Академический Документы
Профессиональный Документы
Культура Документы
stating that minus tolerance of thickness of steel rolled products is 0.3 mm,irrespective of
nominal thickness.
Procedure steps.
3. The Engineering department determines the pitting area percentage and the thickness loss
for the pitted area and refers to above checks them according to the below, applicable IACS
Rules ,as follows.
3.1 All areas found within accepted standards,if uncoated,should be treated to ST 2 minimum
surface standard and coated with modified epoxy high built coating (or equivalent) to min
thickness 600 microns.
3.2 The areas presenting pitting area without plate thickness loss and with scattered pitting of
max 0,3 mm depth,will be accepted without futher actions,except - if uncoated - of the
treatment to ST 2 minimum surface standard and coating with modified epoxy high built
coating (or equivalent), to min thickness 600 microns.
3.3 In the case that the pitting area plate thickness loss is above the applicable rules
tolerances,remedial measures should be taken and approved by both ABS and Owners.
An explanatory Flowchart has been also created as part of these procedures and is included
herebelow.
----------------------------------------------------------------------------------
d = Remaining pitting depth,estimated after removal of scale and paint from the
P% = Percentage of pitted area as a ratio of the total pitted area divided by the total
area of the plating concerned
Written 30/06/2015
Eng.Spiridon Gianniotis
PROCEDURE OF PITTING TREATMENT
START
%
COATING PITTING
N P R= i (mm) CONDITION AREA
(mm) (mm) (mm) (mm) PHOTOS
REMEDIAL MEASURES
NECESSARY BY INSERTING YES
EXECUTION OF REMEDIAL
MEASURES ACTIONS