Вы находитесь на странице: 1из 4

CLASS A, B, C AMPLIFIER

1. In a class A amplifier, conduction extends over 360o because Q point is


a) Located on load line
b) located near saturation point
c) Centered on load line
d) located at or near cut off point
Ref : Electrical Tech- By BL Theraja Page no 2313

2. The circuit efficiency of a class A amplifier can be increased by using


a) Low dc power input
b) Direct coupled load
c) Low rating transistor
d) Transformer coupled load
Ref : Electrical Tech- By BL Theraja Page no 2313

3. Ina class A amplifier, worst case condition occurs with


a) Zero signal input
b) Maximum signal input
c) High load resistance
d) Transformer coupling
Ref: Electrical Tech- By BL Theraja Page no 2313

4. The output of class B amplifier


a) is distortion free
b) consist of positive half cycle only
c) is like the output of a full wave rectifier
d) compromises short duration current pulses
Ref: Electrical Tech- By BL Theraja Page no 2313

5. The maximum overall efficiency of a transformer coupled class A amplifier


is………………….percentage
a) 78.5
b) 25
c) 50
d) 85
Ref: Electrical Tech- By BL Theraja Page no 2313

6. The main purpose of using transformer coupling in a class A amplifier is to


make it more
a) distortion free
b) bulky
c) costly
d) efficient
Ref: Electrical Tech- By BL Theraja Page no 2313

7. The dissipation at collector is zero in quiescent state and increases with


excitation in the case of
a) class A series fed amplifier
b) class A transformer coupled amplifier
c) class AB amplifier
d) class B amplifier
Ref: Electrical Tech- By BL Theraja Page no 2313

8. Class AB operation is often used in power ( large signal) amplifier in order to


a) get maximum efficiency
b) remove even harmonics
c) overcome cross over distortion
d) reduce collector dissipation
Ref: Electrical Tech- By BL Theraja Page no 2314

9. The main use of class C amplifier is


a) as an RF amplifier
b) as stereo amplifier
c) In communication sound equipment
d) as distortion generator
Ref: Electrical Tech- By BL Theraja Page no 2314

10. An amplifier is said to suffer from distortion when it output is


a) low
b) different from its input
c) noisy
d) larger than input
Ref: Electrical Tech- By BL Theraja Page no 2314

11. Which of the following classes of amplifier operation has highest power
efficiency?
a) Class A
b) Class B
c) Class C
d) Class AB
Ref:- Basic electronics by Grob’s Page -1044

12. In Class A amplifier, the collector current Ic flows for


a) 180o of ac input cycle
b) 360o of ac input cycle
c) 120o of ac input cycle
d) 90o of ac input cycle
Ref:- Basic electronics by Grob’s Page -1044

13. The collector current of class C amplifier


a) is rich in harmonics
b) flows for 1200 or less of AC input cycle
c) is non-sinusoidal
d) All the above
Ref:- Basic electronics by Grob’s Page -1044

14. In class B amplifier, collector current ICflows for


a) 120o of ac input cycle
b) 180o of ac input cycle
c) 360o of ac input cycle
d) 60o of ac input cycle
Ref:- Basic electronics by Grob’s Page -1045

15. Class C amplifier is typically used as an


a) audio amplifier
b) linear amplifier
c) tuned RF amplifier
d) none
Ref:- Basic electronics by Grob’s Page -1045

16. A power amplifier delivers 25W of ac power to a 4Ω speaker load. If the dc input
power is 40W, what is the efficiency of the amplifier?
a) a.78.6%
b) b.25%
c) c.62.5%
d) d.160%
Ref:- Basic electronics by Grob’s Page -1045

17. In RC coupled class A amplifier


a) the dc and ac load line are usually same
b) the dc load line is steeper than the ac load line
c) the Q point should be located near cut off an ac load line
d) the ac load line is steeper than dc load line
Ref:- Basic electronics by Grob’s Page -1045

18. Which of the following amplifier has lowest efficiency under large signal
condition?
a) class B push pull
b) class C RF amplifier
c) RC coupled Class A amplifier
d) Class B push pull and with split supplies
Ref:- Basic electronics by Grob’s Page -1045

19. Cross over distortion occurs in


a) Class A amplifier b) Class B amplifier c) Class B push pull
Ref: Electrical Tech- By BL Theraja Page no 2298

20. In a transformer coupled Class A amplifier , the transformer used is


a) Step up transformer b) Step down transformer c) Transformer with ratio 1:1
Ref: Electrical Tech- By BL Theraja Page no 340

Вам также может понравиться