Академический Документы
Профессиональный Документы
Культура Документы
960/2
Physics
2 hours 30 minutes
PHYSICS
PAPER 2
STRUCTURE AND ESSAY
(2 hours and 30 minutes)
Instructions to candidates:
1. Quantum theory states that light consists of discrete packages of energy called photons.
The energy of each photon, E depends on the speed of light in vacuum, c , the
wavelength of the light, λ, and the Planck’s constant, h. The value of Planck’s constant is
6.63x10 -34 J s.
(a) Determine the dimensions of Planck’s constant? [2]
(c) Calculate the energy of one photon of a monochromatic light which has a wavelength
of 500 nm. [1]
(Assume the dimensionless constant = 1)
2
2. A ball is projected horizontally at 15.0 m s-1 from a point 20.0 m above a horizontal
surface. By taking g = 10.0 m s -2;
(a) find the time taken for the ball to reach the horizontal surface. [2]
(b) calculate the speed of the ball when it hits the horizontal surface. [3]
3
3. The figure below shows a man jumps from boat A to boat B. The two boats are stationary initially;
they are identical of mass 250 kg. The mass of the man is 50 kg and the speed of his jump is 1 .00
ms-1.
Find the velocity of the boat A ( VA ) and boat B ( VB ) after the man jump. [4]
4
4. A block of mass 20.0 kg is placed on a rough inclined plane at an angle 30o to the horizontal.
A man pulls the block with a force F parallel to the inclined plane so that it moves up the
plane at a constant speed of 0.400 m s -1. If the coefficient of kinetic friction of the plane is
0.500,
300
5
5. The diagram shows four horizontal forces acting at a point P.
Given that the forces are in equilibrium, calculate the value of T and the size of the
angle θ. [4]
6
6. (a) Explain what is meant by gravitational field strength. [1]
(b) The mass of the Moon is 7.50x10 22 kg and its radius 1730 km. Calculate the
gravitational field strength on the Moon’s surface. [2]
(c) If an athlete can jump a height of 1.50 m on the Earth ’s surface, what is the height he can
jump on the Moon’s surface? [2]
7
7. The diagram below shows a toy car which has a flywheel of moment of inertia 0.75 kg
m2 attached to the axle of its rear wheels. The flywheel is now accelerated to rotate at
2.00 revolution per second and the toy car is allowed to move on a table.
(b) If the effective decelerating force experienced by the car is 20 N, what is the
distance travelled by the car before it stops? [2]
8
8. The diagram below shows a disc X of moment of inertia 2.00 kg m 2 rotates freely with
an initial angular velocity of 2.00 rad s -1 about a vertical axis passing through its center
and disc Y of moment of inertia 0.500 kg m 2 is held above it. After Y is dropped onto
X, both discs rotates together about the same axis.
9
Section B: Answer any four questions from this section.
(b) The diagram below shows a conveyor belt used to transport sand in a factory.
When no sand is transported by the belt, a force of 100 N is supplied by the motor to
move the belt at constant speed of 2.00 m s -1.
sand
2.00 m s -1
(i) Calculate the power supplied by the motor to overcome the frictional force.
[2]
(ii) When sand is loaded on the belt at a rate of 20.0 kg s -1, explain why the motor
must supply additional force to maintain t he speed of the belt. Calculate the
additional force supplied by the motor. [3]
(iii) Calculate the additional power supplied by the motor. [2]
(iv) Explain the motion of the sand after it has fallen on the conveyor belt.
[2]
(v) Calculate the en ergy lost per second due to friction between the conveyor belt and
the sand. [3]
10
10. (a) (i) Explain why a centripetal force is necessary to keep an object moving round a
circle with constant speed. [2]
(ii) State the direction of the force. [1]
(b) A motor bike can turn round a bend on a level road. Explain why the bike moving at an
exceedingly high speed will easily cause accidents. [2]
(c) A small marble of mass 5 .00 g and negligible size is spinning inside a smooth cone
whose sides slope at an angle of 60 o to the horizontal as shown in the Figure below. The
marble is rotated steadily in a horizontal path at a height h = 5.00 cm above the vertex of the
cone.
(i) What is the radius of the ci rcular path of the marble? [1]
(ii) Find the net force acting on the marble. [2]
(iii) Hence, determine the speed of the marble and the period of revolution. [3]
(iv) If the path is at a height h = 7 .00 cm above the vertex of the cone instead, wh at is the
increase in the kinetic energy of the sphere? [3]
(v) If the sphere in Fig 3.1 slowly loses energy due to friction, state what happens to
the radius of path. [1]
(i) Explain why both the stars are revolving around their centre of mass. [2]
(ii) Calculate the centre of mass of the system from star X. [2]
(iii) Calculate the gravitational force b etween the stars. [2]
(iv) Calculate the period of each star. [3]
(v) Discuss the motion of the stars if one of the stars has very large mass compare to the
other. [2]
11
12. (a) Define what is meant by moment of inertia of a rigid body. [1]
(b) State two factors which affect the moment of inertia of a rigid body. [2]
(c) The diagram below shows a thin bike wheel of radius 0.2 00 m and mass 2.0 kg
spinning at 5.00 revs/second. A block is pushed against the top of the wheel with a force
N of 10 N. The coefficient of kinetic friction between the block and the wheel is 0.900.
(d) If the ring wheel is replaced by a disc wheel of same mass and radius, discuss whether it
will stop in a shorter time interval. [2]
12
13. (a) State the conditions that a r igid body acted by a few coplanar forces are in static
equilibrium. [2]
(b) The diagram below shows a uniform rod of length L being acted by two forces of equal
magnitude, F but in opposite directions at its ends.
(c) The diagram below shows a store sign of weight 50.0 N is hung from a uniform bar PQ
of weight 20.0 N and length 100 cm. The sign is suspended from a point 75.0 cm of the
way from the wall. The bar is held up with a cable of length 2.00 m.
2.00m
P Q
75 cm
13