At the time of RESET release SDA signal
(It checks with an oscilloscope. ) It checks by LECORY.
Reference voltage : DGND 20 ms/div 1 V/div Reference voltage : DGND 2 ms/div 1 V/div

CP_RESET

DGND SDA

NRES
DGND

DGND

Waveform 11 Waveform 12

IPOD
E
SCL signal
It checks by LECORY.
Reference voltage : DGND 500 μs/div 1 V/div

SCL

DGND

Waveform 13

AVH-X1600DVD/XNUC
62
1 2 3 4
5 6 7 8

5.4 ERROR CODE LIST


Generation source Method of reset
UART
Error status OSD *1 Meaning USB USB ACC Source Eject/
*2 Disc Play Key
(MSC) (iPod) Off/On Off/On With no device

Media Error UNPLAYABLE DISC 00h A disc containing the unplayable format only X - - X X X - A
INCOMPATIBLE DEVICE 00h USB device that doesn't correspond - X X X X X -

UNPLAYABLE FILE 00h USB device of format alone that cannot be reproduced - X - X X X -
Open (No display) 10h Door open error X - - * * * *
Read Error ERROR-02-99 20h Transfer start error X - - X X X X
Focus Error(Focus Error in
ERROR-02-90 21h Focus error X - - X X X X
mechanism set up)
Focus error during set up
Surface Error ERROR-02-9E 22h (A focus has never been achieved with that disc.) X - - - - X -
Address not found
(Invalid Track) ERROR-02-80 23h Address not found. X - - X X X X

Spindle Lock ERROR-02-91 24h Spindle lock NG(the disc cannot rotate) X - - X X X X
Carriage home NG
Carriage HOME ERROR-02-92 25h (The pick up tries to return to carriage home, X - - X X X X
but it cannot go back and stopped.)
ID/SUBCODE Read Error ID/SUBCODE Read Error (ID/SUBCODE cannot
ERROR-02-94 26h be read due to scratch or stain.) X - - X X X X
AV CHIP decode Error ERROR-02-9A 2Ah AV CHIP decode NG(AV chip cannot be decoded.) X X X X X X X B
AV CHIP Recovery NG ERROR-02-9B 2Bh AV CHIP recovery NG X X - X X X X
Error of PLAY BACK Playback state error
ERROR-02-9C 2Ch (An error due to software bug.) X X - X X X X
Mode Status
Disc Data Error ERROR-02-9D 2Dh Disc Data NG X - - X X X X
Temp Error(In Case of High temperature(Playback is stopped because the pick
THERMAL PROTECTION IN MOTION 30h up temperature is 89 C or higher.) X - - X - - -
High Temperature)
No Disc
(including Disc loading (No display) Disc has not been inserted.
40h (Including Load in process or Eject in process.) X - - * * * *
and ejecting)

(No display) Loading mechanism error


Loading_Mecha Error 50h (The disc cannot be clamped.) X X *11 X *11 X - X *12 -
Communication fault attesting iPod ERROR-02-60 60h Communication fault attesting iPod X *13 - X X - X *14 -
iPod authentication data is abnormal ERROR-02-61 61h iPod authentication data is abnormal X *13 - X X - X *14 -
iPod attestation retrying failure ERROR-02-62 62h iPod attestation retrying failure X *13 - X X - X *14 -
iPod attestation time out ERROR-02-63 63h iPod attestation time out X *13 - X X - X *14 -
Error when iPod is connected/ Error when iPod is connected/
It is generated STALL by the USB ERROR-02-64 64h It is generated STALL by the USB communication - - X X - X -
communication
Error setting iPod ERROR-02-65 65h Error setting iPod - - X X - X -
Demand timeout when Demand timeout when
initial is communicated ERROR-02-66 66h initial is communicated - - X X - X -
C
Protocol version Protocol version non-correspondence
non-correspondence ERROR-02-67 67h (It is necessary to Version Up the iPod by iTunes.) - - X X - X -
Timeout when protocol Timeout when protocol
version is judged ERROR-02-68 68h version is judged - - X X - X -
iPod does not have music.
No songs error (No display) 69h (It is necessary to put music into iPod by iTunes) - - X X - X -
iPod control forwarding/
Intarapta forwarding error ERROR-02-6A 6Ah iPod control forwarding / Intarapta forwarding error - - X X - X -
Demand timeout Demand timeout iPod's reproducing
iPod's reproducing ERROR-02-6B 6Bh - - X X - X -
Remote switch error ERROR-02-6C 6Ch Remote switch error - - X X - X -
Remote switch demand Remote switch demand timeout
timeout ERROR-02-6D 6Dh - - X X - X -
Demand timeout to an Demand timeout to an iPodApl(Pandora)
iPodApl(Pandora) ERROR-02-6E 6Eh - - X X - X -

DRM Error DRM error (All music cannot be played back due
PROTECTED DISC 70h to DRM.) X - - X X X -

NO ACCESSIBLE DATA AVAILABLE 70h DRM error (All music cannot be played back due
to DRM.) - X - X X X -
Region code NG (Unable to be played back due
Region code Error DIFFERENT REGION DISC 90h X - - X X X -
to incorrect mechanism region.)
D
CPRM*7 Key Error *8 UNPLAYABLE DISC 93h Key Error for playback X - - X - X -
REQUEST Error ERROR-02-A0 A0h REQUEST_error X - - X X X X
Failure in issuing read
command (chip dependent) ERROR-02-A1 A1h Failure in issuing the read command X - - X X X X
Adjustment of L0 is NG. ERROR-02-A2 A2h L0 adjustment is NG. X - - X X X X
Adjustment of L1 is NG. ERROR-02-A3 A3h L1 adjustment is NG. X - - X X X X
LD system NG ERROR-02-A4 A4h LD system NG X - - X X X X
Gain adjustment system NG. ERROR-02-A5 A5h Gain adjustment system NG. X - - X X X X
Gain determining system NG. ERROR-02-A6 A6h Gain determining system NG. X - - X X X X
Servo initial setting related items NG. ERROR-02-A7 A7h Servo initial setting related items NG. X - - X X X X
Disc is not clamped yet. ERROR-02-A8 A8h Disc is not clamped yet. X - - X X X X
Tracking system NG. ERROR-02-A9 A9h Tracking system NG X - - X X X X
Media setting system NG. ERROR-02-AA AAh Media setting system NG X - - X X X X
Focus Error ERROR-02-AB ABh JUMP over layers NG X - - X X X X
Error of PLAY BACK
ERROR-02-B0 B0h Navigation command error X - - X X X X
Mode Status
Error of PLAY BACK
ERROR-02-B1 B1h Retry over X - - X X X X
Mode Status
DivX DRM Inofrmation ERROR-02-C1 C1h DivX DRM inofrmation update error X - - X - - - E
Update Error *10
Error when MCS is connected/ Error when MCS is connected / It is generated
It is generated STALL by the USB ERROR-02-D0 D0h - X - - - X -
communication STALL by the USB communication
CBW and CSW forwarding error ERROR-02-D1 D1h CBW and CSW forwarding error - X - - - X -
Audio class band securing failure ERROR-02-D8 D8h Audio class band securing failure - - X X - X -
Audio class FS setting failure ERROR-02-D9 D9h Audio class FS setting failure - - X X - X -
Undefined Error ERROR-FF-FF FFh Undefined error X - - X X X X

X : Cancel the error by operation. - : Error is not cancelled by operation. * : No setting


*1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower
row is for the Touch Panel model and Full GUI (English version).
*2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits.
*7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card.
*8 DVD-VR model only.
*10 This occurs when the DRM information update notice is sent from the DVD mecha but no DRM information update response is returned.
*11 Although it is USB source, it notifies as an error of DISC source.
*12 Although it is USB source, iIt cancels only by Disc eject. F
*13 Although it is DISC source, it notifies as an error of USB source.
*14 Although it is DISC source, It cancels only without Device.

AVH-X1600DVD/XNUC
5 6 7 8
63
1 2 3 4

Error messages
A

Common
AMP Error This DivX rental has expired. Protect
This unit fails to operate or the speaker connection is The inserted disc contains expired DivX VOD con- All the files on the connected USB portable audio
incorrect; the protective circuit is activated. tent. player/USB memory are protected by Windows
Check the speaker connection. If the message Select a file that can be played. Media DRM 9/10.
fails to disappear even after the engine is Transfer audio files not protected by Windows
switched off/on, contact your dealer or an Video resolution not supported Media DRM 9/10 to the USB portable audio
authorized Pioneer Service Station for player/USB memory and connect.
The inserted disc contains a high definition DivX/
assistance. MPEG-1/MPEG-2/MPEG-4 file.
Select a file that can be played. Incompatible USB

Tuner The connected USB device is not supported by this


It is not possible to write it in the flash. unit.
B No Data Provided Connect a USB portable audio player or USB
This unit’s flash memory used as the temporary stor-
This unit cannot receive artist name/song title infor- memory that is USB Mass Storage Class
age area is full.
mation. compliant.
Select a file that can be played.
Move to the desirable location with good The USB device is not formatted with FAT12, FAT16
reception. or FAT32.
Your device is not authorized to play this DivX The connected USB device should be formatted
No Data protected video. with FAT12, FAT16 or FAT32.
This unit cannot receive program service name infor- This unit’s DivX registration code has not been au-
mation. thorized by the DivX VOD contents provider. Check USB
Move to the desirable location with good Register this unit to the DivX VOD contents The USB connector or USB cable has short-
reception. provider. circuited.
Check that the USB connector or USB cable is
Channel Locked not caught in something or damaged.
Locked by the radio Parental Control feature. Unplayable File The connected USB storage device consumes more
C Release the channel lock. This type of file cannot be played on this unit. than maximum allowable current.
Select a file that can be played. Disconnect the USB portable audio player/USB
memory and do not use it. Turn the ignition
DVD Format Read switch to OFF, then to ACC or ON and then
Different Region Disc Sometimes there is a delay between the start of play- connect a compliant USB portable audio player/
back and when you start to hear any sound. USB memory.
The disc does not have the same region number as
this unit. Wait until the message disappears and you hear
sound. Error-02-9X/-DX
Replace the DVD with one bearing the correct
region number. Communication failed.
Video frame rate not supported Perform one of the following operations.
Error-02-XX/FF-FF – Turn the ignition switch OFF and back ON.
DivX file’s frame rate is more than 30 fps.
– Disconnect the USB portable audio player/USB
The disc is dirty. Select a file that can be played.
memory.
Clean the disc.
– Change to a different source.
The disc is scratched. Audio Format not supported Then, return to the USB portable audio player/
D
Replace the disc. This type of file is not supported on this unit. USB memory.
The disc is loaded upside down. Select a file that can be played.
Check that the disc is loaded correctly. This DivX rental has expired.
There is an electrical or mechanical error. The inserted external storage device contains expired
Press RESET. External storage device (USB) DivX VOD content.
Unplayable File Select a file that can be played.
Unplayable Disc
This type of file cannot be played on this unit.
This type of disc cannot be played on this unit. Video resolution not supported
Select a file that can be played.
Replace the disc with one that can be played on The inserted external storage device contains a high
this unit. There are no songs.
definition DivX/MPEG-1/MPEG-2/MPEG-4 file.
Transfer the audio files to the USB portable audio
The inserted disc does not contain any playable files. Select a file that can be played.
player/USB memory and connect.
Replace the disc.
Security for the connected USB memory is enabled. It is not possible to write it in the flash.
E Protect Follow the USB memory instructions to disable
This unit’s flash memory used as the temporary stor-
security.
All the files on the inserted disc are embedded with age area is full.
DRM. Select a file that can be played.
Format Read
Replace the disc.
Sometimes there is a delay between the start of play-
Your device is not authorized to play this DivX
back and when you start to hear any sound.
Skipped protected video.
Wait until the message disappears and you hear
The inserted disc contains DRM protected files. sound. This unit’s DivX registration code has not been au-
Play an audio file not embedded with Windows thorized by the DivX VOD contents provider.
MediaTM DRM 9/10. Register this unit to the DivX VOD contents
Skipped
provider.
The connected USB portable audio player/USB
TEMP
memory contains WMA files that are protected by
Format Read
The temperature of the unit is outside the normal op- Windows Media TM DRM 9/10.
erating range. Play an audio file not embedded with Windows Sometimes there is a delay between the start of play-
Wait until the unit returns to a temperature MediaTM DRM 9/10. back and when you start to hear any sound.
F within the normal operating limits. Wait until the message disappears and you hear
sound.

AVH-X1600DVD/XNUC
64
1 2 3 4
5 6 7 8

A
Video frame rate not supported Error-8D Communication error occured. Please reconnect
DivX file’s frame rate is more than 30 fps. Built-in FLASH ROM encountered an error. your device.
Select a file that can be played. Turn the ignition OFF or ON. If there is no ACK after 10 attempted retries at
750 ms, the accessory should assume that commu-
Audio Format not supported Already stored nication is interrupted and disconnect from
This tag information is already stored in memory. PandoraLink.
This type of file is not supported on this unit.
Please reconnect your iPhone and try again.
Select a file that can be played. Tag information can only be saved once for any
given song. Tag information cannot be saved for
the same song more than once. Device has not been registered. Go to “ Bluetooth
Creating the Database has failed.
Connection Menu” to register.
The mode was switched to video or JPEG image dis-
No Bluetooth device found.
play while the database was being created.
Pandora R (UC) Follow the instructions that appear on the
Create the database again.
screen.
Error-19
Communication failed. B
Connection failed. Press “Connect ” to retry.
iPod Disconnect the cable from the iPod. Once the
Bluetooth connection failed.
iPod’s main menu is displayed, reconnect the
Format Read Follow the instructions that appear on the
iPod and reset it.
Sometimes there is a delay between the start of play- screen.
back and when you start to hear any sound. Start up the Pandora Application from your De-
Wait until the message disappears and you hear Disconnected. Press “ Connect ” to reconnect the
vice.
sound. device.
The Pandora application has not started running yet.
Bluetooth connection lost.
Start up the Pandora application from your
Error-02-6X/-9X/-DX Follow the instructions that appear on the
iPhone.
Communication failed. screen.
Disconnect the cable from the iPod. Once the Unable to save thumb rating. Try again later.
iPod’s main menu is displayed, reconnect the
Unable to save thumb rating.
iPod and reset it. Mirror Link
Try again later.
iPod failure. The application list could not be read out. C
Disconnect the cable from the iPod. Once the Unable to save Bookmark. Try again later. Failed to load the application list.
iPod’s main menu is displayed, reconnect the
Unable to save Bookmark. Disconnect the cable from the smartphone,
iPod and reset it.
Try again later. and then connect the smartphone again after a
few seconds.
Error-02-67
Pandora system maintenance. Try again later. Turn the ignition switch OFF and then to ACC
The iPod firmware version is old. or ON.
Pandora system is undergoing maintenance.
Update the iPod version. If the error message is still displayed after
Try again later.
performing the above action, reset the
Stop smartphone.
Skip limit reached.
There are no songs. If the error message is still displayed after
Skip limit reached.
Transfer songs to the iPod. performing the above action, please contact your
Do not exceed the skip limit. dealer or an authorized Pioneer Service Station.
There are no songs in the current list.
Select a list that contains songs.
This version of the Pandora Application is not There is no supported application on your Mirror- D
supported.
Not Found Link device.
This version of the Pandora application is not sup-
No related songs. No supported applications can be found.
ported.
Transfer songs to the iPod. Disconnect the cable from the smartphone,
Connect an iPhone that has a compatible and then connect the smartphone again after a
version of the Pandora application installed.
few seconds.
iTunes tagging (UC, EW5) Turn the ignition switch OFF and then to ACC
Check Device or ON.
iPod full. Tags not transferred.
Device error message displayed in the Pandora appli- If the error message is still displayed after
Memory used for tag information on the iPod is full. performing the above action, reset the
cation.
Sync the iPod with iTunes and clean up the Please check your iPhone. smartphone.
tagged playlist. If the error message is still displayed after
Pandora is unable to play music. Please see your performing the above action, please contact your
Memory full. Tags not stored. Connect iPod.
Device. dealer or an authorized Pioneer Service Station.
This unit’s flash memory used as the temporary stor-
Unable to play music from Pandora. E
age area is full. Communication error occurred.
Please check your iPhone.
The tag information on this unit is transferred to
There was a communication error.
the iPod automatically when an iPod is
Disconnect the cable from the smartphone,
connected. Please create station. Application on Device.
and then connect the smartphone again after a
No station found. few seconds.
Tag transfer failed. Reconnect your iPod. Create a station in the Pandora application on
Turn the ignition switch OFF and then to ACC
This unit’s tag information cannot transfer to the your iPhone.
or ON.
iPod.
If the error message is still displayed after
Check the iPod and try again. No Active Station
performing the above action, reset the
No station selected. smartphone.
Tag store failed. Select a station. If the error message is still displayed after
Tag information cannot be stored in this unit. performing the above action, please contact your
Try again. dealer or an authorized Pioneer Service Station.

AVH-X1600DVD/XNUC
5 6 7 8
65
1 2 3 4

A
Understanding auto EQ
Launching the application failed.
Failed to launch the application.
error messages
Disconnect the cable from the smartphone,
and then connect the smartphone again after a Please connect the microphone for
few seconds. measurement. When finished, please push
HOME key.
Turn the ignition switch OFF and then to ACC
The microphone is not connected.
or ON.
Plug the optional microphone securely into the
If the error message is still displayed after jack.
performing the above action, reset the
smartphone. Error. Please check xxxx speaker.
If the error message is still displayed after The microphone cannot pick up the measuring
performing the above action, please contact your tone of a speaker.
dealer or an authorized Pioneer Service Station. Confirm that the speakers are connected
B correctly.
Correct the input level setting of the power
USB connection was temporarily disabled for de- amp connected to the speakers.
vice protection. Do not connect this USB device Plug the microphone securely into the jack.
to the unit. To restart USB, restart the unit.
There is an over current error. Do not use this USB Error. Please check noise.
storage device. The surrounding noise level is too high.
Turn the ignition switch OFF and then to ACC or Stop your car in a place that is quiet, and
ON. switch off the engine, air conditioner and
heater.
If the error message is still displayed after
Set the microphone correctly.
performing the above action, please contact your
dealer or an authorized Pioneer Service Station. Error. Please check battery.
Power is not being supplied from the battery to
this unit.
Connect the battery correctly.
Check the battery voltage.
C

AVH-X1600DVD/XNUC
66
1 2 3 4
5 6 7 8

5.5 CONNECTOR FUNCTION DESCRIPTION

FM/AM ANTENNA INPUT AUDIO INPUT USB IF A

REARVIEW FRONT AUX INPUT REAR VIDEO WIRED


CAMERA INPUT REAR MONITOR INPUT REMOTE
SUBWOOFER VIDEO CONTROL
PRE-OUT OUTPUT

POWER SUPPLY NAVI INTERFACE


2 26
16 14 12 10 8 6 4 2
15 13 11 9 7 5 3 1 1 25

1 : CCR 10 : CCAUL 19 : GNDD (DSEN)


1. FR- 9. P. BRAKE 2 : CCG 11 : CCAUR 20 : TVON E
2. RR- 10. MUTE 3 : CCB 12 : GNDAU 21 : GUIDE ON
3. FR+ 11. B.REM 4 : CSYNC 13 : ONSEI+ 22 : MONON
4. RR+ 12. ILM 5 : GNDSIG 14 : ONSEI- 23 : IP5V
5. FL- 13. BGSENS 6 : HSYNC 15 : IPSDA 24 : SYS_TO_NAVI
6. RL- 14. ACC 7 : GNDD 16 : IPSCL 25 : NAVI_TO SYS
7. FL+ 15. GND 8 : VSYNC 17 : NC 26 : GNDD
8. RL+ 16. B.UP 9 : ASENBO 18 : NC (VCLK)

AVH-X1600DVD/XNUC
5 6 7 8
67
1 2 3 4

5.6 EEPROM OPERATION EXPLANATION FOR iPhone 5

Operation Description of EEPROM for iPhone 5


A

The operation of EEPROM that provides a video output setting value to the iPhone 5 upon connection to the iPhone 5 is
described below.
2012 AVH models 2013 AVH models
(AVH-X1500DVD, X2500BT, X3500***, (AVH-X1600DVD, X2600BT, X3600***,
X4500DVD, X5500BT series) X4600DVD, X5600BT series)

EEPROM
embedded
IC3661 in the product
EEP
ROM

EEPROM
embedded
EEP in the cable
ROM

Changed

Lightning to VGA Adapter Lightning to VGA Adapter


(Apple Inc. products) (Apple Inc. products)
(sold separately) (sold separately)
D

iPhone 5 iPhone 5

Operation flow of 2013 AVH models after connecting to the iPhone 5

EEPROM [IC3661] iPhone 5

Turned on upon reception of 5V Supplies 5V to IC3661 of the product


from the iPhone 5
Initial communication
Initial communication

Provides a video output setting value


F to the iPhone 5 Outputs a video signal to the product upon
reception of the video output setting value

AVH-X1600DVD/XNUC
68
1 2 3 4
5 6 7 8

6. SERVICE MODE
6.1 MONITOR TEST MODE
MONITOR TEST MODE MENU SCREEN A

Method for Mode IN


While pressing [Mute] + [Reverse] key, restart the system.

Display specification

Operational description Remote controller key


Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band

AVH-X1600DVD/XNUC
5 6 7 8
69
1 2 3 4

1. Version Information
Method for Mode IN
A

While pressing [Mute] + [Reverse] key, restart the system.


Choose “1. Version Information” among the Monitor Test Menu screen.

Display specification

Page: 1

<Navi>
When Navi is connected : Connect
When Navi is not connected : -
<EEPRM>
C
When set value initialization is performed normally : Init OK
When set value initialization is not performed normally : -
<Eject Lock>
When Eject Lock is on : ON
When Eject Lock is canceled : OFF

Operational description Remote controller key


Return to test mode menu RETURN
Page up NEXT
Page down PREV

Page: 2 Page: 3
D

Page: 4 Page: 5

AVH-X1600DVD/XNUC
70
1 2 3 4
5 6 7 8

2. Touch Panel Test


Method for Mode IN A

While pressing [Mute] + [Reverse] key, restart the system.


Choose “2. Touch Panel Test” among the Monitor Test Menu screen.

Display specification

Top menu

Condition that the mark meaning adjustment is completed, (*) is lit


(the mark is lit when any of one condition is satisfied)
Outermost circle check -1 C
When “Outermost circle check of line calibration-1” is finished normally
When “Outermost circle check of line calibration-2” is finished normally
-> Since “Outermost circle check of line calibration-2” includes “Outermost circle check of line calibration-1.”
Outermost circle check -2
When “Outermost circle check of line calibration-2” is finished normally
Calibration check
When “Calibration check of line calibration” is finished normally

Condition that the mark meaning adjustment is completed, (*) is extinguished


(the mark is extinguished when any of one condition is satisfied)
Outermost circle check -1
When “conditions that the mark is lit” are not satisfied D
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Outermost circle check -2
When “conditions that the mark is lit” are not satisfied
When “Outermost circle check of line calibration-1” is finished abnormally
-> Since “Outermost circle check of line calibration-2” includes “Outermost circle check of line calibration-1.”
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Calibration check
When “conditions that the mark is lit” are not satisfied
When “Data Initialize is executed”
E
When “EEPROM initialize is executed”
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band

AVH-X1600DVD/XNUC
5 6 7 8
71
1 2 3 4

1. Effective Area Calibration - 1

A Outermost circle check screen

First point Second point

Operational description Remote controller key


Check is interrupted Band

Outermost circle check result screen

Finished normally Finished abnormally

Operational description Remote controller key


D Check is finished Band

2. Effective Area Calibration - 2

Outermost circle check screen

First point Second point

AVH-X1600DVD/XNUC
72
1 2 3 4
5 6 7 8

3rd point 4th point

Operational description Remote controller key B


Check is interrupted Band

Outermost circle check result screen

Finished normally Finished abnormally

Operational description Remote controller key


Check is finished Band

3. 16 Point Calibration D

Calibration check screen

Touch the cursor [+] displayed on the screen. By touching it correctly, it disappears and another cursor appears.
By repeating this action 16 times, obtain calibration value of each [+].
When touching the last 17th cursor, calibration values at 16 points and information of normal finish in 17 bytes
are written in EEPROM and the screen returns to TOP menu by pressing a key.

AVH-X1600DVD/XNUC
5 6 7 8
73
1 2 3 4

Operational description Remote controller key


B Return to top menu Band

Calibration check result screen

Operational description Remote controller key


Return to top menu Band

4. Touch Panel Coordinates Test


D

[+] is displayed at a touched place.


(Two [+] are displayed by touching two places.)

Operational description Remote controller key


Return to top menu RETURN

AVH-X1600DVD/XNUC
74
1 2 3 4
5 6 7 8

5. Calibration Test

Calibration confirmation screen A

Touch the cursor [+] displayed on the screen. By touching it correctly, it disappears and another cursor appears.
Otherwise, the cursor is displayed in red.
Repeating this action for 4 points and by pressing the last 4th point, “O.K.” is displayed.

Operational description Remote controller key


Return to top menu RETURN

Calibration confirmation result screen


D

Operational description Remote controller key


Return to top menu RETURN

AVH-X1600DVD/XNUC
5 6 7 8
75
1 2 3 4

6. Data Initialize

B
Condition that the mark meaning adjustment is completed, (*) is lit
(the mark is lit when any of one condition is satisfied)
Outermost circle check
When “Outermost circle check of line calibration-1” is finished normally
When “Outermost circle check of line calibration-2” is finished normally
Calibration check
When “Calibration check of line calibration” is finished normally
Outermost circle check of user calibration
When “Outermost circle check of user calibration” is finished normally
User calibration check
When “Calibration check of user calibration” is finished normally
C
Condition that the mark meaning adjustment is completed, (*) is extinguished
(the mark is extinguished when any of one condition is satisfied)
Outermost circle check
When “conditions that the mark is lit” are not satisfied
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Calibration check
When “conditions that the mark is lit” are not satisfied
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Outermost circle check of user calibration
D When “conditions that the mark is lit” are not satisfied
When “Data initialize is executed”
When “EEPROM initialize is executed”
When Outermost circle check of line calibration or 16-point adjustment is finished
normally after Outermost circle check of user calibration is finished normally
User calibration check
When “conditions that the mark is lit” are not satisfied
When “Data initialize is executed”
When “EEPROM initialize is executed”
When Outermost circle check of line calibration or 16-point adjustment is finished
normally after 16-point adjustment of user calibration is finished normally
E
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band

AVH-X1600DVD/XNUC
76
1 2 3 4
5 6 7 8

3. EEPROM Adjustment
Method for Mode IN A

Choose “3. EEPROM Adjustment” among the Monitor Test Menu screen.

Display specification

Top menu

Operational description Remote controller key


Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
C

1. Flicker Adjustment

1 dot stripe image of black and gray (50% white) will appear.
Adjust the number to minimize the flicker.

< Flicker Adjustment >

Flicker adjustment image (lattice)


D

COM DC

Operational description Remote controller key


Return to top menu RETURN
-1 REV
+1 FF

Following items in EEPROM Adjustment menu are not used on service.

AVH-X1600DVD/XNUC
5 6 7 8
77
1 2 3 4

4. EEPROM Initialize
Method for Mode IN
A

Choose “4. EEPROM Initialize” among the Monitor Test Menu screen.

Display specification

Confirmation screen

Operational description Remote controller key


Return to test mode menu RETURN
Selection cursor left movement REV
Selection cursor right movement FF
Menu enter Band
C

AVH-X1600DVD/XNUC
78
1 2 3 4
5 6 7 8

5. Display Test
Method for Mode IN A

Choose “5. Display Test” among the Monitor Test Menu screen.

Display specification

Top menu

Operational description Remote controller key


Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
C

1. RGB

RGB is plotted in the following pattern:


R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Magenta:100% -> Magenta:50% -> Cyan:100% ->
Cyan:50% -> Yellow:100% -> Yellow:50% -> Black -> Gray -> White -> Green & Magenta dot signal
(The display of the screen will be changed in 1 second.)

R: 100%

E
Operational description Remote controller key
Return to test mode menu RETURN
Stop / restart of auto display Band

AVH-X1600DVD/XNUC
5 6 7 8
79
1 2 3 4

2. Monochrome Stripe

Display of monochrome stripe signals.


A

Monochrome stripe (Vertical)

Operational description Remote controller key


Return to test mode menu RETURN
Pattern change Band

3. Color Bar

C Display of color bar signals.

Color bar (Vertical)

Operational description Remote controller key


Return to test mode menu RETURN
Pattern change Band

AVH-X1600DVD/XNUC
80
1 2 3 4
5 6 7 8

4. Ramp & 10step

Display of step signals and signals for alpha blend check. A

Right-white 64step

Alpha blend set value


(in hexadecimal)

Operational description Remote controller key


Return to test mode menu RETURN
Alpha blend Up (+0x10) Up
Alpha blend Down (-0x10) Down
Alpha blend Up (+0x01) FF
Alpha blend Down (-0x01) REV
Pattern change Band

5. Raster Signal

Display of signals for step confirmation.

White 0%

Operational description Remote controller key


Return to test mode menu RETURN
Pattern change Band
E

AVH-X1600DVD/XNUC
5 6 7 8
81
1 2 3 4

6. Contrast

Display of Black / White signals.


A

Black

Operational description Remote controller key


Return to test mode menu RETURN
Pattern change Band

7. Center Marker

C Display of signal for screen central location setting.

Center marker

Operational description Remote controller key


Return to test mode menu RETURN

AVH-X1600DVD/XNUC
82
1 2 3 4
5 6 7 8

6. Rear Video Output Test


Method for Mode IN A

Choose “6. Rear Video Output Test” among the Monitor Test Menu screen.

Display specification

On this Rear Video Output Test mode, test signals appear only on the rear video output terminal.

Top menu

Operational description Remote controller key


Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down C
Menu enter Band

1. RGB

RGB is plotted in the following pattern:


R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Black -> Gray -> White signal
(The display of the screen will be changed in 1 second.)

R: 100%
D

Operational description Remote controller key


Return to test mode menu RETURN
Stop / restart of auto display Band

AVH-X1600DVD/XNUC
5 6 7 8
83
1 2 3 4

2. Color bar

Display of color bar signals.


A

Color bar (Vertical)

Operational description Remote controller key


Return to test mode menu RETURN

3. Ramp & 10step


C
Display of step signals and signals for alpha blend check.

Right-white 64step

Operational description Remote controller key


Return to test mode menu RETURN
Alpha blend Up (+0x10) Up
Alpha blend Down (-0x10) Down
Alpha blend Up (+0x01) FF
Alpha blend Down (-0x01) REV
E
Pattern change Band

AVH-X1600DVD/XNUC
84
1 2 3 4
5 6 7 8

4. Raster Signal

Display of signals for step confirmation. A

White 0%

Operational description Remote controller key


Return to test mode menu RETURN
Pattern change Band

5. Center Marker
C
Display of signal for screen central location setting.

Center marker

Operational description Remote controller key


Return to test mode menu RETURN

AVH-X1600DVD/XNUC
5 6 7 8
85
1 2 3 4

6. Multiburst

Display of multiburst signal.


A

Multiburst

White Gray Stripe Gray Stripe Gray Stripe Gray Stripe Gray Stripe Gray
94dot 30dot 9dot width 30dot 4dot width 30dot 3dot width 30dot 2dot width 30dot 1dot width 30dot

Operational description Remote controller key


Return to test mode menu RETURN

AVH-X1600DVD/XNUC
86
1 2 3 4
5 6 7 8

6.2 DVD TEST MODE

The service test mode is used to check functions in fault diagnosis by a serviceman in case of any defect found in the A
DVD mecha.
This mode is enabled only when the test mode is activated. At this time, no normal operation is executed.

1. Outline
The service test mode is used to check functions in fault diagnosis by a serviceman in case of any defect found in the
DVD mecha. No general user goes into this mode.
The mode is implemented mainly to check the FE part. It is originally the test mode at the FE part implemented in the
PC communication, which is modified to allow implementation in the HOST communication.
The command for the test mode received in the HOST communication is interpreted by the application part, converted
to the PC communication command and transferred to the OS.
The OS transfers this command to the PC task as if it received the command in the PC communication.
The execution result is noticed to the application part by an e-mail instead of the PC communication. B
The application part then transmits the result in the HOST communication to display OSD.

2. Conditions for operation


(1) This service test mode is enabled only when the test mode is activated. At this time, no normal operation is executed.

3. To enter the test mode.


(1) [MUTE] key + [FORWARD] key -> Turn on BUP and ACC.
(2) DVD SOURCE -> ON
(3) Execute the test mode using each key.

Display on function flow Operation Key C

(0) -
(1) +
(2) MUTE
(3) MENU
(4) TOP MENU
(5) AUDIO
(6) SUB TITLE
(7) ANGLE
(8) RETURN
UP D
DOWN
EJECT EJECT
SOURCE SRC

AVH-X1600DVD/XNUC
5 6 7 8
87
1 2 3 4

Image of the test mode.


Legend: … Key operation
A … Operation state

Start of the test mode. … The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.

TEST [Note] Higher level 4 characters only. Lower level 4 characters are spaces.

(1) (2) (3) (4) (5)


LD power on time Simple FE
FE test selection EDC1 test selection EDC2 test selection mode selection test mode

Hereafter, to FE test Hereafter, to EDC1 Hereafter, to EDC2 Hereafter, to LD power on Hereafter, to simple
mode image. test mode image. test mode image. time mode image. FE test mode.

[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.

Image of the front end test mode. Legend: … Key operation


… Operation state
… The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.
FE test mode

0X00 0000

(1) (2) (3) (4) (5) EJECT


Power on Disc type DVD1 Disc type DVD2
FE offset coefficient Disc type CD Disc type CD-RW EJECT
TE offset coefficient layer layer
0FFF 0000
AS offset coefficient
ENV offset coefficient
TG offset coefficient 0000 0000 0100 0000 0200 0000 0300 0000
DBAL coefficient
C VIN1 offset cancel value
VIN2 offset cancel value
VIN3 offset cancel value
VIN4 offset cancel value
VIN5 offset cancel value
VIN6 offset cancel value
VIN7 offset cancel value
VIN8 offset cancel value
VIN9 offset cancel value

1X00 0000

(1) (2) (3),(4) (5) (6) (7) (8)

F search CRG+/- LD-ON/OFF CRG_HOME CRG_OUTSIDER Power_OFF


F close
S curve
measurement
1FFF 0000 Activates while the key When LO-ON : 1100 0000 1D00 0000 1E00 0000
1A00 0000 When LD-OFF : 1000 0000
is being pressed.
(2) 1B00 0000 : CRG+
1C00 0000 : CRG-
F search STOP
[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically.
D If F close is selected during LD-OFF, it will become an error.
1100 0000 During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected
within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds.
In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again
Focus close state before F close.
FEMAX level
FEMIN level
ASMAX level
ENVMAX level
FE normalization coefficient
Spindle gain coefficient
TEMAX level indication
TEMIN level indication
(2)

2x00 0000

(1) (2) (3),(4) (8)


Tracking balance Focus Jump CRG+/- Power_OFF

When L0 layer : 2000 0000 It operates while the key


2FFF 0000 When L1 layer : 2100 0000 is being pressed.
E 2B00 0000 : CRG+
TBAL coefficient (layer 0) 2C00 0000 : CRG-
TBAL coefficient (layer 1)
TE normalization coefficient (layer 0)
TE normalization coefficient (layer 1)
Off track adjustment result

3000 0000

(1) (3),(4) (5) (8)


Tracking close CRG+/- RF level value Power_OFF

3FFF 0000 It operates while the key 3FFF 0000


is being pressed.
3B00 0000 : CRG+
3C00 0000 : CRG- Tracking close state FBAL coefficient (layer 0)
FBAL coefficient (layer 1)
Focus gain coefficient (layer 0)
Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
AS normalization adjustment value (layer 0)
F

A B C

AVH-X1600DVD/XNUC
88
1 2 3 4
5 6 7 8

A B C
A
5000 0000

(1) (2) (7) (8)


RF level value Error rate
indication start measurement T.OPEN Power_OFF

Error rate
RF level is informed Focus gain coefficient (layer 0) To (2)
every 500msec. Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
(1) AS normalization adjustment value (layer 0)
RF level value AS normalization adjustment value (layer 1)
indication end

FBAL coefficient (layer 0)


Tracking close state FBAL coefficient (layer 1)
Focus gain coefficient (layer 0)
Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
AS normalization adjustment value (layer 0) B
4000 0000

4x00 0000

(1) (2) (5) (6) (3),(4) (7) (8)


Error rate Playback speed T.Jump+/- Power_OFF
measurement switching Focus Jump ID Search T.OPEN

Error rate Jump+ : 4B00 0000


Focus gain coefficient (layer 0) When L0 layer : 4x00 0000 4A00 0000 Jump- : 4C00 0000 To (2)
DVDX1.3 -
Focus gain coefficient (layer 1) When L1 layer : 4x00 0000
Tracking gain coefficient (layer 0) 1.6CAV (3)
(1)-(4)
Tracking gain coefficient (layer 1) CDX4CLV: ID Track number
AS normalization adjustment value (layer 0) 4x00 0000 designation designation
AS normalization adjustment value (layer 1)

ID display Track number


indication The higher 2 digits of the designated ID are the value showing the test state.
(5) (5) The lower 6 digits show the ID.
Search Jump Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.
L0 layer DVD X CAV,CD X 2CLV :4000 0000 start start
L0 layer DVD X 1CLV,CD X 1CLV :4200 0000 C
Error occurrence L1 layer DVD X CAV :4100 0000
L1 layer DVD X 1CLV :4300 0000
V Change The number for designation of the track number shall be selected from the track numbers previously prepared.
V Switch to cyclic by (3). Fix by (4).
L0 layer DVD X 1.3 - 1.6CAV, CD X 4CLV :4000 0000 For CD: Tracks 1, 4, 10, 11 and 32
Error display
L0 layer DVD X 1CLV :4200 0000 For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100
L1 layer DVD X 1.3 - 1.6CAV :4100 0000
(8) L1 layer DVD X 1CLV :4300 0000 Change the method for ID address designation.
Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).
Power_OFF

Error occurrence at Power_OFF

[Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again.

Error display

AVH-X1600DVD/XNUC
5 6 7 8
89
1 2 3 4

EDC. Image of the test mode Legend: … Key operation


… Operational state
A … The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.

EDC1/2 test mode [Note] Image is the same for both EDC1 and EDC2.

0000 0000

(1) (2) [Note] Eject can be effected any time during the
EJECT operation
EDC test mode.
Layer 0 selection Layer 1 selection

Eject
0000 0000 0100 0000 Test mode Eject

B 1003 0000 1103 0000


After completion of EJECT operation

(1)-(4)
ID designation

Layer 0:10** ****


Layer 1:11** ****
[Note] ** **** is the ID designation value

(5)
EDC1/2 start

Layer 0:20** ****


Layer 1:21** ****
[Note] ** **** is the present ID designation value
C
**** ****
[Note] **** **** is the present ID designation value
[Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.

Image of the LD power on time mode.

Legend: … Key operation


… Operational state
D LD power on time mode
… The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.
0000 0000

(1) (2) (5) (6)


CD LD power on DVD LD power on CD LD power on DVD LD power on
time indication time indication time setting time setting

10** **** 20** ****


[Note] ** **** is the CD LD [Note] ** **** is the DVD LD 30** **** 40** ****
power on time. power on time. [Note] ** **** is the setting time. [Note] ** **** is the setting time.

(1)-(4) (1)-(4)
Setting time (8) Setting time (8)
designation designation
(5)
(5)
E
Setting time Setting time
registration registration

10** **** 20** ****


[Note] ** **** is the CD LD
[Note] ** **** is the DVD LD
power on time.
power on time.

[Method of setting time designation]


Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4).
Fix by command (5). Cancel by command (8).

[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours.
[Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.

AVH-X1600DVD/XNUC
90
1 2 3 4
5 6 7 8

Simple test mode

The selection of the figure of each screen can be selected by "Key command for the test".
A

<Flow chart>
TEST MODE

1: LD ON
2: ASMAX
3: Skew Adjustment
4: Error Rate
5: CRG Move Outer
6: Eject

Please Input Number

LD ON LD ON LD ON
1 select B
1: DVD Single Layer LD ON 1: Power OFF
2: DVD Dual Layer select Completion select
5 Return 3: CD
select 4: CD-RW
5: Return

Please Input Number Now Running Please Input Number

2 select ASMAX ASMAX ASMAX

1: DVD Single Layer ASMAX 1: Power OFF


2: DVD Dual Layer select value set select
5 Return 3: CD
select 4: CD-RW
5: Return ASMAX Level : 000000 ASMAX
Level display
Please Input Number Now Running Please Input Number

Skew Adjustment Skew Adjustment Skew Adjustment


3 select
1: DVD Single Layer
select
value set
RF Level
1: Power OFF C
select
5 Return
select RF Level
5: Return RF Level : 000000 display
Update 500 msec.
Search ID
Please Input Number Now Running 0x00100000 Please Input Number

*1 *1
4 select Error Rate Error Rate Error Rate - Inner Error Rate - Inner

1: DVD Single Layer DVD 1: Inner Measurement Error Rate 1: Power OFF
select 2: Outer Measurement select set select
5 Return 3: CD 3: Middle Measurement
select
5: Return 5: Return Error Rate : 000000
5 Return
select
Please Input Number Please Input Number Search ID Now Running Please Input Number
inner :
0x00040000 *1 : The position in which Error Rate
outer :
0x00200000 select was done is display
*1
Error Rate - CD displayed.
Error Rate -CD
DVD Inner
CD select DVD Outer D
DVD Middle
CD CD

Now Running
Search CRG
home position

5 select CRG Move Outer CRG Move Outer CRG Move Outer

1: DVD Single Layer CRG Move 1: Power OFF


2: DVD Dual Layer select Completion select
5 Return 3: CD
select 4: CD-RW
5: Return CRG moves
to the most
Please Input Number Now Running Please Input Number
outer

<Error>
ERROR

1: Power OFF select E

Code : 00000000

Please Input Number

<Error : Power OFF>


ERROR

Code : 00000000

Please Reset

AVH-X1600DVD/XNUC
5 6 7 8
91
1 2 3 4

7. DISASSEMBLY
While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.
A

Removing the Monitor Assy (Fig.1)

1 Remove the four screws (5 mm length). 1 1

2 Release the six latches.

3 Disconnect the connector and then remove


B the Monitor Assy. 1
1

Monitor Assy
2 2

2 2

2 2
Fig.1

Removing the Service Unit (Monitor) (Fig. 2) Service Unit (Monitor)

1 Disconnect the four connectors. 2 2

2 Remove the four screws and then remove


the Service Unit (Monitor). 1 1
2
1
2 1

Fig.2

Removing the Service Unit (Keyboard) (Fig.3) Holder(1) Service Unit (Keyboard)
E

Remove the the Holder(1).

1 1
1 Release the seven latches and then remove
the Holder(2).

Remove the Service Unit (Keyboard).


1

Note) 1
With this model, the Cushion of Touch
F Panel was attached using a jig in the 1 1 1
factory line. Holder(2)
Fig.3

AVH-X1600DVD/XNUC
92
1 2 3 4
5 6 7 8

Removing the DVD Mechanism Module (Fig.4) A

1 Remove the four screws (6 mm length). DVD Mechanism Module

1
2 Disconnect the connector and then remove
the DVD Mechanism Module.

DVD Mechanism Module 1

1 1

Bracket
2
Attention at assembly)
When installing the DVD Mechanism Module,
pulling the side Bracket to the DVD
Mechanism Module, tighten the screws. C
Put the dowels of the DVD Mechanism
Module in the slits of the side Bracket
securely.

Attention of removing
Don’t remove this screws excluding the
dismantlement of the DVD Mechanism
Module.

Fig.4 D

Removing the Heat Sink and the Holder (Fig.5)

Heat Sink Holder


1 Remove the two screws.

2 Remove the two screws (6 mm length) and 2 2


then remove the Heat Sink and the Holder.

E
1 1

Fig.5

AVH-X1600DVD/XNUC
5 6 7 8
93
1 2 3 4

Removing the Service Unit (Mother I/F) (Fig.6)


A

Service Unit (Mother I/F)


1 Remove the two screws (6 mm length).

1 1
B

2 Loose the four screws (5 mm length).

3 Remove the three screws (5 mm length)


and then remove the Service Unit
(Mother I/F).

3 3 3

2 2 2 2

Service Unit Holder Service Unit Holder

Note)
Remove the Service Unit Holder with tweezers.
If forcefully removed, it may be deformed.

Attention at assembly)
E When you assemble the Service Unit Holder and the Bracket,
the Claw enters the hole.
They are hardly separated, so pay attention to the deformation.

The Service Unit Holder should contact the Bracket.


F

Fig.6

AVH-X1600DVD/XNUC
94
1 2 3 4
5 6 7 8

Removing the Interface PCB and the Mother PCB (Fig.7) A

1 Disconnect the connector.


Interface PCB

2 Remove the three screws and then remove


the Interface PCB.
2
3 Straighten the tab at location indicated.
2 2
1

4 Remove the three screws and then remove


the Mother PCB. 4 B
4

3
4
Mother PCB
C

Fig.7

AVH-X1600DVD/XNUC
5 6 7 8
95
1 2 3 4

8. EACH SETTING AND ADJUSTMENT


8.1 DVD ADJUSTMENT
A

This product uses 5 V and 3.3 V as standard voltages.


The electrical potential that is the reference for signals, is not GND, but VREF (approximately 2.2 V) and VHALF
(approximately 1.65 V) .
During product adjustments, if the reference voltage is mistakenly taken as GND, and a grounding contact is made,
not only would it be impossible to measure the accurate electrical potential, but also the servo motor
would malfunction, resulting in the application of a strong impact on the pick up.
The following precautionary measures should be strictly adhered to, in order to avoid such problems.
The reference voltage and GND should not be confused when using the minus probe of a measurement device.
B
When an oscilloscope is being used special care should be taken to make sure that the reference voltage is not
connected to the probe of ch1 (on the minus side), while the probe of ch2 (on the minus side), is connected to GND.
Further, since the body frame of most measurement devices have the same electrical potential as the minus side of
the probe, the body frame of the measurement device should be set to floating ground.
If the reference voltage is connected to GND by mistake, turn the regulator OFF immediately, or turn the power OFF.

Remove the filters and wires used for measurements only after the regulator has been turned OFF.
After the power supply is turned on, regulator ON the following adjustment and measurement are promptly done.
Whenever the product is in the test mode, the software will not take any protective action. For this reason, special
care should be taken to make sure that no mechanical or electrical shock could be applied to the product when
taking measurements in the test mode.
C Whenever the EJECT key is pressed to eject the disk, no other keys, other than the EJECT key, should be pressed
until the disk eject action has been completed.
Press the EJECT key only after the disk has stopped completely.
If the product hangs up turn the power OFF immediately.
Don't touch the volume for laser power adjustment other than the time of POWER adjustment.
(Laser diode may be damaged.)

AVH-X1600DVD/XNUC
96
1 2 3 4
5 6 7 8

- Power Adjustment

Power Adjustment A
To turn VR of the circuit for Power adjustment and adjust the optical output level of PU laser diode to make the level
of signal (RF signal) read from the media appropriate level during the reproduction of media, CD and DVD.
It has been decided that Power adjustment circuit (circuit from IMON to CDMP, DVDMP) which adjusts the optical
output level of PU laser diode should be installed on DVD Core Unit in the DVD mecha module.
Therefore, in the replacement of CRG mecha (with PU unit) and DVD Core Unit, Power adjustment should be
implemented.
The Power adjustment method of mecha module is shown below.

Items to be Prepared

Measuring instrument: Oscilloscope (digital or analog)


B
Frequency band of oscilloscope in DVD whose frequency is higher than CD Adjustable 10 MHz
and higher (enough to check the level)
(In LS2, DVD (x 1.5CLV) MAX RF 6.55 MHz / DVD (x 1.5CLV) MIN RF 1.40 MHz)
DISC: DVD TEST DISC (TDV-582 or TDV-520) Almedio
CD TEST DISC (TCD-782 or TCD-792) Almedio
Adjustment screwdriver : crosshead, No.0, nonmetal (ceramic screwdriver for adjustment)

Line Locating

The following line locating is required.

1 RF Power adjustment
C
2 VREF1 Power adjustment

Connection Diagram

: Checking terminal for oscilloscope


The figure in parentheses of resistor / capacitor is constant. Universal board

RF VREF1

Enlarged

E
For CDt

For DVDt

AVH-X1600DVD/XNUC
5 6 7 8
97
1 2 3 4

Method of Power Adjustment

A 1. Monitor RF by using the analog oscilloscope. (line locating of RF and VREF1)


2. Turn VR1101 and VR1102 to set the PP value of RF at the value shown in the right lower table.

RF waveform after F-ON / before T-ON (waveform measured by analog oscilloscope)

Adjust VR in order that this


width is within the range of
target RF level adjustment value.
Power adjustment standard
RF level adjustment value
(F-ON STEP 10, 24)
B
DVD 200 mV to 1200 mV
CD 200 mV to 1200 mV

RF waveform after the completion of all adjustment (waveform measured by analog oscilloscope)
Adjust VR in order that this
C width is within the range of
target FR level adjustment value.
Power adjustment standard
RF level adjustment value
(The setup is completed. STEP 12, 26)
DVD 848 mV to 892 mV
CD 658 mV to 702 mV

AVH-X1600DVD/XNUC
98
1 2 3 4
5 6 7 8

Procedure of Power Adjustment


Flow
1. DVD Power adjustment in the state where F is ON A
2. DVD Power adjustment in the state where the setup is completed
3. CD Power adjustment in the state where F is ON
4. CD Power adjustment in the state where the setup is completed

Procedure of Adjustment
STEP No.

1. Set the mecha to clockwise.

2. Turn on power.

3. Test Mode In Refer to FE test mode function flow. B

4. Insert DVD TDV-582 (or TDV-520).

5. Set the mecha to counterclockwise.

6. Adjustment of the initial position of VR for Power adjustment Adjust the angle at the D cut position to the initial position
(initial position shown in Fig.1).
1st 2nd 3rd
CD (VR1101) -30°
DVD (VR1102) -30° -45° -90° 0° CD VR (VR1101)
Adjustment of the initial position
-30° - 1st, 2nd, 3rd is the same, too

3rd - -90°

2nd - -45°

DVD VR (VR1102)
Adjustment of the initial 0°
position
1st - -30°
7. Set DISC TYPE to DVD single layer. Fig.1

8. Power on. Refer to FE test mode function flow.

9. LD-ON. Refer to FE test mode function flow.


D
Refer to FE test mode function flow.
10. Execute until Focus close state is reached.
If the waveform is similar to RF waveform after F-ON and before T-ON (waveform measured by analog oscilloscope), Focus Close is reached.
Go to STEP 9.
If the RF waveform does not appear, Focus Close is not reached.
Return to STEP 7 and change the angle of initial position of DVD VR (VR 1102). If Focus Close is not reached after the 3rd VR adjustment,
replace the whole CRG mecha (including PU unit) and start again from STEP 1.

DVD 200 mV to 1200 mV

11. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.)
DVD 848 mV to 892 mV
12. Execute until Tracking Close is reached.
E
13. Conduct Power adjustment. (Conduct the adjustment in the state of Tracking Close.)
DVD 2.0E – 4 and under

14. Check the ERR rate after Power adjustment.


DVD 820 mV to 917 mV
DVD 2.0E – 4 and under
15. Power off.

16. Return the state of mecha to clockwise.

17. Set up again (state of mecha to clockwise / setting of DVD single layer) and conduct the final check of RF level and ERR rate.
F
(Check in the state of Tracking Close)

18. Eject.

AVH-X1600DVD/XNUC
5 6 7 8
99
1 2 3 4

19. Take out DVD TDV-582 (or TDV-520).


Insert CD TCD-782 (or TCD-792).
A
20. Set the mecha counterclockwise.

21. Adjustment of the initial position of VR for Power adjustment Adjust the angle at the D cut position to the initial position
(initial position shown in Fig.2).
1st 2nd 3rd
-45° -90° CD VR (VR1101)
CD (VR1101) -30° Adjustment of the initial position

DVD (VR1102) As the adjustment is 1st - 30°
completed, never change. 2nd - -45°

3rd - -90°

B
DVD VR (VR1102)
As the adjustment is
completed, never change. 0°
Fig.2

22. Set DISC TYPE to CD. Refer to FE test mode function flow.

23. Power on. Refer to FE test mode function flow.

24. Execute until Focus Close 1 is reached. Refer to FE test mode function flow.
If the waveform is similar to RF waveform after F-ON and before T-ON (waveform measured by analog oscilloscope), Focus Close is reached.
Go to STEP 20.
If the RF waveform does not appear, Focus Close is not reached. Return to STEP 21 and change the angle of initial position of CD VR (VR1101).
C If Focus Close is not reached after the 3rd VR adjustment, replace the whole CRG mecha (including PU unit) and start again from STEP 1.

25. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.)

CD 200 mV to 1200 mV

26. Execute until Tracking Close is reached. Refer to FE test mode function flow.

27. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.)
CD 658 mV to 702 mV

28. Check ERR rate.


D CD 1.0E – 2 and under Refer to FE test mode function flow.

29. Power off. Refer to FE test mode function flow.

30. Return the state of mecha to clockwise.

31. Set up again (state of mecha to clockwise / setting of CD layer), and conduct the final check of RF level and ERR rate.
(Check in the state of Tracking Close)

CD 528 mV to 832 mV Refer to FE test mode function flow.


CD 1.0E – 2 and under

32. Eject. Refer to FE test mode function flow.


E

33. Take out CD TCD-782 (or TCD-792).

34. Power off.

AVH-X1600DVD/XNUC
100
1 2 3 4
5 6 7 8

8.2 PCL OUTPUT CONFIRMATION

- PCL Output
With the TESTIN (72 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started.
The clock signal is output from the CLKOUT terminal IC601 (Pin 78).
The frequency of the clock signal is 9.375 MHz(± 375 Hz).
If the clock signal out of the range, the X’tal (X601) should be replaced with new one.

AVH-X1600DVD/XNUC
5 6 7 8
101
1 2 3 4

9. EXPLODED VIEWS AND PARTS LIST


NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
A
Therefore, when replacing, be sure to use parts of identical designation.
"
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
9.1 PACKING

RC, RD, RI, ID

RC, RI EW5

UC, RC, RD
RI, ID

EW5, UW5

UC, RC, RD, RI, ID


F

UC, EW5
UW5
EW5, UW5, RI

AVH-X1600DVD/XNUC
102
1 2 3 4
5 6 7 8

(1) PACKING SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Cord Assy See Contrast table (2) 12 Panel See Contrast table (2)
2 USB Extended Cable CDP1585 13 IM CD-ROM See Contrast table (2)
A
3 Polyethylene Bag CEG1160 14-1 Owner's Manual See Contrast table (2)
4 Screw See Contrast table (2) * 14-2 Warranty Card See Contrast table (2)
5 Screw TRZ50P080FTC
14-3 Quick Start Guide See Contrast table (2)
6 Handle See Contrast table (2) 14-4 Installation Manual See Contrast table (2)
7 Cover See Contrast table (2) * 14-5 Caution Card See Contrast table (2)
8 Unit Box See Contrast table (2) * 14-6 Caution Card See Contrast table (2)
9 Contain Box See Contrast table (2) * 14-7 Service Network See Contrast table (2)
10 Protector See Contrast table (2)
15 Cord Assy See Contrast table (2)
11 Card Remote Control Unit See Contrast table (2) B

(2) CONTRAST TABLE


AVH-X1600DVD/XNUC, AVH-X1600DVD/XNEW5, AVH-X1600DVD/XNUW5, AVH-X1650DVD/XNRC, AVH-
X1650DVD/XNRD, AVH-X1650DVD/XNRI and AVH-X1690DVD/XNID are constructed the same except for the fol-
lowing:
AVH-X1600DVD/ AVH-X1600DVD/ AVH-X1600DVD/ AVH-X1650DVD/
Mark No. Description
XNUC XNEW5 XNUW5 XNRC
1 Cord Assy CDP1668 CDP1436 CDP1436 CDP1668
4 Screw CRZ50P090FTC CRZ50P090FTC CRZ50P090FTC Not used
6 Handle Not used CND6289 CND6289 Not used
7 Cover CEG1359 CEG1356 CEG1356 CEG1356
C
8 Unit Box CHG8426 CHG8434 CHG8435 CHG8427

9 Contain Box CHL8426 CHL8434 CHL8435 CHL8427


10 Protector CHP4598 CHP4599 CHP4599 CHP4598
11 Card Remote Control CXE5116 Not used Not used CXE5116
Unit
12 Panel Not used Not used Not used CNS9475
13 IM CD-ROM Not used CPJ1471 Not used Not used

14-1 Owner's Manual CRD4758 Not used CRB4290 CRD4759


* 14-2 Warranty Card QRY3001 CRY1376 CRY1330 Not used
14-3 Quick Start Guide Not used CRD4756 Not used Not used
14-4 Installation Manual Not used CRD4757 Not used Not used D

* 14-5 Caution Card Not used CRP1436 Not used Not used

* 14-6 Caution Card Not used CRP1441 Not used Not used
* 14-7 Service Network Not used Not used Not used Not used
15 Cord Assy Not used Not used Not used CDP1655

AVH-X1650DVD/ AVH-X1650DVD/ AVH-X1690DVD/


Mark No. Description
XNRD XNRI XNID
1 Cord Assy CDP1668 CDP1668 CDP1668
4 Screw Not used Not used Not used
6 Handle Not used CND6289 Not used E
7 Cover CEG1356 CEG1356 CEG1356
8 Unit Box CHG8428 CHG8436 CHG8429

9 Contain Box CHL8428 CHL8436 CHL8429


10 Protector CHP4598 CHP4599 CHP4598
11 Card Remote Control CXE5116 CXE5116 CXE5116
Unit
12 Panel CNS9475 CNS9475 CNS9475
13 IM CD-ROM Not used Not used Not used

14-1 Owner's Manual CRD4760 CRD4761 CRB4291


* 14-2 Warranty Card Not used Not used CRY1304 F
14-3 Installation Manual Not used Not used Not used
14-4 Installation Manual Not used Not used Not used
* 14-5 Caution Card Not used Not used Not used

AVH-X1600DVD/XNUC
5 6 7 8
103
1 2 3 4
AVH-X1650DVD/ AVH-X1650DVD/ AVH-X1690DVD/
Mark No. Description
XNRD XNRI XNID

* 14-6 Caution Card Not used Not used Not used


A * 14-7 Service Network Not used Not used CRY1305
15 Cord Assy Not used CDP1655 Not used

Owner's Manual,Installation Manual


Part No. Language

CRD4758 English, French, Spanish(Espanol)

CRD4756 English, French, Italian, Spanish(Espanol), German, Dutch

CRD4757 English, French, Italian, Spanish(Espanol), German, Dutch

CRB4290 Russian
B CRD4759 English, Traditional Chinese

CRD4760 English, Spanish(Espanol), Portuguese(B)

CRD4761 English, Arabic, Persian

CRB4291 English

CONTENTS OF CD-ROM (Operation Manual), CPJ1471


Part No. Language
* CRB4277 English
* CRB4278 French
C
* CRB4279 Italian
* CRB4280 Spanish(Espanol)
* CRB4281 German
* CRB4282 Dutch
* CRB4283 Swedish
* CRB4284 Norwegian
* CRB4285 Finnish
* CRB4286 Danish
* CRB4287 Portuguese
D * CRB4288 Greek
* CRB4289 Turkish
All operation manuals are supplied in PDF files by the CD-ROM.
Regarding the availability of paper manual, contact Pioneer Service representative in your region.

AVH-X1600DVD/XNUC
104
1 2 3 4
5 6 7 8

AVH-X1600DVD/XNUC
5 6 7 8
105
1 2 3 4

9.2 EXTERIOR (1)

A
A

D
B

A
E

D EW5, UW5, RI

EW5, UW5, RI

F
C B
D

AVH-X1600DVD/XNUC
106
1 2 3 4
5 6 7 8

(1) EXTERIOR (1) SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Screw BSZ26P050FTC 17 Cushion CNN4274


2 Screw BSZ26P120FTC 18 Touch Panel CSX1184
A
3 Screw BSZ26P060FTC 19 Lighting Conductor CNW2588
4 FFC CDE9765 20 Lighting Conductor CNW2589
5 FFC CDE9767
21 Holder CNW2590
6 Holder YND5148 22 TFT LCD CWX4218
7 Heat Sink CNR2147 23 Grille Assy See Contrast table (2)
8 Screw ASZ26P050FTC 24 Button CAI3844
9 Button (HOME) CAI3845 25 Plate CNN4709
10 FFC CDE9768
26 Grille See Contrast table (2)
11 Holder CND6527 27 DVD Mechanism Module (LS2) CXK8003 B
12 Cover CNN2628 28 •••••
13 Cushion CNN4186 29 Service Unit (Monitor) CXX6055
14 Sheet CNN4187 30 Service Unit (Keyboard) CXX6059
15 Service Unit (Touch Panel) CXX6233
31 Holder See Contrast table (2)
16 Cushion CNN4273 32 Panel See Contrast table (2)

(2) CONTRAST TABLE


AVH-X1600DVD/XNUC, AVH-X1600DVD/XNEW5, AVH-X1600DVD/XNUW5, AVH-X1650DVD/XNRC, AVH-
X1650DVD/XNRD, AVH-X1650DVD/XNRI and AVH-X1690DVD/XNID are constructed the same except for the fol-
lowing: C
AVH-X1600DVD/ AVH-X1600DVD/ AVH-X1600DVD/ AVH-X1650DVD/
Mark No. Description
XNUC XNEW5 XNUW5 XNRC
23 Grille Assy CXE6859 CXE6858 CXE6858 CXE6860
26 Grille CNU2542 CNU2541 CNU2541 CNU2543
31 Holder Not used CND6288 CND6288 Not used
32 Panel Not used CNS9952 CNS9952 Not used

AVH-X1650DVD/ AVH-X1650DVD/ AVH-X1690DVD/


Mark No. Description
XNRD XNRI XNID
23 Grille Assy CXE6860 CXE6860 CXE6861
26 Grille CNU2543 CNU2543 CNU2544 D
31 Holder Not used CND6288 Not used
32 Panel Not used CNS9952 Not used

AVH-X1600DVD/XNUC
5 6 7 8
107
1 2 3 4

9.3 EXTERIOR (2)

UC, RC, RD, RI, ID

B
UC, RC, RD, RI, ID EW5, UW5

AVH-X1600DVD/XNUC
108
1 2 3 4
5 6 7 8

(1) EXTERIOR (2) SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Screw ASZ26P050FTC 10 Screw BSZ26P060FTC


2 Screw BSZ26P050FTC A
3 Cord Assy See Contrast table (2) 11 •••••
4 Card Remote Control Unit See Contrast table (2) 12 Screw ASZ26P050FTC
5 Battery Cover See Contrast table (2) 13 Screw BPZ26P080FTC
14 FFC CDE9766
6 Chassis CNA3210 15 Holder CND6555
7 Bracket CND6336
8 Holder CND6530 > 16 Fuse (10 A) YEK5001
9 Bracket CND6635 17 Service Unit (Mother I/F) See Contrast table (2)

(2) CONTRAST TABLE


AVH-X1600DVD/XNUC, AVH-X1600DVD/XNEW5, AVH-X1600DVD/XNUW5, AVH-X1650DVD/XNRC, AVH- B
X1650DVD/XNRD, AVH-X1650DVD/XNRI and AVH-X1690DVD/XNID are constructed the same except for the fol-
lowing:
AVH-X1600DVD/ AVH-X1600DVD/ AVH-X1600DVD/ AVH-X1650DVD/
Mark No. Description
XNUC XNEW5 XNUW5 XNRC
3 Cord Assy CDP1668 CDP1436 CDP1436 CDP1668
4 Card Remote Control CXE5116 Not used Not used CXE5116
Unit
5 Battery Cover CNU1624 Not used Not used CNU1624
17 Service Unit (Mother I/F) CXX6037 CXX6035 CXX6036 CXX6038

AVH-X1650DVD/ AVH-X1650DVD/ AVH-X1690DVD/


Mark No. Description C
XNRD XNRI XNID
3 Cord Assy CDP1668 CDP1668 CDP1668
4 Card Remote Control CXE5116 CXE5116 CXE5116
Unit
5 Battery Cover CNU1624 CNU1624 CNU1624
17 Service Unit (Mother I/F) CXX6039 CXX6040 CXX6041

AVH-X1600DVD/XNUC
5 6 7 8
109
1 2 3 4

9.4 DVD MECHANISM MODULE (1)

B
B A
(C)

(A)
C
(C)

D
(A)
C (NOTE)

D
(C)

(C)
D

(NOTE) (A)
(A)
(C)
(A) (B)
(A)
(NOTE)
(A) (A)(NOTE)

E E
C
E

B
A
(C) (C)

(A) : GEM1045
F
(B) : GEM1038

(C) : GEM1024 (NOTE) Apply grease to the whole part.

AVH-X1600DVD/XNUC
110
1 2 3 4
5 6 7 8

DVD MECHANISM MODULE (1) SECTION PARTS LIST


Mark No. Description Part No. Mark No. Description Part No.

1 Screw BSZ20P040FTC 35 Gear CNW1186


2 Screw BSZ26P060FTC A
3 Screw (M2 x 4) CBA1835 36 Gear CNW1187
4 Washer CBF1038 37 Clamper CNW1190
5 Spring CBH2855 38 Arm CNW1192
39 Holder CNW1193
6 Spring CBH2860 40 Holder CNW1194
7 Spring CBH3010
8 Spring CBH3011 41 Damper CNW2439
9 Spring CBH3014 42 Damper CNW2440
10 Spring CBH3015 43 Arm CNW1726
44 Guide CNW2240
11 Spring CBH3016 45 Arm CNW2241 B
12 Spring CBH3017
13 Spring CBH3019 46 Rack CNW2265
14 Spring CBH3086 47 Gear CNW2287
15 Spring CBH3095 48 Motor Unit(M1)(CRG(L/E)) CXC4026
49 Screw Unit CXC8894
16 Spring CBH3096 * 50 Chassis Unit CXE6044
17 Plate Spring CBL1824
18 ••••• 51 •••••
19 Case CNB3763 * 52 Support Wheel CNW2052
20 Bracket CND4553 * 53 Spindle Motor(M2)(SPINDLE) EXM2002
54 Arm Assy CXE6232 C

21 Lever CND5398 55 Washer CBF1037


22 Bracket CND5710
23 Bracket CND6127 56 Washer CBF1038
24 Arm CND6406 57 Arm CND6242
25 Sheet CNN3678 58 Roller CNW2500
59 Collar CNW2444
26 Roller CNW1172 60 Gear Unit CXC6225
27 Roller CNW1175
28 Arm CNW1177 61 Washer YE15FTC
29 Arm CNW1178 62 Screw JFZ20P025FTC
D
30 Gear CNW1180 63 Screw JGZ17P020FTC
64 Screw (M2 x 5) EBA1028
31 Gear CNW1181 65 DVD Core Unit YWX5032
32 Gear CNW1183
33 Rack CNW1184 66 Mechanism Unit(Service) CXX4548
34 Gear CNW1185

(NOTE) Pickup, Spindle Motor and Support Wheel are not available as service parts, because they need adjustment by special equipment after
replacing.

AVH-X1600DVD/XNUC
5 6 7 8
111
1 2 3 4

9.5 DVD MECHANISM MODULE (2)

(C)

(C)

(C)

(A)

(B)

(A) : GEM1045

(B) : GEM1038

(C) : GEM1024

AVH-X1600DVD/XNUC
112
1 2 3 4
5 6 7 8

AVH-X1600DVD/XNUC
5 6 7 8
113
1 2 3 4

10. SCHEMATIC DIAGRAM


10.1 MOTHER PCB (ANALOG BLOCK)
A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".
ANA-SYS BUS
101 - : AV.SEL
201 - : AEQ
INNER BUS
A 2/6
251 - : E.VOL

RR
301 - : PWAMP

FR
RL
FL
AV_LOUT1
801 - : SENS
ANA-I/O BUS
A 5/6

RCA_SWR
RCA_SWL

RCA_RR

BTANAR
RCA_FR
RCA_RL
BUSL+
AUX_L

BTANAL
BUS-

RCA_FL
AEQMICIN

iNAVI
RCAMUTE

A 6/6

SYS+B
ANA-TUN BUS

EV12
10u 10V 2125
A
B

1608
2125 2125

CCG1192-A
R256 R258 R260
E.VOL

R264

R265
1000p/50

1000p/50

NM
NM 0 0

0
100p/50
R257 R259 R261 FL

C278

C280
NM 0

NM
0 FR
2125 2125

CCG1192-A
E. VOL IC INPUT GNDA

100p/50

R262

C283
C284

C281
C252

R263

C282

C285

C286

0.1u/16
NM

NM
NM

1608
RR
1 -

C279

1608
1u/10
RL
2 AV SEL
3 BT TEL AUDIO

2125
3216

10u
64
63
62
61
60
59
58
57
56
55
54
53
52
51
FRONT_R 50
49
4 SXI 1608 GNDA

PGND

PRE_SWR
C253

VP
PRE_SWL

PREF

REAR_R
NC13

NC12

NC11

NC10
1 48

REAR_L
FRONT_L
5 NAVI/app GUIDE
S
10p/50

1u/10 2 47 C269
C251

6 - SVIN_RL
2125
3 TOUT_RL 1u/10 1608
M - NC10.22u/50
46
4 C254 45 C270
APF_2 SVIN_FR TOUT_RR
TOUT_FR 1608
E.VOL Input C255 1u/10

NC14
5 44

TOUT_FL
SVIN_RR

SVIN_FL
APF_1 SVIN_PRE
0.22u/50 6 43 C271
2125 NC2 TOUT_PRE
FM/AM(30%) (except B, C): -15.0 dBs 7 42 1u/10
1608
GNDA
FM/AM(30%) (B, C): -11.0 dBs 1608
C256
1u/10 8
IN1L NC9
41
TV:+2.2 dBs IN2L IC251 IN1R 1608
C272 1u/10
DC_FILTER

C257 9
TEST_OUT

40 AV_ROUT1
AUX:+2.2 dBs NM IN3L PML020A IN2R
10 39 C268 NM
MIC_IN

VCR:+2.2 dBs

C275

10p/50
NC3 IN3R
C USB(LS2 Decode):+5.1 dBs C258 11
IN4L+ NC8
38 O
NM PCHANG
USB(SH Decode):+2.2 dBs C259 12 37 C273
NM GNDA BUSR+
IN4L- IN4R+
DVD/CD(LS2):+5.1 dBs NM
13 36 C274 NM BUS-
MIC_AMP_OUT

SA_TEST_OUT
NC4 IN4R-
Navi Guide:+8.6 dBs 1u/10 C260
R201

R251 14 35
1608
0

IN5L NC7 SYS+B


1.6k C261 15 IN5G DVCC 34
C290

IN5R MUTE
SAOUT
SACLK
0.01u/16

DGND
CREF

DATA
1u/10 16 33
GND
VCC
NC5
NC6

CLK
STB
1608
E.VOL Output

2125 10u
CCG1192-A
SPEED
GNDA

0.1u/10
C276

C277
17
18
19
20
21
22
23
24
CCG1192-A 10u 25
26
27
28
29
30
31

FM/AM(30%) (except B, C): -6.9 dBs 32


R202 C203
FM/AM(30%) (B, C): -2.9 dBs MAO EVMUTE
C267 2125
CCG1192-A 0.47u/10

CCG1218-A-T
SYS+B

TV:+9.3 dBs 1.8k


C264

R253

R255
100p/50
1608

47k
NM

C291 2.2u/10
2200p/50
C201

AUX:+9.3 dBs NM
1608
C266
C287
1000p/50

VCR:+9.3 dBs
2125 10u

GNDA
USB(LS2 Decode):+9.2 dBs C292 EVSEL
1000p/50

100p/50

USB(SH Decode):+9.3 dBs


C288

C263

C265

C289

C262
0.1u/16
NM

only E
3216

1608

1u/10 EVSDA
DVD/CD(LS2):+9.2 dBs GNDA
Navi Guide: -12.5 dBs GNDA GNDV EVSCK
GNDA
C113 CCG1192-A 10u EVSACLK T
2125 GNDA
C114 EVSAOUT
GNDA
0.1u/10
AVSCL
D AV SELECTOR
AVSDA

AUDIO CH VIDEO CH C129 1608 R112 SH_L P


1u/10 100
CH1 SH CH1 iCOMP C137 1608 R116
1u/10 100
C128 1608 R113 SH_R
CH2 iTV CH2 VCR 1u/10 100
C132 1608 R114 iTV_L
CH3 LS-2 CH3 AUX 1u/10 100
C138 1608 R117
CH4 VCR CH4 LS-2 1u/10 100
C133 1608 R115 iTV_R
CH5 AUX CH5 BC GNDA

A 3/6
GNDV 1u/10 100
B
CH6 TUN CH6 -
48
47
46
45
44
43
42
41
40
39
RIN2 38
37
VCOM

1608
GND1

GND2
SDA

VSS1

R101 1 36 C134 R108 LS_L


RIN1

1608
LIN1

LIN2

100 1u/10 56
BC_VGND 8 C101 0.1u/10 2 35 C135 R119 1608
1 1608
VIN6 LIN3 1u/10 56
BCAM_IN 7 C102 0.1u/10 3 VGND5 GND3 34 C136 R120 1608 LS_R
2 1608 GNDA
VGND6
SCL
VSS2

VIN5 RIN3 1u/10 56


LS2_VGND 6 C103 0.1u/10 4 33 C119 R121 1608 VCR_L
3 1608 56
VGND4 LIN4 1u/10
LS_V 5 C104 0.1u/10 5 32 C120 R109 1 8 VCR_GND A
4 1608
VIN4 GND4 1u/10 100
AUX_VGND 8 C105 0.1u/10 6 31 C121 7 VCR_R
1 1608 2
VGND3 IC101 RIN4 1u/10
C106
ANA-SH BUS

AUX_V 2 7 0.1u/10 7 30 C122 1608 3 6 AUX_L


E GNDV VIN3 AK4223VQ LIN5 1u/10
VCR_VGND 6 C107 0.1u/10 8 29 C123 5 AUX_AGND
3 1608 4
VGND2 GND5 1u/10
VCR_V 5 C108 0.1u/10 9 28 C124 R110 1 8 AUX_R
4 1608
VIN2 RIN5 1u/10 100
R102 C131 10 27
100 0.1u/10 C125 1608 2 7 TUN_L
VGND1 LIN6 1u/10
iCOMP GNDV R111 C130 0.1u/10 11 VIN1 GND6 26 C126 6
1608 3 (TUN AGND)
VR2 RIN6
ROUT2

ROUT1
VOUT2
VOUT1

LOUT2
LOUT1

NM 1u/10
REGV

RVDD
VVDD
AVDD
RSTN

C109 0.1u/10 12 25 C127 1608 4 5 TUNAG TUN_R


VR1

1u/10
AV SELECTOR Input
R118
NM

R107 B
13
14
15
16
17
18
19
20
21
22
23
24

SYS+B NM
GNDV SYS+B FM/AM(30%) (except B, C): -15.0 dBs
CCG1192-A 10u

R103 R106 GNDA FM/AM(30%) (B, C): -11.0 dBs


75 D%

NM 1608
75

C117 1608

C118 2125
270p/50 R122

TV:+2.2 dBs
2125 10u
1608
47

NM
CCG1192-A
C110 2125
CCG1192-A

1000p/50
0.1u/10

0.1u/16

C139

D101 1608 AUX:+2.2 dBs


0.1u/10

C116
C111

0.1u/16
R104

C112

VCR:+2.2 dBs
C140

R105

NM BGSENS1
C115

NM USB(LS2 Decode):+5.1 dBs


AV_ROUT1
AV_LOUT1

USB(SH Decode):+2.2 dBs


RCA_V

D102
GNDA DVD/CD(LS2):+5.1 dBs
GNDA GNDV ANA-I/O BUS

INNER BUS
MONVBS

AVSRST

F
ANA-SH BUS

ANA-SYS BUS

A 1/6
AVH-X1600DVD/XNUC
114
1 2 3 4
5 6 7 8

BUP_1
A-SYS BUS

A 1/6 MOTHER PCB

R312

1k
(ANALOG BLOCK)

DA2J101
A AVH-X1600DVD/XNUC

SYS+B
D312
IC341
Q311 B AVH-X1600DVD/XNEW5 PA2032A
C2 3 4 E2 C AVH-X1600DVD/XNUW5 1 OFFSET
B1 2 5 B2 D AVH-X1650DVD/XNRC AMP

100u/16
2 PW.GND2

C311

R331

NM
E1 1 6 C1

105
RN4987
E AVH-X1650DVD/XNRD FR- 3 RR-
TE Q331
F AVH-X1650DVD/XNRI 4 STBY
E2 4 3 C2
G AVH-X1690DVD/XNID FR+ 5 RR+

R332

R333
B2 5 2 B1

47k

1k
GNDA C351 6 VCC1/2
C1 6 1 E1
NM NM FL- 7 RL-
3216 C353 8 PW.GND1
AMPPW GNDA CCG1291-A 9 RL+
B
FL+
4.7u 50V
C350 10 SVR
1608
FL 0.22u C341 CCG1313-A CCG1291-A 3216 11 FLIN
1608 4.7u 50V
FR 0.22u C342 CCG1313-A 12 FRIN
13 S-GND
1608
RR 0.22u C343 CCG1313-A GNDA 14 RRIN
1608
RL 0.22u C344 CCG1313-A 15 RLIN

C340 NM

C345 NM

C346 NM

C347 NM
2125 C349 1u 16 ACGND
CCG1325-A RL+ 17 FL+
R311 C348
D311

NM
NM
18 PW.GND3
NM

SYS+B
SYSMUTE AMPMUTE RL- 19 FL-
R321 R323 GNDA
Q321 20 VCC3/4
SYS+B

OFFMUTE
1 6 68k 68k RR+ 21 FR+
R301

NM

AMMUTE
R322 R324 22 MUTE
9.0V D301 R302 5

CCG1201-A
C321
2 1.5k 100 RR- 23 FR-
DA2J101 10k R303 D302
CCG1192-A

24 PW.GND4
C301

3 4

2125
4.7u
100k DZ2J082M0
2125

Q301 25 H-SW
R304
10u

47k

LSCR523UB
RN1903
T1

GNDA

C352

C307

C308
10p/50
100p/50
C

1608
GNDA

0.1u/16
OFFSET

VDD33
PCHANG
DD5

R306
C886

10k
NM
R886

R884
NM

NM

GNDD
SPEED-App R305
R891 NM
C887

R893

R882
NM

NM

NM

R896 NM
IC881
R885

NM

NM VCC 6 R889 NM
NM 2 R892 7 C885 R883
1608 GNDD 8
Q882 1 R890 NM
NM NM NM NM
EVMUTE 5
D883

IC881
NM

4
C884

(Rb=10K,Rbe=10k)
NM

3
1608

NM
R888

R895
NM

GND
1608
C883

NM

PCNG D881 R881


NM
R894

R887
NM

NM

Q881 NM
NM NM 1608
EVSEL
D882

C882

C881
NM

NM

NM
1608

1608
(Rb=Rbe=10k)
VDD33

EVSDA GNDD
PBSENS
EVSCK
R867 B.REM
C1 R864

GNDD
47k

EVSACLK TELMUTE
HN1A01FU(YGR)

D853 D304
1k R866 L852 NM
EVSAOUT
B2
E2
R861

NM
NM
6
5
4
47k

10k

D303

0.1u/16
C305
AVSCL
D

1608
Q854

DAN202UM
C860

NM

C861

C862
0.1u/50

NM
1608

1608

1608

C306
AVSDA
NM
C2
1
2
3
E1
B1

R868 GNDD R865 1608 GNDD


SH_L PBSENS
GNDA
TELMUTE
1k 47k
GNDD JA801
R863 GNDD D821 FR- CKM1376-A
SH_R R821 L821 FR-
1 FR-
22k RR-
NM RR-
2 RR-
0.1u/50

15k
C821
1608

FR+
DAN202UM FR+
3 FR+
ASENS RR+

POWER SUPPLY
RR+
4 RR+
FL-
D871 GNDD FL-
UDZV6R2(B) 5 FL-
R872 R873 R880 RL-
BSENS RL-
6 RL-
1k FL+
HN1C01FU(YGR)

NM 10k FL+
3216 7 FL+
BSENS
C1
B2
E2

RL+
6
5
4

LS_L D873 RL+


R878 8 RL+
R874

R875

C871

NM
3.9k

1608
47k
Q871

PBK
BSN2 100k 9 P.B.
R876 D872 UDZV7R5(B)
R879

Q872 MUTE
47k

LS_R
C2
1
2
3

10 MUTE
E1
B1

NM NM NM BREM
R877

NM

11 B.REM
R871 ILM
ASENS GNDD 12 ILM
GNDD
BGSN
NM 13 BGSENS
GNDD ACC
14 ACC
ISENS
ISENS
GND2 GND3 GND1
E
BUP_1

15 GND
R841 D841 R842 FUSE
BGSENS-AVH
BUP2
3300u/16

Q841
C801

16 B.UP
D801
D802

LTC014EEB
BUP1
105

10k DA2J101 1k YEK5001


GNDD
C841

C842

NM
1u/10

3216
1608

1608

10 A
VDD33
3.4V 14.4V L801 >
1SR154-400
1SR154-400

CTH1221-A
R832

100k

600uH
R834

3216
1k

GNDD
BGSENS0 Q831
LTC014EEB R833 L831
D831
SOC33_1
NM
FM/AM(30%) (except B, C):+19.1 dBs
BGSENS-App DZ2J056M0 10k
3.4V FM/AM(30%) (B, C):+23.1 dBs
R831

NM

TV:+35.3 dBs
R801

C831

C832
NM

NM
0.1u/50
1608

AUX:+35.3 dBs
BGSENS1
Q801 VCR:+35.3 dBs
NM USB(LS2 Decode):+35.2 dBs
R802
NM

GNDD
USB(SH Decode):+35.3 dBs
SERVICE UNIT(MOTHER I/F) DVD/CD(LS2):+35.2 dBs
NOTE : Navi Guide:+13.5 dBs
Symbol indicates a resistor. GNDD
Consists of
No differentiation is made between chip resistors and
MOTHER PCB
discrete resistors.
INTERFACE PCB F
Symbol indicates a capacitor.
: The power supply is shown with the marked box.
No differentiation is made between chip capacitors and
discrete capacitors. NM : No Mount
A 1/6
AVH-X1600DVD/XNUC
5 6 7 8
115
1 2 3 4

10.2 MOTHER PCB (SYSTEM BLOCK) (GUIDE PAGE)

A-a A-b
Large size
SCH diagram
A-a 2/6

SYS+B
9.0V

VD8

R759
LS2 SYS-TUN BUS

1k
CN751

6
5
4
CKS6025-A
8.0V
A-a A-b Guide page VD8 1

CCG1192-A

RN4982
10V
SYS-I/O BUS

0.1u/10

Q752
VD8 2

C753
C751

C757

NM
2125
VD8 3 PGD

10u
PGND

VD5
PGND 4

1
3

2
PGND

CCG1192-A
10u 10V
PGND 5
SYS-POWER BUS

C752

C754

C755

NM
DGND

2125
GND
PGND 6

NM
A-a A-b Detailed page GNDD
VD5 7
AMTE R752 470

INNER BUS
AMUTE AMUTE
AMUTE 8
R753 1k /XRST XRST
XRESET 9
1 8 IRQPW IRQPW
SYS-SH BUS
IRQPWR 10
S LS2TX 2 7 SYSTOLS
HSTCMD 11

B
LS2 SRX 3 6 LSTOSYS
SLVSTS 12

C STANBY

AGND
13

14
C758
NM
4

R751
5 STNBY STANBY
SYS-ANA BUS
220
CN1952 ANA_R_OUT 15
LS_ROUT GNDD LS_R

AGND 16
LS_LOUT LS_L
ANA_L_OUT 17
R754
AGND 18
GNDA 0 LS_V
MOVBS 19

VIDEO_GND 20
GNDV
WAKEUP 21
USB(LS2 Decode):+5.1 dBs

HN1C01FU(YGR)
D- 22 DVD/CD(LS2):+5.1 dBs

C2
E1

B1
4.7k
R757

3
D+ 23

Q751
DGND 24

4
R758

C1
4.7k

B2

E2
IECOUT 25

DGND 26

SCL 27

SDA 28 GNDA

CPRST 29

CPRDY 30
DGND

GNDD

USB SW
R707

C
DM

DP 100k

SOC33
ASENBO
R750

1608

S CH MEDIA CONNECTED DEVICE WIREDPU


0

IC751
AVSDA R700
BD11600NUX L 1D Audio TO SH Hi SPEED
R692
1 10 220
H 2D Video TO LS2 FULL SPEED AVSRST
1D+ VCC
2 9 USB_SW AVSCL R612
1D- 11 S R601
3 8 220
D+
2D+ D+ R603 100k
4 FIN 7 D-
2D- D- R605 100k

GND
5 6
OE
* 100k
R607 100
C756

0.1u/10

BSENS

ASENS

REMIN R622
100
R609
GNDD
NM

WIRED
D6
WIREDAD DB2J31

COMDC

EVSAOUT R626

* POS
0
C603
D R601 R602 R603 R604 R605 R606 ANTSENS

A NM NM NM NM NM NM
TEMPSENS
B 100k NM 100k NM 100k NM
C605
C 100k NM 100k NM NM 100k KDT1

KDT0
D 100k NM 100k 100k NM
NM
E 100k NM NM 100k NM 100k
F NM 100k 100k NM 100k NM
G NM 100k 100k NM NM 100k
VDD33

CN601
NM
VDD 1

NC 2

GND 3
RESET
NRST 4
OSMD
NDMOD 5
E GND 6
OSCK
SCL 7

GND 8
OSDA
SDA 9

GND 10

GNDD
SYS-ANA BUS

SYS-SH BUS

601 - : SYSTEM SYS-POWER BUS


751 - : LS2

SYS-I/O BUS
SERVICE UNIT(MOTHER I/F) CHIP SIZE LEGEND
Consists of 1608
2125
MOTHER PCB 3216
INTERFACE PCB SYS-TUN BUS

F
INNER BUS

A 2/6
AVH-X1600DVD/XNUC
116
1 2 3 4
5 6 7 8

A-b 2/6
A 2/6 MOTHER PCB
(SYSTEM BLOCK)
SYS-TUN BUS
A 6/6
SYS-I/O BUS
A 5/6 A
B
AVH-X1600DVD/XNUC
AVH-X1600DVD/XNEW5

G_PWM

R_PWM

B_PWM
MOT1

MOT0

LCDPW

BEEP
C AVH-X1600DVD/XNUW5
D AVH-X1650DVD/XNRC
SYS-POWER BUS
A 4/6 E AVH-X1650DVD/XNRD
F AVH-X1650DVD/XNRI

SYSPW
MOTPW2

DDCCLK
VDCNT8

VDCNT5
HIOUTCLK
G AVH-X1690DVD/XNID

S SYS-SH BUS
A 3/6
SHRST
SHMUTE

SHIRQ

SYS-ANA BUS
B
YS-ANA BUS
A 1/6

AMPPW
PBSENS
BGSENS0
ISENS

TELMUTE
C690
NM

R705
220

220

220

8.2k

R690
R694

R691
R681

R682

R683

R697

NM

NM

2.7k
1k
R689

R693

VDD33
R695
R699

R698

NM R625
R687
NM

NM

NM

NM

NM
47k
100k

100k
47k

C617

C616

C618

GNDD

L601

NM

CCG1321-A
1000p/50

50V
TELMUTE

0.01u/16
R688

C621

C614
47k

C615
0.1u/10

1608
C613
R684

R685

R686
220

220

220

0.1u
TESTIN1
PBSN

CLKOUT GNDD
72

71

70

69

68

67

66

65
96

95

94

93

92

91

90

89

88

87

86

85

84

83

82

81

80

79

78

77

76

75

74

73

TESTIN
R707
97 64
C
NC

NC

NC

NC

NC

DDCERR
G_PWM

AMPPW
R_PWM

VSS
B_PWM
MOT1

MOT0

LCDPW

SYSPW
BEEP
MOTPWR2

NC DDCCLK
VDD50

CLKOUT

PBSENS

VDCNT8

VDCNT5
/BGSENS

TESTIN
HIOUTCLK

FLAPLESS

/ISENS

TELMUTEIN

100k 98 63
NC
99 62 AEQAUXSW
NC
100 ASENBO 61

101 60 R704
FAN_PWM
SOCIRQPW

TXIE/NC FAN_PWM
SOCAMUTE1

/SOCXRST

/DDCERR
SOCTESTIN

VSS BTMD NM
102 WREMCONT BTTESTMD 59
R620 10k AEQAUXSW
VSDA R700 103 NC 58 R678 NM
AVSDATA BTTESTIN R677
R692 100k BTRT
220 104 57 R676
VSRST /AVSRST /BTRST BTRST
R611 10k NM R675 R673
R612 105 56 NM
VSCL AVSCK BTRX NM BTTOSYS
R601 R602 100k NM
220 106 55 R674
MODEL0/NC BTTX NM SYSTOBT
R603 100k R604 100k
107 MODEL1/NC SXIPWREN/NC 54 SXIPWEN
R605 100k R606 100k R672
* 100k
108 MODEL2/NC RXSXI/NC 53

R669
NM
R702
NM
SXTOS

NM 109 MODEL3/NC TXSXI/NC 52 NM STOSX


R607 100k
R608 R617 100k
SENS 110 /BSENS BLEND 51 R706 BLEND
R618 100k
111 50 NM R680
SENS /ASENS IC601 SXIPW/ANTPW ANTPW
R622 112 49 NM
REMIN HDPWR33/NC TU3VON
only A PDB117A8
100 113 48
NC HDPWR11/NC TU1VON
R609 R610 except A PDB118A8
114 MODEL4/NC NC 47
NM 100k
115 NC BTMIX 46 BTMIX
D601 AUTOANT
116 NC AUTOANT 45
RB501VM-40 R667
R623 10k
117 WIRED TUNCLK 44 10k R668 TUNCLK
D602 R624 10k R666
118 43 R619 1k
DB2J31400 WIREDAD /TUNRST TUNRST
R664 1k 100k
A, B, C : J% 119 COMDC TUNDATA 42 10k R665 TUNDATA
R626 D, E, F, G : D% 120 41 0
VSAOUT SAIN NC R703
0 121 40
C603 330p/50 POS RXHD/NC NM DTUNtoSYS
D604
NM
R679 122 SXISENS/ANTSENS TXHD/NC 39
STDT
SYStoDTUN D
NM R663 SMTE
123 AVSS SYSMUTE 38 C604 SYSMUTE
47k
R627
/GUIDEON

47k
EVLMUTE

124 37 R638
/RGBARI

TEMPSEN /SOCSTB SHSTBY


RXNAVI
TXNAVI

RXSOC
TXSOC

C601 0.1u/10 0.1u/10 1k


offset

125 36 R662
/STB

AVDD SACLK EVSACLK


C605 NM R613 0
R616 126 35 R661
4.7k 470 KDT1 EVSEL EVSEL
(OCD_SDA)

(OCD_SCL)

NOCDMOD

R615 0
R614 127 34 R660
4.7k EVSCK
/H&OSW

470 EVSCK
MICSEN

VOUT18

KDT0
RXDVD

AMUTE
TXDVD

IRQPW

ATRST
VDD50

0
/XRST

OSCO

NRST
OSCI

128 33 R659
TSO

TCK

VSS

VSS

VREFH EVSDA EVSDA


TSI

XO
XI

0
R628 NM
C602
1

9
5

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

0.1u/10
OSMD
OSDA

OSCK

UGD
TSO
1k
470

470

1000p/50
R629
R651

R701
R656

C619

C608

C612

R621
NM

TCK

47k

47k
NM
TSI

0.1u/10
0
R633

DCH1246-A-T
R653

R654

4.7k

4.7k

1u/10
R631

R655

R635

R644

R645

R649

NM
100k

4.7k
R630

NM
47k

1k

1k
VDD33
STL
LTS

R636

R637

C607
LSCR523UB

10p/50
R650

D603
NM

NM
RST
R642

C606
100k
R632

R634

R658

R647

IC602
47k

100k
47k

47k
Q601

8p/50 1 5
OUT NC2
2
DCH1246-A-T

0.1u/10
C620

C610

VDD
1u/10

3 4
C609

C611
NM

NM

R652 VSS NC1

E
47k
NM
120

120

X601
R657
NM

SYS-ANA BUS

4 3 GNDD
GND2 X2
R646

R648

1 2
X1 GND1
EVMUTE
OFFSET

CSS1839-A
12.500MHz
SYS-SH BUS

SYS-ANA BUS
SYS-POWER BUS
SYStoSH

SHtoSYS

S
SYS-I/O BUS
MICSENSR
GUIDEON

S_TO_N

N_TO_S
RGBARI

H/OSW

RESET

SYS-TUN BUS

F
SYSTOLS

LSTOSYS

STANBY
AMUTE
IRQPW

RESET
OSMD
OSDA

OSCK
XRST

A 2/6
AVH-X1600DVD/XNUC
5 6 7 8
117
F
E
B
A

D
C

118
A-a A-b
A-b 2/6
PCB

1
1

A 2/6 MOTHER
(SYSTEM BLOCK)
SYS-TUN BUS
A 6/6
SYS-I/O BUS
A AVH-X1600DVD/XNUC
A 5/6 B AVH-X1600DVD/XNEW5
C AVH-X1600DVD/XNUW5

MOT1
MOT0
BEEP

G_PWM
R_PWM
B_PWM
LCDPW
D AVH-X1650DVD/XNRC
SYS-POWER BUS
E AVH-X1650DVD/XNRD
A 4/6 F AVH-X1650DVD/XNRI
G AVH-X1690DVD/XNID

SYSPW

MOTPW2
VDCNT8
VDCNT5
DDCCLK

HIOUTCLK
SYS-SH BUS
A 3/6

2
2

SHIRQ
SHRST

SHMUTE
SYS-ANA BUS
A 1/6
C690

ISENS
AMPPW

PBSENS
NM

BGSENS0
TELMUTE
R705

220
220
220
8.2k

1k

NM
NM
2.7k

R690

R694
R691

R681
R682
R683
R697
NM
NM
NM
NM
NM

AVH-X1600DVD/XNUC
47k

47k
R689
R693

R695

R699
100k
R698
R687
100k
VDD33

GNDD

NM R625

C617
C616
C618
L601

3
3

NM
50V

47k

R688
C621
C614
C615
1608

C613

220
220
220
1000p/50
0.01u/16

0.1u/10

R684
R685
R686
TELMUTE
CCG1321-A
0.1u

PBSN
CLKOUT GNDD

TESTIN1
72
71
70
69
68
67
66
65

96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
TESTIN
R707
97 64 DDCERR

NC
NC
NC
NC
NC
NC

VSS
00k 98 63

MOT1
MOT0
BEEP
NC

G_PWM
R_PWM
B_PWM
VDD50
LCDPW
AMPPW
SYSPW

CLKOUT
/ISENS
PBSENS
TESTIN
VDCNT8
VDCNT5
DDCCLK

99 62 AEQAUXSW
NC

MOTPWR2
/BGSENS

HIOUTCLK
FLAPLESS
100 61

TELMUTEIN
ASENBO
101 60 R704
TXIE/NC FAN_PWM FAN_PWM
/DDCERR
VSS BTMD NM
102 WREMCONT BTTESTMD 59
R620 10k AEQAUXSW
103 NC 58 R678 NM
AVSDATA BTTESTIN R677

SOCIRQPW
/SOCXRST
100k

SOCTESTIN
SOCAMUTE1
BTRT R676
104 /AVSRST /BTRST 57 BTRST
R611 10k NM R675 R673
105 56 NM
AVSCK BTRX NM BTTOSYS
R602 100k NM
106 55 R674
MODEL0/NC BTTX NM SYSTOBT
100k

4
4

R604 100k
107 MODEL1/NC SXIPWREN/NC 54 SXIPWEN
100k R606 100k R672
108 MODEL2/NC RXSXI/NC 53 R702 SXTOS
100k
NM
109 52 R669 NM
NM MODEL3/NC TXSXI/NC NM STOSX
100k
R608 R617 100k
110 /BSENS BLEND 51 R706 BLEND
R618 100k
111 50 NM R680
/ASENS IC601 SXIPW/ANTPW ANTPW
112 49 NM
REMIN HDPWR33/NC TU3VON
only A PDB117A8
113 NC HDPWR11/NC 48 TU1VON
R609 R610 except A PDB118A8
114 MODEL4/NC NC 47
NM 100k
115 NC BTMIX 46 BTMIX
D601 AUTOANT
116 NC AUTOANT 45
RB501VM-40 R667
R623 10k
117 WIRED TUNCLK 44 10k R668 TUNCLK
D602 R624 10k R666
NM MODEL3/NC TXSXI/NC NM STOSX
100k
R608 R617 100k
110 /BSENS BLEND 51 R706 BLEND
R618 100k
111 50 NM R680
/ASENS IC601 SXIPW/ANTPW ANTPW
112 49 NM
REMIN HDPWR33/NC TU3VON
only A PDB117A8
113 NC HDPWR11/NC 48 TU1VON
R609 R610 except A PDB118A8
114 MODEL4/NC NC 47
NM 100k
115 NC BTMIX 46 BTMIX
D601 AUTOANT
116 NC AUTOANT 45
RB501VM-40 R667
R623 10k
117 WIRED TUNCLK 44 10k R668 TUNCLK
D602 R624 10k R666
118 43 R619 1k
2J31400 WIREDAD /TUNRST TUNRST
R664 1k 100k
A, B, C : J% 119 COMDC TUNDATA 42 10k R665 TUNDATA
D, E, F, G : D% 120 41 0
SAIN NC R703
5

121 40

5
330p/50 POS RXHD/NC NM DTUNtoSYS
D604 STDT
R679 122 SXISENS/ANTSENS TXHD/NC 39 SYStoDTUN
NM
NM R663 SMTE
123 AVSS SYSMUTE 38 C604 SYSMUTE
47k
R627 47k
124 TEMPSEN /SOCSTB 37 R638 SHSTBY
C601 0.1u/10 0.1u/10
125 36 R662 1k
AVDD SACLK EVSACLK
NM R613 0

offset
/GUIDEON
/RGBARI
TXNAVI
RXNAVI
/STB
TXSOC
RXSOC
EVLMUTE
R616 126 35 R661
4.7k 470 KDT1 EVSEL EVSEL
R615 0
R614 127 34 R660
4.7k 470 KDT0 EVSCK EVSCK
0
128 33 R659 EVSDA
VREFH EVSDA
0

MICSEN
TXDVD
RXDVD
/XRST
/H&OSW
TSO
TSI
TCK
(OCD_SDA)
(OCD_SCL)
IRQPW
AMUTE
NOCDMOD
OSCO
OSCI
VSS
XI
XO
VDD50
VOUT18
NRST
VSS
ATRST
R628 NM
C602

1
2
3
4
6
7
8
9

5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
0.1u/10

UGD

OSDA
OSCK
OSMD

TSO

1k

470
470
0

NM
NM
47k
47k

R629

TSI
TCK

R651
R701

R656
C619
C608
C612
R621

1000p/50

R633
0.1u/10

R653
R654
4.7k
4.7k
1u/10

1k
1k
NM

NM

47k
4.7k
DCH1246-A-T

R631
100k
R655
R635
R644
R645
R649

R630

6
6

STL
LTS
R636
R637
VDD33
C607

10p/50
NM
NM

C606

RST
IC602
R650
D603

47k

47k
47k
R642
100k

R632
R634
R658
100k
R647
8p/50 1 5

Q601
LSCR523UB
OUT NC2
2
VDD
3 4

C620
C610
R652

0.1u/10

1u/10
VSS NC1
NM
NM

C609
C611

47k

DCH1246-A-T
NM

120
120
X601
4 3 GNDD

NM
X2

R657
GND2

R646
R648
1 2
X1 GND1
CSS1839-A

AVH-X1600DVD/XNUC
12.500MHz
SYS-ANA BUS

OFFSET
EVMUTE

7
7

SYS-SH BUS

SYStoSH
SHtoSYS
SYS-POWER BUS
SYS-I/O BUS

GUIDEON
RGBARI
S_TO_N
N_TO_S
MICSENSR
H/OSW
RESET
SYS-TUN BUS
8

8
SYSTOLS
LSTOSYS
XRST
OSDA
OSCK
IRQPW
AMUTE
OSMD
STANBY
RESET

A-a A-b
A-b 2/6

119
E
A

D
C

F
B
F
E
B
A

D
C

120
A-a A-b
A-b 2/6

A-a 2/6
SYS+B

1
1

9.0V

1k
LS2

VD8
SYS-TUN BUS

R759
6

4
CN751
CKS6025-A
8.0V
VD8 1

VD8 2 SYS-I/O BUS

10V
NM
Q752

C753
RN4982

C751
C757
2125
VD8 3 PGD

0.1u/10
10u
CCG1192-A
PGND
PGND 4

3
2

VD5
PGND
PGND 5
DGND GND SYS-POWER BUS

NM
PGND 6

C752
C754
C755
2125

NM
GNDD

10u 10V
VD5 7

CCG1192-A
AMTE R752 470 AMUTE AMUTE
AMUTE 8
R753 1k /XRST XRST
XRESET 9
1 8 IRQPW IRQPW
SYS-SH BUS
IRQPWR 10
S LS2TX 2 7 SYSTOLS
HSTCMD 11

INNER BUS
LS2 SRX 3 6 LSTOSYS
SLVSTS 12

2
2

4 5 STNBY STANBY
STANBY 13 C758 SYS-ANA BUS
C AGND 14 NM
R751
220
LS_ROUT GNDD LS_R
CN1952 ANA_R_OUT 15

AGND 16
LS_LOUT LS_L
ANA_L_OUT 17
R754
AGND 18
GNDA 0 LS_V
MOVBS 19

VIDEO_GND 20
GNDV
WAKEUP 21
USB(LS2 Decode):+5.1 dBs
D- 22 DVD/CD(LS2):+5.1 dBs

1
E1
B1
2
3
C2

4.7k

R757
D+ 23

Q751
DGND 24

6
5
4

C1
B2
E2
IECOUT 25

AVH-X1600DVD/XNUC
HN1C01FU(YGR)

4.7k

R758
DGND 26

SCL 27

SDA 28 GNDA

3
3

CPRST 29

CPRDY 30
DGND

GNDD

USB SW
R707
DM

DP 100k

SOC33
ASENBO

0
S CH MEDIA CONNECTED DEVICE WIREDPU
R6

R750
IC751

1608
AVSDA R700
BD11600NUX L 1D Audio TO SH Hi SPEED
R692 100k
1 10 220
H 2D Video TO LS2 FULL SPEED AVSRST
1D+ VCC R
2 9 USB_SW AVSCL R612
1D- 11 S R601 R602 100k
3 8 220
D+

4
4

2D+ D+ R603 100k R604 100k


4 FIN 7 D-
2D- D- R605 100k R606 100k
5 6
* 100k
GND OE
R607 100k NM
R608 R6
BSENS

C756
R6
ASENS

0.1u/10
REMIN R622
100
R609 R610
GNDD
NM 100k

D601
RB501VM-40
R62
WIRED
D602 R62
R607 100k NM
R608 R6
BSENS

C756
R6
ASENS

0.1u/10
REMIN R622
100
R609 R610
GNDD
NM 100k

D601
RB501VM-40
R62
WIRED
D602 R62
WIREDAD DB2J31400

COMDC A
R626 D, E
EVSAOUT
0
5

5
* POS C603 330p/50
D604
R601 R602 R603 R604 R605 R606 ANTSENS NM

A NM NM NM NM NM NM R6
TEMPSENS
NM C6
B 100k NM 100k 100k NM
C605 NM R613
C 100k NM 100k NM NM 100k KDT1 4.7k
R615
KDT0 4.7k
D 100k NM NM
100k 100k NM
E 100k NM NM 100k NM 100k R628

F NM 100k 100k NM 100k NM


G NM 100k 100k NM NM 100k

6
6

VDD33
CN601
NM
VDD 1

NC 2

GND 3
RESET
NRST 4
OSMD
NDMOD 5

GND 6
OSCK
SCL 7

GND 8
OSDA
SDA 9

GND 10

AVH-X1600DVD/XNUC
GNDD
SYS-ANA BUS

7
7

SYS-SH BUS

601 - : SYSTEM SYS-POWER BUS


751 - : LS2

SYS-I/O BUS
SERVICE UNIT(MOTHER I/F) CHIP SIZE LEGEND
1608
Consists of 2125
MOTHER PCB 3216
INTERFACE PCB SYS-TUN BUS
8

8
INNER BUS

A-a A-b

A-a 2/6
A-b 2/6

121
E
A

D
C

F
B
1 2 3 4

10.3 MOTHER PCB (SH BLOCK) (GUIDE PAGE)

A-a 3/6
RGB VIDEO ISOLATOR

DD5 INNER BUS

DEEM

VDCRST
VDEC_D7

VDEC_D6

VDEC_D5
L1005

2520
10u
SH-I/O BUS

CCG1192-A

POL

LOAD

B0

B1
B2
B3
B4
CLK
VCLK

DIO
L1001

10u 10V
C1006
R1011
CTF1545-A 15p/50
100
Q1003
LSCR523UB
SH-SYS BUS C1382
C1001

R1381
GNDV

C1364
C1365
56p/50
56p/50
0.1u/10

0
GNDD
SH-POWER BUS
IC1001

C1362
56p/50
C1383

C1363

C1366
C1010

56p/50
6p/50
1 5 GNDSIG
GNDV
2 1u/10 SH-TUN BUS
L1004 GNDV GND
R1012 L1006 3 4 C1011 CSYNC

L1378
R1378

C1378
NM

NM
VCC

0
CTF1545-A C1005
100 NM N_CSYNC 1u/10
Q1002
LSCR523UB
0.1u/10
BH7673G SH-ANA BUS GNDD

B C1381
C1002

0.1u/10

100 VTL1126-A
100 VTL1126-A
100 VTL1126-A
100 VTL1126-A
VTL1126-A
VTL1127-A
IC1002

L1415
NM

L1306
C1012

R1426
1 5 GNDSIG

VTL1126-A

L1411
L1413

L1409
L1407
2 1u/10

L1377
0
0
GNDV GND

R1425

R1427
L1007 3 4 C1013
GNDV ANR

0
C1007 VCC
L1002 NM

R1416

R1414
R1010 0.1u/10 N_R 1u/10

100
330
R1013

0
BH7673G C1014

47p/50
C1360
CTF1545-A iCOMP

R1379
100

R1412

R1410
R1408
R1406
Q1001 100 iPodVideo

0
1u/10

R1365

R1376
LSCR523UB IC1003 26pim
1 5 C1015 GNDSIG
C1003
0.1u/10

2 1u/10

100
GNDV GND
L1008 C1016

0.1u/10
C1390

R1393

R1342

C1342

C1343

C1344

C1345

C1346
3 4 ANB

10p/50

0.1u/10

0.1u/10

0.1u/10
100k
C1008 VCC
NM N_B 1u/10
GNDV
0.1u/10
BH7673G only A, E
L1003 IC1004
R1009 1 5 C1017
CTF1545-A GNDSIG

Q1004 100 2 1u/10


GNDV GND
LSCR523UB L1009 3 4 C1018 ANG
VCC PG18
C1004

NM C1009 N_G
0.1u/10

0.1u/10 1u/10 PG19


BH7673G

181
191

184

182
189
192

190

187
186
185

183

180
179
178
177
176

PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175
Vss15 174
173
172
171
170
169
168
167
166
188
PG23/LCD_DATA23/LCD_TCON6/TxD5/AUDATA3
PG24/LCD_CLK

PG22/LCD_DATA22/LCD_TCON5/RxD5/AUDSYNC
PG26/LCD_TCON1
PG25/LCD_TCON0

PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4
MONVBS

PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2
PG27/LCD_TCON2/LCD_EXTCLK

Vcc14

Vss16

PVcc14
PG19/DV_DATA5/LCD_DATA19/SPDIF_OUT/SCK5

PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F
Vcc13

PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G
PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5
PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5
PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H

PVcc13
PG18/DV_DATA4/LCD_DATA18/SPDIF_IN/SCK4

PG15/D31/LCD_DATA15/PINT7
PG14/D30/LCD_DATA14/PINT6
PG13/D29/LCD_DATA13/PINT5
PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0
GNDV

FLCLK_1 193 PF0/BREQ/QSPCLK_1/RSPCK1/TIOC4A/DREQ0/AUDCK


C1301 194 PVcc15
FCS1
VIDEO DECODER FLCS_1 0.1u/10 195 PF1/BACK/QSSL_1/SSL10/TIOC4B/DACK0
196 Vss17
FIO0_1 197 PF2/WAIT/QMO_1/QIO0_1/MOSI1/TIOC4C/TEND0/SPBMO_1/SPBIO0_1
FIO1_1 C1361 198 PF3/CS2/QMI_1/QIO1_1/MISO1/TIOC4D/AUDIO_XOUT/SPBMI_1/SPBIO1_1
R1390 R1308 NM
BCK 199 PF4/CS5/CE1A/SSISCK0/SGOUT_0
C
L1052
VDEC15 VDEC33 56p/50 R1309 NM
LRCK NM 200 PF5/SSIWS0/SGOUT_1
NM
NM

NM

NM
C1077

R1310
0

DATA 201
R1080

R1079

R1087

C1065

C1067

PF6/CE2A/SSITxD0/SGOUT_2
0.1u/10

0.1u/10

R1076

R1077

100
0

SYStoSH R1302 202 PF7/SSIRxD0/RxD0/SGOUT_3/CTS1


GNDD SHtoSYS 27k 203 PF8/A23/TxD0
GNDV
PF9
R1397 204 PF9/BS/DV_DATA0/SCK0/MMC_D4/RTS1
C1084 R1078 BCLK
Q1051 NM C1302 205
CCG1192-A

CCG1192-A

PVcc16
2.2k

2.2k

NM NM NM R1394
10u

LRCLK
10u
R1086

C1072

C1076

PF10
NM

NM 0.1u/10 206
R1074

R1075

PF10/CS1/SSISCK1/DV_DATA1/SCK1/MMC_D5
DATA_BT R1399
207 Vss18
NM
VDEC15 R1373 208 PF11/SSIWS1/DV_DATA2/RxD1/MMC_D6
V_SCL0
VDEC33
GNDV 32.000MHz V_SDA0 209 PF12/SSIDATA1/DV_DATA3/TxD1/MMC_D7
1u/10

NM
75

C1071 5p/50 VDEC_FLD R1377 210


R1051

C1062

R1052

PF13/A24/SSISCK2/SCK2
R1083

100 R1059

R1368 211
1

BTTOSH PF14/A25/SSIWS2/RxD2
0

470

NM NM
SHTOBT R1421 212 PF15/A0/SSIDATA2/WDTOVF/TxD2/UBCTRG
C1063 10u

CSS1818-A

C1303
100

NM
3 3 X1051

213
1M
CCG1192-A
CCG1192-A

PVcc17
1000p/50
C1057

C1058

C1060

C1064

R1053

R1058
0.01u/16

0.1u/10

4.7k

0.1u/10 214 PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5


10u

R1071
215
R1055
R1056

Vss19
2
2

47k SHIRQ 216 PF16/SD_CD_0/FCE/IRQ4/MMC_CD


C1070
5p/50

C1075 BGSENS1 R1374 217 PF17/SD_WP_0/FRB/IRQ5


only A, E NM
64
63
AVDD4 62
61
60
59
58
57
56
55
54
53
52
51
XOSCO 50
49

C1083 0.01u/16 PCHANG R1375 218


1u/10 PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1
C1085 R1072 NM PJ11
DGND5

SDA
AGND4

SAS
PGND_A

SCL

1 GNDD
PVDD_A
CVBS4
CVBS3
CVBS2
CVBS1

48
DVDD_C5

219
XOSCI

5p/50 VDCRST
DVDD_IO4

PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6
R1085

R1304
R1088

C1054 2 47 R1073 100 NM 220


NM

VDECCLK MTCHRST PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7


75

GIN1
0.01u/16 3 GIN2 RESETN 46 100 C1073 L1051 R1305
USB_SW R1306 120 221 PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
AVDD1 CLKO CTF1740-A
C1055 4 DVDD_IO3 45 0.1u/10 C1304 222 PVcc18
1000p/50 AGND1 DGND4 100k
5 44 C1074 BLEN 0.1u/10 223
BIN1 DVDD_C4 PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0
C1082 1u/10 0.1u/10
R1089

6 43 R1060
R1084

VDEC_D7 224 Vss20


NM
75

BIN2 DO7 390


7 42 R1061 R1345 PF20
VDEC_D6 225 PF20/SD_CLK_0/SSIDATA3/MMC_CLK
REF DO6 47k
390 C1305
C1051 C1056 8 41 R1062 226
D
VDEC_D5 Vcc15
REFP IC1051 DO5
0.47u/6.3
C1053

0.47u/6.3 0.01u/16 390


9 40 R1063 VDEC_D4 0.1u/10 227 PF21/SD_CMD_0/SCK3/MMC_CMD
C1052 REFN ML86V7675TBZA3A DO4 390
10 39 R1064 VDEC_D3 228 PF22/SD_D3_0/RxD3/MMC_D3
0.47u/6.3 AGND2 DO3 390
11 38 R1065 VDEC_D2 229 PF23/SD_D2_0/TxD3/MMC_D2
C1078 TAOUT DO2 390
GNDV 1u/10 12 R1066
DO1 37 VDEC_D1 D0 230 PD0/D0/PWM1A
RIN1 DO0 390
13 R1067 C1306
RIN2 VSYNC_L 36 VDEC_D0 231 PVcc19
R1082

R1090

C1081 HSYNC_L 390


NM

DVDD_C1

SSCK
75

14 R1068 0.1u/10
1000p/50 FID 35 VDEC_VD SSCK 232 PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7
DGND1

C1080 AVDD3
DVDD_IO1

DVDD_IO2

220
DVDD_C2

DVDD_C3

0.01u/16 15 34 R1069 VDEC_HD 233 Vss21


STATUS

AGND3
DGND2

DGND3
SLEEP

220
TEST1
TEST2
TEST3

16 33 R1070 234
CHSI

CSYNC_A VDEC_FLD D1 PD1/D1/PWM1B


VSI

DE

560 235
C1079 D2 PD2/D2/PWM1C
R1081

R1091

1u/10
75

NM

17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32

D3 236 PD3/D3/PWM1D
R1057 SDI
VDECSTUS SDI 237 PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7
560 SDO
SDO 238 PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7
R1423
GNDV VSYNC BLSYNC 239 PJ27/SGOUT_3/TIOC1A/CTS7
GNDD
HSYNC 2.2k C1307 240
R1430 PVcc20
0.1u/10
0.1u/10
C1059

C1061

C1066

R1054

C1068

C1069
0.1u/10
0.1u/10

C1086
0.1u/10

0.1u/10 241
47k

Vss22
NM
0.1u/10 D4 242 PD4/D4/FRE/PWM1E
D5 243 PD5/D5/FCLE/PWM1F
GNDV GNDD
D6 244 PD6/D6/FALE/PWM1G
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK
GNDD PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC
PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD
D7 245 PD7/D7/FWE/PWM1H
246
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6

PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7

D8 PD8/D8/NAF0/PWM2A
D9 247 PD9/D9/NAF1/PWM2B
SOC33 D10 248 PD10/D10/NAF2/PWM2C
249
SDRAM D11 PD11/D11/NAF3/PWM2D
PC6/CAS/SCK7/CTx0/CTx0&CTx1&CTx2
CTF1786-A

PC5/RAS/CRx0/CRx0/CRx1/CRx2/IRQ0

PC7/CKE/RxD7/CRx1/CRx0/CRx1/IRQ1

C1308 250 PVcc21


L1101

D12 0.1u/10 251


PC8/CS3/TxD7/CTx1/CTx0&CTx1

PD12/D12/NAF4/PWM2E
252
Vss23
PC4/WE1/WE/DQMLU/TxD6

E IC1101 D13 253


PD13/D13/NAF5/PWM2F
PC3/WE0/DQMLL/RxD6

C1101 1 54
D14 254 PD14/D14/NAF6/PWM2G
VDD1 VSS3
2 53
3 PC2/RD/WR/SCK6

0.1u/10 255
DQ0 DQ15 R1108 D15 PD15/D15/NAF7/PWM2H
PB3/A3/TIOC0C

PB4/A4/TIOC0D

R1101
PB1/A1/TIOC0A
PB2/A2/TIOC0B

PB5/A5/TIOC1A
PB6/A6/TIOC1B

D0 C1102 3 52 D15 R1301 MDCLK


VDDQ1 VSSQ4 256 MD_CLK0
5 4 0.1u/10 4 51 5 4
D1 D14 NM
R5S7269*

DQ1 DQ14
PC1/RD

6 3 6 3
R1307

5 50
PVcc1

PVcc2

PVcc3

D2 D13
2 PVcc
47k

Vss1

Vcc1

Vss2

Vcc2

DQ2 DQ13
7 2 6 49 C1106 7 2
D3 D12
VSSQ1 VDDQ4
8 1 7 48 0.1u/10 8 1
1

6
7
8
9

220
5

220
10
11
VTL1127-A 12
13
14
15
16
17
DAMT18

19
20
21
22
23
24
25
26
27

DQ3 DQ12
8 47
DQ4 DQ11
L1313

R1102 R1109
D4 C1103 9 46 D11
VTL1127-A

VDDQ2 VSSQ3
VTL1127-A

VTL1126-A

5 4 0.1u/10 10 45 5 4
D5 D10
L1315
0.1u/10

L1312

DQ5 DQ10
C1310

L1311

L1305

R1418

6 3 11 44 6 3
100

D6 D9
DQ6 DQ9
7 2 12 43 C1107 7 2
D7 D8
VSSQ2 VDDQ3
8 1 0.1u/10 8 1
R1346

4.7k

R1316

R1317

R1318

13 42
4.7k

220
NM

220
R1311

R1313

DQ7 DQ8
0.22u/16
0.1u/10
C1311

0.1u/10
C1312

C1313

C1314

C1399

C1315

C1104 R1106
0.1u/10

0.1u/10

14 41 UDQM
NM

100k

VDD2 VSS2
R1315
4.7k

4.7k

470
LDQM R1103 0.1u/10 15 40 L1107 SDCK
LDQM NC2
470 5 4 16 39 CTF1645-A
WE C1108
WE UDQM
R1312

R1314

6 3
R1319

17 38
4.7k

4.7k

CAS
100k

CAS CLK 47p/50 R1112 CKE


7 2 18 37
RAS
RAS CKE R1110 470
1 470
SDCS R1104 8 19 36 R1113 A12 SH-TUN BUS
CS NC1
USBCNT
USBFLG

470 5 4 20 35 5 4 NM
BA0 A11
BA0 A11
6 3 21 34 6 3
BA1 A9
7 2 22
BA1 A9
33 7 2 SH-POWER BUS
A10 A8
A10_AP A8
8 1 23 32 8 1
A0 A7
A0 A7
5 4 5 4
A1 24
A1 A6
31 A6 SH-SYS BUS
6 3 25 30 6 3
A2 A5
A2 A5
7 2 7 2
DIMMER

A3 26 29 A4
A3 A4
F 8
R1105
470
1 C1105

0.1u/10
27
VDD3 VSS1
28 8
R1111
470
1
SH-I/O BUS
M12L128168A-5TG2N
DACMUTE
UDQM
LDQM

SDCS
RAS

CAS

CKE

GNDD
WE

A0
A1
A2

A3

A4
A5

INNER BUS

A 3/6
AVH-X1600DVD/XNUC
122
1 2 3 4
_ _
NM
USBFLG L1305 16 177 VDEC_D7

O0_1
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6 PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H
C1313 VTL1126-A C1344
17

PBIO1_1
PVcc3 Vcc13 176
0.1u/10 DAMT18 R1414 L1415
DACMUTE R1318 PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7 PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175 0.1u/10 B0
C1362
100k 19 Vss2 Vss15 174 100 VTL1126-A
56p/50

GNDD
A3 20 PB4/A4/TIOC0D PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G 173 VDEC_D6
R1319 C1314 21 172 C1345
Vcc2 PVcc13
DIMMER 100k 0.1u/10 R1418 22 171 0.1u/10 VDEC_D5
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F
C1399 C1363
100 23 PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0 170 R1412 L1413 56p/50 B1
0.22u/16 100 VTL1126-A
USBCNT 24 PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD PG15/D31/LCD_DATA15/PINT7 169 R1410 L1411 B2
100 VTL1126-A C1364
A4 25 PB5/A5/TIOC1A PG14/D30/LCD_DATA14/PINT6 168 R1408 L1409 56p/50 B3
100 VTL1126-A C1365
A5 26 PB6/A6/TIOC1B PG13/D29/LCD_DATA13/PINT5 167 R1406 L1407 56p/50 B4
C1315 L1315 C1346 100 VTL1126-A C1366
27 PVcc4 Vcc12 166
0.1u/10 VTL1127-A 56p/50
A6 28 PB7/A7/TIOC2A PG12/D28/LCD_DATA12/PINT4 165 0.1u/10 R1404 L1405 B5
100 VTL1126-A C1367
29 Vss3 Vss14 164
163 56p/50
A7 30 PB8/A8/TIOC2B PG11/D27/LCD_DATA11/PINT3/TIOC3D R1402 L1403 G0
C1316 L1316 C1347 100 VTL1126-A C1368
31 Vcc3 PVcc12 162
VTL1127-A 56p/50
A8 0.1u/10 32 PB9/A9/TIOC3A PG10/D26/LCD_DATA10/PINT2/TIOC3C 161 0.1u/10 R1400 L1401 G1
100 VTL1126-A C1369
A9 33 PB10/A10/TIOC3B PG9/D25/LCD_DATA9/PINT1/TIOC3B 160 R1398 L1399 56p/50 G2
100 VTL1126-A C1370
34 159

IC1302
A10 PB11/A11/TIOC3C PJ4/DV_DATA4/LCD_DATA4/SD_CLK_1/PWM1E 56p/50 VDEC_D4
35 158
5

A11 PB12/A12/TIOC3D PJ3/DV_DATA3/LCD_DATA3/SD_D0_1/PWM1D VDEC_D3

5
R5S72690RW266FP
R1303 L1301 36 157
MCK PJ19/DV_DATA19/LCD_DATA19/MISO0/TIOC0D/SIOFRxD/AUDIO_XOUT PJ2/DV_DATA2/LCD_DATA2/SD_D1_1/PWM1C VDEC_D2
C1309 CTF1786-A C1317 L1317 C1348
0 37 PVcc5 Vcc11 156
47p/50 VTL1127-A SCS 38 155 L1397
SCS 0.1u/10 PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2 PG8/D24/LCD_DATA8/PINT0/TIOC3A 0.1u/10 R1396 G3
BA0 R1353 100 VTL1126-A C1371
39 Vss4 Vss13 154
0
40 56p/50
A12 R1354 PB13/A13/QIO2_1/SPBIO2_1 PJ1/DV_DATA1/LCD_DATA1/SD_WP_1/PWM1B 153 VDEC_D1
NM C1318 L1318 C1349
41 Vcc4 PVcc11 152
BA1 R1355
0 0.1u/10 VTL1127-A
TPIRQN 42 PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2 PJ0/DV_DATA0/LCD_DATA0/SD_CD_1/PWM1A 151 0.1u/10 VDEC_D0
R1347 TPIRQ 43 C1372
STV2 R1428 0 R1341 PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1 PG7/D23/LCD_DATA7/IRQ7/TIOC2B 150 R1395 L1394 56p/50 G4
0 100k 100 VTL1126-A
OEV R1429 R1356 0 44 PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1 PG6/D22/LCD_DATA6/IRQ6/TIOC2A 149 R1392 L1393 G5
0 R1389 100 VTL1126-A C1373
BA0 R1357 45 PB14/A14/QIO3_1/SPBIO3_1 PG5/D21/LCD_DATA5/IRQ5/TIOC1B 148 100 L1391 56p/50 R0
NM R1388 L1390 VTL1126-A R1
BA1 R1358 46 PB15/A15/QIO2_0/SPBIO2_0 PG4/D20/LCD_DATA4/IRQ4/TIOC1A 147 100 L1387 VTL1126-A R2
NM C1319 L1319 C1350 R1386 VTL1126-A C1374 56p/50
FLSIO2 R1359 47 PVcc6 Vcc10 146
100 C1351
0 MT10 48 C1375 56p/50
FLSIO3 R1360 0.1u/10 VTL1127-A PB16/A16/QIO3_0/SPBIO3_0 PG3/D19/LCD_DATA3/IRQ3/TIOC0D 145 0.1u/10
12p/50

2
0 C1376 56p/50
49 Vss5 Vss12 144

3 X2
FLCK 50

GND1
PB17/A17/QSPCLK_0/RSPCK0/SPBCLK AUDIO_X1 143
C1320 51 R1350
Vcc5 AUDIO_X2 142 X1303
0.1u/10 CSS1794-A
FLCS 52 1.5k C1352
R1322 PB18/A18/QSSL_0/SSL00/SPBSSL PVcc10 141 X1

GND2
16.9344MHz

FLSIO0 53 0.1u/10 C1353

4
PB19/A19/QMO_0/QIO0_0/MOSI0/SPBMO_0/SPBIO0_0 PG2/D18/LCD_DATA2/IRQ2/TIOC0C 140 1
47k 12p/50
FLSIO1 54 PB20/A20/QMI_0/QIO1_0/MISO0/SPBMI_0/SPBIO1_0 Vss11 139 C1377
56p/50 R3
55 Vss6 PG1/D17/LCD_DATA1/IRQ1/TIOC0B 138 R1385 100 L1384 VTL1126-A
C1354 R4
56 PB21/A21/CRx2/IERxD Vcc9 137 R1382 100 C1379
L1383

PB21
C1321 57 0.1u/10 VTL1126-A 56p/50
Vcc6 PG0/D16/LCD_DATA0/IRQ0/TIOC0A 136 R5
0.1u/10 R1380 100 L1381
58 PB22/A22/CTx2/IETxD/CS4 135 VTL1126-A
Vss10
R1320 100k C1380

PB22
59 PC0/CS0/MD_BOOT2 TCK 134 56p/50 TCKJ
C1322 L1322
60 PVcc7 133 TMSJ
TMS
SDCK R1344 0.1u/10 VTL1127-A 61 132 TDIJ
CKIO TDI
15
62 TDO 131 TDOJ
Vss7
C1359 NM R1321

6
6

100k 63 ASEBRKJ
C1398 PA0/MD_BOOT0 ASEBRKAK/ASEBRK 130
C1323 L1323 R1351
64 129
INNER BUS

NM Vcc7 TRST
C1397 0.1u/10 VTL1127-A 1k TRSTJ
NM
C1396 R1352

PLLVcc
USBUVss
1 8

VIDEO_X1
VIDEO_X2

EXTAL
XTAL
Vss9

NMI
USBAPVss
USBAPVcc
PVcc9

PLLVss1
VDAVcc
VDAVss

USBAVcc
USBAVss
PH1/AN1/PINT1
PH2/AN2/PINT2
PH3/AN3/PINT3

PJ31/DV_CLK
REFRIN

USBDVcc
USBDVss
USBUVcc

PJ28/SSISCK5/TIOC1B/RTS7
PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK

PJ30/SSIDATA5/TIOC2B/IETxD
PE2/SCL1/TCLKC/IOIS16/DV_VSYNC
AVref

PJ29/SSIWS5/TIOC2A/IERxD

PA1/MD_BOOT1
NM
2 7

65
66
67
69
72
PE3/SDA1/TCLKD/ADTRG/DV_HSYNC 73
PE4/SCL2/RxD4/DV_VSYNC 74
PE5/SDA2/RxD5/DV_HSYNC 75
PE6/SCL3/RxD6 76
PE7/SDA3/RxD7 77
PVcc8 78
79
Vss8 80
ASEMD 81
Vcc8 82
83
84
85
86
PLLVss2 87
RES 88
RTC_X1 89
RTC_X2 90
USBDPVcc 91
USBDPVss 92
DM 93
DP 94
VBUS 95
96
97
98
99
100
101
102
103
104
USB_X1 105
USB_X2 106
107
108
109
110
111
112
VIN1 113
VIN2 114
VRT 115
VRB 116
BIAS 117
PH0/AN0/PINT0 118
119
120
121
PH4/AN4/PINT4 122
PH5/AN5/PINT5/LCD_EXTCLK 123
AVss 124
PH6/AN6/PINT6 125
AVcc 126
PH7/AN7/PINT7 127
128
C1395
3 6
NM C1334 4 5
SH-I/O BUS

PE0/SCL0/TCLKA/LCD_EXTCLK 70 R1323
71 R1383

68 R1384
C1393 0.1u/10

NMI
1k

L1302
47k
SH-TUN BUS

TP1301
1k
CPPW
SH-SYS BUS

R1391

100
100
NM

CTF1545-A
100k
100k
100k

NM
NM

100k

R1432
R1436
R1411

NM

R1433
R1409
SH-POWER BUS

BLR R1431

R1407
R1401
C1394
NM

NM
R1405 NM
R1403 NM

5.6k
C1388

R1334
R1329
R1326
R1325
R1435

C1335
R1330
R1335
100k

0.1u/10
R1340
2.2k

100k
R1324
R1333
C1391
C1333
R1328
C1332
C1331
R1327
C1328
C1327
C1326
R1336
C1325
C1324

0.1u/10
0.1u/10

0.1u/10

0.1u/10
0.1u/10

0.1u/10

0.1u/10
0.1u/10

NM
330p/50
R1434 100k

C1385 NM
F%

47k
47k
47k
680
NM

47k

100k
R1338 100k
0

C1384 1u/10
24k F%

DCH1246-A-T
C1329 0.1u/10
C1330 0.1u/10
C1386
A 5/6

SC33

C1341

GNDD
1000p/50

27k
X1301
0.1u/10
X1302 R1331 10k 4 R1422 C1356
A 6/6
A 4/6
A 2/6

IC1301 X2 3 1000p/50

0
4 GND2 NM
X2 3 C1389 0.01u/16

R1424
GNDD

GND2

R1339
FLCS_1 1 CS 8 C1336
SOC33_1

GNDUSB
GNDUSB
VCC C1387 C1358
1 2

4.7k
1u/10

R1387
FIO1_1 R1419 2 SO/SIO1 7 R1349 1 2 GND1
HOLD DCH1246-A-T X1 330p/50 CCG1192-A
0 0 GND1

48.000MHz
X1

NM
3 WP 6
A-b 3/6

CSS1760-A 10u

100
C1355

TAGGING
SCLK

R1332

13.3333MHz
CSS1840-A SH_L

C1392
4 GND 5 R1256 48.00MHz

12p/50
10p/50
10p/50

C1340
C1339
C1338
C1337

12p/50
SI/SIO0 13.3333MHz 0.01u/16
GNDD
B
A

D
C

SH_R
L1304

0
R1253
VTL1129-A

MX25L8006EM2I-12G USB5 C1357


SH-ANA BUS

0 CCG1192-A
10u

SH-SYS BUS
L1303

SHSTBY

AVH-X1600DVD/XNUC
SHRST

SHMUTE
DP
DM
VTL1129-A
SOC33
Consists of

SH-I/O BUS
SHRST
SOC12

7
7

R1337
R1348

100
100
G AVH-X1690DVD/XNID
F AVH-X1650DVD/XNRI

MTCH_SCL0
MOTHER PCB

MTCH_SDA0
LPSYNC
E AVH-X1650DVD/XNRD
AVH-X1650DVD/XNRC
AVH-X1600DVD/XNUC

BLERR
AVH-X1600DVD/XNEW5
AVH-X1600DVD/XNUW5

A 1/6
INTERFACE PCB

INNER BUS
FIO0_1
FLCLK_1
V_SCL0
V_SDA0
CP_SCL
VDECSTUS

VDECCLK
VDEC_VD
CP_SDA
VDEC_HD
ASEMDJ

CPRST
CPPW
BCK

TDIJ
MCK

TCKJ
FLCS
FLCK

TMSJ
TDOJ
DATA
LRCK
DEEM

CPPW

TRSTJ
CPRST

FLSIO1
FLSIO3
FLSIO2
FLSIO0
SERVICE UNIT(MOTHER I/F)

NM
CP_SCL

R1288
CP_SDA

ASEMDJ

ASEBRKJ
IC1151
DACMUTE

WM8761BGED
220

SOC33
R1209

47
47
47
47
A, D
1 LRCIN 14

R1252
R1259
R1260
R1257
C1287 MCLK
13

R1287
R1286
R1285
R1284
R1283
R1282
R1281
R1258 47
2 DIN

R1251 22
R1262

B, C, E, F, G
ipod CP

NM FORMAT

GNDD
NM 3 BCKIN 12
R1206
R1205

R1261 C1151 DEEMPH


11
DAC

except P-V

4 NC1
NM NM
USB(SH Decode):+2.2 dBs

C1152 NC2
5 CAP 10

NM
NM
NM
NM
NM
NM
NM
MUTE R1152
100
100
A 3/6 MOTHER

LSAR523UB CCG1192-A 9

SOC33_1

GNDD
6 VOUTR
Q1201 10u VOUTL

CXX5991
CXX5989
NC3 NC2 8

*
820
3216
2125
1608

GNDD
7 GND

10
11
12
13
14
15
16

9
5 4 VDD
SCL PAD NC1
C1156

GNDA
1151 - : DAC
(SH BLOCK)

SI
1281 - : JTAG

WP
VIO
1800p/50

6 3 C1153

VSS
SCK
RST SDA
1251 - : FLASH

9
8
7
6
5
4
3
2
1

12
11
10
DNU2
DNU4
DNU3
1101 - : SDRAM

9 0.1u/10
PCB

7 2

FLASH
1201 - : IPOD CP

R1203
R1201
GNDA

NM
1301 - : SH PART

VCC GND
C1157

C1154

IC1251

CXX5989

to JTAG JIG
NM

TDI
L1201

8 1

TCK
CHIP SIZE LEGEND

TMS
TDO
CCG1192-A

GND
GND
TRST
C1155

MDMP

A_RST
1800p/50

10u

SOC33
C1202
1000p/50

IC1202
2.2k
2.2k

NM

ASEBRE
R1151

SOCRST
SO 8
CS 7
RFU 6
NC 5
DNU1 4
RESET 3
VCC 2
HOLD 1
GNDD

337S3959
1001 - : RGB VIDEO ISO

C1252 820
1051 - : VIDEO DECODER

L1251 GND4 R1202

CN1281
R1254 NM
L1151

CTF1786-A 18k
C1201
SOC33

NM
GNDD

V D5
CTF1786-A

0.1u/10
GNDD

C1251
8

8
0.1u/10

A 3/6
123
E
A

D
C

F
B
4 3 2 1
124
AVH-X1600DVD/XNUC
PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5 VDCRST
177 VDEC_D7
O0_1

PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H
C1344
PBIO1_1

Vcc13 176
R1414 L1415
PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175 0.1u/10 B0
C1362
Vss15 174 100 VTL1126-A
56p/50
GNDD

PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G 173 VDEC_D6


172 C1345
PVcc13 F
PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F 171 0.1u/10 VDEC_D5
C1363
170 R1412 L1413 56p/50 B1
A-b 3/6

PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0
100 VTL1126-A
PG15/D31/LCD_DATA15/PINT7 169 R1410 L1411 B2
100 VTL1126-A C1364
PG14/D30/LCD_DATA14/PINT6 168 R1408 L1409 56p/50 B3
100 VTL1126-A C1365
PG13/D29/LCD_DATA13/PINT5 167 R1406 L1407 56p/50 B4
166 C1346 100 VTL1126-A C1366
Vcc12
56p/50
PG12/D28/LCD_DATA12/PINT4 165 0.1u/10 R1404 L1405 B5
100 VTL1126-A C1367
Vss14 164
163 56p/50
PG11/D27/LCD_DATA11/PINT3/TIOC3D R1402 L1403 G0
C1347 100 VTL1126-A C1368
PVcc12 162
56p/50
PG10/D26/LCD_DATA10/PINT2/TIOC3C 161 0.1u/10 R1400 L1401 G1
100 VTL1126-A C1369
PG9/D25/LCD_DATA9/PINT1/TIOC3B 160 R1398 L1399 56p/50 G2
100 VTL1126-A C1370
159
IC1302

PJ4/DV_DATA4/LCD_DATA4/SD_CLK_1/PWM1E 56p/50 VDEC_D4


PJ3/DV_DATA3/LCD_DATA3/SD_D0_1/PWM1D 158 VDEC_D3
R5S72690RW266FP

PJ2/DV_DATA2/LCD_DATA2/SD_D1_1/PWM1C 157 VDEC_D2


156 C1348
Vcc11
155 L1397
PG8/D24/LCD_DATA8/PINT0/TIOC3A 0.1u/10 R1396 G3
100 VTL1126-A C1371
Vss13 154
56p/50
PJ1/DV_DATA1/LCD_DATA1/SD_WP_1/PWM1B 153 VDEC_D1
E
C1349
PVcc11 152
PJ0/DV_DATA0/LCD_DATA0/SD_CD_1/PWM1A 151 0.1u/10 VDEC_D0
C1372
PG7/D23/LCD_DATA7/IRQ7/TIOC2B 150 R1395 L1394 56p/50 G4
100 VTL1126-A
PG6/D22/LCD_DATA6/IRQ6/TIOC2A 149 R1392 L1393 G5
R1389 100 VTL1126-A C1373
PG5/D21/LCD_DATA5/IRQ5/TIOC1B 148 100 L1391 56p/50 R0
R1388 L1390 VTL1126-A R1
PG4/D20/LCD_DATA4/IRQ4/TIOC1A 147 100 L1387 VTL1126-A R2
C1350 R1386 VTL1126-A C1374 56p/50
Vcc10 146 100 C1351
C1375 56p/50
PG3/D19/LCD_DATA3/IRQ3/TIOC0D 145 0.1u/10
12p/50
2

C1376 56p/50
Vss12 144
3 X2
GND1

AUDIO_X1 143
R1350
X1303

AUDIO_X2 142
CSS1794-A

1.5k C1352
PVcc10 141
X1

GND2
16.9344MHz

0.1u/10 C1353
4
1

PG2/D18/LCD_DATA2/IRQ2/TIOC0C 140 12p/50


Vss11 139 C1377
56p/50 R3
PG1/D17/LCD_DATA1/IRQ1/TIOC0B 138 R1385 100 L1384 VTL1126-A
C1354 R4
Vcc9 137 R1382 100 L1383 C1379
0.1u/10 VTL1126-A 56p/50
PG0/D16/LCD_DATA0/IRQ0/TIOC0A 136 R5
R1380 100 L1381
135 VTL1126-A
Vss10
C1380
D
TCK 134 56p/50 TCKJ
133 TMSJ
TMS
132 TDIJ
TDI
TDO 131 TDOJ
ASEBRKAK/ASEBRK 130 ASEBRKJ
R1351
129
INNER BUS

TRST
1k TRSTJ
R1352

USBUVss
1 8

VIDEO_X1
VIDEO_X2
Vss9
VIN1
VIN2

USBAPVss
USBAPVcc
PVcc9
VDAVcc
VDAVss

USBAVcc
USBAVss
PH1/AN1/PINT1
PH2/AN2/PINT2
PH3/AN3/PINT3

REFRIN
USBDVss
USBUVcc
AVref

2 7

97
98
99
100
101
102
103
104
USB_X1 105
USB_X2 106
107
108
109
110
111
112
113
114
VRT 115
VRB 116
BIAS 117
PH0/AN0/PINT0 118
119
120
121
PH4/AN4/PINT4 122
PH5/AN5/PINT5/LCD_EXTCLK 123
AVss 124
PH6/AN6/PINT6 125
AVcc 126
PH7/AN7/PINT7 127
128

3 6
4 5
SH-I/O BUS

47k
SH-TUN BUS
SH-SYS BUS
A-a A-b

100k
100k
100k

NM
NM

100k

R1432
R1436
R1411

NM

R1433
R1409
SH-POWER BUS

BLR R1431

R1407
R1401

NM
R1405 NM
R1403 NM

5.6k
C1388

R1325
R1435
100k

R1327
C1328
C1327
C1326
R1336
C1325
C1324

0.1u/10
0.1u/10

0.1u/10
0.1u/10

0.1u/10
330p/50

R1434 100k

F%
R1326 680
NM

24k F%

C1329 0.1u/10
C1330 0.1u/10
C1386
A 5/6

SC33

1000p/50
C
X1301

R1422
C1356
4
A 6/6
A 4/6
A 2/6

X2 3 1000p/50

NM
GND2 C1389 0.01u/16
GNDD
SOC33_1

GNDUSB
1 2 C1387 C1358
X1 GND1
330p/50 CCG1192-A

48.000MHz
CSS1760-A C1355 10u
SH_L
48.00MHz

10p/50
10p/50

C1338
C1337
0.01u/16

GNDD
SH_R
L1304

VTL1129-A

C1357
SH-ANA BUS

CCG1192-A
10u

L1303

VTL1129-A
SOC33
Consists of

SOC12
G AVH-X1690DVD/XNID
F AVH-X1650DVD/XNRI

MOTHER PCB
E AVH-X1650DVD/XNRD
D AVH-X1650DVD/XNRC
A AVH-X1600DVD/XNUC

BLERR
B AVH-X1600DVD/XNEW5
C AVH-X1600DVD/XNUW5

A 1/6
INTERFACE PCB

VDECSTUS

BCK
MCK

DATA
LRCK
DEEM

CPRST
SERVICE UNIT(MOTHER I/F)

IC1151

DACMUTE
WM8761BGED

220
SOC33

R1209
1 LRCIN 14
MCLK
2 DIN 13

ipod CP
FORMAT
3 BCKIN 12
C1151 DEEMPH
4 11

DAC

except P-V
NM NC1

USB(SH Decode):+2.2 dBs


C1152 NC2
5 CAP 10
MUTE R1152
A 3/6 MOTHER

LSAR523UB CCG1192-A 6 9
10u VOUTR
Q1201 VOUTL
NC3 NC2 7 8 820

3216
2125
1608
GND
5 4 VDD
SCL PAD NC1

C1156

GNDA
1151 - : DAC
(SH BLOCK)

1281 - : JTAG

1800p/50
6 3 C1153
RST SDA

1251 - : FLASH
1101 - : SDRAM
9 0.1u/10
PCB

7 2

1201 - : IPOD CP

GNDA

NM
1301 - : SH PART
VCC GND

C1157
C1154

L1201
8 1

CHIP SIZE LEGEND


CCG1192-A

C1155

1800p/50
10u

C1202
1000p/50
IC1202 R1151

GNDD
337S3959

1001 - : RGB VIDEO ISO


820

1051 - : VIDEO DECODER


A

L1151

GNDD
V D5

CTF1786-A
4 3 2 1
8 7 6 5
125
AVH-X1600DVD/XNUC
A2 R1317 PB3/A3/TIOC0C
NM
USBFLG L1305 16 PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
C1313 VTL1126-A
17 PVcc3
0.1u/10 DAMT18
DACMUTE R1318 PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7
100k 19 Vss2
A3 20 PB4/A4/TIOC0D
R1319 C1314 21
F Vcc2
DIMMER 100k 0.1u/10 R1418 22 PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK
C1399 100 23 PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC
A-b 3/6

USBCNT 0.22u/16 24 PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD


A4 25 PB5/A5/TIOC1A
A5 26 PB6/A6/TIOC1B
C1315 L1315
27 PVcc4
0.1u/10 VTL1127-A 28
A6 PB7/A7/TIOC2A
29 Vss3
A7 30 PB8/A8/TIOC2B
C1316 L1316
31 Vcc3
0.1u/10 VTL1127-A 32
A8 PB9/A9/TIOC3A
A9 33 PB10/A10/TIOC3B
34
IC1302

A10 PB11/A11/TIOC3C
A11 35 PB12/A12/TIOC3D
R5S72690RW266FP

R1303 L1301 36
MCK PJ19/DV_DATA19/LCD_DATA19/MISO0/TIOC0D/SIOFRxD/AUDIO_XOUT
C1309 CTF1786-A C1317 L1317
0 37 PVcc5
47p/50 VTL1127-A SCS 38
SCS 0.1u/10 PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2
BA0 R1353 39
0 Vss4
A12 R1354 40 PB13/A13/QIO2_1/SPBIO2_1
E
NM C1318 L1318
41 Vcc4
BA1 R1355
0 0.1u/10 VTL1127-A
TPIRQN 42 PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2
R1347 TPIRQ 43
STV2 R1428 0 R1341 PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1
0 100k
OEV R1429 R1356 0 44 PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1
0
BA0 R1357 45 PB14/A14/QIO3_1/SPBIO3_1
NM
BA1 R1358 46 PB15/A15/QIO2_0/SPBIO2_0
NM C1319 L1319
FLSIO2 R1359 47 PVcc6
0 MT10 48
FLSIO3 R1360 0.1u/10 VTL1127-A PB16/A16/QIO3_0/SPBIO3_0
0
49 Vss5
FLCK 50 PB17/A17/QSPCLK_0/RSPCK0/SPBCLK
C1320 51 Vcc5
0.1u/10 52
FLCS R1322 PB18/A18/QSSL_0/SSL00/SPBSSL
FLSIO0 53 PB19/A19/QMO_0/QIO0_0/MOSI0/SPBMO_0/SPBIO0_0
47k
FLSIO1 54 PB20/A20/QMI_0/QIO1_0/MISO0/SPBMI_0/SPBIO1_0
55 Vss6
56 PB21/A21/CRx2/IERxD
PB21

C1321 57 Vcc6
0.1u/10 58 PB22/A22/CTx2/IETxD/CS4
R1320 100k
PB22

59
D
PC0/CS0/MD_BOOT2
C1322 L1322
60 PVcc7
SDCK R1344 0.1u/10 VTL1127-A 61 CKIO
15
62
Vss7
C1359 NM R1321
100k 63
C1398 PA0/MD_BOOT0
C1323 L1323
NM 64 Vcc7
C1397 0.1u/10 VTL1127-A
NM
C1396
PLLVcc
Vcc8
USBUVss

EXTAL
XTAL

NMI
USBAPVss
USBAPVcc

PLLVss1
PLLVss2

PVcc8
USBAVcc
USBAVss

PJ31/DV_CLK
REFRIN

USBDVcc
USBDVss
USBUVcc

PJ28/SSISCK5/TIOC1B/RTS7
PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK

PJ30/SSIDATA5/TIOC2B/IETxD
PE2/SCL1/TCLKC/IOIS16/DV_VSYNC

PJ29/SSIWS5/TIOC2A/IERxD

NM
PA1/MD_BOOT1 65
66
67
69
72
PE3/SDA1/TCLKD/ADTRG/DV_HSYNC 73
PE4/SCL2/RxD4/DV_VSYNC 74
PE5/SDA2/RxD5/DV_HSYNC 75
PE6/SCL3/RxD6 76
PE7/SDA3/RxD7 77
78
79
Vss8 80
ASEMD 81
82
83
84
85
86
87
RES 88
RTC_X1 89
RTC_X2 90
USBDPVcc 91
USBDPVss 92
DM 93
DP 94
VBUS 95
96
97
98
99
100
101
102
103
104
USB_X1 105
USB_X2 106

C1395
NM C1334
PE0/SCL0/TCLKA/LCD_EXTCLK 70 R1323
71 R1383

68 R1384

C1393 0.1u/10
NMI
1k

L1302

TP1301
1k
CPPW
R1391

100
100

NM
CTF1545-A

A-a A-b
C1394
NM
5.6k

R1334
R1329

C1335
R1330

R1335
0.1u/10
R1340
2.2k

100k
R1324
R1333
C1391
C1333
R1328
C1332
C1331
R1327
C1328
0.1u/10

0.1u/10
0.1u/10

0.1u/10
0.1u/10

NM
C1385 NM
F%

47k
47k
47k
R1326 680

47k

100k
R1338 100k

0
C1384 1u/10

DCH1246-A-T
C1329 0.1u/10
C1330 0.1u/10

C1341

GNDD
C
27k

0.1u/10
IC1301 X1302 R1331 10k 4

0
4 G
X2 3
R1424
GND2
R1339
FLCS_1 1 CS 8 C1336
GNDUSB
GNDUSB

VCC
1
4.7k

SO/SIO1 1u/10
R1387

FIO1_1 R1419 2 7 R1349 1 2


HOLD DCH1246-A-T X1
0 0 X1 GND1
NM
3 WP 6 C
100

TAGGING
SCLK
R1332

13.3333MHz

CSS1840-A
C1392
4 GND 5 R1256
12p/50
10p/50

C1340
C1339
C1338

12p/50

SI/SIO0 13.3333MHz
0
R1253
MX25L8006EM2I-12G USB5
0

SH-SYS BUS
SHSTBY
SHRST

SHMUTE
DP
DM

SH-I/O BUS
SHRST
R1337
R1348

100
100
MTCH_SCL0
MTCH_SDA0
LPSYNC

INNER BUS
B

FIO0_1
FLCLK_1
V_SCL0
V_SDA0
CP_SCL

VDECCLK
VDEC_VD
CP_SDA
VDEC_HD
ASEMDJ

CPRST
CPPW

TDIJ
TCKJ
FLCS
FLCK

TMSJ
TDOJ
CPPW

TRSTJ
CPRST

FLSIO1
FLSIO3
FLSIO2
FLSIO0

NM
CP_SCL

R1288
CP_SDA

ASEMDJ

ASEBRKJ
220

SOC33
R1209

47
47
47
47
A, D

R1252
R1259
R1260
R1257
C1287

R1287
R1286
R1285
R1284
R1283
R1282
R1281
R1258 47
R1251 22
R1262

B, C, E, F, G
NM

GNDD
NM
R1206
R1205

R1261
except P-V

NM

NM
NM
NM
NM
NM
NM
NM
100
100
LSAR523UB

SOC33_1

GNDD
Q1201

CXX5991
CXX5989
NC3

GNDD
10
11
12
13
14
15
16

9
5
SCL

SI

WP
VIO
6

VSS
SCK
RST

9
8
7
6
5
4
3
2
1

12
11
10
DNU2
DNU4
DNU3
7

FLASH
R1203
R1201
VCC

IC1251

CXX5989

to JTAG JIG
NM

TDI
L1201
8

TCK
TMS
TDO

GND
GND
TRST
MDMP

A_RST
SOC33
C1202
1000p/50
I

2.2k
2.2k

NM

ASEBRE

SOCRST
SO 8
CS 7
RFU 6
NC 5
DNU1 4
RESET 3
VCC 2
HOLD 1
33
C1252
L1251 GND4 R1202

CN1281
NM
A
R1254 18k
CTF1786-A C1201

SOC33
NM

GNDD
0.1u/10

GNDD
C1251
0.1u/10
8 7 6 5
F
E
B
A

D
C

126
A-a A-b
A-b 3/6

A-a 3/6
RGB VIDEO ISOLATOR

1
1

DD5 INNER BUS

DEEM
VDCRST

10u
VDEC_D7
VDEC_D6
VDEC_D5

2520

L1005
SH-I/O BUS
B0
B1

L1001

POL
CLK
DIO
R1011

VCLK
LOAD
CTF1545-A 15p/50

C1006
10u 10V
Q1003 100

CCG1192-A
LSCR523UB
SH-SYS BUS C1382

GNDV

0
GNDD

C1001
R1381
SH-POWER BUS

0.1u/10
IC1001
1 5 C1010 GNDSIG
GNDV
C1362

C1383
6p/50
C1363

56p/50

2 SH-TUN BUS
56p/50

1u/10
L1004 GNDV GND
R1012 L1006 3 4 C1011 CSYNC
0

CTF1545-A C1005 VCC


NM
NM

100 NM 0.1u/10 N_CSYNC 1u/10


L1378

Q1002
R1378
C1378

LSCR523UB BH7673G SH-ANA BUS GNDD


C1381

2
2

IC1002 NM

C1002
1 5 C1012 GNDSIG

0.1u/10
L1415

L1306

2
R1426
0

1u/10
0
VTL1126-A

GNDV GND
VTL1127-A

L1007 C1013
L1413

3 4
0

GNDV
L1377

ANR
VCC
100 VTL1126 A

VTL1126-A

C1007
R1425
R1427

L1002 NM N_R 1u/10


R1010 0.1u/10
0

BH7673G R1013 C1014


100

330

CTF1545-A iCOMP
0
R1416
R1414

Q1001 100 100 iPodVideo 1u/10


C1360
47p/50

LSCR523UB 26pim
R1379

IC1003
R1412

1 5 C1015
R1365
R1376

GNDSIG
2 1u/10

C1003
GNDV GND
100

0.1u/10
L1008 3 4 C1016 ANB
C1008 VCC
N_B
100k

NM 1u/10
C1390
R1393
R1342
C1342
C1343
C1344
C1345

0.1u/10

0.1u/10
10p/50
0.1u/10
0.1u/10
0.1u/10

GNDV BH7673G only A, E


L1003 IC1004
R1009 1 5 C1017
CTF1545-A GNDSIG

Q1004 100 2 1u/10


GNDV GND
LSCR523UB L1009 3 4 C1018 ANG
C1009 VCC PG18
NM N_G 1u/10

AVH-X1600DVD/XNUC
0.1u/10 PG19
BH7673G

C1004
0.1u/10
181

191
184
182

189

192
190
187
186
185
183
180
179
178
177
173
172
171
170

188

MONVBS
GNDV
Vcc14
Vss16
Vcc13 176
Vss15 174

PVcc14
PVcc13

3
3

FLCLK_1 193 PF0/BREQ/QSPCLK_1/RSPCK1/TIOC4A/DREQ0/AUDCK


C1301 194 PVcc15
PG24/LCD_CLK

0.1u/10 FCS1
195
PG26/LCD_TCON1
PG25/LCD_TCON0

VIDEO DECODER FLCS_1 PF1/BACK/QSSL_1/SSL10/TIOC4B/DACK0


196 Vss17
FIO0_1 197 PF2/WAIT/QMO_1/QIO0_1/MOSI1/TIOC4C/TEND0/SPBMO_1/SPBIO0_1
FIO1_1 C1361 198 PF3/CS2/QMI_1/QIO1_1/MISO1/TIOC4D/AUDIO_XOUT/SPBMI_1/SPBIO1_1
R1390 R1308 NM
PG27/LCD_TCON2/LCD_EXTCLK

BCK 199 PF4/CS5/CE1A/SSISCK0/SGOUT_0


L1052
VDEC15 VDEC33 56p/50 R1309 NM
LRCK NM 200 PF5/SSIWS0/SGOUT_1
NM

0
NM
NM
NM
DATA R1310 201 PF6/CE2A/SSITxD0/SGOUT_2
100

0
0
202

C1077
SYStoSH R1302 PF7/SSIRxD0/RxD0/SGOUT_3/CTS1
PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H
PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G

R1080
R1079
R1087
C1065
C1067
PG18/DV_DATA4/LCD_DATA18/SPDIF_IN/SCK4

R1076
R1077
PG23/LCD_DATA23/LCD_TCON6/TxD5/AUDATA3
PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F

0.1u/10
0.1u/10
PG22/LCD_DATA22/LCD_TCON5/RxD5/AUDSYNC
PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5
PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5

203
PG19/DV_DATA5/LCD_DATA19/SPDIF_OUT/SCK5

GNDD
PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4

GNDV SHtoSYS 27k PF8/A23/TxD0


PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0

PF9
R1397 204 PF9/BS/DV_DATA0/SCK0/MMC_D4/RTS1
C1084 R1078 BCLK
PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175

Q1051 NM C1302 205


NM NM NM R1394 PVcc16
LRCLK
PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2

2.2k PF10
2.2k

0.1u/10

10u
206

10u
NM

NM
PF10/CS1/SSISCK1/DV_DATA1/SCK1/MMC_D5
R1399

R1086
C1072
C1076
DATA_BT 207 Vss18
R1074
R1075

NM

CCG1192-A
CCG1192-A
VDEC15 R1373 208 PF11/SSIWS1/DV_DATA2/RxD1/MMC_D6
V_SCL0
VDEC33
GNDV 32.000MHz V_SDA0 209 PF12/SSIDATA1/DV_DATA3/TxD1/MMC_D7
NM

75
C1071 5p/50 VDEC_FLD R1377 210

1u/10
PF13/A24/SSISCK2/SCK2

0
1
4
R1368 211

0
BTTOSH PF14/A25/SSIWS2/RxD2

R1051
C1062
R1052
1
4

4
4

NM

470
NM

R1083
SHTOBT R1421 212 PF15/A0/SSIDATA2/WDTOVF/TxD2/UBCTRG
NM C1303 213 PVcc17

100
100 R1059
1M
0.1u/10 214 PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5

4.7k

10u
R1071

C1057
C1058
C1060
C1063 10u
C1064
R1053
R1058
CSS1818-A

215

0.1u/10
Vss19

1000p/50
0.01u/16
CCG1192-A

CCG1192-A
2
3 3 X1051

47k SHIRQ 216 PF16/SD_CD_0/FCE/IRQ4/MMC_CD

R1055
R1056
C1075 BGSENS1 R1374 217 PF17/SD_WP_0/FRB/IRQ5
NM
5p/50
C1070

0.01u/16

64
63
61
60
59
58
57
56
55
54
53
52
51
49
C1083 only A, E PCHANG R1375 218 PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1
1u/10
1 48 GNDD C1085 R1072 NM PJ11
5p/50 VDCRST 219 PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6

SAS
SCL
C1054 2 SDA 47 R1073 100 VDECCLK MTCHRST R1304 NM 220 PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7

AGND4
AVDD4 62
CVBS4
CVBS3
CVBS2
CVBS1
DGND5
XOSCO 50
XOSCI

NM
GIN1

75
PGND_A
PVDD_A

R1085
0.01u/16 3 GIN2 RESETN 46 100 C1073 L1051 R1305

R1088
DVDD_C5
USB_SW R1306 120 221 PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
CLKO CTF1740-A

DVDD_IO4
C1055 AVDD1
4 DVDD_IO3 45 0.1u/10 C1304 222
1000p/50 AGND1 DGND4 PVcc18
100k
5 44 C1074 BLEN 0.1u/10 223
BIN1 DVDD_C4 PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0
0.1u/10
C1082 1u/10 6 43 R1060 224

89
VDEC_D7

84
5
Vss20

M
BIN2 DO7
4

1
R1071

C
C
C
C
C
R
R
CS
215

0.1
Vss19

1000
0.01
CCG

CCG
2
33
47k SHIRQ 216 PF16/SD_CD_0/FCE/IRQ4/MMC_CD

R1055
R1056
C1075 BGSENS1 R1374 217 PF17/SD_WP_0/FRB/IRQ5
NM

5p/50
C1070
0.01u/16

57

64
63
61
60
59
58
56
55
54
53
52
51
49
C1083 only A, E PCHANG R1375 218 PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1
1u/10
1 48 GNDD C1085 R1072 NM PJ11
5p/50 VDCRST 219 PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6

SAS
SCL
SDA
C1054 2 47 R1073 100 VDECCLK MTCHRST R1304 NM 220 PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7

AGND4
AVDD4 62
CVBS4
CVBS3
CVBS2
CVBS1
DGND5
XOSCO 50
XOSCI

NM
GIN1

75
PGND_A
PVDD_A

R1085
0.01u/16 3 GIN2 RESETN 46 100 C1073 L1051 R1305

R1088
DVDD_C5
USB_SW R1306 120 221 PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
CLKO CTF1740-A

DVDD_IO4
C1055 AVDD1
4 DVDD_IO3 45 0.1u/10 C1304 222
1000p/50 AGND1 DGND4 PVcc18
100k
5 44 C1074 BLEN 0.1u/10 223
BIN1 DVDD_C4 PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0
0.1u/10
C1082 1u/10 6 43 R1060 VDEC_D7 224 Vss20
BIN2 DO7

75
NM
390 R1345 PF20
7 42 R1061 225

R1089
VDEC_D6

R1084
REF DO6 47k PF20/SD_CLK_0/SSIDATA3/MMC_CLK
390 C1305
C1051 C1056 8 41 R1062 VDEC_D5 226 Vcc15
REFP IC1051 DO5 390
0.47u/6.3 0.01u/16 9 40 R1063 0.1u/10 227
C1052 VDEC_D4 PF21/SD_CMD_0/SCK3/MMC_CMD
REFN ML86V7675TBZA3A DO4 390

C1053
10 39 R1064 228
5

VDEC_D3 PF22/SD_D3_0/RxD3/MMC_D3

5
0.47u/6.3

0.47u/6.3
AGND2 DO3 390
11 38 R1065 VDEC_D2 229 PF23/SD_D2_0/TxD3/MMC_D2
C1078 TAOUT DO2 390
GNDV 1u/10 12 R1066 230
DO1 37 VDEC_D1 D0 PD0/D0/PWM1A
RIN1 DO0 390
13 R1067 VDEC_D0 C1306 231
RIN2 VSYNC_L 36 PVcc19
C1081 HSYNC_L 390 SSCK
0.1u/10

75
14 R1068 232

NM
1000p/50 FID 35 VDEC_VD SSCK PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7
AVDD3

R1082
R1090
C1080 220
0.01u/16 15 34 R1069 VDEC_HD 233 Vss21
AGND3 220

DVDD_C1
DGND1
16 33 R1070 VDEC_FLD D1 234 PD1/D1/PWM1B
CSYNC_A
560

DVDD_IO1
CHSI
VSI
TEST1
TEST2
TEST3
DVDD_C2
DGND2
SLEEP
STATUS
DVDD_C3
DGND3
DVDD_IO2
DE
D2 235 PD2/D2/PWM1C
C1079
1u/10

75
236

17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
D3

NM
PD3/D3/PWM1D

R1081
R1091
R1057 SDI
VDECSTUS SDI 237 PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7
560 SDO
SDO 238 PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7
R1423
GNDV GNDD VSYNC BLSYNC 239 PJ27/SGOUT_3/TIOC1A/CTS7
HSYNC 2.2k C1307 240
R1430 PVcc20
C1086 0.1u/10 241 Vss22

47k
NM

C1059
C1061
C1066
R1054
C1068
C1069
0.1u/10
0.1u/10 242

0.1u/10
0.1u/10

0.1u/10
D4

0.1u/10
PD4/D4/FRE/PWM1E
D5 243 PD5/D5/FCLE/PWM1F
GNDV GNDD
D6 244 PD6/D6/FALE/PWM1G
GNDD 245
D7 PD7/D7/FWE/PWM1H
D8 246 PD8/D8/NAF0/PWM2A
247

6
6

D9 PD9/D9/NAF1/PWM2B
SOC33 D10 248 PD10/D10/NAF2/PWM2C
D11 249 PD11/D11/NAF3/PWM2D
SDRAM C1308 250 PVcc21
D12 0.1u/10 251 PD12/D12/NAF4/PWM2E

L1101
252

CTF1786-A
Vss23
IC1101 D13 253
PD13/D13/NAF5/PWM2F
C1101 1 54
D14 254 PD14/D14/NAF6/PWM2G
VDD1 VSS3
0.1u/10 2 53 255
DQ0 DQ15 R1108 D15 PD15/D15/NAF7/PWM2H
R1101 C1102
D0 3 52 D15 R1301 MDCLK 256
VDDQ1 VSSQ4 MD_CLK0
5 4 0.1u/10 4 51 5 4
D1 D14 NM
DQ1 DQ14
6 3 5 50 6 3
D2 D13
DQ2 DQ13
47k

7 2 C1106 7 2
R1307

D3 6 49 D12
PC1/RD
PVcc1
PC2/RD/WR/SCK6
PC3/WE0/DQMLL/RxD6
PC4/WE1/WE/DQMLU/TxD6
PC5/RAS/CRx0/CRx0/CRx1/CRx2/IRQ0
PVcc2
PC6/CAS/SCK7/CTx0/CTx0&CTx1&CTx2
Vss1
PC7/CKE/RxD7/CRx1/CRx0/CRx1/IRQ1
Vcc1
PC8/CS3/TxD7/CTx1/CTx0&CTx1
PB1/A1/TIOC0A
PB2/A2/TIOC0B
PB3/A3/TIOC0C
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
PVcc3
PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7
Vss2
PB4/A4/TIOC0D
Vcc2
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK
PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC

R5S7269*

VSSQ1 VDDQ4
8 1 0.1u/10 8 1
1
2 PVcc
3
4
6
7
8
9

7 48
5

220 220
10
11
13
14
15
16
17
19
20
21
22
23

DQ3 DQ12
8 47
R1102 DQ4 DQ11 R1109
C1103
DAMT18

D4 9 46 D11
VDDQ2 VSSQ3
L1313

5 4 0.1u/10 10 45 5 4
D5 D10
VTL1127-A 12

DQ5 DQ10
6 3 6 3

AVH-X1600DVD/XNUC
D6 11 44 D9
100

L1312

DQ6 DQ9
L1311

C1310
L1305

VTL1127-A
R1418

VTL1127-A
VTL1126-A

0.1u/10

7 2 12 43 C1107 7 2
D7 D8
VSSQ2 VDDQ3
8 1 13 42 0.1u/10 8 1
220

7
7

220 DQ7 DQ8


4.7k

NM
4.7k

C1104 14 41 R1106
R1346
R1316
R1317
R1318

UDQM
R1311
R1313

VDD2 VSS2
NM

470
C1311
C1312
C1313
C1314
C1399

0.1u/10

15 40
0.1u/10

R1103 0.1u/10
100k

LDQM L1107 SDCK


4.7k
4.7k
0.1u/10
0.1u/10

LDQM NC2
R1315

470 5 4 16 39 CTF1645-A
WE C1108
WE UDQM
6 3 17 38
CAS
CAS CLK 47p/50 R1112 CKE
4.7k
4.7k

R1312
R1314

7 2
100k

18 37
R1319

RAS
RAS CKE R1110 470
1 470
SDCS R1104 8 19 36 R1113 A12 SH-TUN BUS
CS NC1
470 5 4 20 35 5 4 NM
BA0 A11
BA0 A11
6 3 21 34 6 3
BA1 A9
USBFLG

BA1 A9 SH-POWER BUS


7 2 22 33 7 2
A10 A8
A10_AP A8
8 1 23 32 8 1
A0 A7
A0 A7
5 4 24 31 5 4
A1 A6 SH-SYS BUS
A1 A6
6 3 25 30 6 3
A2 A5
A2 A5
7 2 26 29 7 2
A3 A4
A3 A4
8 1 C1105 27 28 8 1
R1105 VDD3 VSS1 R1111
DIMMER

470 0.1u/10 470 SH-I/O BUS


M12L128168A-5TG2N

GNDD
WE
LDQM
UDQM
RAS
CAS
CKE
SDCS
A0
A1
A2
DACMUTE
A3

INNER BUS
8

8
A-a A-b

A-a 3/6
A-b 3/6

127
E
A

D
C

F
B
1 2 3 4

10.4 MOTHER PCB (POWER SUPPLY BLOCK)

1
2
EV12 12.3V 18.0V
V18HI CN1831
A EV12
R1853
Q1853
V18 NM
DA2J101
D1853

270k 3 4 D1852 L1851 R1864


Q1851
14.1V
FAN
LSCR523UB 2 NM NM NM

R1858

NM
3 4 5

CCG1244-A-T
R1851

R1865

R1857
NM

68k
680

2 1 6 IC1851

NM
C1855

R1852
Q1854

C1856

22k
RN4982

10u/6.3
5 D NM C1858 8 1

NM
NM
EaIn

R1854

C1853
FB

NM

NM (D)
6

27k
1

NM
NM
NM
NM

R1859
7 2

(D)
G Q1855

R1863
C1854
SCP

C1860

C1861
OSC

NM

NM

NM
Q1852 NM
6 3
DZ2J130M0

HN1B04FU(YGR) Vcc
D1851
C1851

C1852

GND

C1831

C1832
C1833
0.1u/16

NM

R1831
R1836
S 5 4

NM
Out BR/CTL

NM (D)
GNDA GNDA

C1857
R1860

R1861

R1862
C1859
NM

NM

NM
NM
R1866

Q1856 10 GNDFA
GNDA DD5 1 6
GNDHI
5
R1868 GNDA 2
10k
3 4

RN1907 GNDA

B 1.2V 3.3V
IC1911 IC1901
NM
TUN12 TUN33 NJM2886DL3-05 TUN5
5.0V

CONT

CONT
IC1922

VOUT

VOUT
2 GND

GND

GND
3 Vout

NM

VIN

VIN
TUN12 TUN33 TUN5
1 Vin

NC

NC
TU11 IC1921 TUPW TU33 TU5

5
4
3
2
1

5
4
3
2
1
1 6 D1921 D1911 D1901 D1902 L1901
VOUT VIN

CCG1192-A
CCG1201-A

2 5 CRG03 NM NM CRG03 NM
10V
C1921

C1922

D1922

C1911
C1924

C1912

C1902
VSS1 VSS2

C1901
4.7u 10V

C1923
CCG1201-A

CCG1218-A-T
2.2u/10
NM

NM
NM

1u/10

1u/10
3 4
ON/OFF NC
4.7u

10u
NM
R1903 GNDD R1902
0 0
GNDD GNDRF R1901
NM

RFVCC33
DAB33 IC1931
RFVCC33 L1902 P1911
3.3V 1 6 D1904
VOUT VIN 1 2
NM

2 5 NM CRG03 NM

CEK1381-A
2
CCG1201-A

CCG1201-A
C1904
C1905

VSS1 VSS2
4.7u

3 4 (2.5A)

P1951

(1A)
4.7u

ON/OFF NC 1.25V 3.3V


>
R1904

C SOC12 SOC33

1
NM R2003

0
SOC12 SOC33
IC2011 IC2001
R1905

SC12
1k

GNDRF 1 8 1 6
VO VCC VOUT VIN
VO FIN VCC

NM
NM
NM
R2011 R2012

2 9 7 2 5
22k

FB NC

C2003

R2001
VSS1 VSS2

NM
FB NC3
C2011

C2012
3 6 3 4
1u/10

1u/10
GND NC ON/OFF NC

C2002

C2001
IC2061 R2052 GND FIN NC2
NM 4 5
4.7k

1.8V NC EN
3.3V NC1 EN
0 NM
CONTROL

BT18 BT33 R2013


CONT
VOUT

IC2051
GND

GND

NM BD00IA5WEFJ
VIN

VIN

47k
NC
VO

NC

BT18 BT33

R2002

NM
BT18 BT33 GNDD
5
4
3
2
1

5
4
3
2
1

GNDD
D2051 P2051
8.1V
1 2
NM DD8
4.7u

NM
C2051

C2052
CCG1201-A

NM

NM

(0.5A)
C2061

R2024
C2062
1u/10

R2051

NM

3.3V

D2052 GNDD TPN33


NM P2052 VDEC15 TPN33

C1957
GNDD NM IC2021
D 1 NM 2 1.5V
VDEC15 VDEC33 VOUT NC
IC2031 4 3
0

VDC33
R2022

GND
5.2V 5.18V 5 1 R2031 2
NM

VIN CONT VIN CONT


C2021

1k 5 1

R2023

R2021
VDC15 2
CCG1192-A

NM

NM
PWRVI VD5 For LS2 Mecha GND
C2023

NM

PWRVI
> >
4
VOUT NC
3

VD5
C2022

NM
C2031

C2032

Fast acting Fast acting


10u
1u/10

1u/10

Fuse Fuse NJM2878F3-15


PVI VD5
P2081 L2071 P2071
1 2 1 2
CEK1380-A NM
CEK1382-A
C2081

C2082

C2083

C2071
NM

0.1u/10

0.1u/10
NM

(0.75A) (1.25A) GNDD GNDD

GNDD
GNDD
D2162
1SR154-400
5.0V
R2179
USB5
USB5 NM L2161 USB5
R2171 CTH1524-A
10u For LS2 Mecha
VD8
E ACN7160-A
C2175 R2175

6.4V
L2162

>
R2161 1k
R2170 1k
R2163 1k
1k

CTF1793-A
NM
DCH1256-A
105

0.056
0.1u/16
R2162

C2185

C2186
100u/16

8.1V VD8 Fast acting MOTV


C2163

fuse
NM

M8V
22u

RB060M-30

P2151 MOTV
MTV
D2161

1 2 Q2131
IC2161 2SD1760F5(QR) D2132
CEK1385-A
GNDD 1 NC1 24 (2.5A) NM
LX
2 RSO 23 R2132
PGND
DZ2J062M0

3 NC2 22 GNDD C2161 120


D2131

BT
4 PVCC1 21 0.1u/16 ILMB
>
C2131

C2132

R2131

BTVCC
100u/16

1u/10

47k

5 PVCC2 20 C2167 R2133


ILMB
C2172
C2162

TL 8.1V Fast acting


47u/16
10u/35

R2172 6 VCC 19 22
105

0.1u/16 fuse
FLAG ILL8
0 R2176 R2165 P2152
C2133

7 NC3 18
0.1u/10
C2173
0.1u/16

RADJ 1 2
8 RSIN 17 47k (D) 365.8/413.9kHz Q21
NM CEK1383-A LTC
C2151

GNDD SYNC
0.1u/16

9 VREG 16 (1.5A)
33k (D)

C2170
C2168 R2166

R2178 R2167

EN
1.5k

10 SGND 15 C2165
27p/50
R2169 C2169 GNDD 11 COMP
CT
14 R2164
1000p/50 NM
RT
470p/50

220k GNDD
7.5k 2200p/50 12 FB 13 C2166
0

SS 4700p/25

AN33014UA R2174 R2173 GNDD


F
R2168 R2177

only A, E
0

200k 390k
C2164

1u/10
8.2k (D)

C2152
1000p/50

A 4/6
GNDD
GNDD

AVH-X1600DVD/XNUC
128
1 2 3 4
5 6 7 8

1
2

A AVH-X1600DVD/XNUC A
8.1V

A 4/6 MOTHER
DD8 B AVH-X1600DVD/XNEW5

B UP _ 1
FAN
4
Q1831
3
(1.0A)
P1831 C AVH-X1600DVD/XNUW5 PCB
3 1 NM 2 D AVH-X1650DVD/XNRC
5
4
5 2
2
R1832 E AVH-X1650DVD/XNRD (POWER SUPPLY BLOCK)
6 1
6 1 NM F AVH-X1650DVD/XNRI

2
NM

CEK1380-A

FSMD020-R
Fast acting (0.75A)
G AVH-X1690DVD/XNID
NM
NM
NM

P1902

P1901
NM
NM

SYS+B VDD33
C1831

C1832
C1833

1
R1831

IC1821
R1836

IC1801
BUP_1 NJM2387ADL3 NJW4181U3-33B PWR-I/O BUS
A 5/6

B UP _ 1
DABSX12 9.0V 3.3V

Fuse

CONT
VOUT

1 VOUT
VADJ
SYS+B VDD33

GND

2 GND

BT18ON
VIN

3 VIN
GNDFAN VD33 VDIN
PWR-SH BUS
A 3/6

1
2
3
4
5
Q1901 D1801
2SA1577(QR) Q1903 SYB
2SD2114K(VW) 1SR154-400

USBCNT
USBFLG
47u/16
105
(F) 100k

10k
R1906

1000u/16
0.1u/10
PWR-SYS BUS

0.1u/50
R1909

R1822 R1823

C1805

C1802

C1803

C1804
10k

NM

105
R1911
A 2/6

C1801
910

MOTPW2
ANTPW

SYSPW

DDCERR

FAN_PWM
100u/16

DDCCLK
TU1VON
TU3VON

VDCNT8
VDCNT5
ANTSENS
C1821
C1906

R1907

C1822

HIOUTCLK
1u/16

82k
1/4W
2.2k
NM

105
B
(D) 18k
NM

DZ2J160M0
C1907

R1910

D1903

C1903

0.1u/16

R1824

15k
Q1902 GNDD
LTC014EEB

R1821
GNDA
NM NM
GNDD

DDIN L1953
P1952 CTH1486-A D1953
CEK1381-A
2

1 2 10uH
Fast acting
P1951

(1A)

NM RB080L-30
>
Fuse

C1975

C1977

C1979

C1982
1000p/50

10u/35

NM
Slow Blow Fuse

3300u/16
C

105
DDC 5/8 (4.5A)
1

GNDD
0.047u/50
C1962

10u/35
10u/35
C1965

C1967

C1968
1000p/50

10u/35
C1963

C1964
NM

NM

C1973

NM
C2001

CCN1321-A

IC1951
R1962
CCN1341-A

0.012

47u 10V
47u 10V

1 VCC 24
R1959

Q1952

10u/35
10u/35
10u/35
10u/35

VCC_S2 RSD140P06 3 S
0.011

Q1951 2 VCC_S1 23
RS2
S 3 RSD140P06 3 RS1 22
HSD1 HSD2 1
CCG1229-A-T
CCG1236-A-T
CCG1236-A-T
21 C1970 0.1u/16
CCG1236-A-T
CCG1236-A-T
CCG1229-A-T

8.1V 4 HSD1 G
1 SS2
DD8 G GNDD C1969 5 SS1 20 D 5.2V

1000p/50
1000p/50

PGND 2
0.1u/10

0.1u/10
D R1964 C1955 0.1u/16 6 COMP1 19 C1952 R1956 DD5
L1951 2 COMP2 L1952
C1953

8p/50

CTH1446-A 4.7k 0.01u/16 12k CTH1519-A


C1954

0.01u/16 7 FB1 18
8p/50

FB2
10uH R1968 C1956 8 EN1 17 C1951 R1952 15u
VREG
510 1000p/50 470p/50 560
C1972

9 EN2 16
1u/10

R1967 SGND R1953


RB056L-40

RB056L-40

3225size
3225size

C1981
C1957

C1961
C1958
C1959
C1960

D1951

D1952

C1974
C1976
C1978
C1980

10 CT 15
33k
R1955 R1954

10k RT
D
R1966 R1965

4.3k

(D)
(D)

(D) 11 TL_CTRL 14
300 1.1k
(D)

TL
12 FLAG 13
0.1u/10

0.1u/10
C1971

R1963
C1966

R1957

R1958

SYNC
NM

220k
10k

3.6k
(D)

(D)

AN33012UA R1969
R2021
NM

NM

R1960
NM
R1951 200k GNDD GNDD
NM R1961

390k 365.8/413.9kHz

3.3V
DDC33
DDC33 IC2101
DDC33 L2101
CTH1524-A R2105
LX
1 8
VCC C2106 0
E
10u 2 7
9
RB056L-40
C2109
47u/16

C2101

C2102

D2101
0.01u/16

10u/35

GND BST
C2107

C2108

3 6
0.01u/16

0.01u/16
105

10u/35

VC FIN EN
4 5
Fast acting

2
CEK1384-A

Q2131
Fuse

NM

60F5(QR) D2132 FB SYNC


1801 - : VDD33
P2131

(2A)

C2103
6800p/25

1821 - : SYS+B
C2104

C2105

NM GNDD BD9876EFJ
1

R2132 1851 - : EV12


NM GNDD
DZ2J062M0

120 R2101 R2102 1901 - : TUN


22k (D)
D2131

1951 - : DDC 5/8


R2103

R2104

3.6k 47k
2.2k
1000p/50
C2134

(D) (D)
R2133 365.8/413.9kHz 2001 - : SOC
22 2051 - : BT
GNDD 2101 - : DDC33
C2133
0.1u/10

Q2132 2161 - : USB5


LTC014EEB

GNDD

CHIP SIZE LEGEND SERVICE UNIT(MOTHER I/F) The > mark found on some component parts indicates
1608
2125 Consists of the importance of the safety factor of the part.
3216
MOTHER PCB Therefore, when replacing, be sure to use parts of F
INTERFACE PCB identical designation.

A 4/6
AVH-X1600DVD/XNUC
5 6 7 8
129
F
E
B
A

D
C

130
A 5/6
BT18

1
1

A 4/6
A 3/6
A 2/6
A 1/6
U1671

NM
NM

BT33
C1672 RT1 RT1

NM
R1673
CCG1192-A RT2 RT2

DUMMY
10u

GNDD
GNDD

NM
R1672
C1680 NM
C1681

C1673 0.1u/16

I/O-SH BUS
I/O-ANA BUS
CCG1192-A 10u

USB IF
BT18ON

I/O-SYS BUS
R1682

I/O-POWER BUS
C1677 NM
R1674 BTRST

INNER BUS
100
0.01u/16 R1686 BTTOSYS
R1676 R1671 0
CKN1091-A

DBGT
DBGR
JA1601

NM R1677 NM R1687 SYSTOBT


USB5

R1675 100 0 C1601


R1688 BTTOSH L1601
NM 11 2 2
R1601 1 USB5V
C1689 C1684

GNDD
NM R1689 SHTOBT D- 0.1u/50
NM 2 USB_D-
0.1u/10 NM R1694 NM

GNDD
C1688 C1687 DATA_BT D+
NM 3 USB_D+
R1695 BCLK 44 3 3 R1602
100p/50 CCG1192-A NM
4 USBGND

GNDD
R1685 BTANAR CTF1713-A D1602
GNDD

10u NM
USB

820 R1696 LRCLK RT1 Shield1


NM PESD0402-140

LINEOUT_L

LINEOUT_R
RT2 Shield2

UART_AT_TX
UART_AT_RX

BT33V

BT18_EN
UART_DBG_TX
D1601

UART_DBG_RX

BT18V
BT18V

VSS
nRESET
7
6
5
4
3
2
1
C1683
GNDD

1800p/50
PESD0402-140

NM
DIN

NC1
CAP
GNDA

GND

1 24
2 23
3 22
4 21
5 20
6 19
7 18
8 17
9 16
10 15
11 14
12 13
LRCIN

BCKIN

VOUTR

NM
IC1671

CN1671
NM
R1691

VSS
R1678

VOUTL
NC2
FORMAT
MCLK

DEEMPH

MUTE

VDD

I2S_IN

MIC1_P
MIC1_N
1k

BOOTS

MIC2_P
I2S_CLK

MIC2_N
I2S_OUT
R1679

8
9
10
11
12
13
14

I2S_MCLK
I2S_SYNC

MIC_BIAS
1k
C1674 R1693

GNDA
C1685
NM 0
C1675

2
2

R1692 0.1u/10 L1672


NM

BBOT

C1678
C1679
C1676 0 C1682 CTF1786-A

L1671
R1697

1u/10
220u/4

0
CCG1192-A

NM
CTF1786-A
R1690
180 10u
IF

C1671

GNDA

GNDD
100p/50

VD5 1800p/50
C1686

NM
C1690
R1684 BTANAL

1k
820

R1680
R1683
BTMICN
DD5

BTMICP

BT IF
SOC33_1

R1681
NM
R1762

BT33
R1704
10k

NM SPEED
R1763

NM
BCG
AUX_AGND BC_VGND
50 BCAMGND
BCI
AEQMICIN BCAM_IN
49 BCAMIN
BEEP
48 BEEP
47 AUXAGND

AEQMIN
AUR
AUX_R
46 AUXR
AUAG
AUX_AGND
45 AUXAGND
AUL

1.5k

GNDA
AUX_L

R1664
44 AUXL
R1662 DZ2J039M0 R1663 AUVG R1764
SYS+B AUX_VGND
43 AUXVGND
0 AUV

Q1661
GNDA
10k D1661 1.2k AUX_V
42 AUXV

AVH-X1600DVD/XNUC
E1 1
B1 2
C2 3
GNDSIG
41 GNDSIG

2SD2114K(VW)
ANR
40 ANR

Q1662

RN4984
39 GNDSIG
ANG

5 B2
4 E2

6 C1
38 ANG

(3.9V)
A-a 5/6

37 GNDSIG

GNDA
C1661
ANB

MIC SENS

3
3

36 ANB
Q1663 470p/50
C2 3 35 APPPUP
4 E2
CSYNC
B1 2 34 CSYNC
5 B2
HSYNC
33 HSYNC
E1 1 6 C1

GNDA
VSYNC
RN4984 32 VSYNC
10.5 MOTHER PCB (IN/OUT BLOCK) (GUIDE PAGE)

31 GND
GNDD

AEQAUXSW
30 DTVL
29 DTVAG
28 DTVR
RGBARI
27 TVON
B

GUIDEON
26 GUIDEON
25 ONSEI+
24 ONSEI-

GNDD
23 GND
GNDD

S_TO_N
22 SYSTON
C1707
CN3601

N_TO_S
21 NTOSYS

only E
1u/10 COMDC
COMDC 1 20 GND
POL BTMICN
POL 2 19 BTMICN
VCLK BTMICP
VCLK 3 P1701 18 BTMICP
OEV 1 2
OEV 4 17 GNDD
GNDD

STV2 FSMD075-24R
STV2 5 16 GNDD
5.1V R1701
LCDGND 6 Q1701 15 GNDD
CLK R1702 2.2k
HCLK 7 E2 C2 14 SXTOS
4 3 5.6k R1703
GNDD

ASENBO B2 B1
14.4V

LCDGND 8 13 STOSX
LOAD 5 2 3.3k
LD 9 C1 E1 12 GND
ASBO
BUP_1

6 1
GNDD

R5
R5 10 UMF23N 11 ASENBO
BUSRP
R4 BUSR+

4
R4 11 10 SXR
4

BUSRM
R3 BUS-
R3 12 9 GNDA
R2 BUSL+
R2 13 8 SXL
R1 SXIPWEN
R1 14 7 SXPWR
R1711 NM
R0 WIRED
DABSX12

2
3

6 SXPWR
1

R0 15 R1712
GNDD

G5 WIREDAD
G5 16 WIREDPU 5 SXEN
G4 NM
G4 17 4 GNDSX
6
5
4
NM

G3
Q1711

G3 18 3 GNDSX
NM

G2
GNDSX

G2 19 2 WIRED
4

5
6

G1
G1 20 1 WIREDAD
Q1731
RN4982
DD5

G0
G0 21
B5
B5 22
1
3
2

B4 BTMIX R1718 47k R1714


B4 23 R1744
B3 R1717 47k 1k
10k C1737 R1742
CKS6535-A

B3 24 BTANAL
GNDA
GNDD

B2
2
3

2.2u/10 27k R1713 470


CN1701

B2 25
B1 D%
B1 26
3 CT1
2 O/I1
1 I/O1

4 GND

B0
&Mixing on

B0 27
NM
Q1712

IC1732

other

LCDGND 28
HN1B04FU(YG

O/
A, B, C : J%

only D, E,

I/O

D
V
C

RGB in:VGA se
D, E, F, G : D%
5 6 7 8

A-b 5/6
A 5/6 MOTHER PCB
WIREDAD
GNDSX
WIRED

CN1701
CKS6535-A
(IN/OUT BLOCK)
3
2
1

SYS+B

A AVH-X1600DVD/XNUC
B AVH-X1600DVD/XNEW5
GNDSX C AVH-X1600DVD/XNUW5
D AVH-X1650DVD/XNRC
DD5
E AVH-X1650DVD/XNRD
F AVH-X1650DVD/XNRI
A, B, C : J%
RCA V IN OUT G AVH-X1690DVD/XNID
D, E, F, G : D% PREOUT
IC1751

R1751

NM

VCR_RIN
VCR_VIN

VCR_LIN

VCR_RG
VCR_VG

VOUT_G
VCR_LG

1 SWROUT
2 SWLOUT
1 5

VOUT

RROUT
3 FROUT

RLOUT
4 FLOUT

7 GNDA
8 GNDA
Q1721 INB VCC
2
JA1621 JA1631
VDD33

LSCR523UB
INA
470

3 4 CKB1110-A XKB7001-B
D%

8
7
6
5
4
GND OUTY

3
2
1

5
6
R1714

R1730

C1722

R1729
C1723 1u/10
4.7k
1k

1k
R1713

C1752

C1751
1u/10

NM

NM

NM
NM
DZ2J051M0

VOVG

VCRG
VCVG

VCVO
VCLG
1k

VCRI
DD5

VCVI

VCLI

SWRO

RRO
FRO
SWLO

RLO
GNDA1
FLO
R1728

D1721
47k
47k

3 4
100p/50
1k R1715

FSMD075-24R
15k

15k
15k
15k

15k
15k

15k

11 2

C1637

C1638

P1631
GNDD

NM

NM
5 VCR:+8.2 dBs
R1731
R1724
R1718
R1717

GNDA
4 SOC33_1 VDD33

1
1 6 IC1721
R1716

R1727
R1722

R1725
R1721

C1721
R1723

Q1712
HN1B04FU(YGR) 1 A_OUTPUT 8
5 V+

6
GNDD 2 A-INPUT
B_OUTPUT
7 only A, E C1607 C1608 C1609 C1610 C1611 C1612 GNDRF GNDA GNDA

M only D, E, F, G 3 A+INPUT
B-INPUT
6
27p/50 27p/50 27p/50 27p/50 27p/50 27p/50
0.1u/10
R1726 100p/50

4 V- 5

R1765
15k

NM
B+INPUT GNDA
IC1741 GNDA GNDA
R1632 R1634 R1638 R1641 R1644 R1647
C1725

NJM4565V 1 5
C1724

D1621
G VCC NM 22k 22k 22k 22k 22k 22k
2
C1736
NM

IN_A D1622
3 4 DZ2S180C
27k

Q1631 Q1632 Q1633


R1742

R1743

GND OUT_Y D1623


27k

C1735 DZ2S180C 2C 2E 2C 2E 2C 2E
R1740 GNDA D1624
15k 3 4 3 4 3 4
2.2u/10 NM DZ2S180C 1B 2B 1B 2B 1B 2B
R1733 C1732
C1737

C1738

C1622 2 5 2 5 2 5
2.2u/10

27k
2.2u/10

R1734 C1731 2.2u/10 GNDD 0.1u/50 1E 1C 1E 1C 1E 1C


27k C1623 1 6 1 6 1 6
2.2u/10 NM HN1C01FU(YGR) HN1C01FU(YGR) HN1C01FU(YGR)

R1650 NM
NM
R1732 C1621
R1633 R1635 R1639 R1640 R1645 R1646

75
0.1u/50

R1649
R1621
IC1732 C1624 4.7k 4.7k 4.7k 4.7k 4.7k 4.7k
15k C1734 0.1u/50

FSMD075-24R
100p/50

P1623
1 I/O1 8 IC1731 FOR SERVICE

R1642

R1643

R1648
R1631

R1636

R1637
VCC

820

820

820

820

820

820
Q1731 2 O/I1 7 1 A_OUTPUT 8 R1739 P1621
RN4982 CT2 V+ 1 2
R1744

1
3 CT1 6 2 A-INPUT 7 15k
NM
O/I2 B_OUTPUT
4 3 R1736 P1622
10k

4 GND R1737

CCG1201-A

CCG1201-A

CCG1201-A
5 3 A+INPUT 6 GNDD

CCG1201-A
CCG1201-A
I/O2 B-INPUT

CCG1201-A
C1631

C1632

C1633

C1634

C1635

C1636
2 15k 1 2
47k 4 V- 5 R1738 NM

4.7u

4.7u

4.7u

4.7u

4.7u

4.7u
B+INPUT 15k
5 NM GNDV R1622 R1623
0.1u/10
C1739

6 1 NJM4565V
22k 22k
C1733 0.1u/10

C
R1735

GNDA
15k

NM GNDA
VCR_VGND

RCA_SWR

RCAMUTE
VCR_GND

RCA_SWL

RCA_RR
BTANAR

RCA_FR

RCA_RL
BTANAL

RCA_FL
VCR_R
VCR_V

RCA_V
VCR_L
iTV_R
iTV_L
iNAVI

AEQMICIN

FM/AM(30%) (except B, C): -6.9 dBs


FM/AM(30%) (B, C): -2.9 dBs
TV:+9.3 dBs
BTMIX AUX:+9.3 dBs
RGB in:VGA select VCR:+9.3 dBs
&Mixing on H
USB(LS2 Decode):+9.2 dBs
other L USB(SH Decode):+9.3 dBs
DVD/CD(LS2):+9.2 dBs
STOSX
SXTOS

Navi Guide: -12.5 dBs


BTMIX

G_PWM
R_PWM
B_PWM

POS
LCDPW

MOT1
MOT0
H/OSW
RESET
KDT1
KDT0
TEMPSENS

REMIN

MICSENSR

D
G3
G2
G1
G0
B5
B4
B3
B2
B1
B0

BLEN
MTCHRST

BLERR
DIO

DIMMER
LPSYNC

BLSYNC
MTCH_SDA0
TPIRQN
MTCH_SCL0

C1651
CHIP SIZE LEGEND D1662 DZ2S180C
0.1u/10
1608
R1653

D1663
680

DZ2S180C
2125 R1651
C1602 NM
3216 47k
C1604 R1652 MOTV
0.1u/16 47k
C1603 NM
VDD33
C1605
0.1u/16 C1652 GNDD
C1606 NM
0.1u/16
D1603

NM

GNDD
GNDA GNDD
1
3
2

H/O SW 10
GNDD 9
8
7
MOT1 6
MOT0 5
GNDD 4
GNDD 3
MOTV 2
MOTV 1

CN1651
POS
VDD33

JA1661 NM
NM
E
NM

1601 - : USB IF
1611 - : OPT
LCDPW

LPSNC

TEMP

1621 - : VCR IN/OUT


1631 - : PREOUT
V18HI

1651 - : AUTO FLAP


1661 - : MIC SENS,Auto EQ MIC
DZ2S180C

DZ2S180C
D1781

D1782

1671 - : BT
PWRVI

1701 - : TO IF
R1781
NM

1781 - : TO MONITOR
0

GNDD
R1782

TPN33
0.1u/10
C1702

ILMB
NM
NM
C1701

470p/50

C1704
0.1u/10

C1703
C1706

C1705

BLGND
0.1u/16 SERVICE UNIT(MOTHER I/F)
Consists of
MOTHER PCB
INTERFACE PCB
F
MTCHDA 46
47
KEYGND 48
TOUCHGND 49
50
51
BLEN 52
53
54
BLGND 55
BLGND 56
BLGND 57
58
59
60
G3 18
G2 19
G1 20
G0 21
22
23
24
25
26
27
LCDGND 28
29
LCDGND 30
LCDPW 31
32
33
LCDGND 34
35
36
PWM_G 37
PWM_R 38
PWM_B 39
40
41
RST 42
43
44
MTCHCK 45

CN1751
BLERR
KDT1
KDT0

LCDGND
TMPSENS
B5
B4
B3
B2
B1
B0

DIO

DIMMER
PWRVI

BLSYNC
LPSYNC

REMIN

TPN33

ILMB
ILMB
ILMB
TPIRQN
V18HI

CKS6536-A

D CN5401

A 5/6
AVH-X1600DVD/XNUC
5 6 7 8
131
F
E
B
A

D
C

132
A-a A-b
A-b 5/6

1
1

A 5/6 MOTHER PCB


(IN/OUT BLOCK)

WIREDAD
CN1701
CKS6535-A

1
SYS+B

A AVH-X1600DVD/XNUC
B AVH-X1600DVD/XNEW5
C AVH-X1600DVD/XNUW5
D AVH-X1650DVD/XNRC
DD5
E AVH-X1650DVD/XNRD
F AVH-X1650DVD/XNRI
A, B, C : J%
RCA V IN OUT G AVH-X1690DVD/XNID
D, E, F, G : D% PREOUT
IC1751

NM
1 5

R1751
Q1721 INB VCC
2

VCR_VIN
VCR_VG
VCR_LIN
VCR_LG
VOUT
VOUT_G
VCR_RIN
VCR_RG
LSCR523UB JA1621 RROUT JA1631
RLOUT

INA

FROUT
FLOUT
GNDA
GNDA

3 4 CKB1110-A XKB7001-B

470
VDD33
8
7
6
5
4
3
2
1
1 SWROUT
2 SWLOUT
3
4
5
6
7
8

R1729 GND OUTY

D%

1k
4.7k
1k

R1714
R1730
C1722
NM

NM
NM
NM

1u/10

R1713
C1752
C1751
DD5

1k

2
2

VCVI
VCVG
VCLI
VCLG
VCVO
VOVG
VCRI
VCRG

C1723 1u/10
FRO
FLO
RRO
RLO

3 4
2

SWRO
SWLO

47k
47k
R1728
D1721
GNDA1

DZ2J051M0
15k
15k
2 GNDD

15k
15k
15k
15k
15k
100p/50
NM
NM

5 VCR:+8.2 dBs

1k R1715
C1637
C1638
P1631

GNDA
4
1

1 6 IC1721 SOC33_1 VDD33

R1731
R1724

R1718
FSMD075-24R

R1717
Q1712
8

R1716
R1727
R1722
R1725
R1721
C1721
R1723
HN1B04FU(YGR) 1 A_OUTPUT
5 V+
GNDD 2 A-INPUT 7 GNDRF GNDA GNDA
6 B_OUTPUT only A, E C1607 C1608 C1609 C1610 C1611 C1612
3 A+INPUT 6
only D, E, F, G B-INPUT 27p/50 27p/50 27p/50 27p/50 27p/50 27p/50
4 V- 5

15k
B+INPUT

NM
GNDA GNDA GNDA

0.1u/10
IC1741

R1765
R1632 R1634 R1638 R1641 R1644 R1647
NJM4565V 1 5 D1621
G VCC NM 22k 22k 22k 22k 22k 22k

C1725
2

C1724
R1726 100p/50
IN_A D1622

NM
3 4 DZ2S180C

C1736
Q1631 Q1632 Q1633

27k
GND OUT_Y D1623
DZ2S180C 2C 2E 2C 2E 2C 2E

27k
R1740 C1735

R1742
GNDA D1624

R1743
15k 3 4 3 4 3 4
2.2u/10 NM DZ2S180C 1B 2B 1B 2B 1B 2B
R1733 C1732
C1622 2 5 2 5 2 5

AVH-X1600DVD/XNUC
27k 2.2u/10 0.1u/50 1E 1C 1E 1C 1E 1C
R1734 C1731 GNDD

C1737
1 6 1 6 1 6

C1738
27k C1623

2.2u/10
2.2u/10 HN1C01FU(YGR) HN1C01FU(YGR)

2.2u/10
NM HN1C01FU(YGR)
C1621
NM

R1732 R1633 R1635 R1639 R1640 R1645 R1646


0.1u/50

75
IC1732 C1624 4.7k 4.7k 4.7k 4.7k 4.7k 4.7k

2
15k C1734 0.1u/50

3
3

R1649
R1650 NM

100p/50

R1621
1 I/O1 8 IC1731 FOR SERVICE
VCC
P1621

P1623
820
820
820
820
820

731 2 O/I1 7 8 R1739


820

1 A_OUTPUT
R1642
R1643
R1648

R1631
R1636
R1637

982 CT2 V+

1
15k 1 2
3 CT1 6 2 A-INPUT 7 NM
FSMD075-24R
O/I2 B_OUTPUT
3 R1736 P1622

R1744
4 GND 5 3 A+INPUT 6 R1737 GNDD

10k
I/O2 B-INPUT 15k 1 2
2 47k 4 V- 5 R1738 NM
B+INPUT
C1631
C1632
C1633
C1634
C1635
C1636

15k
4.7u
4.7u
4.7u
4.7u
4.7u
4.7u

NM GNDV R1622 R1623


CCG1201-A
CCG1201-A
CCG1201-A

CCG1201-A

NJM4565V
CCG1201-A

1
CCG1201-A

22k 22k

C1739
0.1u/10
C1733 0.1u/10
GNDA

15k
R1735
GNDA

BTANAL
BTANAR
iTV_L
iTV_R

iNAVI
VCR_V
VCR_VGND
VCR_L
RCA_V
VCR_R
VCR_GND
RCA_SWR
RCA_SWL
RCA_FR
RCAMUTE
RCA_FL
RCA_RR
RCA_RL

FM/AM(30%) (except B, C): -6.9 dBs


FM/AM(30%) (B, C): -2.9 dBs
TV:+9.3 dBs
AEQMICIN

BTMIX AUX:+9.3 dBs


RGB in:VGA select VCR:+9.3 dBs
H

4
&Mixing on
4

USB(LS2 Decode):+9.2 dBs


other L USB(SH Decode):+9.3 dBs
DVD/CD(LS2):+9.2 dBs
Navi Guide: -12.5 dBs

BTMIX
STOSX
SXTOS
POS

KDT1
KDT0
MOT1
MOT0

LCDPW
G_PWM
R_PWM
B_PWM
RESET
REMIN
H/OSW

TEMPSENS
MICSENSR
8 7 6 5
133
AVH-X1600DVD/XNUC
G1
G1 20
G0
G0 21
B5
B5 22
B4 BTM
B4 23
B3
B3 24
B2
B2 25
B1
B1 26
F
B0
B0 27
A-b 5/6

LCDGND 28
D

DIO
DIO 29
LCDGND 30 LCDPW
LCDPW
LCDPW 31 C1706 LPSNC
NM LPSYNC
LPSYNC 32 C1705
NM R1781 V18HI
V18HI 33
C1701 NM
CN5401

LCDGND 34
470p/50
PWRVI 35 PWRVI
TEMP
C1702 TEMPSENS
TMPSENS 36 0.1u/10
G_PWM
PWM_G 37
R_PWM
PWM_R 38
B_PWM
PWM_B 39
KDT1
KDT1 40
KDT0
KDT0 41
RESET
RST 42
R1782 REMIN
REMIN 43
0 MTCHRST
LCDGND 44
E
MTCH_SCL0
MTCHCK 45
MTCH_SDA0
MTCHDA 46
TPIRQN
TPIRQN 47
D1781
DZ2S180C
KEYGND 48
C1704
TOUCHGND 49 D1782
0.1u/10
TPN33 50
TPN33
GNDD

DZ2S180C BLSYNC
BLSYNC 51
BLEN
BLEN 52
DIMMER STO
DIMMER 53
BLERR SXT
BLERR 54
BLGND 55
BLGND 56
BLGND

BLGND 57
ILMB 58
C1703
0.1u/16

ILMB 59
ILMB 60 ILMB
D
3216
2125
1608

CKS6536-A
CN1751
CHIP SIZE LEGEND

A-a A-b
GNDA

MICSENSR
1
3
NM

2
C1603
C1602
D1663
D1662

NM
0.1u/16

NM
D1603
C1605
C1604

C
C1606
NM
NM

JA1661
0.1u/16
0.1u/16
DZ2S180C
DZ2S180C

GNDD
GNDD
R1652
R1651
0.1u/10

NM
C1652
C1651

47k
47k

H/OSW
H/O SW 10
GNDD 9

1781 -
1701 -
1671 -
1661 -
1651 -
1631 -
1621 -
1611 -
1601 -
VDD33 8

VDD33
R1653 POS
POS 7

: BT
680 MOT1
6

: OPT
MOT1
B

: TO IF

Consists of
MOT0
5

: USB IF
MOT0

: PREOUT
GNDD 4

: AUTO FLAP
GNDD 3

MOTHER PCB
: VCR IN/OUT

: TO MONITOR
MOTV 2

GNDD

INTERFACE PCB
MOTV 1

MOTV

: MIC SENS,Auto EQ MIC


NM
CN1651

SERVICE UNIT(MOTHER I/F)


A
8 7 6 5
4 3 2 1
134
AVH-X1600DVD/XNUC
A-a 5/6
F
A 2/6
A 1/6
I/O-ANA BUS
USB IF

I/O-SYS BUS

BTRST
INNER BUS

1686 BTTOSYS
0
CKN1091-A
JA1601

1687 SYSTOBT
USB5

0 C1601
L1601
11 2 2
R1601 1 USB5V
GNDD

D- 0.1u/50
NM 2 USB_D-
D+
3 USB_D+
44 3 3 R1602
NM
4 USBGND
BTANAR CTF1713-A D1602
GNDD
USB

RT1 Shield1
E
PESD0402-140
RT2 Shield2
D1601
GNDD

PESD0402-140
IF

BTANAL
BTMICN
DD5

BTMICP
SOC33_1

NM
R1762

R1704
D
10k

SPEED
R1763

NM
BCG
AUX_AGND BC_VGND
50 BCAMGND
BCI
AEQMICIN BCAM_IN
49 BCAMIN
BEEP
48 BEEP
47 AUXAGND
AUR
A-a A-b

AUX_R
46 AUXR
AUAG
AUX_AGND
45 AUXAGND
AUL
AUX_L
44 AUXL
AUVG R1764
AUX_VGND
43 AUXVGND
0 AUV
AUX_V
42 AUXV
IG
41 GNDSIG
40 ANR
39 GNDSIG
38 ANG
37 GNDSIG
36 ANB
35 APPPUP
C
C
34 CSYNC
C
33 HSYNC
C
32 VSYNC
31 GND
GNDD

AEQAUXSW
30 DTVL
29 DTVAG
28 DTVR
RGBARI
27 TVON
B

GUIDEON
26 GUIDEON
25 ONSEI+
24 ONSEI-
23 GND
GNDD

S_TO_N
22 SYSTON
CN3601

N_TO_S
21 NTOSYS
COMDC
20 GND
BTMICN
19 BTMICN
BTMICP
P1701 18 BTMICP
1 2
17 GNDD

GNDD
FSMD075-24R
16 GNDD
B
5.1V R1701
Q1701 15 GNDD
R1702 2.2k
E2 C2 14 SXTOS
4 3 5.6k R1703

GNDD
ASENBO B2 B1

14.4V
13 STOSX
5 2 3.3k
C1 E1 12 GND
ASBO

BUP_1
6 1
GNDD

UMF23N 11 ASENBO
BUSRP
BUSR+
10 SXR
BUSRM
BUS-
9 GNDA
BUSL+
8 SXL
SXIPWEN
7 SXPWR
R1711 NM
WIRED
DABSX12

2
6 SXPWR

1
R1712

GNDD
WIREDAD
WIREDPU 5 SXEN
NM
4 GNDSX

6
5
4
NM
Q1711
3 GNDSX

NM
GNDSX
2 WIRED

5
6
1 WIREDAD

Q1731
RN4982
DD5

1
3
2
BTMIX R1718 47k R1714
R1744
A
R1717 47k 1k
10k C1737 R1742

CKS6535-A
BTANAL

GNDA
GNDD
2
3

1
2.2u/10 27k R1713 470

CN1701
D%

3 CT1
2 O/I1
1 I/O1

4 GND

&Mixing on
RGB in:VGA
NM
Q1712
A, B, C : J
A-b 5/6

othe
HN1B04FU(Y

IC1732
D, E, F, G : D

only D, E

O
4 3 2 1
8 7 6 5
135
AVH-X1600DVD/XNUC
A-a 5/6
F
BT18
A 4/6
A 3/6
A 2/6

U1671
NM

NM
BT33

C1672 RT1 RT1


NM
R1673

CCG1192-A RT2 RT2


DUMMY

10u
GNDD
GNDD

NM
R1672

C1680 NM
C1681
C1673 0.1u/16
I/O-SH BUS

CCG1192-A 10u BT18ON


I/O-SYS BUS

R1682
I/O-POWER BUS

C1677 NM
R1674 BTRST
100
0.01u/16 R1686 BTTOSYS
R1676 R1671 0
DBGT
DBGR

NM R1677 NM R1687 SYSTOBT


R1675 100 0
R1688 BTTOSH
C1689 C1684 NM
NM R1689 SHTOBT D-
0.1u/10 NM R1694 NM
GNDD

C1688 C1687 DATA_BT D+


NM
R1695 BCLK
100p/50 CCG1192-A
GNDD

10u R1685 NM
820 R1696 LRCLK
E
NM
LINEOUT_L

LINEOUT_R
UART_AT_TX
UART_AT_RX

BT33V

BT18_EN
UART_DBG_TX
UART_DBG_RX

BT18V
BT18V

VSS
nRESET
7
6
5
4
3
2
1
C1683
1800p/50

NM
DIN

NC1
CAP
GNDA

GND

1 24
2 23
3 22
4 21
5 20
6 19
7 18
8 17
9 16
10 15
11 14
12 13
LRCIN

BCKIN

VOUTR

NM
IC1671

CN1671
NM
R1691

VSS

R1678
VOUTL
NC2
FORMAT
MCLK

DEEMPH

MUTE

VDD

I2S_IN

MIC1_P
MIC1_N

1k
BOOTS

MIC2_P
I2S_CLK

MIC2_N
I2S_OUT

R1679
8
9
10
11
12
13
14

I2S_MCLK
I2S_SYNC

MIC_BIAS

1k
C1674 R1693
GNDA

C1685
NM 0
C1675 R1692
NM 0.1u/10 L1672
BBOT

C1679

C1676 0 C1682 CTF1786-A


L1671

R1697
1u/10

220u/4
0

CCG1192-A
C1678 NM
CTF1786-A
R1690

180 10u
C1671
GNDA

GNDD
100p/50
VD5 1800p/50
C1686

NM
C1690

R1684
0

1k

820
R1680
R1683

BT IF
R1681
BT33

D
NM
BEE
AEQMIN

A-a A-b
1.5k

GNDA
R1664

R1662 DZ2J039M0 R1663


SYS+B
Q1661
GNDA

10k D1661 1.2k


E1 1
B1 2
C2 3

GNDSIG
2SD2114K(VW)

ANR
Q1662

RN4984

ANG
5 B2
4 E2

6 C1
(3.9V)

GNDA

C1661
ANB
MIC SENS

Q1663 470p/50
C2 3 4 E2
CSYNC
C
B1 2 5 B2
HSYNC
E1 1 6 C1

GNDA
VSYNC
RN4984
AEQAUXSW
RGB
GUI

GNDD
S_T
C1707 N_T

only E
1u/10 COMDC
COMDC 1
POL
POL 2
VCLK
VCLK 3
OEV
OEV 4
STV2
B
STV2 5
LCDGND 6
CLK
HCLK 7
ASE
LCDGND 8
LOAD
LD 9
R5
R5 10
R4
R4 11
R3
R3 12
R2
R2 13
R1 SXIP
R1 14
R0 WIR
R0 15
G5 WIR
G5 16 WIR
G4
G4 17
G3
G3 18
G2
G2 19
G1
G1 20
G0
G0 21
B5
B5 22
B4 BTM
B4 23
A
B3
B3 24
B2
B2 25
B1
B1 26
B0
B0 27

A-b 5/6
LCDGND 28

D
8 7 6 5
1 2 3 4

10.6 MOTHER PCB (TUNER BLOCK)

A A AV
B AV
C AV
D AV
TUN-SH BUS E AV

A 3/6 F AV
G AV

JA451
FM/AM
RFG2
YKS5041-A
ANTENNA
B 2 1

IMSA-6803-01Y900
TUN33
3

NM
C455

D452
P451

3p/50
R401
U401 X-2062
NM
ACLK 1 8 A_CLK RFG1
R403
41 DGND5 27
AWS 2 7 A_WS SDO

NM
L401
SDI
40 26 5 4
ADI 3 6 A_DI
SDO
SDI only A, E
39 25 6 3 GNDRF
ADO 4 5 A_DO SSCK
SSCK
38 24 7 2 C401
0 BLEND/SCK SCS

NM
R410

C404
NM
SCS
1k

37
DGND6
23 8
0
1 only
*4
DGND4
36 22 C5
DVCC33_2
BBCLK R402 DVCC33_1 21 GNDD
35 R407 22p
1 8 BB_CLK TUNRST
RESET 0
34 20 R405
BBWS 2 7 BB_WS SYStoDTUN
RX 0
C BBD0 3 6
33
BB_DII
19 R406 DTUNtoSYS

R519

R521
TX TUN12 0

220

750
32 18
BBD1 4 5 BB_DIQ/REF_CLK
GPIO 17 L402
31
0 DVCC11_2
DVCC11_1

RN731VN

RN731VN
30 16 NM

D501

D502
I2C1_SCL GNDRF C526
only A, E
NM
C402

C405

DGND3
NM

29 15 L502 L506 NM
I2C1_SDA C509 0.27u CTF1794-A C527
28 DGND2 14
0.01u/16
TUCLK 33p/50

NM
2p/50
C454

0.01u/16
I2C0_SCL

6p/50
0.15u
C525

C510

C513

C518
L501

0.01u/16

0.01u/16
13 GNDD TUDAT
I2C0_SDA

C516

C517
TUN33

1u/10
12 TUNAG
DGND1
11 R404
CN401 GNDRF
orRFGND C528
RDSINT 8 1 ACLK NM
NM
10 GNDD GNDRF
LCH 7 2 AWS
1 L503
C529 10u

9
AGND 6 3 R409 ADI
RFVCC33

2 CTF1786-A C519 C521


D
0.1u/10
8 0
4 R408
C514
5 ADO
CCG1192-A

RCH
3 0.1u/10 0.01u/16
7 0
RFGND3 220 TUNAG
L403 4 C522
6
RFVCC5 L504 GNDRF C523 0.01u/16
5
5 NM
FMAMANT GNDRF CTF1806-A 10u
6 CCG1192-A
0.1u/10
C515

4
NM

NM

NM
C511

RFGND2 C524
C403

C406

7
3 GNDRF 0.022u/16
DABANT
8
RFGND1
2 except A,
9 TUNAG R522 R5
1
10 C512 L505 L519 1.5k

GNDRF 0.01u/50 CTF1389-A 10n L507 L5


22u
only A,
R520

1M

DABSX12 GNDD
3p/50

JA452
NM
D503

C520

R523

1M

E
2 NM
3 1 L451
only A, E
NM
4
VA451

NM

NM
D451

NM
C453

C462

NM

R455

NM

C458
GNDRF
NM GNDRF
5p/50 R456

C459
NM
only A except A
NM
C457

4p/50
5p/50 R457 R454 C460 R451 R452

4p/50
F C456 0 0 NM NM
C461
GNDD GNDRF GNDD
GNDRF GNDRF TUNAG GNDRF GNDRF
4p/50

A 6/6 TUNAG only A, E


AVH-X1600DVD/XNUC
136
1 2 3 4
5 6 7 8

A
B
AVH-X1600DVD/XNUC
AVH-X1600DVD/XNEW5
A 6/6 MOTHER PCB
(TUNER BLOCK)
A

C AVH-X1600DVD/XNUW5
D AVH-X1650DVD/XNRC
TUN-ANA BUS
E AVH-X1650DVD/XNRD
F AVH-X1650DVD/XNRI A 1/6
G AVH-X1690DVD/XNID FM/AM(30%) (except B, C): -15.0 dBs

TUN_R

TUN_L
FM/AM(30%) (B, C): -11.0 dBs
TUN-SYS BUS
C560
A 2/6

BLEND

TUNRST
TUNCLK

TUNDATA
C561 10p/50

10p/50
only A, E
C562
4700p/25

TUN5
C563 TUNER
4700p/25 B
TUNAG

2.2u/10
NM

10p/50

only A, E
CTF1786-A

CTF1786-A

10p/50
36.48MHz TUNAG
C564

C566
X501
4 3
X2

CCG1218
GND2
0.22u/6.3

L512

GNDD

NM
C567

C570

C568

C569

C574
22p/50

22p/50
0.1u/10
L513

1 2
L517
C559

GND1
1u/10

X1
C558

CSS1805-A CTF1786-A
only
*4 A, E L515
NM
0.22u/16

C556
NM
R540
0.1u/10

L516
C557

C565

NM
22p/50 R541
NM
64

63

62

61

60

59

58

57

56

55

54

53

52

51

50

49

L514
CTF1786-A C
VCC-ADC_DAC

1 48
TCFM
PLLTEST

GND-PLL

GND-ADC_DAC

C571
VCC-PLL

OSCOUT

VDDPLL1V2
TVDAC

CCG1218-A-T
DACOUTR

VCC-REF
OSCIN

VDDIO1V2
DACOUTL

VREFDEC

GND-REF

2.2u/10
2 47 C573
3 46 0.1u/10

GNDRF C526
NM 4 45 R501
506 FMMIXIN2
794-A C527 TEST GPIO0 NM
5 44 R531 BBD1
FMMIXIN1 VDD_CORE GPIO1
0.01u/16 FMPINDRV NM
6 43 R532 BBD0
GNDRF FMPINDDEC GND1V2 GPIO2
C525 7 42 NM
FMMIXDEC R533 BBWS
TCAM GPIO3
1u/10 8 41 NM
R534 BBCLK
UNAG VCCRF IC501 GPIO4
rRFGND C528 9 40 NM
TDA7706 R535 ADO
CK_SEL GPIO5
NM 10 39 NM
R536 ADI
GNDVCO GPIO6
11 38 NM
VDD3V3 R537 AWS
LFREF GPIO7
9 C521 12 I2CSCL 37 NM
LF1 TCAM2 I2CSDA GPIO8
R538 ACLK D
TUN33

/10 0.01u/16 13 PINDDEC 36 NM


VCCVCO PINDIN GND3V3
C522 14 35
VCCREG1V2

C523 0.01u/16 C555


GNDSLINK

15 34
AMMIXIN1

AMMIXIN2
LNAOUT2

LNADEC2

VREG3V3

0.1u/10
GNDLNA

LNADEC

LNAOUT

REG1V2

GNDD
RDSINT

10u
LNAIN2

CCG1192-A
LNAIN

16 33
RSTN
VDIG

C524 L518
F 0.022u/16
NM
17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

except A, E L511
R522 R524 R539
0 CTF1786-A
10u
CCG1192-A

0.1u/10

0.1u/10

1.5k
C540

1k
GNDRF
C538

L507 L508 68n


22u
NM
C530

only A, E
1000p/50
22p/50
0.1u/10
47u

0.1u/10

0.1u/10
C546

C547

C548

C549

C553

C554
680
33
R526

L509
470

R527

82p/50

1/4W
3p/50

R523

1M

R528 R529 R530 only A, E E


3p/50

100p/50
C531

C542
C541
C539

0.01u/16

GNDD
5.6 5.6 5.6
R525

L510

only A, E CTF1786-A
100p/50

0.1u/10
C545

C550
CCG1218
C544
2.2u/10
0.1u/10

only A, E
C543

GNDRF only A, E GNDD GNDRF

401 - : HD TUNER UNIT CHIP SIZE LEGEND


1608 SERVICE UNIT(MOTHER I/F)
451 - : ANT PART 2125 Consists of
R452 501 - : HIT2 PART 3216 MOTHER PCB
INTERFACE PCB
NM F
GNDD
GNDRF GNDRF

A 6/6
AVH-X1600DVD/XNUC
5 6 7 8
137
1 2 3 4

10.7 INTERFACE PCB

A JA3621
BZ CKB1106-A
R3621 1
1
1 2 B.
2 75

C3621

NM
2
CN3601

D3621
NM
CKS6605-A-TBB
GND BZ3631
CPV1062-A R3644
BCAMGND 1 AUX
NM GND
BCAMIN 2
BEEP 3 JA3641
R3645 NM CKN1106-A
R3641 2
AUXAGND 4
NM GND
R3642 R3646 4
AUXR 5 22k
R3647 AUXL

D3641 DZ2S180C

DZ2S180C

DZ2S180C
NM 3
AUXAGND 6 22k
AUXR
R3643
AUXL 7 1
B 75
R3648
VIDEO
AUXVGND 8 NM

5
C3641

C3642
0.1u/50
D3642

D3643
AUXV 9

R3661
0.1u/50
GNDSIG 10

4
1
AUX:+2.2 dBs
ANR 11
GND
GNDSIG 12

ANG 13

GNDSIG 14
APPPUP
ANB 15
1000p/50
APPPUP 16
C3722
CSYNC 17

HSYNC 18
C3601 2.2u/10
VSYNC 19
C3602 2.2u/10
C GND 20
A 5/6 CN1701

C3603 2.2u/10
DTVL 21
DTVAG 22
C3724
DTVR 23
C3604 2.2u/10
TVON 24 C3723 1000p/50 2.2u/10
1000p/50 C3605
GUIDEON 25
IC3661
ONSEI+ 26
1 NC_1 8
ONSEI- 27 VCC
2 NC_2 7
GND 28 C3725 VCLK
18p/50 3 NC_3 6
SYSTON 29 C3726 SCL
18p/50 4 GND 5
NTOSYS 30 SDA

R3682
GND 31
NM
BTMICN 32 GND
D
BTMICP 33

GNDD 34 GNDD

GNDD 35

GNDD 36

SXTOS 37 GNDD
STOSX 38
C3721 1000p/50
GND 39

ASENBO 40 GND
SXR 41

GNDA 42

SXL 43 SXPWR
C3606
SXPWR 44
NM
E SXPWR 45
GND
SXEN 46

GNDSX 47

GNDSX 48 NM
R3691

NM

WIREDD 49 GNDSX WIRED REMOTE BT MIC JA3691


WIREDAD 50 R3692 NM
NM
R3731
JA3731 1
3
NM CKS6437-A R3693 2
NM

R3732 1k NM
R3694
VA3691
0.1u/10

NM

VA3692

WIREDAD
C3692

NM

NM

2 WIRED
C3691

3 GND
1
C3731

C3732

D3732
NM
D3731
NM

NM

NM

GND

1 1 GN
GND GNDD
KN3601 KN360
B M2R6TP_GND M2R6TP_GND

AVH-X1600DVD/XNUC
138
1 2 3 4
5 6 7 8

A
JA3621
CKB1106-A
1

2 B.CAMERA INPUT
B INTERFACE PCB

CN3661
CKS4497-A

D3666 1 CCR
NM
2 CCG
D3667
NM
3 CCB
D3668 B
NM
4 CCSYNC
8

D3669 5 GNDSIG
R3661

R3685
75

NM
D3670 6 HSYNC
NM
2

4
1

NM
D3671 7 GNDD
R3686 NM

NAVI/DTV INTERFACE
8 VSYNC
D3665 NM GNDD
9 ASENBO
GND R3674 NM
NM
R3662 22k 10 CCAUL
GND R3675 NM
R3663 22k NM 11 CCAUR
R3676
12 GNDAU IF-Mother Connector part : 3601 - 3620
R3677 2.7k
R3664 13 Back Camera part : 3621 - 3630
ONSEI+
R3678 2.7k
5.6k
14 ONSEI- Buzzer part : 3631 - 3640
R3684 NM
15 IPSDA AUX part : 3641 - 3660
R3683 NM
16 IPSCL NAVI part : 3661 - 3690 C
17 NC BT mic part : 3691 - 3700
R3687
18 NC SXi part : 3701 - 3730
NM
1k 19 DSEN Wired remote part : 3731 - 3740
R3665
20 TVON
R3680 NM

GND to GND : 3741 -


R3681 NM

R3666 1k
21 GUIDEON
IC3661
22 MONON
1 NC_1 8
R3679
APPPUP CHIP SIZE LEGEND
VCC 23 IP5V
2 NC_2 7
R3668 470 1608
NM
VCLK 24 SYS_TO_NAVI TV:+2.2 dBs 2125
3 NC_3 6 R3669 470 Navi Guide:+14.5 dBs
SCL 25 NAVI_TO_SYS 3216
4 GND 5
NM

NM

NM

NM

D3672 GNDD
SDA 26
NM
R3682

C3661

GNDD
NM

D3661

D3662

D3663

D3664

NM
NM

C3743
D3673 D
NM NM
GND GND GND
R3706 8.2k SXPWR
R3707 470
JA3701
R3712 NM
NM
10 PWEN
R3713

100k

D3705

D3706
NM

NM

9 SXPWR
R3711
D3704
NM

NM 8 GNDSX
C3702
0.1u/25

6 SXRX
R3704
R3708 GND SXi
5 GNDA
R3702 NM
180 GND 4 SXR
R3701 R3709
22k
3
R3703
470 NM
2
R3705 R3710 SXTX E
22k
1 SXL
180 NM
NM

NM

NM
C3701

NM

GNDSX
D3702
D3703
D3701

GND
C3744
1u/10
C3742 NM
NM
R3741
NM
TP3741 SERVICE UNIT(MOTHER I/F)
C3741 Consists of F
NM MOTHER PCB
1 1 GND INTERFACE PCB
601 KN3602
_GND M2R6TP_GND
B
AVH-X1600DVD/XNUC
5 6 7 8
139
1 2 3 4

10.8 DVD CORE UNIT (GUIDE PAGE)

C-a

SDODAC

TEMP
FD
TD
D+
SCKDAC
LTDAC

D-

COMPOSITE
IECOUT
C1806
C1801 CCG1192-A
CCG1201-A R1803 10u
ROUT
4.7u 820 (2125)

1800p/50
R1801

C1803
(2125)

100k

VCOM 10
11

12
MD 13
MC 14
ML 15
SCK 16
AGND 9
ADAC

PCM1753DBQ

IC1801
GNDAU1

VOUTR
VOUTL

DGND
LRCK
DATA
VCC

BCK
NC
1800p/50
R1802

C1804
100k

8
7
6
5
4
3
2
1
C1802
CCG1201-A R1804
LOUT

200 (D)
R1672
4.7u 820 X1501 27.000 MHz
(2125) CSS1823-A
4 C1604
NC2 X2 3 GNDV

R1601
68p/50

12k
VCC5_AU D1901
1 2 RSB6R8SM C1602

C1805

C1809
NC1

0.1u/10

0.1u/10
X1 100p/50
C1510 C1512
10p/50 10p/50 RSB6R8SM C1605
D1902

R1602
68p/50

12k
R1501
1.2k

IEC
GNDD R1955 15k C1603

B
GNDAU GNDD
R1503 R1954 15k R1670 R1983 100p/50

24 (F) (1608)
10k 100 R1671
1M

R1504
120
VCC33 GNDD (D) (D) 24k

(1608)
220
C1674 (D)

24 (F)
R1950

R1951
MDQ15

GNDD5
R1508
0.1u/10
MDQ0
R1603

0.1u/10

1u/10
10k (D)

100

TEMP
0

30k (D)
VTL1126-A

100
100
MDQ14

L1511
0.1u/10

0.1u/10

0.1u/10
C1673
(1608)
C1511

R1674

C1606
C1515
GNDA

0.1u/10
0.1u/10
C1601

C1514
MDQ1

C1671

C1676
R1506
R1507
R1987
R1505
VCC12 0.01u/16
AD2

CCG1192-A
CCG1192-A
C1502

C1501
(2125)

162
161

MDQ14 160
MDQ0 159

158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
10u

10u
(2125)

AVDDG

COMP2

COMP1
OSCO

AVDDH
MDQ1

TEMP
AVSSG

AVDDE
ROUT

FD
TD

VDSENS
ADOUT

DACCK

DAC5OUT

AVDDF
DAC1OUT
DAC2OUT
DAC3OUT

AVSSH
SRCK

LOUT

VREF
MDQ15

AVSSE

AD4
AD2
AVSSF
LRCK

COMPOSITE
163

OSCI

VSS_9
MDQ13

IECOUT

AVDDI

VIN1
VIN2
VSS_10

AVSSI

IREF1
VDD12_4

VDD33_6
MDQ2 164
165 MDQ13
MDQ2
C1504 166 VSS_11
VDD33_7
MDQ12 0.1u/10 167
MDQ12
MDQ3 168
MDQ3
MDQ11 169
MDQ11
MDQ4 170
MDQ4
MDQ10 171
MDQ10
MDQ5 172
MDQ5
173
VSS_12
C1505 174
VDD33_8
MDQ9 0.1u/10 175
MDQ9
MDQ6 176
MDQ6
MDQ8 177
MDQ8
MDQ7 178
MDQ7
DQM0 179

C
DQM0
DQM1 180
DQM1
XWE 181
NWE
182
L1501 VSS_13
MCK R1512 183
MCK
47 CTF1743-A C1506 184
VDD33_9
0.1u/10 185
MCKI
186
VSS_14
C1503
R1538

187
100k

VDD12_5
XCAS 0.1u/10 188
NCAS
XRAS 189 IC1501
NRAS MN2DS0018MA
XCSM 190
NCSM
STANDBY 191
STANDBY
MA11 192
DQM3
BA0 193
BA0
MA9 194
MA9
195
VSS_15
C1507 196
VDD33_10
BA1 0.1u/10 197
BA1
MA8 198
MA8
MA10 199
MA10
MA7 200
MA7
MA0 201
MA0
MA6 202
MA6
MA1 203
MA1
204
VSS_16
C1508 205
VDD33_11
MA5 0.1u/10 206
MA5
MA2 207

D
MA2
MA4 208
MA4
MA3 209
MA3
210
VSS_17
C1509 211
VDD12_6
0.1u/10 212
EXADT0
213
NEXCE
214 NEXOE
EXDT0
EXADR16

EXADR19

EXADR18
EXADR17
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
VDD33_1

VDD33_2

VDD12_1

VDD33_3

VDD12_2
215
EXADT9
EXADT8

EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
EXDT8
EXDT10

EXDT11

EXDT12

EXDT13

EXDT14

EXDT15

NEXWE
3 EXDT1
EXDT9
4 EXDT2

EXDT3

EXDT4

EXDT5

EXDT6

EXDT7
VSS_1

VSS_2

VSS_3

VSS_4

VSS_5
216
1
2

6
7
8
9
5

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
VCC33
DEBUG

GNDD
GNDD4

0.1u/10

0.1u/10

0.1u/10

0.1u/10

0 1u/10
C1513

C1516

C1517

C1518

C1519
1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
10 11

CN1951 R1517 10k R1539


NM 100
R1529 10k R1533
GNDD
R1971 NM
R1972 NM
R1973 NM
R1974 NM
R1975 NM
R1976 NM
R1977 NM
R1978 NM
R1979 NM

R1531 10k NM

R1547
R1518 10k
R1528 10k
R1530 10k R1542
10
R1527 6.8
TRCDATA3
TRCDATA2
TRCDATA1
TRCDATA0

SCLOCK
TRCCLK
EXTRG0

R1546 6.8
TRCST

SDATA

XCSF2

XWR1
XRD

D10

D11

D12

D13

D14

D15

A16
A15
A14
A13
A12
A11
A10

A19

A18
A17

A20
D0
D8

D1
D9
D2

D3

D4

D5

D6

D7
A0

A9
A8

A7
A6
A5
A4
A3
A2
A1

VCC33

E
L1904
CTF1528-A
CCG1192-A

FLASH 16M FLASH 16M


1000p/50
C1490

C1489

10u
(2125)

IC1401 VCC33 IC1402 VCC33


C1480 IC1480
1 54 A15 1 48 C1404 A16 A15 1 48 C1409 A16
A15 A16 A15 A16
MDQ0 R1490 0.1u/10 2 VDD1 GND3 53
R1485 A14 2 47 CCG1201-A A14 2 47 CCG1201-A
DQ0 DQ15 56 A14 BYTE A14 BYTE
56 C1481 3 52 3 46 4.7u (2125) 3 46 4.7u (2125)
MDQ15 A13 A13
VDDQ1 GNDQ4 A13 VSS2 A13 VSS2
0.1u/10 4 51 5 4 4 A12 45 4 A12 45
MDQ1 MDQ14 A12 D15 A12 D15
DQ1 DQ14 DQ15/A-1 DQ15/A-1
5 4 5 50 6 3 5 44 5 44
MDQ2 MDQ13 A11 D7 A11 D7
DQ2 DQ13 A11 DQ7 A11 DQ7 VHALF
6 3 R1480 6 49 C1488 7 2 6 43 6 43
MDQ3 56 MDQ12 A10 D14 A10 D14
GNDQ1 VDDQ4 A10 DQ14 A10 DQ14
7 2 7 48 0.1u/10 8 1 7 42 7 42
MDQ4 A9 D6 A9 D6 VHALF
DQ3 DQ12 A9 DQ6 A9 DQ6
8 1 8 47 8 41 8 41 IC1251
R1486 A8 D13 A8 D13
DQ4 DQ11 A8 DQ13 A8 DQ13
2
56
C1482 9 46 MDQ11 A19 9 40 D5 A19 9 40 D5 1 VR 28
VDDQ2 GNDQ3 XWR1 10 A19 DQ5 A19 DQ5 PreVcc
5 4 0.1u/10 10 45 5 4 39 10 39 2 OPIN2+ 27 C1524
MDQ5 MDQ10 XWR1 D12 A20 D12 TD2 0.047u/16
DQ5 DQ10 NC1 DQ12 NC1 DQ12
6 3 R1481 11 44 6 3 11 38 11 38 TD1 R1251 3 OPIN2-OPIN3+ 26 MD1 MD2
MDQ6 56 MDQ9 FRES D4 XWR1 D4 TD
DQ6 DQ9 WE DQ4 WE DQ4
4
7 2 12 43 C1487 7 2 12 %RESET 37 C1403 12 %RESET 37 C1408 33k R1252 OPIN3-
4 OPOUT2 25 R1255
MDQ7 MDQ8 FRES
R1401

C1401

GNDQ2 VDDQ3
220

VCC VCC OPOUT3


0.1u/16

8 1 13 42 0.1u/10 8 1 13 36 0.1u/10 13 36 0.1u/10 47k 5 OPIN1+ 24 18k


D11 D11 FD2
DQ7 DQ8 NC2 DQ11 NC2 DQ11 OPINSL CRGDRV
C1484 14 41 C1410 14 35 D3 14 35 D3 FD FD1 R1253 6 OPIN1- 23 R1256 7.5k
VDD2 GND2 WP DQ3 WP DQ3 OPOUTSL
DQM0 0.1u/10 15 40 0.1u/16 15 34 D10 15 34 D10 33k R1254 7 OPOUT1 22
LDQM NC2 RY/BY RY/BY
5 4 NRES DQ10 DQ10 LDIN C1523
XWE 16 39 R1489 DQM1 A18 GNDD 16 33 D2 A18 16 33 D2 47k
WE UDQM A18 DQ2 A18 DQ2 0.22u/6.3
6 3 R1482 17 38 56 17 32 17 32 29 30
XCAS 56 MCK A17 D9 A17 D9
CAS CLK A17 DQ9 A17 DQ9 FIN1 FIN2
7 2 18 37 18 31 18 31
XRAS A7 D1 A7 D1
RAS CKE A7 DQ1 A7 DQ1
8 1 19 36 19 30 19 30 8 GND1 21 R1258 220
XCSM MA11 A6 D8 A6 D8
CS NC1 A6 DQ8 A6 DQ8 CNT
5 4 20 35 5 4 20 29 20 29 CNT2 R1257 220 9 MUTE 20
BA0 MA9 A5 D0 A5 D0 CONT2
BA0 A11 A5 DQ0 A5 DQ0 GND2
6 3 R1483 21 34 R1487 6 3 21 28 21 28 C1254 10 PowVcc1 19 C1255
BA1 56 56 A4 DGND1 XRD A4 DGND2 XRD
BA1 A9 A4 OE A4 OE
7 2 22 33 7 2 22 27 22 27 FOP2 0.1u/16 11 PowVcc2 18 0.1u/16
MA10 MA8 A3 A3 FOP
A10 A8 A3 VSS1 A3 VSS1 VO1- VO4-
8 1 23 32 8 1 23 26 23 26 FOM2 12 17
MA0 MA7 A2 XCSF1 A2 XCSF2 FOM
A0 A7 R1488 5 A2 CE A2 CE VO1+ VO4+
5 4 24 31 4 24 25 100k 24 25 R1405 TOM2 13 16
MA1 56 MA6 A1 A1 TOM
A1 A6 A1 A0 A1 A0 VO2- VO3-
6 3 R1484 25 30 6 3 R1402 100k TOP2 14 15
MA2 56 MA5 A0 A0 TOP
F MA3 7
8
2
1 C1485
26
A2
A3
A5
A4
29 7
8
2
1
MA4 CWW5043 GNDD
CWW5044
R1406
VO2+ VO3+

27 28 4.7k BA5839FP
CCG1222-A
4.7u (2125)

VDD3 GND1
C1253

C1252

C1251

0.1u/10
0.1u/16

M12L64164A-5TG2Y
GNDD3 GNDP5 GNDP4
GNDD
SDRAM MOTOR DRIVER
GNDD

C
GNDP

AVH-X1600DVD/XNUC
140
1 2 3 4
5 6 7 8

C-b
TEMP
FD
TD

FE2
FE1

F+H_G+H
E+G_E+F
C DVD CORE UNIT
1000->1049 :POWER SUPPLY
1100->1199 :PU
1200->1299 :ACT+SPDL
1400->1449 :FLASH
1480->1499 :SDRAM
1500->1599 :DV5(SYS)
1600->1669 :DV5(FE)
1670->1699 :DV5(BE)
1700->1749 :VIDEO
04 1800->1849 :AUDIO (ANALOG)
R1601

0 1850->1899 :AUDIO (DIGITAL)


12k

02 IC1004
1900->1950 :OUTSIDE I/F NJM2855DL1-33
50 1950->1999 :USB

2 GND
3 Vout
05

1 Vin
R1602

0
12k

VDSENS VCC33
03

B
VCC33 VD5
50

2.2u/10
71

C1010

C1011
1u/10
k VHALF

IC1953
S-1135D12-A6
R1603 VCC12 GNDD
C1608 (2125) VCC33 1 6
GNDA3

10k (D) CCG1201-A


TEMP

VREF1 VCC12 VOUT VIN


2 7 5

C1953
1u/10
0.1u/10
C1606

C1601 4.7u C1607 VSS NC2


VREF CCG1192-A 3 4

C1954
10u

1u/10
0.01u/16 VREF2 C1623 NC1 ON/OFF
AD2
1u/10 (1608) (2125)
GND
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112

E+G_E+F 111
VHALF 110

109

C1609
1M
R1605 1M

0.1u/10
GNDD
AVDDH

TEMP
FD
TD

VDSENS
DAC2OUT
DAC3OUT

AVSSH

VREFH
AD4
AD2

R1604

108
F+H_G+H
VIN7
VIN1
VIN2
VIN4
VIN3

VIN6
VIN5
VIN8

107
AVSSB 106
AVDDB LPCO2
LPCO2 105
CDMPD
CDMPD
104 LPCO1
LPCO1
103 DVDMPD
DVDMPD
102
VREFL5 F1001
101 DTF1106-A
VREFH5
100 C1612 L1902
0.1u/10 B VD8 1 3
VIN3RF
99 C1613 A CTF1487-A
VIN4RF 0.1u/10
98 C1614 2
0.1u/10 C
VIN2RF
97 C1615 0.1u/10 D
VIN1RF IC1003
96 C1616 0.1u/10 RF VCC5_AU
RFINP 5 1 GNDP
95 C1617 VOUT VIN C1040
RFINN 0.1u/10 VCC5_AU

(1608)
2
94 VSS 820p/50
ANAMONI2 ANAMONI2
C1001

C1005
4 3
(1608)
1u/10
93 NC ON/OFF R1043
ANAMONI1 ANAMONI1
C1625

1u/16
92 0.1u/10 NM

C
AVDDC S-1200B50-M5 (3216)
91 C1618 100p/50 GNDAU GNDV
CDATA
90 C1619 5600p/25 IC1002 C1041
CCAPA S-1133B50-U5
89 0.1u/16 VIN 4 270p/50
3 ON/OFF

GNDP3
AVSSC R1045
88 C1620 C1002
VREFL7 0.22u/6.3 VCC5 2 VSS NM
87 GNDAU (3216)
VCC5 VOUT5 1 NC
AVSSD
86 C1621 0.22u/6.3 GNDP GNDD

CCG1201-A
GNDA

GNDP2
VREFH7

C1004
85 C1622

(2125)
0.1u/16
GNDA1

4.7u
0.033u/16
C1003
PLFIL1 GNDA2
84 C1624 0.1u/10
AVDDD
83 C1521 CN1952
CKS6025-A

GNDP1
VDD12_3 VD8_P2 VD8_P1
82 0.1u/10
VSS_8 GNDA 30 VD8
81 C1015
TRCST TRCST 1000p/50 VD8
TRCST 29
80 TRCDATA3 VD8_A VD8
TRCDATA3 28
79 TRCDATA2 VD5 1 3 PGND
TRCDATA2 27
78 TRCDATA1 F1002 GNDD1 GNDD2 PGND
TRCDATA1 2 26
77 TRCDATA0 DTL1106-A VD5_2 VD5_1
TRCDATA0 25 DGND
76 TRCCLK L1903 CTF1558-A
TRCCLK 24 VD5
75 AMUTE AMUTE R1019 AMUTE AMUTE
EXTRG1 23
74 EXTRG0 NRES 100 NRES XRESET
EXTRG0 22
73 SDATA SDATA IRQPWR IRQPWR IRQPWR
SDATA 21
72 SCLOCK SCLOCK CMDCOMN CMDCOMN HSTCMD
SCLOCK 20
71 STSCOMN STSCOMN
FG 19 SLVSTS
70 R1523 NRES STANDBY R1025 STANBY
NRES 18 STANBY
100k

C1522
4.7k
100k

69 220 100
1k
1k

AGND
0.01u/16

VDD33_5 17
RO
A 2/6
C1526

R1522
R1516
R1510
R1509
R1524

68 0.1u/10 ROUT ANALOG ROUT


VSS_7 16
67 R1513 CRGDRV
CRGDRV 10k 15 AGND
66 R1514 LO
MD
65
18k
HOME
MD LOUT
14 ANALOG LOUT
CN751
HOME 13 AGND
64 CONT2 COMPOSITE R1027 COMPOSITE COMPOSIT
D
CONT2 12
63 CONT1 100 VIDEO GND
CONT1 11
62 LDIN
LDIN 10 DGND
61 CP_RESET R1532 CP_RST D- D-
CP_Reset 9 D-
P13 60 100 D+ D+ D+
XCSSR 59 8
XCSF1 DGND
SCKDAC 7
SDODAC 58 SCKDAC IECOUT
LTDAC 6 IECOUT
12EJ 57
USB_CLOCK

SDODAC
CMDCOMN

5 DGND
STSCOMN
EXADR18
EXADR17

I2C_SCL
VDD33_3

VDD12_2

VDD33_4
I2C_SDA

56 SCL
IRQPWR

LTDAC I2C_SCL
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1

4
VSS_5

VSS_6

55 SDA SCL
08EJ

12EJ I2C_SDA
A20

3 SDA
CP_RST CP_RST
2 RESET
100k
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54

100k

GNDAU2
10k

VD8
1k
10k

1 DGND
GNDV1 GNDV2
R1004

47k
R1537
R1525
R1519
R1535

R1526

VSENS
R1540 STSCOMN VDSENS
GNDAU3

220
0.1u/10
0.1u/10

0.1u/10

C1520
C1518

C1519

R1541
1000p/50

220 CMDCOMN
0.1u/10
R1007

C1018

C1016
6.8k

R1539 R1534 IRQPWR


100k 220
R1533 C1528 470p/50
NM R1536 100k GNDD GNDAU GNDV CN1101
CKS6331-A
R1547
NM

TOP TOP1
1 T+
FOM
R1542 2 F-
10k 08EJ FOP FOP1
3 F+
R1527 6.8k R1544 180 I2C_SDA TOM
4 T-
R1546 6.8k R1543 180 I2C_SCL VCC5 VREF
5 GND
TEMP
A18
A17

A20
A7
A6
A5
A4
A3
A2
A1

X1950 6 TEMP
C1950 4 X2 3
R1952

GND2 C1108 7
0.01u/16 TEMP GND
0.1u/10
C1952
10p/50
1M

8 Vref
5 1 1 2 VCC5_PU

E
VCC NC X1 GND1 9 VCC
R1953

2 F+H_G+H F+H_G+H C1110 0.01u/16


820

IN_A CSS1760-A 10 F+H/G+H


4 3 48.000 MHz E+G_E+F E+G_E+F
OUT_Y GND 11 E+G/E+F
PU UNIT (DP11)
48MHz

C1951
10p/50

12 SW
IC1951 CDLD0
CDLDO 78LD
13
TC7SZU04FU DVDLD0
DVDLDO 65LD
14
GNDD LD GND
15
B B
HOME
CSN1080-A A A
16 B

HOME S1 17 A
4 31

HOME R1223 C C
2

18 C
560 C1223 D D
19 D
IC1251 NM FE1 FE1
S2 NM 20 FE1
4 31

28 08EJ R1224 08EJ FE2 FE2


VR
2

PreVcc VR1101 21 FE2


27 C1524 NM C1224 IMON
OPIN2+ 0.047u/16 CCP1447-A 22
OPIN3+ CDMPD CDMPD 2 IMON
OPIN2- 26 MD1 MD2 MD NM
S3 CSN1081-A R1982 23 RF
OPIN3-
4 31

25 R1255 12EJ R1225 12EJ DVDMPD DVDMPD 2


OPOUT2 R1113 R1118 3 1 8.2k
2

VCC5
OPOUT3
1
24 18k CRGDRV 470 6.8k(B)
OPIN1+ C1225 R1110 3.9 3.9
CDLD1
CDLD2

OPINSL CRGDRV 3 1
OPIN1- 23 R1256 7.5k VR1102
(2125)

3.3
OPOUTSL
LDIN
SWITCHES: 12EJ GNDD NM (1608*4) CCP1449-A
C1105
10u (2125)

R1105

0.1u/10

22 RF 15k(B)
DCH1256-A

LDIN RF
430

OPOUT1
CCG1192-A

R1114 R1117
(F)

C1112

LDIN C1523
0.22u/6.3
DVD CORE UNIT
C1101

3.3 3.9
22u

30
FIN1 FIN2
S1:HOME SWITCH.........ON-OFF
C1109

C1111
0.22u/16

0.22u/16
(1608)

(1608)

CNT1 Q1104
LPCO2 Q1102 2SB1132(QR) CDLDO
21 R1258
GND1 CNT
220 CONT1
S3:12EJ SWITCH............ON-OFF LSCR523UB
R1102

R1106

MUTE GND2 20
100k

C1107
560

The underlined indicates the switch position.


(F)

19 C1255 0.01u/16
PowVcc1 GNDA

3
PowVcc2 18 0.1u/16 R1112 R1115
LECRGP
VO1- VO4-
17 3.3 2.7
DVDLD1
DVDLD2

LECRGM R1109
(2125)

VO1+ VO4+ (1608*4)


16 WHITE 3.3
DCH1256-A

SPDLP LECRGM LECRGM


VO2- VO3- M
0.1u/10

M1 CXC4026
C1104
C1113

3
R1103
1

15 R1111 R1116
430

SPDLM
F
(F)
0.1u/16
C1955

VO2+ VO3+
22u

CRG(L/E) MOTOR 3.3 2.7


VD8 Q1103
BA5839FP LECRGP GREEN 2SB1132(QR)
LECRGP DVDLDO
CCG1222-A
4.7u (2125)

LPCO1 Q1101
1

LSCR523UB
C1253

C1252

C1251

100u/16

SPDLM BLK
0.1u/16

SPDLM
M
1

M2 EXM2002
R1101

R1104

DP5 GNDP4
100k
0.1u/16

510
C1210

(F)

SPINDLE MOTOR GNDA4 C1106


SPDLP SPDLP RED 0.01u/16

C
GNDP
1

GNDA

AVH-X1600DVD/XNUC
5 6 7 8
141
F
E
B
A

D
C

142
C-a C-b
C-b

FE2
FE1

TEMP
DVD CORE UNIT

F+H_G+H
E+G_E+F

1
1

C
1000->1049 :POWER SUPPLY
1100->1199 :PU
1200->1299 :ACT+SPDL
1400->1449 :FLASH
1480->1499 :SDRAM
1500->1599 :DV5(SYS)
1600->1669 :DV5(FE)
1670->1699 :DV5(BE)
1700->1749 :VIDEO
1800->1849 :AUDIO (ANALOG)
1850->1899 :AUDIO (DIGITAL)
IC1004
1900->1950 :OUTSIDE I/F NJM2855DL1-33
1950->1999 :USB

3 Vout
2 GND
1 Vin
VDSENS VCC33
VCC33 VD5

VHALF

1u/10

2.2u/10

2
2

C1010
C1011
IC1953
S-1135D12-A6
03 VCC12 GNDD
C1608 (2125) VCC33 1 6
k (D) VREF1 CCG1201-A VCC12 VOUT VIN
2 7 5
01 4.7u C1607

TEMP
VSS NC2

GNDA3
CCG1192-A 3 4

1u/10
VREF

C1953
u/16 VREF2 C1623 10u NC1 ON/OFF
AD2

1u/10
C1954
1u/10 (1608) (2125)
GND
C1609

123
122
121
120
119
118
117
116
115
114
113
112
109
0.1u/10

1M
GNDD
108

AD2
VIN7

TEMP
VIN1
VIN2
VIN4
VIN3
VIN6
VIN5

VIN8
107

R1604
R1605 1M

VHALF
VREFH 110

VDSENS
AVSSB 106

F+H_G+H
E+G_E+F 111
AVDDB LPCO2
LPCO2 105
CDMPD
CDMPD
104 LPCO1
LPCO1
103 DVDMPD
DVDMPD

AVH-X1600DVD/XNUC
102
VREFL5 F1001
101 DTF1106-A
VREFH5
100 C1612 L1902
0.1u/10 B VD8 1 3
VIN3RF
99 C1613 A CTF1487-A
VIN4RF 0.1u/10
98 C1614 2

3
3

0.1u/10 C
VIN2RF
97 C1615 0.1u/10 D
VIN1RF IC1003
96 C1616 0.1u/10 RF VCC5_AU
RFINP 5 1 GNDP
95 C1617 VOUT VIN C1040
RFINN 0.1u/10 VCC5_AU
2
94 VSS 820p/50
ANAMONI2 ANAMONI2
(1608)

4 3
93 NC ON/OFF R1043
ANAMONI1 ANAMONI1

C1001
1u/10
C1005

C1625

(1608)
92 0.1u/10 NM
AVDDC S-1200B50-M5 (3216)
1u/16

91 C1618 100p/50 GNDAU GNDV


CDATA
90 C1619 5600p/25 IC1002 C1041
CCAPA S-1133B50-U5
89 0.1u/16 VIN 4 270p/50
AVSSC 3 ON/OFF
R1045
88 C1620 0.22u/6.3 VCC5 C1002
VREFL7 2 VSS NM
GNDAU
GNDP3

87 VOUT5 (3216)
AVSSD VCC5 1 NC
86 C1621 0.22u/6.3 GNDP GNDD
VREFH7 GNDA
85 C1622 0.033u/16 GNDA1
PLFIL1 GNDA2
4.7u
GNDP2

84 C1624
C1004
(2125)

0.1u/10
C1003
0.1u/16

AVDDD CN1952
CCG1201-A

83 C1521
VDD12_3 VD8_P2 VD8_P1 CKS6025-A
82 0.1u/10
VSS_8 GNDA 30 VD8
C1015
GNDP1

81 TRCST TRCST 1000p/50


TRCST 29 VD8
80 TRCDATA3 VD8_A VD8
TRCDATA3 28
79 TRCDATA2 VD5 1 3 PGND
TRCDATA2 27

4
4

78 TRCDATA1 F1002 GNDD1 GNDD2 PGND


TRCDATA1 2 26
77 TRCDATA0 DTL1106-A VD5_2 VD5_1
TRCDATA0 25 DGND
76 TRCCLK L1903 CTF1558-A
VD5
TRCCLK 24
75 AMUTE AMUTE R1019 AMUTE AMUTE
EXTRG1 23
74 EXTRG0 NRES 100 NRES XRESET
EXTRG0 22
73 SDATA SDATA IRQPWR IRQPWR IRQPWR
SDATA 21
72 SCLOCK SCLOCK CMDCOMN CMDCOMN HSTCMD
SCLOCK 20
71 STSCOMN STSCOMN
FG 19 SLVSTS
70 R1523 NRES STANDBY R1025 STANBY
NRES 18 STANBY
69 C1522 220 100

1k
1k AGND
4.7k

100k
VDD33_5 17

100k
68 0.1u/10 ROUT RO
VSS_7 16 ANALOG ROUT
67 R1513

C1526
R1522
R1516
R1510
R1509
R1524

0.01u/16
CRGDRV
CRGDRV
R1514
10k
LO 15 AGND
A 2/6
66 18k MD LOUT ANALOG LOUT
MD 14 CN751
75 AMUTE AMUTE R1019 AMUTE AMUTE
EXTRG1 23
74 EXTRG0 NRES 100 NRES XRESET
EXTRG0 22
73 SDATA SDATA IRQPWR IRQPWR IRQPWR
SDATA 21
72 SCLOCK SCLOCK CMDCOMN CMDCOMN HSTCMD
SCLOCK 20
71 STSCOMN STSCOMN
FG 19 SLVSTS
70 R1523 NRES STANDBY R1025 STANBY
NRES 18 STANBY
69 C1522 220 100

1k
1k
AGND

4.7k

100k
VDD33_5 17

100k
68 0.1u/10 ROUT RO
VSS_7 16 ANALOG ROUT
67 R1513

C1526
R1522
R1516
R1510
R1509
R1524

0.01u/16
CRGDRV
CRGDRV
R1514
10k
LO 15 AGND
A 2/6
66 18k MD LOUT ANALOG LOUT
MD 14 CN751
65 HOME
HOME 13 AGND
64 CONT2 COMPOSITE R1027 COMPOSITE
CONT2 12 COMPOSIT
63 CONT1 100 VIDEO GND
CONT1 11
62 LDIN
LDIN 10 DGND
5

5
61 CP_RESET R1532 CP_RST D- D-
CP_Reset 9 D-
P13 60 100 D+ D+
8 D+
XCSSR 59 XCSF1 DGND
SCKDAC 7
SDODAC 58 SCKDAC IECOUT
LTDAC 6 IECOUT
12EJ 57 SDODAC
5 DGND
56 LTDAC I2C_SCL SCL
4 SCL
55 12EJ I2C_SDA SDA
3 SDA

I2C_SCL
I2C_SDA
08EJ

EXADT3
EXADT2
EXADT1
VSS_5
VDD12_2
IRQPWR
USB_CLOCK
VSS_6
VDD33_4
CMDCOMN
STSCOMN

A20
CP_RST CP_RST
2 RESET

41
42
43
45
46
47

40
44
48
49
50
51
52
53
54
VD8

1k
1 DGND

10k

100k
10k
100k
GNDAU2

47k
VSENS

R1004
R1540

R1537
R1525
R1519
R1535
R1526
220 STSCOMN VDSENS
R1541 CMDCOMN
220

C1520
GNDV1 GNDV2

0.1u/10
GNDAU3

0.1u/10
C1519
6.8k

R1007
C1018
C1016
0.1u/10
1000p/50
R1539 IRQPWR
100k R1534 220
R1533 C1528 470p/50
NM R1536 100k GNDD GNDAU GNDV CN1101
CKS6331-A
TOP1

NM
TOP
1

R1547
T+
FOM
R1542 2 F-
10k 08EJ FOP FOP1

6
6

3 F+
R1527 6.8k R1544 180 I2C_SDA TOM
4 T-
R1546 6.8k R1543 180 I2C_SCL VCC5 VREF
5 GND
TEMP
6 TEMP

A3
A2
A1
A20
C1950 4 X1950
GND2 X2 3 C1108 7
0.01u/16 TEMP GND
0.1u/10

R1952
8 Vref

1M
5 1 1 2 VCC5_PU

C1952
10p/50
VCC NC X1 GND1 9 VCC
2 F+H_G+H F+H_G+H C1110 0.01u/16
IN_A CSS1760-A 10 F+H/G+H

820
4 3

R1953
48.000 MHz E+G_E+F E+G_E+F
OUT_Y GND 11 E+G/E+F
12 SW
PU UNIT (DP11)
IC1951 CDLD0

48MHz
CDLDO

C1951
13 78LD

10p/50
TC7SZU04FU DVDLD0
DVDLDO 65LD
14
GNDD LD GND
15
B B
16 B
HOME
CSN1080-A A A
HOME S1 17 A
R1223

2
HOME C C C
18

4 31
560 C1223 D D
19 D
NM S2 NM FE1 FE1

AVH-X1600DVD/XNUC
20 FE1
R1224 08EJ FE2

2
08EJ FE2
21 FE2

4 31
C1524 NM C1224 VR1101 IMON
0.047u/16 CCP1447-A 22
CDMPD CDMPD 2 IMON

7
7

D1 MD2 MD NM
S3 CSN1081-A R1982 23 RF
R1255 R1225 12EJ DVDMPD

2
12EJ VCC5 R1113 R1118 DVDMPD 2 3 1 8.2k

4 31
18k CRGDRV 470 6.8k(B)
C1225 R1110 3.9 3.9
RGDRV 1 3 1
R1256 7.5k VR1102
LDIN NM 3.3 (1608*4) CCP1449-A
CDLD1
CDLD2
LDIN 12EJ GNDD RF RF 15k(B)
SWITCHES: R1114 R1117

(2125)

430

(F)
C1523
C1105

R1105
0.22u/6.3 0.1u/10 3.3 3.9

C1112
DVD CORE UNIT
22u

10u (2125)

C1101
DCH1256-A

CCG1192-A
CNT1 S1:HOME SWITCH.........ON-OFF Q1104
LPCO2 Q1102 2SB1132(QR) CDLDO
C1109
C1111

(1608)
(1608)

R1258 220 CONT1 LSCR523UB


0.22u/16
0.22u/16

S3:12EJ SWITCH............ON-OFF
C1107
560

(F)
C1255 0.01u/16

100k
The underlined indicates the switch position.

R1102
R1106
GNDA
0.1u/16 LECRGP R1112 R1115

LECRGM
3 R1109 3.3 2.7
LECRGM WHITE 3.3 (1608*4)
SPDLP LECRGM
(2125)

1
M
DVDLD1
DVDLD2

M1 CXC4026 R1111 R1116


SPDLM
430

(F)
C1104

C1113

3 CRG(L/E) MOTOR
0.1u/10

R1103

3.3 2.7
22u

VD8 Q1103
DCH1256-A

C1955
0.1u/16
LECRGP GREEN 2SB1132(QR)
LECRGP LPCO1 Q1101 DVDLDO

1
SPDLM SPDLM BLK LSCR523UB

1
M M2 EXM2002

C1253
C1252
C1251

0.1u/16
100u/16
510

(F)

CCG1222-A
4.7u (2125)
100k

SPINDLE MOTOR GNDA4 C1106


R1101
R1104
8

8
C1210
0.1u/16
SPDLP SPDLP RED 0.01u/16

1
GNDA

C-a C-b
C-b

143
E
A

D
C

F
B
F
E
B
A

D
C

144
C-a C-b
C-b

C-a
D+
D-
FD
TD
FE2
FE1

TEMP

LTDAC

SDODAC
SCKDAC
IECOUT
C1806

1
1

COMPOSITE
C1801 CCG1192-A
CCG1201-A R1803 10u
ROUT
4.7u 820 (2125)
(2125)

11
12

100k
R1801
C1803
ADAC

1800p/50
MD 13
MC 14
ML 15
SCK 16

AGND 9
VCOM 10
GNDAU1

IC1801

VOUTR
VOUTL
VCC
NC
DGND
LRCK
DATA
BCK

PCM1753DBQ
8
7
6
5
4
3
2
1
C1802

100k
R1802
C1804
CCG1201-A

1800p/50
LOUT R1804

4.7u 820 X1501 27.000 MHz


(2125)

R1672
200 (D)
CSS1823-A C1604
4 X2 3
NC2 GNDV
68p/50
VCC5_AU D1901
12k

1 2 RSB6R8SM C1602
R1601

X1 NC1
C1512 100p/50
C1510

C1805
C1809
C1605

0.1u/10
0.1u/10
10p/50 10p/50 RSB6R8SM
D1902
68p/50
12k

GNDD R1955 15k C1603


R1602

IEC

1.2k
GNDAU GNDD

R1501
R1503 R1954 15k R1670 R1983 100p/50
10k 100 R1671
1M
VCC33 GNDD (D) (D) 24k

2
2

120
C1674 (D)

220

R1504
MDQ15
(1608)
0.1u/10

24 (F) (1608)
24 (F)
MDQ0

R1950
R1951

R1508
GNDD5
R1603

0
MDQ14 10k (D)

100
100
100
1u/10

0.1u/10

GNDA C1601
TEMP

MDQ1
30k (D)

L1511
(1608)
C1673

C1511
R1674
C1606

0.1u/10
C1515
0.1u/10
0.1u/10

0.01u/16

C1514
0.1u/10

0.1u/10
VCC12

VTL1126-A
AD2
C1671
C1676

R1506
R1507
R1987

R1505

162
161
158
157
156
155
154
153
152
151
150
149
148
147
140
133
132
131
130
129
128
127
126
125
124
123
120
119

146
145
144
143
142
141
139
138
137
136
135
134
122
121
118
117
116
115

10u
10u

C1502
C1501

(2125)
(2125)

CCG1192-A
163

CCG1192-A
FD
TD

MDQ13
AD4
AD2
VIN7

LOUT
VREF
TEMP
VIN1
VIN2
VIN4
VIN3
VIN8

MDQ1
MDQ0 159
OSCO
OSCI
LRCK
SRCK
ROUT

MDQ2 164
AVSSG
AVDDG
AVDDE
AVSSE
AVSSF
COMP2
IREF1
COMP1
AVDDF
AVDDH
AVSSH

MDQ14 160
MDQ15
VSS_9
ADOUT
DACCK
AVDDI
AVSSI
VDSENS

VSS_10
IECOUT
165 MDQ13
DAC1OUT

DAC5OUT
DAC2OUT
DAC3OUT

VDD12_4
VDD33_6
MDQ2
VSS_11
COMPOSITE

C1504 166
VDD33_7
MDQ12 0.1u/10 167
MDQ12
MDQ3 168
MDQ3

AVH-X1600DVD/XNUC
MDQ11 169
MDQ11
MDQ4 170
MDQ4
MDQ10 171
MDQ10
MDQ5 172
MDQ5
173

3
3

VSS_12
C1505 174
VDD33_8
MDQ9 0.1u/10 175
MDQ9
MDQ6 176
MDQ6
MDQ8 177
MDQ8
MDQ7 178
MDQ7
DQM0 179
DQM0
DQM1 180
DQM1
XWE 181
NWE
182
L1501 VSS_13
MCK R1512 183
MCK
47 CTF1743-A C1506 184
VDD33_9
0.1u/10 185
MCKI
186
VSS_14
C1503 187
VDD12_5
100k

0.1u/10 188
R1538

XCAS
NCAS
XRAS 189 IC1501
NRAS MN2DS0018MA
XCSM 190
NCSM
STANDBY 191
STANDBY
MA11 192
DQM3

4
4

BA0 193
BA0
MA9 194
MA9
195
VSS_15
C1507 196
VDD33_10
BA1 0.1u/10 197
BA1
MA8 198
MA8
MA10 199
MA10
MA7 200
MA7
MA0 201
MA0
MA6 202
MA6
MA1 203
MA1
204
VSS_16
C1508 205
VDD33_11
0 1 /10
C1507 196
VDD33_10
BA1 0.1u/10 197
BA1
MA8 198
MA8
MA10 199
MA10
MA7 200
MA7
MA0 201
MA0
MA6 202
MA6
MA1 203
MA1
204
VSS_16
C1508 205
VDD33_11
MA5 0.1u/10 206
MA5
MA2 207
MA2
MA4 208
MA4
MA3 209
MA3
5

5
210
VSS_17
C1509 211
VDD12_6
0.1u/10 212
EXADT0
213
NEXCE
214 NEXOE
215 EXDT0
EXDT8
216
I2C_SCL
I2C_SDA

EXDT1
EXDT10
VSS_1
VDD33_1
EXDT3
EXDT11
EXDT4
EXDT12
EXDT5
EXDT13
EXDT6
EXDT14
VSS_2
VDD33_2
EXDT7
EXDT15
VSS_3
VDD12_1
EXADR16
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
EXADT9
EXADT8
EXADR19
NEXWE
VSS_4
VDD33_3
EXADR18
EXADR17
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
VSS_5
VDD12_2
IRQPWR

A20

1
2
3 EXDT9
4 EXDT2
6
7
8
9

5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48

VCC33
DEBUG

GNDD

GNDD4
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10

C1513
C1516
C1517
C1518
C1519

CN1951

1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
R1539

10 11
NM R1517 10k 100k
R1529 10k R1533
GNDD R1531 10k NM
NM

R1518 10k
R1547

R1971 NM
R1972 NM
R1973 NM
R1974 NM
R1975 NM
R1976 NM
R1977 NM
R1978 NM
R1979 NM
R1528 10k
R1530 10k R1542
10k

6
6

R1527 6.8k
R1546 6.8k

TRCST
TRCDATA3
TRCDATA2
TRCDATA1
TRCDATA0
TRCCLK
EXTRG0
SDATA
SCLOCK
A0
XCSF2
XRD
D0
D8
D1
D9
D2
D10
D3
D11
D4
D12
D5
D13
D6
D14
D7
D15
A16
A15
A14
A13
A12
A11
A10
A9
A8
A19
XWR1
A18
A17
A7
A6
A5
A4
A3
A2
A1
A20

VCC33
L1904
CTF1528-A
FLASH 16M FLASH 16M
IC1401 IC1402 VCC33

10u
VCC33

C1490
C1489
C1480 IC1480

(2125)

1000p/50
1 54 A15 1 48 A16 A15 1 48 C1409 A16

CCG1192-A
A15 A16 C1404 A15 A16
MDQ0 R1490 0.1u/10 2 VDD1 GND3 53
A14 2 47 CCG1201-A A14 2 47 CCG1201-A
DQ0 DQ15 R1485 A14 BYTE A14 BYTE
C1481 56 4.7u (2125) 4.7u (2125)
56 3 52 MDQ15 A13 3 46 A13 3 46
VDDQ1 GNDQ4 A13 VSS2 A13 VSS2
0.1u/10 4 51 5 4 45 45
MDQ1 MDQ14 A12 4 A12 D15 A12 4 A12 D15
DQ1 DQ14 DQ15/A-1 DQ15/A-1
5 4 5 50 6 3 5 44 5 44
MDQ2 MDQ13 A11 D7 A11 D7
DQ2 DQ13 A11 DQ7 A11 DQ7 VHALF
6 3 R1480 6 49 C1488 7 2 6 43 6 43
MDQ3 56 MDQ12 A10 D14 A10 D14
GNDQ1 VDDQ4 A10 DQ14 A10 DQ14
7 2 7 48 0.1u/10 8 1 7 42 7 42
MDQ4 A9 D6 A9 D6 VHALF
DQ3 DQ12 A9 DQ6 A9 DQ6
8 1 8 47 8 41 8 41 IC1251
R1486 A8 D13 A8 D13

AVH-X1600DVD/XNUC
DQ4 DQ11 56 A8 DQ13 A8 DQ13
C1482 9 46 MDQ11 A19 9 40 D5 A19 9 40 D5 1 VR 28
VDDQ2 GNDQ3 DQ5 A19 DQ5 PreVcc
4 4
MDQ5 5 0.1u/10 10 45 5 MDQ10
XWR1 10 A19 39 D12 A20 10 39 D12
2 2 OPIN2+ 27 C1524
DQ5 DQ10 XWR1 NC1 DQ12 NC1 DQ12 TD2 0.047u/16
OPIN3+

7
7

6 3 R1481 11 44 6 3 11 38 11 38 TD1 R1251 26 MD1 MD2


MDQ6 56 MDQ9 FRES D4 XWR1 D4 TD 3 OPIN2- M
DQ6 DQ9 WE DQ4 WE DQ4 OPIN3-
7 2 12 43 C1487 7 2 37 C1403 37 C1408 33k R1252 25 R1255
MDQ7 MDQ8 12 %RESET FRES 12 %RESET 4 OPOUT2
GNDQ2 VDDQ3 VCC VCC OPOUT3
8 1 8 1 0.1u/10
4 18k

220
13 42 0.1u/10 13 36 D11 13 36 0.1u/10 D11 47k 5 OPIN1+ 24 CRGDR
FD2

R1401
C1401
DQ7 DQ8 NC2 DQ11 NC2 DQ11 OPINSL CRGDRV
C1484 14 41 C1410 14 35 14 35 FD1 R1253 23 R1256 7.5k

0.1u/16
D3 D3 FD 6 OPIN1-
LDIN
VDD2 GND2 WP DQ3 WP DQ3 OPOUTSL
DQM0 0.1u/10 15 40 0.1u/16 15 RY/BY 34 D10 15 RY/BY 34 D10 33k R1254 7 OPOUT1 22 LDIN
LDQM NC2 NRES DQ10 DQ10 LDIN
5 4 16 39 R1489 33 16 33 47k C1523
XWE DQM1 A18 GNDD 16 D2 A18 D2 0.22u/6.3
WE UDQM A18 DQ2 A18 DQ2
6 3 R1482 17 38 56 17 32 17 32 29 30
XCAS 56 MCK A17 D9 A17 D9
CAS CLK A17 DQ9 A17 DQ9 FIN1 FIN2
7 2 18 37 18 31 18 31
XRAS A7 D1 A7 D1 CNT1
RAS CKE A7 DQ1 A7 DQ1
8 1 19 36 19 30 19 30 21 R1258 220
XCSM MA11 A6 D8 A6 D8 8 GND1 CONT
CS NC1 A6 DQ8 A6 DQ8 CNT
5 4 20 35 5 4 20 29 20 29 CNT2 R1257 220 20
BA0 MA9 A5 D0 A5 D0 CONT2 9 MUTE
BA0 A11 A5 DQ0 A5 DQ0 GND2
6 3 R1483 21 34 R1487 6 3 21 28 21 28 C1254 10 19 C1255
BA1 56 56 A4 DGND1 XRD A4 DGND2 XRD PowVcc1
BA1 A9 A4 OE A4 OE
7 2 22 33 7 2 22 27 22 27 FOP2 0.1u/16 11 PowVcc2 18 0.1u/16
MA10 MA8 A3 A3 FOP LECRG
A10 A8 A3 VSS1 A3 VSS1 VO1- VO4-
8 1 23 32 8 1 23 26 23 26 FOM2 12 17
MA0 MA7 A2 XCSF1 A2 XCSF2 FOM LECRG
A0 A7 A2 CE A2 CE VO1+ VO4+
5 4 24 31 R1488 5 4 24 25 100k 24 25 R1405 TOM2 13 16
MA1 56 MA6 A1 A1 TOM SPDL
A1 A6 A1 A0 A1 A0 VO2- VO3-
6 3 R1484 25 30 6 3 R1402 100k TOP2 14 15
MA2 56 MA5 A0 A0 TOP SPDL
A2 A5 VO2+ VO3+
7 2 26 29 7 2 CWW5043 GNDD R1406
MA3 MA4 CWW5044 VD8
A3 A4
8 1 C1485 27 28 8 1 4.7k BA5839FP
VDD3 GND1
0.1u/10
M12L64164A-5TG2Y
C1253
C1252
C1251

GNDD3 GNDP5 GNDP4


0.1u/16
100u/16

GNDD
CCG1222-A
4.7u (2125)

SDRAM
8

MOTOR DRIVER

8
GNDD GNDP

C-a C-b

C-a
C-b

145
E
A

D
C

F
B
1 2 3 4

10.9 SERVICE UNIT (MONITOR) (GUIDE PAGE)

D-a

33.3MHz
3.3V
TFT LCD

9.2V

VDDG+18V
OEV(Low)

VEEG-6V
UD(Low)

XON(Hi)
L/R (Hi)

DVDD
AVDD
AVDD
LOAD

HCLK

VCLK

Vcom

Vcom
VR10

STV2

STV1
DIO1

DIO2
GND

GND
GND

GND
GND
GND

GND
GND
POL
VR1
VR2
VR3
VR4
VR5
VR6
VR7
VR8
VR9
CN5001

NC

NC

NC

NC

NC
G0
G1
G2
G3
G4
G5
R0
R1
R2
R3
R4
R5
B0
B1
B2
B3
B4
B5
CKS6536-A

60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
TO LCD

R5028
47k

R5029
47k

R5026

47k
LCDGND

HCLK
R5024

LOAD

VCLK
OEV

POL
STV
DIO

G0
G1
G2
G3
G4
G5
R0
R1
R2
R3
R4
R5
B0
B1
B2
B3
B4
B5
47k

B C5021
C5028
1000p/50 NM C5038
C5022 C5033
NM
C5029 NM C5042
R5003 R5005 R5007 R5009 R5011 R5013 R5015 R5017 R5019 R5021 NM C5034 0.1u/16
C5023 C5039 0.1u/16
180 47 39 100 130 100 39 47 180 33 1000p/50 C5035
D% D% D% D% D% D% D% D% D% D% 0.1u/16 C5030 0.1u/50
4.7u/16V
C5024 0.1u/10 C5040

DTL1096-A
R5018

L5003
R5001 R5002 R5004 R5006 R5008 R5010 R5012 R5014 R5016 R5020 R5022 NM 3216 C5031 0.33u/50
R5108 CCG1192-A-T
4.7 56 2.2 0 4.7 8.2 0 8.2 4.7 0 2.2 2.4 C5025 10u/35

BTX1042-A
10k D% 10u/10V C5036
Q5106

DTL1096-A
CCG1236-A

CTF1635-A

L5004
2SA1577(QR)
R5139

L5001

L5002
3216
NM

NM

1000p/50

1000p/50
C5001

C5002

C5003

C5004

C5005

C5006

C5007

C5008

C5009

C5010

C5011

C5012

C5013

C5014

C5015

C5016

C5017

C5018

C5019

C5020
NM

NM

NM

NM

NM

NM

NM

NM

NM

NM

NM

NM

NM

Вам также может понравиться