"al
ATextron Company
208B (675 SHP) Caravan |
Information Manual |
FOR AIRPLANES WITH i
PT6A-114A (675 SHP) ENGINE
P/N - D1329-13NOTICE
AT THE TIME OF ISSUANCE, THIS INFORMATION
MANUAL WAS AN EXACT DUPLICATE OF THE
OFFICIAL PILOT'S OPERATING HANDBOOK AND
FAA-APPROVED AIRPLANE FLIGHT MANUAL AND
IS TO BE USED FOR GENERAL PURPOSES ONLY.
IT WILL NOT BE KEPT CURRENT AND, THEREFORE,
CANNOT BE USED AS A SUBSTITUTE FOR THE
OFFICIAL PILOT'S OPERATING HANDBOOK AND
FAA-APPROVED AIRPLANE FLIGHT MANUAL
INTENDED FOR OPERATION OF THE AIRPLANE.
THE PILOT'S OPERATING HANDBOOK MUST BE
CARRIED IN THE AIRPLANE AND AVAILABLE TO
THE PILOT AT ALL TIMES.
CESSNA AIRCRAFT COMPANY
ORIGINAL ISSUE - 1 MAY 1990GENERAL CESSNA
INFORMATION MODEL 208B
GENERAL INFORMATION
Cargo Passenger
Version Version
* SPEED (KTAS)
Maximum Cruise at 10,000 FT 175 KNOTS 184 KNOTS
Maximum Cruise at 20,000 FT 164 KNOTS 174 KNOTS
RANGE: With 2224 pounds usable fuel and fuel allowance
for engine start, taxi, takeoff, climb descent and
45 minutes reserve.
Maximum Cruise at 10,000 Ft . : 962 NM 907 NM
= woe eeeee St 5.1 HRS. 5.1 HRS
‘Maximum Cruise at 18,000 Ft 1044 NM 1109 NM.
oe uate 6.6 HRS. 6.6 HRS.
‘Maximum Range at 10,000 Ft ‘| cc) 963.NM 1026 NM
7 8.4 HRS 6.6 HRS
Maximum Range at 18,000 Ft = 1076 NM 1163 NM
7.2 HRS 7.8 HRS
RATE OF CLIMB AT SEA LEVEL Dolieleeeiis 925 PM 975 FPM
SERVICE CEILING Vee sees 22,800 FT 23,700 FT
MAXIMUM OPERATING ALTITUDE ad 25,000 FT 25,000 FT
TAKEOFF PERFORMANCE:
Ground Roll eerie 1405 FT 1965 FT
Total Distance Over 50-Foot Obstacle 2500 FT 2420 FT
LANDING PERFORMANCE:
Ground Roll : : : 915 FT 950 FT
Total Distance Over 50-Foot Obstacle 1740 FT 1795 FT
STALL SPEED (KCAS):
Flaps Up, idle Power 78 KNOTS, 78 KNOTS
Flaps Down, Idle Power Tea 61 KNOTS, 61 KNOTS
MAXIMUM WEIGHT:
Ramp poate 8785 LBS 9785 Les
Takeoft aoe : 8750 LBS 8750 LBS
Landing |... -. 8500 LBS 8800 LBS
STANDARD EMPTY WEIGHT:
‘SIN 20880179, 20880230 thru 20880381, and
early serials modified by SK208-80 ........ 4040 LBS 4162 LBs,
‘SIN 20880382 andon .... 4071 LBS. 4237 LBS
MAXIMUM USEFUL LOAD
‘SIN 20880179, 20880230 thru 20880381, and
early serials modified by SK208-80 .... 4745 Las 4623 LBS.
SIN 20880382 andon ..-----..- 4714 BS. 4548 LBS
WING LOADING : 7
coos) 31.8 LBSISQ FT
POWER LOADING 13.0 LBSISHP
FUEL CAPACITY: Total
‘SIN 20880001 thru 20880089 not modified by Sk208-52 : 335 GAL
S/N 20880001 thru 20880089 modified by SK208-52
‘and S/N 20860090 and on : ae | 338.6 GAL
OWL CAPACITY o.oo eee ee eee 14aTs
ENGINE: Pratt & Whitney Canada, Inc. Free Turbine
Fiat Rated at 675 Shaft Horsepower PTEATIAA,
PROPELLER: Hartzell 3-Bladed, Constant Speed,
Full Feathering, Reversible. Diameter . o 100 IN.
McCauley 3-Bladed, Constant Speed, Full
Feathering, Reversible. Diameter aa 106 IN.
* Speeds are based on mid-cruise weight.
NOTE
‘The above performance figures are based on the indicated weights, standard atmospheric
conditions, level hard-surface dry runways and no wind. They are calculated values
derived from flight tests conducted by Cessna Aircraft Company under carefully
documented conditions and will vary with individual airplanes and numerous factors
affecting performance. Performance for other operational conditions can be derived by
reference to operational data in other sections of this handbook.
Original Issue - 1 May 1990
ii Revision 15 - 17 January 1997