Академический Документы
Профессиональный Документы
Культура Документы
(Autonomous)
Bachupally, Kukatpally, Hyderabad – 500 090, A.P., India. (040) 6686 4440
ASSIGNMENT SHEET – 1
Semester : I
1 Design a concrete mix for casting the present pretensioned girder to suit the following requirements
Characteristics cube strength –M-45
Use IS:383 code requirements.
Type of cement-ordinary Portland corresponding to typeF[57.5-62.5 N/mm2]
Degree of quality-very good
Type of exposure-mild.
2.A prestressed concrete beam with a rectangular section 120 mm wide by 300mm deep supports a
uniformly distributed load of 4kN/m,which includes the self-weight of the beam.The effective span of the
beam is 6 m.The beam is economically prestressed by a cable carrying a force of 180kN.Locate the
position of the pressure line in the beam.
3. Explain about pressure line?
C.Outcome Nos. :( 1)
ASSIGNMENT SHEET – 2
Semester : I
1. A Post –tensioned concrete beam of rectangle section,100mm wide and 300mm deep, is stressed
by a parabolic cable with zero eccentricity at the supports and an eccentricity of 50mm at the
centre of span.The area of the cable is 200mm2,initial stress in the cable is 1200n/mm2.If the
ultimate creep strain is 30X10-6 N/mm2 of stress E=2X105 N/mm2,Compute the loss stresses in
steel only due to creep of concrete.
2. List out various types of losses of prestress in post tensioned and pre tensioned members?
3. A concrete beam of 10o mm wide and 300 mm deep, is prestressed by 3 cables.The area of each
cable is 200 mm2 and the initial stress in the cable is 1200 n/mm2 .Cable 1 is parabolic with an
eccentricity of 50 mm above the centriod at supports and 50 mm below at the centre of span.cable
2 is also parabolic with zero eccentricity at supports and 50 mm below the centriod at the centre of
span. Cable 3 is staright with uniform eccentricity of 50 mm below the centriod.If the cables are
tensioned from one end only,estimate the percentage loss of stress in each cable due to friction .
4. What is anchorage slip? How do you compute the loss of stress due to anchorage slip?
Outcome Nos. :( 2)
Date: Date:
GokarajuRangaraju Institute of Engineering and Technology
(Autonomous)
Bachupally, Kukatpally, Hyderabad – 500 090, A.P., India. (040) 6686 4440
ASSIGNMENT SHEET – 3
Semester : I
1. What are the different types of flexural failure mode observed in prestressed concrete beams?
Explain with neat sketches?
2. Explain magnel’s method for investigation on anchorage zero stresses.
3. Using Guyo’s method, compute the position and magnitude of maximum tensile stress for the end
block with concentric anchor force of 100kN.
4. Explain the terms a) End Block b)Anchorage zone c) Busting Tension with reference to post-
tensioning prestressed members.
ASSIGNMENT SHEET – 4
Semester : I
Outcome Nos. :( 4)
ASSIGNMENT SHEET – V
Semester : I
C.Objective Nos.: ( 4)
C.Outcome Nos. :( 4)
Date: Date: