Академический Документы
Профессиональный Документы
Культура Документы
Application is located in a reference air duct and is ex- Explanation of characteristic quantities
posed to the surrounding atmosphere by an
Combustion processes aperture. Under normal conditions, the air Å Air ratio
– Oil burner here has an oxygen content of 20.9 percent ¹ Nernst voltage
– Gas burner by volume. $ Variable pump voltage
Warranty claims
Block diagram
Sensor LSU4 with wire harness and connector Evaluation with IC CJ125
O2, CO, HC, H2, NOX APE IP Pin 6 red IP IPmeas
Measuring Resistance
+
UA
o2– Pin 2 green IA 61,9 V
–
IPN
Pin 5 yellow +
VM=2,5V
Reference
Voltage –
450 mV
RE UN
Pin 1 black
IP
Permissible short-term impact capacity B 300 m/s² 1,0
Service life in operation F 12.000 hours
0,0
Service life in standby mode F 50.000 hours
–1,0
Output signals with CJ125
Output voltage at Å = 0.8 ... 1,2 2 0,5 ... 2 V –2,0
Output voltage at Å = 1; ± = 0.0 % 2 = 1.5 V 0,7 1,0 1,3 1,6 1,9 2,2 2,5
3* = Pump current
Å = Air ratio
Dimensional drawing
1 6
2
27
3
ø12
4
5
35
61,9
85
Notes
Installation instructions
Å Air ratio
¹ Nernst voltage
$ Variable pump voltage
Technical data
Sensor element
Nominal internal resistance of Nernst cell 7 As new (operating point, calibration value), (measurement with 1...4 kHz): 300 ,
Max. current load of Nernst cell Continuous AC ?(f = 1...4 kHz) for 7 measurement B 250 .
Recommended reference pump current (sustained) = 20 .
Max. pump current to pump cell for rich-gas signal (ÅF 0.65) F - 9 mA
Max. pump current to pump cell for lean-gas signal (air) B 6 mA
Heater supply
Nominal voltage 7,5 V
Nominal heat output at 7.5 V Heating voltage in steady-state condition with air approx. 7,5 W
Typical cold resistance of heater at room temperature, including cable and connector 3,2 ,
Minimum cold resistance of heater at -40C 1,8 ,
Operating temperatures
Exhaust gas () B 930 °C
Hexagon at sensor housing () B 600 °C
Cable outlet (PTFE sheath) - sensor side (PTFE socket, /) B 250 °C
Cable outlet (PTFE sheath) - cable side (upper sleeve, ) B 200 °C
Cable and protective sheathing B 250 °C
Connector B 120 °C
Maximum temperatures (max. 40 h cumulative over service life in intervals of max. 10 min)
Cable outlet (PTFE sheath) - sensor side (PTFE socket, /) B 280 °C
Cable outlet (PTFE sheath) - cable side (upper sleeve, ) B 230 °C
Cable and protective sheathing B 280 °C
LI
97
27,8 57
7,5
8,7
M18x1,5 6e
2
SW 22
ø22,6
ø15
ø17,6
1 3 5
2 4 6
Sensor LSU4 with wire harness and connector Evaluation with IC CJ125 mA
O2, CO, HC, H2, NOX APE IP Pin 6 red IP IPmeas
3,0
Measuring Resistance
+
UA 2,0
o2– Pin 2 green IA 61,9 V
–
IP
IPN
Pin 5 yellow + 1,0
VM=2,5V
Reference
Voltage –
450 mV 0,0
RE UN
Pin 1 black
–1,0
only with CJ125
Ri -control 80 V
and AWS
H– Pin 4 white – –2,0
UH 0,7 1,0 1,3 1,6 1,9 2,2 2,5
H+ Pin 3 grey + l
0 261 230 109 56 0 280 218 089 100 0 281 002 772 41
0 261 230 110 57 0 280 218 113 101 0 281 002 787 77
0 261 230 112 58 0 280 218 119 102 0 281 002 802 108
0 261 230 121 43 0 280 218 176 106 0 281 002 841 72
0 261 230 145 80 0 281 002 209 92 0 281 002 842 73
Notes